SAFETY DATA SHEET SL-914 FLOATING SOLVENT LIFT STATION CLEANER. 1. Product and Company Identification. 2. Hazards Identification

Transcription

1 Product Code: Product Name: Company Name: Web site address: 1. Product and Company Identification 9140 SUNBELT LABORATORIES Phone Number: P.O. BOX 1563 (81) STAFFORD, TX Emergency Contact: CHEM-TEL (800) Flammable Liquids, Category 4 Skin Corrosion/Irritation, Category Skin Sensitization, Category 1 Aquatic Toxicity (Chronic), Category 1. Hazards Identification Page: 1 GHS Signal Word: GHS Hazard Phrases: GHS Precaution Phrases: GHS Response Phrases: GHS Storage and Disposal Phrases: OSHA Regulatory Status: Potential Health Effects (Acute and Chronic): Warning Combustible liquid. Causes skin irritation. May cause an allergic skin reaction. Very toxic to aquatic life with long lasting effects. Keep away from heat/sparks/open flames/hot surfaces. - No smoking. Avoid breathing dust/fume/gas/mist/vapors/spray. Wash hands thoroughly after handling. Contaminated work clothing should not be allowed out of the workplace. Avoid release to the environment. Wear protective gloves/protective clothing/eye protection/face protection. IF ON SKIN: Wash with plenty of soap and water. Specific treatment see... on this label. If skin irritation occurs, get medical advice/attention. If skin irritation or rash occurs, seek medical advice/attention. Take off contaminated clothing and wash before re-use. Wash contaminated clothing before reuse. Collect spillage. Store in cool/well-ventilated place. Dispose of contents/container to... This material is classified as hazardous under OSHA regulations. Prolonged or repeated skin contact may cause defatting and dermatitis. There was NO evidence of carcinogenic activity of d-limonene for female rats, for male mice, or for female mice. Inhalation: Skin Contact: Eye Contact: May cause respiratory tract irritation. May cause irritation with burning pain, itching and redness. Causes skin irritation. May cause skin sensitization, an allergic reaction, which becomes evident upon re-exposure to this material. Prolonged and/or repeated contact may cause defatting of the skin and dermatitis. Causes eye irritation.

2 Ingestion: Aspiration hazard. May cause irritation of the digestive tract. Page: 3. Composition/Information on Ingredients CAS # Hazardous Components (Chemical Name) Concentration Hydrotreated light distillate (petroleum) % (R)-1-Methyl-4-(1-methylethenyl)-cyclohexene % Emergency and First Aid Procedures: 4. First Aid Measures In Case of Inhalation: In Case of Skin Contact: In Case of Eye Contact: In Case of Ingestion: Note to Physician: If inhaled, remove to fresh air. If breathing is difficult, give oxygen. Get medical aid. Remove contaminated clothing and shoes. Get medical aid if irritation develops and persists. Wash clothing before reuse. In case of contact, immediately flush skin with soap and plenty of water. In case of contact, immediately flush eyes with plenty of water for at least 15 minutes. Get medical aid. Potential for aspiration if swallowed. Get medical aid immediately. Never give anything by mouth to an unconscious person. If vomiting occurs naturally, have victim lean forward. Treat symptomatically and supportively. 5. Fire Fighting Measures Flash Pt: > F (4. C) Explosive Limits: LEL: UEL: Autoignition Pt: Fire Fighting Instructions: Flammable Properties and Hazards: Suitable Extinguishing Media:Use water spray, dry chemical, carbon dioxide, or appropriate foam. As in any fire, wear a self-contained breathing apparatus in pressure-demand, MSHA/NIOSH (approved or equivalent), and full protective gear. During a fire, irritating and highly toxic gases may be generated by thermal decomposition or combustion. Use water spray to keep fire-exposed containers cool. Containers may explode in the heat of a fire. Flammable liquid and vapor. Vapors are heavier than air and may travel to a source of ignition and flash back. Vapors can spread along the ground and collect in low or confined areas. This liquid floats on water and may travel to a source of ignition and spread fire. 6. Accidental Release Measures Steps To Be Taken In Case Material Is Released Or Spilled: Use proper personal protective equipment as indicated in Section 8. Spills/Leaks: Absorb spill with inert material (e.g. vermiculite, sand or earth), then place in suitable container. Avoid runoff into storm sewers and ditches which lead to waterways. Clean up spills immediately, observing precautions in the Protective Equipment section. Remove all sources of ignition. Provide ventilation. Forms smooth, slippery surfaces on floors, posing an accident risk.

