Section 1 Chemical Product and Company Identification Product Name or Number: G, H, K, L and M Filament Texturized Rovings -- E Glass Products Date of Preparation or Last Change: November 3, 1997 Section 2 Composition/Information on Ingredients Chemical/Common Name C.A.S. Number % By Weight Glass,oxide,chemicals/Amorphous Silica Fiber 65997-17-3 99-100 Remaining components not determined hazardous and/or NA Trace hazardous components present at less the 1.0% (0.1% for carcinogens) Section 3 Hazards Identification Potential Health Effects Eye Contact: Eye contact with fibers and dust may produce temporary irritation. Skin Contact: Skin contact with fibers and dust may produce temporary irritation. Oral Ingestion: Not a normal route of exposure. - i -
Section 4 First Aid Measures Emergency/First Aid Procedures Skin: Wash with mild soap and running water. Use a washcloth to help remove fibers. Do not rub or scratch irritated areas. If irritation persists, seek medical attention. Eye: Inhalation: Ingestion: Section 5 In case of contact immediately wash eyes with large amounts of water for 15 minutes. If irritation persists seek medical attention. In case of overexposure immediately move person from contaminated area to fresh air. Get medical attention if necessary. Seek medical attention, if gastrointestinal irritation persists or other symptoms such as nausea, vomiting, abdominal pain or diarrhea develop. Fire Fighting Measures Extinguishing Media: Use extinguishing agent suitable for type of surrounding fire. Special Fire Fighting Instructions: Flash Point: Flammability Limits: Lower Explosive Limit: Upper Explosive Limit: Auto Ignition Temperature: Section 6 Accidental Release Measures Action To Take For Spills/Leaks - ii -
Notification Information: There are no specific reporting requirements for release of this material as supplied under the Comprehensive Environmental Response Compensation and Liability Act (CERCLA) (40 CFR 302) or the Superfund Amendment and Reauthorization Act (SARA) (40 CFR 355). There may be specific reporting requirements for the release of this material at the local, regional or state level. Section 7 Handling and Storage Handling and Storage Procedures Store in a clean, dry place. Keep containers closed. Section 8 Exposure Controls/Personal Protection Engineering Controls/Work Practices Ventilation: Control airborne concentrations below the exposure guidelines specified by Occupational Safety and Health Administration (OSHA) or other local, state and federal regulations. Personal Protective Equipment/Protective Measures Respiratory Protection: Respiratory protection is not normally necessary. Respiratory protection may be needed when handling used material in non-routine or emergency situations. If exposure limits may possibly exceed the TLV or respiratory irritation is experienced, NIOSH/MSHA approved respiratory protection should be worn. An industrial hygienist or other qualified professional should be consulted during the respiratory selection process to assure that the respiratory protection used is appropriate under the conditions of use. A respiratory protection program that meets OSHA s 29 CFR 1910.134 requirements must be followed whenever workplace conditions warrant a respirator s use. Protective Clothing: Protective Clothing is not normally necessary. - iii -
Eye Protection: Eye protection is not normally necessary. Exposure Guidelines: Component Glass, oxide, chemicals PEL 6 mg/m 3, for amorphous silica (OSHA) TLV 10 mg/m 3, for fibrous glass dust (ACGIH) OSHA revoked the Final Rule Limits of January 19, 1989 in response to the 11 th Circuit Court of Appeals decision (AFL-CIO v. OSHA) effective June 30, 1993. See CFR 1910.1000 (58 FR 35338). Section 9 Physical and Chemical Properties Physical State: Solid Color and Odor: Caramel woven textile with no odor; White texturized rope with no odor. % Solubility in Water: Specific Gravity (water =1): 2.10 Vapor Pressure: Vapor Density (air=1): Viscosity: Melting Point: Boiling Point: >1704.4 C Evaporative Rate (water=1): % Volatile By Volume: - iv -
Four Point: ph: Section 10 Stability: Stability and Reactivity Stable under normal conditions of use. Incompatibility: Incompatible with fluorine, oxygen difluoride, chlorine bifluoride and alkalides. Hazardous Decomposition Products: Thermal decompositions may be hazardous and may produce carbon monoxide and carbon dioxide. Hazardous Polymerization: Section 11 Toxicology Information Persons with pre-existing skin and respiratory disorders may be more susceptible to the effects of this material. Section 12 Ecological Information ND Section 13 Disposal Consideration Waste Disposal Method - v -
The transportation, storage, treatment, and disposal of this waste material must be conducted in compliance with all applicable Federal, state and local regulations. Discharge to any source of drinking water is prohibited. Section 14 Transportation Information DOT Information Hazard Class: Proper Shipping Name: Labels Required: Placards Required: Bill of Lading Description: UN/NA Code: Section 15 Product Name Regulatory Information All components of this product are listed on the Toxic Substances Control Act (TSCA) inventory. All components of this product are listed in the Canadian Domestic Substances List (DSL) Inventory. The Canadian Workplace Hazardous Materials Information System (WHMIS) other toxic effects category apply to this product. = Not Applicable ND = No Data - vi -