SAFETY DATA SHEET QUIK-CARE AEROSOL FOAM HAND SANITIZER Section 1. Chemical product and company identification Product name Recommended use and restrictions QUIK-CARE AEROSOL FOAM HAND SANITIZER Skin antiseptic Use only for the purpose on the product label. Product dilution information Not applicable Supplier's information Code Date of issue Section 2. Hazards identification GHS Classification GHS label elements Ecolab Inc. Healthcare Division 370 N. Wabasha St. St. Paul, MN 55102 1-866-781-8787 901103-08 11 Jul 2013 EMERGENCY HEALTH INFORMATION 1-800-328-0026 Outside United States and Canada CALL 1-651-222-5352 (in USA) FLAMMABLE AEROSOLS. - Category 1 GASES UNDER PRESSURE - Compressed gas SERIOUS EYE DAMAGE/ EYE IRRITATION - Category 2B SPECIFIC TARGET ORGAN TOXICITY (SINGLE EXPOSURE) [Narcotic effects] - Category 3 Signal word Symbol Danger Hazard statements Precautionary statements Prevention Response Extremely flammable aerosol. Contains gas under pressure; may explode if heated. Causes eye irritation. May cause drowsiness and dizziness. Keep away from heat, sparks, open flames and hot surfaces. - No smoking. Pressurized container Do not pierce or burn, even after use. Use only outdoors or in a well-ventilated area. Avoid breathing vapor. Intentional misuse by deliberate inhalation may be harmful or fatal. No special protection is required. Page 1/8
Section 2. Hazards identification Storage Disposal Other hazards IF INHALED Remove victim to fresh air and keep at rest in a position comfortable for breathing. Call a POISON CENTER or physician if you feel unwell. IF IN EYES Rinse cautiously with water for several minutes. Remove contact lenses, if present and easy to do. Continue rinsing. If eye irritation persists Get medical attention. Protect from sunlight. Do not expose to temperatures exceeding 50 C/122 F. Store in a well-ventilated place. See section 13 for waste disposal information. None known. Section 3. Composition/information on ingredients Substance/mixture Hazardous ingredients Mixture Concentration Range (%) CAS number ALCOHOL >50 64-17-5 ISOBUTANE 1-5 75-28-5 GLYCERIN 1-5 56-81-5 HYDROFLUOROCARBON 152A 1-5 75-37-6 Hazardous ingredients Concentration Range (%) CAS number Section 4. First aid measures Eye contact Skin contact Inhalation Ingestion Rinse cautiously with water for several minutes. Remove contact lenses, if present and easy to do. Continue rinsing. Rinse with water for a few minutes. Get medical attention if symptoms appear. Remove victim to fresh air and keep at rest in a position comfortable for breathing. Get medical attention if you feel unwell. Get medical attention if symptoms occur. Protection of firstaiders No action shall be taken involving any personal risk or without suitable training. It may be dangerous to the person providing aid to give mouth-to-mouth resuscitation. Notes to physician In case of inhalation of decomposition products in a fire, symptoms may be delayed. The exposed person may need to be kept under medical surveillance for 48 hours. See toxicological information (section 11) Page 2/8
Section 5. Fire-fighting measures Suitable fire extinguishing media Specific hazards arising from the chemical Hazardous thermal decomposition products Specific fire-fighting methods Special protective equipment for fire-fighters Personal precautions Environmental precautions Methods for cleaning up Use water spray, fog or foam. Section 6. Accidental release measures Handling Storage Extremely flammable aerosol. In a fire or if heated, a pressure increase will occur and the container may burst, with the risk of a subsequent explosion. Gas may accumulate in low or confined areas or travel a considerable distance to a source of ignition and flash back, causing fire or explosion. Bursting aerosol containers may be propelled from a fire at high speed. Runoff to sewer may create fire or explosion hazard. Decomposition products may include the following materials carbon dioxide carbon monoxide halogenated compounds carbonyl halides Promptly isolate the scene by removing all persons from the vicinity of the incident if there is a fire. No action shall be taken involving any personal risk or without suitable training. Move containers from fire area if this can be done without risk. Use water spray to keep fire-exposed containers cool. Fire-fighters should wear appropriate protective equipment and self-contained breathing apparatus (SCBA) with a full face-piece operated in positive pressure mode. No special measures required. Avoid contact of large amounts of spilled material and runoff with soil and surface waterways. Absorb with an inert material. Use a water rinse for final clean-up. Section 7. Handling and storage Store and use away from heat, sparks, open flame or any other ignition source. Liquid and vapor under pressure. Do not puncture, incinerate or store the container at temperatures above 49 C (120 F) or in direct sunlight. Wash hands after handling. Keep out of reach of children. Keep container tightly closed. Keep container tightly closed and sealed until ready for use. Keep container in a cool, well-ventilated area. Avoid all possible sources of ignition (spark or flame). Do not puncture or incinerate container. Store between the following temperatures 0 and 40 C Page 3/8
