Safety Data Sheet Material Name: Additive Solution Formula 3 (AS-3 )

Transcription

1 Material Name: Additive Solution Formula 3 (AS-3 ) * * * Section 1 - Identification of the Substance/Preparation and the Company/Undertaking * * * Manufacturer Information Haemonetics Corporation 400 Wood Road Braintree, MA Contact the Environmental, Health & Safety Department (781) * * * Section 2 - Composition / Information on Ingredients * * * EC # Component Percent Symbols Risks Water Glucose Monohydrate Sodium citrate Sodium chloride Phosphoric acid, monosodium salt, monohydrate Citric acid Adenine (6-Aminopurine) * * * Section 3 - Hazards Identification * * * Human and Environmental Hazards May cause eye, skin, gastrointestinal, and/or respiratory tract irritation. * * * Section 4 - First Aid Measures * * * First Aid: Eyes Flush immediately with water for at least 15 minutes. Do not rub eyes. First Aid: Skin For skin contact, flush with large amounts of water. If irritation persists, get medical attention. First Aid: Ingestion If ingestion of a large amount does occur, seek medical attention. First Aid: Inhalation Move person to non-contaminated air. If the affected person is not breathing, apply artificial respiration. * * * Section 5 - Fire Fighting Measures * * * General Fire Hazards Hazardous Combustion Products Not determined Extinguishing Media Use extinguishing media appropriate for surrounding fire. Fire Fighting Equipment/Instructions Firefighters should wear full protective gear. * * * Section 6 - Accidental Release Measures * * * Containment Procedures Contain the discharged material. Clean-Up Procedures Wear appropriate protective equipment and clothing during clean-up. Use sand or perlite or vermiculite as an absorbent for large spills of this material. Page 1 of 5 Issue Date: 01/26/09 Revision: Print Date: 1/28/2009

2 Evacuation Procedures Isolate area. Keep unnecessary personnel away. Special Procedures Avoid contact with skin and eyes. * * * Section 7 - Handling and Storage * * * Handling Procedures Wash hands after handling and before eating. Storage Procedures Keep this material in a cool, well-ventilated place. (25 C(77 F)). Avoid excessive heat and protect from freezing. Specific Use Blood coagulation prevention * * * Section 8 - Exposure Controls / Personal Protection * * * Substance Exposure Limits The EU, ACGIH, Austria, Belgium, Denmark, Finland, France, Germany, Greece, Ireland, Italy, Netherlands, Portugal, Spain, Sweden, and United Kingdom have not developed exposure limits for any of the substances in this preparation. Engineering Controls required under normal product use conditions. PERSONAL PROTECTIVE EQUIPMENT Personal Protective Equipment: Eyes/Face Wear safety glasses; chemical goggles (if splashing is possible). Personal Protective Equipment: Skin Use impervious gloves. Personal Protective Equipment: Respiratory Not normally needed. Personal Protective Equipment: General Eye wash fountain is recommended. * * * Section 9 - Physical & Chemical Properties * * * Appearance: Clear Odor: Physical State: Liquid ph: ND Vapor Pressure: ND Vapor Density: ND Boiling Point: ND Melting Point: ND Solubility (H2O): Soluble Specific Gravity: ND Evaporation Rate: ND VOC: ND Octanol/H2O Coeff.: ND Flash Point: ND Flash Point Method: ND Upper Flammability Limit ND (UFL): Lower Flammability Limit ND Burning Rate: ND (LFL): Auto Ignition: ND * * * Section 10 - Chemical Stability & Reactivity Information * * * Chemical Stability This is a stable material. Chemical Stability: to Avoid Incompatibility Not Determined Hazardous Decomposition Not Determined Hazardous Polymerisation Will not occur. Page 2 of 5 Issue Date: 01/26/09 Revision: Print Date: 1/28/2009

