SERVE RT TEL. Refill capacity of coolant & lubricant. Radiator and reservoir tank oolant spec : ixture of water and ethylene glycol base antifreeze. hange interval : Every,000 hours. apacity WTER TREEZE WTER TREEZE ST UE L0, T L0, T L0, T L0, T L5, T L5, T L0 L0 L0, L80 0 (.9) 0 (.9) 5 (9.) 5 (9.) 5 (9.) 5 (9.) 0 (0.) 9 (0.) 5 (.8) 5 (.) oolant Engine oil UEL T WTS0 rain plug WTS0. Engine crankcase il spec : SE 5W0 apacity and change interval Every 50 hours L0, T L0, T L0, T L0, T L80 (.9) (.9). (.) (.) 8 (0.0) Every 500 hours L5, T L5, T L0 L0 L0 L0. (.) (.) (.) 8 (.8) 0 (5.) (.) oolant rain plug Engine oil UEL T WTS0 WEEL LER
SERVE RT. ydraulic tank ) il level check Set the machine as shown in the figure. Turn off the engine and leave it approx 5 minutes. heck the oil level at the sight gauge. TEL Sight gauge ) hange the hydaulic oil Prepare a suitable container to receive the drained oil. Relief the pressure in the tank by pushing the top of the air breather. Remove the cover on top of the tank and the drain plug from the bottom. fter oil is drained, install the drain plug and refill the specified new oil. nstall the cover and bleed the air in hydraulic pump as below. il spec : S V hange interval : Every,000 hours apacity yd tank yd system L0, T 90 (.8) 5 (.0) L0, T 90 (.8) 5 (.0) L0, T 05 (.) 5 (.) L0, T 05 (.) 5 () L5, T 0 (.) 5 (.) L5, T 0 (.) 5 (.) L0, 50 (9.) 0 (8.) L0, 00 (5.8) 0 (8.5) L80 0 (55.5) 0 (90) WTS05 ) ir bleeding procedure Start the engine and operate the machine slowly, as below. Retract and extend all cylinders a few times with full stroke. heck the oil level and refill with specified new oil, if necessary. WEEL LER
R LEVEL SERVE RT. xle and differential il spec : SE 80W90LS (P L5) for wet type brake & limited slip differential obil lube LS 85W90 (L80 only) apacity and change interval L0, T L0, T L0, T L0, T L5, T L5, T L0, ront 8. (.9) 8. (.9). (5.). (5.) 9 (.) 9 (.) 5 (.9) 8(0.0) Rear 8. (.9) 8. (.9). (5.). (5.) 9 (.) (.) 0 (0.) (8.) hange interval (hrs),000,000,000,000,500,500,500 rain position TEL ir breather ill plug rain plug Level check or refill position L0, L80 8 (0.) 5(.5) 0 (5.9) 5 (.0) (.) 0 (5.9),500,000 ir breather ill & oil level plug Volvo axle Z axle rain plug R LEVEL rain position Level check or refill position WTS0.5 Transmission il spec : SE 5W0 hange interval : Every,000 hours apacity ir breather RER RE L0, T L0, T L0, T L0, T L5, T L5, T L0, L0, L80 0 (5.) 0 (5.) (.) (.) (.) (.) (8.5) 50 (.) (.) rain plug WTS0 WEEL LER
SERVE RT. Lubrication of pin, bushing and bearing ) ttachment, steering cylinder, drive line / rease spec : L o. Lubrication interval : Every 50 hours L0, L0, L0, L0 TEL (R),0(L) 8 9 o. 5 8 9 0 ucket cylinder pin oom cylinderfront frame connection pin oom cylinderboom connection pin ell crankbucket link connection pin ucketboom connection pin ucketbucket link connection pin oombell crank connection pin ucket cylinderbell crank connection pin oomfront frame connection pin ront drive shaft enter drive shaft (slip yoke) 5 WTS L0T, L0T, L0T, L0T o. 5 8 9 5 8 9 0 5 Quick couplerlink connection pin Linklink connection pin ucket cylinderlink connection pin ucket cylinderlink connection pin oomlink connection pin Linklink connection pin ront frameboom connection pin ront framelink connection pin ront frameboom cylinder connection pin Quick couplerboom connection pin oomlink connection pin oom cylinderboom connection pin ront drive shaft enter drive shaft (slip yoke) 5 0 (L) 5 WTS5 WEEL LER 5
SERVE RT ttachment, steering cylinder, drive line / L5,, L0,, L0, TEL L5,L0:#05 L0:#0 LE o. E L ucket cylinder (front frame side) pin oom cylinder (front frame side) right pin oomfront frame right connection pin oomfront frame left connection pin oom cylinder (front frame side) left pin oom cylinderboom connection pin ucket cylinderbell crank connection pin oombell crank connection pin ell crankbucket link connection pin ucketbucket link connection pin ucketboom connection pin ront drive shaft enter drive shaft (slip yoke),e( L side R side L5,L0:#05 L0:#0 model:#000 ) WTS L5T, L5T o. 5 8 9 0 Quick couplerlink connection pin Linklink connection pin ucket cylinderlink connection pin oomlink connection pin Quick couplerboom connection pin oom cylinderboom connection pin oom cylinderfront frame connection pin Linkfront frame connection pin oomfront frame connection pin ront drive shaft (flange bearing) enter drive shaft (slip yoke) (#009) L R ETL 5 9 8 (#000) 0 WTS WEEL LER
SERVE RT TEL ttachment, steering cylinder, drive line / L80 o. E L P Q ucket cylinder (front frame side) right pin oom cylinder (front frame side) right pin oomfront frame right connection pin Steering cylinder (front frame side) right pin oomfront frame left connection pin oom cylinder (front frame side) left pin ucket cylinder (front frame side) left pin Steering cylinder (front frame side) left pin rive shaft (middle) pin oom cylinderboom connection pin ucket cylinderbell crank connection pin oombell crank connection pin ell crankbucket link connection pin ucketbucket link connection pin ucketboom connection pin enter drive shaft (slip yoke) ront frame side plate(l) Q L E ront frame side plate(r) Rear frame side plate(r) P WTS0 ) enter pivot bearing : ll model rease spec : L o. Lubrication interval : Every,000 hours WTS9 WEEL LER