1. IDENTIFICATION 2. HAZARDS IDENTIFICATION. Serious eye damage/eye irritation Category 2. Physical State Liquid

Transcription

1 Safety Data Sheet Issue Date: 5/1/2014 Revision Date: 5/1/2014 Version: 1 1. IDENTIFICATION Product Identifier Product Name Other means of identification Product Code/SDS # E-Z Extract CACC04 Recommended use of the chemical and restrictions on use Recommended Use. Details of the supplier of the safety data sheet Supplier Address Chemsafe Brands 1480 Grandview Ave. Paulsboro, NJ Emergency Telephone Number Company Phone Number Emergency Telephone (24 hr) (Infotrac) Classification 2. HAZARDS IDENTIFICATION Serious eye damage/eye irritation Category 2 Signal Word Warning Hazard Statements Causes serious eye irritation Physical State Liquid Precautionary Statements - Prevention Wash face, hands and any exposed skin thoroughly after handling Wear eye/face protection Precautionary Statements - Response IF IN EYES: Rinse cautiously with water for several minutes. Remove contact lenses, if present and easy to do. Continue rinsing Get medical attention if irritation occurs Page 1 / 7

2 Hazards Not Otherwise Classified (HNOC) Causes mild skin irritation Other Hazards Harmful to aquatic life with long lasting effects Harmful to aquatic life First Aid Measures 3. COMPOSITION/INFORMATION ON INGREDIENTS Chemical Name CAS No Weight-% 1-10 Tetrasodium EDTA Tetrapotassium pyrophosphate FIRST-AID MEASURES Eye Contact Skin Contact Inhalation Ingestion IF IN EYES: Rinse cautiously with water for several minutes. Remove contact lenses, if present and easy to do. Continue rinsing. Get medical attention if irritation occurs. Wash off immediately with plenty of water for at least 15 minutes. Remove to fresh air. Clean mouth with water and drink afterwards plenty of water. Most important symptoms and effects Symptoms May cause skin and eye irritation. Indication of any immediate medical attention and special treatment needed Notes to Physician Treat symptomatically. 5. FIRE-FIGHTING MEASURES Suitable Extinguishing Media Use extinguishing measures that are appropriate to local circumstances and the surrounding environment. Unsuitable Extinguishing Media. Specific Hazards Arising from the Chemical Non-flammable. Protective equipment and precautions for firefighters As in any fire, wear self-contained breathing apparatus pressure-demand, MSHA/NIOSH (approved or equivalent) and full protective gear. Page 2 / 7

3 6. ACCIDENTAL RELEASE MEASURES Personal precautions, protective equipment and emergency procedures Personal Precautions Use personal protective equipment as required. Methods and material for containment and cleaning up Methods for Containment Methods for Cleaning Up Prevent further leakage or spillage if safe to do so. Keep in suitable, closed containers for disposal. 7. HANDLING AND STORAGE Precautions for safe handling Advice on Safe Handling Handle in accordance with good industrial hygiene and safety practice. Wash face, hands, and any exposed skin thoroughly after handling. Use personal protection recommended in Section 8. Conditions for safe storage, including any incompatibilities Storage Conditions Incompatible Materials Keep containers tightly closed in a dry, cool and well-ventilated place. None known based on information supplied. 8. EXPOSURE CONTROLS/PERSONAL PROTECTION Exposure Guidelines Chemical Name ACGIH TLV OSHA PEL NIOSH IDLH TWA: 20 ppm Appropriate engineering controls TWA: 50 ppm TWA: 240 mg/m 3 (vacated) TWA: 25 ppm (vacated) TWA: 120 mg/m 3 (vacated) S* S* IDLH: 700 ppm TWA: 5 ppm TWA: 24 mg/m 3 Engineering Controls Apply technical measures to comply with the occupational exposure limits. Individual protection measures, such as personal protective equipment Eye/Face Protection Skin and Body Protection Respiratory Protection Risk of contact: Wear approved safety goggles. Wear suitable protective clothing. Ensure adequate ventilation, especially in confined areas. General Hygiene Considerations Handle in accordance with good industrial hygiene and safety practice. Page 3 / 7