3 Precautions To Be Taken in Handling: Precautions To Be Taken in Storing: 7. Handling and Storage Page: 3 Wash thoroughly after handling. Use with adequate ventilation. Avoid contact with eyes, skin, and clothing. Empty containers retain product residue, (liquid and/or vapor), and can be dangerous. Keep container tightly closed. Avoid ingestion and inhalation. Do not pressurize, cut, weld, braze, solder, drill, grind, or expose empty containers to heat, sparks or open flames. Ground and bond containers when transferring material. Keep away from heat, sparks and flame. Avoid breathing dust, mist, or vapor. Keep away from sources of ignition. Store in a tightly closed container. Store in a cool, dry, well-ventilated area away from incompatible substances. Keep away from heat, sparks and flame. Flammables-area. Separate from oxidizing materials. Partially filled containers should be blanketed with nitrogen. 8. Exposure Controls/Personal Protection CAS # Partial Chemical Name OSHA TWA ACGIH TWA Other Limits Hydrotreated light distillate (petroleum) (R)-1-Methyl-4-(1-methylethenyl)-cycloh exene Respiratory Equipment (Specify Type): Eye Protection: Protective Gloves: Other Protective Clothing: Engineering Controls (Ventilation etc.): TLV: 00 mg/m3 Follow the OSHA respirator regulations found in 9 CFR or European Standard EN 149. A respiratory protection program that meets OSHA's 9 CFR and ANSI Z88. requirements or European Standard EN 149 must be followed whenever workplace conditions warrant respirator use. Wear appropriate protective eyeglasses or chemical safety goggles as described by OSHA's eye and face protection regulations in 9 CFR or European Standard EN166. Wear chemical splash goggles. Wear appropriate protective gloves to prevent skin exposure. Wear appropriate protective clothing to prevent skin exposure. Facilities storing or utilizing this material should be equipped with an eyewash facility and a safety shower. Use adequate ventilation to keep airborne concentrations low. 9. Physical and Chemical Properties Physical States: [ ] Gas [ X ] Liquid [ ] Solid Appearance and Odor: ph: orange. solvent odor. NA Melting Point: NE Boiling Point: NA Flash Pt: > F (4. C) Evaporation Rate:.1 (BuAC=1) Flammability (solid, gas): Explosive Limits: LEL: UEL: Vapor Pressure (vs. Air or 3.4 at 68.0 F (0.0 C) mm Hg): Vapor Density (vs. Air = 1): NA Specific Gravity (Water = 1):.90 Solubility in Water: Insoluble

4 Percent Volatile: Autoignition Pt: % by volume. 10. Stability and Reactivity Page: 4 Stability: Conditions To Avoid - Instability: Incompatibility - Materials To Avoid: Hazardous Decomposition or Byproducts: Possibility of Hazardous Reactions: Conditions To Avoid - Hazardous Reactions: Unstable [ ] Stable [ X ] ignition sources, Excess heat. Strong oxidizing agents. Nitrogen oxides, Carbon monoxide, oxides of sulfur, irritating and toxic fumes and gases. Will occur [ ] Will not occur [ X ] Product will not undergo polymerization. 11. Toxicological Information Toxicological Information: Carcinogenicity/Other Information: Epidemiology: No information found. Teratogenicity: No information available. Reproductive Effects: Mutagenicity: Neurotoxicity: CAS# : Not listed by ACGIH, IARC, NTP, or CA Prop 65. CAS# : Not listed by ACGIH, IARC, NTP, or CA Prop 65. CAS # Hazardous Components (Chemical Name) NTP IARC ACGIH OSHA Hydrotreated light distillate (petroleum) n.a. n.a. A4 n.a (R)-1-Methyl-4-(1-methylethenyl)-cyclohexene n.a. 3 n.a. n.a. 1. Ecological Information General Ecological Information: Waste Disposal Method: Environmental: May bioconcentrate in aquatic organisms and fish. Has low mobility in soil and may rapidly volatilize in the atmosphere. Limonene can be readily degraded in soil. Physical: No information available. Other: Dipentene, which is optically inactive limonene, is a marine pollutant. 13. Disposal Considerations Chemical waste generators must determine whether a discarded chemical is classified as a hazardous waste. US EPA guidelines for the classification determination are listed in 40 CFR Parts 61. Additionally, waste generators must consult state and local hazardous waste regulations to ensure complete and accurate classification. RCRA P-Series: None listed. RCRA U-Series: None listed. 14. Transport Information LAND TRANSPORT (US DOT): DOT Proper Shipping Name: DOT Hazard Class: UN/NA Number: LAND TRANSPORT (Canadian TDG): TDG Shipping Name: Not Regulated. DIPENTENE. Not Regulated. DIPENTENE.

5 CAS # Hazardous Components (Chemical Name) 15. Regulatory Information EPA SARA (Superfund Amendments and Reauthorization Act of 1986) Lists Page: 5 S. 30 (EHS) S. 304 RQ S. 313 (TRI) Hydrotreated light distillate (petroleum) No No No (R)-1-Methyl-4-(1-methylethenyl)-cyclohexene No No No This material meets the EPA 'Hazard Categories' defined for SARA Title III Sections 311/31 as indicated: [X] Yes [ ] No Acute (immediate) Health Hazard [X] Yes [ ] No Chronic (delayed) Health Hazard [X] Yes [ ] No Fire Hazard [ ] Yes [X] No Sudden Release of Pressure Hazard [ ] Yes [X] No Reactive Hazard CAS # Hazardous Components (Chemical Name) Other US EPA or State Lists Hydrotreated light distillate (petroleum) TSCA: Inventory (R)-1-Methyl-4-(1-methylethenyl)-cyclohexene TSCA: Inventory 16. Other Information Revision Date: 06/18/015 Hazard Rating System: HMIS: HEALTH FLAMMABILITY REACTIVITY PPE 0 Flammability Health NFPA: Instability Special Hazard Additional Information About This Product: Company Policy or Disclaimer: DISCLAIMER: To the best of our knowledge, the information contained herin is accurate. There is no assumption of liability for accuracy contained within this information. The information given is designed only as a guidance for safe handling, use, processing, storage, transportation, disposal and release and is not to be considered a warranty or quality specification. The information relates only to the specific material designated and may not be valid for such material used in combination with any other materials or in any process, unless specified in the text.