3 * * * Section 11 - Toxicological Information * * * Potential Health Effects B: Substance Analysis - LD50/LC50 Water ( ) Oral LD50 Rat: >90 ml/kg Sodium chloride ( ) Inhalation LC50 Rat: >42 g/m3/1h; Oral LD50 Rat:3 g/kg; Dermal LD50 Rabbit:>10 g/kg Citric acid ( ) Oral LD50 Rat: 3000 mg/kg Adenine (6-Aminopurine) ( ) Oral LD50 Rat: 227 mg/kg Carcinogenicity B: Substance Carcinogenicity of the substances in this preparation are listed by IARC, Austria, Belgium, Denmark, France, Germany, Ireland, Luxembourg, Netherlands, Spain, or United Kingdom. * * * Section 12 - Ecological Information * * * Ecotoxicity B: Substance Analysis - Ecotoxicity - Aquatic Toxicity Sodium citrate ( ) Poecilia reticulata mg/l 96 Hr EC50 Chlorella vulgaris mg/l 48 Hr EC50 Daphnia magna 5600 mg/l Sodium chloride ( ) Lepomis macrochirus Lepomis macrochirus Oncorhynchus mykiss mg/l [flow-through] 48 Hr EC50 Daphnia magna mg/l [flow-through] mg/l [static] mg/l [static] 7050 mg/l [semi-static] mg/l [static] 1000 mg/l Page 3 of 5 Issue Date: 01/26/09 Revision: Print Date: 1/28/2009

4 Citric acid ( ) Lepomis macrochirus 1516 mg/l [static] 72 Hr EC50 Daphnia magna 120 mg/l Mobility Persistence & Degradation Bioaccumulation Other Adverse Effects * * * Section 13 - Disposal Considerations * * * Waste Disposal Instructions Avoid disposal, attempt to utilize preparation completely. Prior to disposal of unused preparation, consult an approved waste disposal operative to ensure regulatory compliance. Refer to local statutory requirements and the Toxic Industrial Waste Regulations (TIWR) for proper disposal instructions. * * * Section 14 - Transportation Information * * * IATA Information ICAO Information IMDG Information * * * Section 15 - Regulatory Information * * * EU MARKING AND LABELLING: Symbol(s): Not Classified Risk Phrases: Safety Phrases: Page 4 of 5 Issue Date: 01/26/09 Revision: Print Date: 1/28/2009

5 B: Substance Analysis - Inventory Component/CAS EC # EEC CAN TSCA Water EINECS DSL Yes Glucose Monohydrate - No No No Sodium citrate EINECS DSL Yes Sodium chloride EINECS DSL Yes Phosphoric acid, monosodium salt, monohydrate - No No No Citric acid EINECS DSL Yes Adenine (6-Aminopurine) EINECS DSL Yes * * * Section 16 - Other Information * * * Key/Legend ACGIH = American Conference of Governmental Industrial Hygienists; ADG = Australian Code for the Transport of Dangerous Goods by Road and Rail; ADR/RID = European Agreement of Dangerous Goods by Road/Rail; AS = Standards Australia; DFG = Deutsche Forschungsgemeinschaft; DOT = Department of Transportation; DSL = Domestic Substances List; EEC = European Economic Community; EINECS = European Inventory of Existing Commercial Chemical Substances; ELINCS = European List of Notified Chemical Substances; EU = European Union; HMIS = Hazardous Materials Identification System; IARC = International Agency for Research on Cancer; IMO = International Maritime Organization; IATA = International Air Transport Association; MAK = Maximum Concentration Value in the Workplace; NDSL = Non-Domestic Substances List; NFPA = National Fire Protection Association; NOHSC = National Occupational Health & Safety Commission; NTP = National Toxicology Program; STEL = Short-term Exposure Limit; TDG = Transportation of Dangerous Goods; TLV = Threshold Limit Value; TSCA = Toxic Substances Control Act; TWA = Time Weighted Average End of Sheet Page 5 of 5 Issue Date: 01/26/09 Revision: Print Date: 1/28/2009