4 Information on basic physical and chemical properties 9. PHYSICAL AND CHEMICAL PROPERTIES Physical State Liquid Appearance Clear to slightly hazy liquid Odor Mild Color Clear to Straw Odor Threshold Property Values Remarks Method ph (1% Solution) = Melting Point/Freezing Point Boiling Point/Boiling Range Flash Point Evaporation Rate Flammability (Solid, Gas) n/a-liquid Upper Flammability Limits Lower Flammability Limit Vapor Pressure Vapor Density Relative Density (Specific Gravity) g/l Water Solubility Soluble in water Solubility in other solvents Partition Coefficient Autoignition Temperature Decomposition Temperature Kinematic Viscosity Dynamic Viscosity Explosive Properties Oxidizing Properties Reactivity Not reactive under normal conditions. Chemical Stability Stable under recommended storage conditions. Possibility of Hazardous Reactions None under normal processing. Conditions to Avoid Keep out of reach of children. Incompatible Materials None known based on information supplied. Hazardous Decomposition Products None known based on information supplied. 10. STABILITY AND REACTIVITY Page 4 / 7

5 Information on likely routes of exposure Product Information 11. TOXICOLOGICAL INFORMATION Eye Contact Skin Contact Inhalation Ingestion Causes serious eye irritation. Causes mild skin irritation. Avoid breathing vapors or mists. Do not taste or swallow. Component Information Chemical Name Oral LD50 Dermal LD50 Inhalation LC50 = 470 mg/kg ( Rat ) = 2270 mg/kg ( Rat ) = 220 mg/kg ( = 2.21 mg/l ( Rat ) 4 h = 450 ppm Rabbit ) ( Rat ) 4 h Tetrasodium EDTA = 10 g/kg ( Rat ) Tetrapotassium pyrophosphate - > 4640 mg/kg ( Rabbit ) Sodium xylenesulfonate = 7200 mg/kg ( Rat ) - - Information on physical, chemical and toxicological effects Symptoms Please see section 4 of this SDS for symptoms. Delayed and immediate effects as well as chronic effects from short and long-term exposure Carcinogenicity Not classifiable as a human carcinogen. Chemical Name ACGIH IARC NTP OSHA A3 Group 3 Legend ACGIH (American Conference of Governmental Industrial Hygienists) A3 - Animal Carcinogen IARC (International Agency for Research on Cancer) Group 3 IARC components are "not classifiable as human carcinogens" Numerical measures of toxicity Page 5 / 7

6 12. ECOLOGICAL INFORMATION Ecotoxicity Harmful to aquatic life. Harmful to aquatic life with long lasting effects. Chemical Name Algae/aquatic plants Fish Toxicity to microorganisms 1490: 96 h Lepomis macrochirus mg/l LC50 static 2950: 96 h Lepomis macrochirus mg/l LC50 Tetrasodium EDTA Tetrapotassium pyrophosphate : 72 h Desmodesmus subspicatus mg/l EC50 41: 96 h Lepomis macrochirus mg/l LC50 static 59.8: 96 h Pimephales promelas mg/l LC50 static 100: 96 h Oncorhynchus mykiss mg/l LC50 Crustacea : 24 h Daphnia magna mg/l EC : 48 h Daphnia magna mg/l EC50 610: 24 h Daphnia magna mg/l EC50 100: 48 h water flea mg/l EC50 Persistence/Degradability Bioaccumulation Mobility Chemical Name Partition Coefficient 0.81 Other Adverse Effects 13. DISPOSAL CONSIDERATIONS Waste Treatment Methods Disposal of Wastes Contaminated Packaging Disposal should be in accordance with applicable regional, national and local laws and regulations. Disposal should be in accordance with applicable regional, national and local laws and regulations. 14. TRANSPORT INFORMATION Note DOT IATA IMDG Please see current shipping paper for most up to date shipping information, including exemptions and special circumstances. Not regulated Not regulated Not regulated Page 6 / 7

7 International Inventories US Federal Regulations SARA 313 US State Regulations 15. REGULATORY INFORMATION Chemical Name CAS No Weight-% SARA Threshold Values % U.S. State Right-to-Know Regulations Chemical Name New Jersey Massachusetts Pennsylvania X X X 16. OTHER INFORMATION NFPA HMIS Health Hazards Health Hazards 2 Flammability Flammability 0 Instability Physical Hazards 0 Special Hazards Personal Protection B Issue Date 5/1/2014 Revision Date: 5/1/2014 Revision Note New product Disclaimer The information provided in this Safety Data Sheet is correct to the best of our knowledge, information and belief at the date of its publication. The information given is designed only as a guidance for safe handling, use, processing, storage, transportation, disposal and release and is not to be considered a warranty or quality specification. The information relates only to the specific material designated and may not be valid for such material used in combination with any other materials or in any process, unless specified in the text. End of Safety Data Sheet Page 7 / 7