Section 8. Exposure controls/personal protection Control parameters Ingredient name Exposure limits ALCOHOL ACGIH TLV (United States, 3/2012). STEL 1000 ppm 15 minutes. OSHA PEL (United States, 6/2010). TWA 1900 mg/m³ 8 hours. TWA 1000 ppm 8 hours. NIOSH REL (United States, 6/2009). TWA 1000 ppm 10 hours. TWA 1900 mg/m³ 10 hours. ISOBUTANE ACGIH TLV (United States, 3/2012). TWA 1000 ppm 8 hours. NIOSH REL (United States, 6/2009). TWA 800 ppm 10 hours. TWA 1900 mg/m³ 10 hours. GLYCERIN OSHA PEL (United States, 6/2010). TWA 5 mg/m³ 8 hours. Form Respirable fraction TWA 15 mg/m³ 8 hours. Form Total dust ACGIH TLV (United States, 3/2012). TWA 10 mg/m³ 8 hours. HYDROFLUOROCARBON 152A AIHA WEEL (United States, 10/2011). TWA 1000 ppm 8 hours. Appropriate engineering controls Personal protection Eye protection No special protection is required. Hand protection No special protection is required. Skin protection No special protection is required. Respiratory No special protection is required. protection Hygiene measures Physical state Color Odor ph Flash point Melting point Boiling point Evaporation rate (butyl acetate = 1) Vapor pressure Vapor density No special ventilation requirements. No special measures required. Section 9. Physical and chemical properties Explosion limits Flammability (solid, gas) Aerosol White Alcohol-like 6.4 to 6.7 (100%) Not applicable. Page 4/8
Section 9. Physical and chemical properties Relative density Solubility Partition coefficient n-octanol/water Auto-ignition temperature Decomposition temperature Odor threshold Viscosity Aerosol product Type of aerosol Heat of combustion Ignition distance Flame height Flame duration Stability Possibility of hazardous reactions 0.88 to 0.9 (Water = 1) Spray Hazardous decomposition products 16.24 kj/g Section 10. Stability and reactivity Conditions to avoid Avoid all possible sources of ignition (spark or flame). Materials to avoid Section 11. Toxicological information Route of exposure Ingestion Acute toxicity Eye contact Skin contact Inhalation The product is stable. Under normal conditions of storage and use, hazardous reactions will not occur. Under normal conditions of storage and use, hazardous decomposition products should not be produced. Skin contact, Eye contact, Inhalation, Ingestion Symptoms Eye contact Adverse symptoms may include the following irritation watering redness Skin contact No specific data. Inhalation Adverse symptoms may include the following respiratory tract irritation coughing nausea or vomiting headache drowsiness/fatigue dizziness/vertigo unconsciousness No specific data. Causes eye irritation. Page 5/8
Section 11. Toxicological information Ingestion Toxicity data Product/ingredient name ethanol glycerin difluoroethane Chronic toxicity Carcinogenicity Mutagenicity Teratogenicity Developmental effects Fertility effects Can cause central nervous system (CNS) depression. May cause drowsiness and dizziness. Intentional misuse by deliberate inhalation may be harmful or fatal. Can cause central nervous system (CNS) depression. LC50 Inhalation Rat 117 mg/l Vapor LD50 Dermal Rabbit 15800 mg/kg LD50 Oral Rat 10470 mg/kg LC50 Inhalation Rat >2.75 mg/l Dusts and mists LD50 Dermal Rabbit 23000 mg/kg LD50 Oral Rat 18300 mg/kg LC50 Inhalation Rat >437500 ppm Gas. Section 12. Ecological information Ecotoxicity Aquatic and terrestrial toxicity Product/ingredient name Result Species Exposure ethanol Acute LC50 11000 mg/l Fish 96 hours glycerin Acute LC50 855 mg/l Fish 96 hours Other adverse effects Section 13. Disposal considerations Disposal methods Avoid disposal. Attempt to use product completely in accordance with intended use. Disposal should be in accordance with applicable regional, national and local laws and regulations. Do not puncture or incinerate container. Discard empty container in trash. Page 6/8
Section 14. Transport information Certain shipping modes or package sizes may have exceptions from the transport regulations. The classification provided may not reflect those exceptions and may not apply to all shipping modes or package sizes. DOT DOT Classification DOT Proper shipping name Class Packing group IMO/IMDG IMO/IMDG Classification IMO/IMDG Proper shipping name Class Packing group Not intended for transport. UN1950 Aerosols, flammable 2.1 - UN1950 AEROSOLS, FLAMMABLE 2.1 - For transport in bulk, see shipping documents for specific transportation information. Section 15. Regulatory information U.S. Federal regulations TSCA 8(b) inventory All components are listed or exempted. SARA 302/304/311/312 extremely hazardous substances No listed substance SARA 302/304 emergency planning and notification No listed substance SARA 313 Product name CAS number Concentration Form R - Reporting requirements California Prop. 65 No listed substance No listed substance Section 16. Other information Hazardous Material Information System (U.S.A.) Health Flammability Physical hazards * 1 2 0 National Fire Protection Association (U.S.A.) Health 1 2 0 Flammability Instability/Reactivity Special Page 7/8
Section 16. Other information NFPA Aerosol Level Level 1 Date of issue Prepared by 11 Jul 2013 Regulatory Affairs 1-800-352-5326 Notice to reader The above information is believed to be correct with respect to the formula used to manufacture the product in the country of origin. As data, standards, and regulations change, and conditions of use and handling are beyond our control, NO WARRANTY, EXPRESS OR IMPLIED, IS MADE AS TO THE COMPLETENESS OR CONTINUING ACCURACY OF THIS INFORMATION. Page 8/8