SAFETY DATA SHEET. Green Powder Designed to remove clogs and eliminate slow drains.

Transcription

1 SAFETY DATA SHEET 1. Product and Company Identification PRODUCT NUMBER: 3415 COMPANY PHONE: PRODUCT NAME: CLOG BUSTER EMERGENCY TELEPHONE: INFO TRAC: PRODUCT DESCRIPTION: PRODUCT APPLICATION: Green Powder Designed to remove clogs and eliminate slow drains. COMPANY INFORMATION: Pro Chem Inc Bluegrass Lakes Parkway Alpharetta, GA Hazards Identification Splashing or direct contact may cause eye irritation. May cause digestive tract irritation. GHS Classification: Not a dangerous substance according to GHS. POTENTIAL HEALTH EFFECTS: Eye Contact: May cause irritation if contact occurs. Ingestion: May cause gastrointestinal irritation with nausea, vomiting and diarrhea. Inhalation: May cause respiratory tract irritation. Skin Contact: May cause irritation if contact occurs. Chronic: Not known. 3. Composition / Information on Ingredients INGREDIENTS CAS NO. WEIGHT % Microbes Enzymes Potassium Carbonate Glucose Proprietary Proprietary First Aid Measures EYE CONTACT: Flush eyes for fifteen minutes with water. If irritation persists, contact a physician. SKIN CONTACT: Not normally required. Wash with soap and water. INHALATION: Not normally required. Move to fresh air. INGESTION: Not normally required. Drink two glasses of water. Do not induce vomiting. If symptoms persist, seek medical attention. 5. Fire Fighting Measures EXTINGUISHING MEDIA: Unused form: Water spray, dry chemical or carbon dioxide. Used form: That which is compatible to liquid (s) absorbed. SPECIAL FIRE FIGHTING PROCEDURES: None required. HAZARDOUS COMBUSTION PRODUCTS: Carbon monoxide and/or carbon dioxide. UNUSUAL HAZARDS: None expected. Refer to absorbed liquid(s) MSDS(s). Extreme heat may cause pressure to build up inside drum. 6. Accidental Release Measures SPILL OR LEAK PROCEDURES: If material is unused, collect and recover for reuse. Wear protective equipment. Not a listed hazardous waste. 7. Handling and Storage HANDLING PRECAUTIONS: Avoid contact with skin and eyes. Do not swallow. Wash hands thoroughly after handling. STORAGE PRECAUTIONS: Store in cool, dry area. Prevent product from freezing. Keep out of the reach of children. Shelf life: 3 years as long as the product is kept in a clean, dry environment away from direct sunlight and/or excessive heat. GENERAL: Refer to absorbed liquid(s) MSDS(s). Follow label directions carefully. Make sure all containers are labeled properly. The container can be hazardous when empty. Follow label cautions even after the container is empty. Do not re-use empty containers for food, clothing or products for human or animal consumption, or where skin contact can occur. 8. Exposure Controls / Personal Protection ENGINEERING CONTROLS: Use adequate ventilation to keep airborne concentrations low. PERSONAL PROTECTION EYES: Safety goggles or glass with side shields RESPIRATOR: NIOSH/MSHA approved respirator when ventilation is inadequate. GLOVES: Impervious gloves. OTHER: Maintain eyewash and safety shower in work area. OSHA HAZARDOUS COMPONENTS (29 CFR ): EXPOSURE LIMIT 8 hrs. TWA (ppm) OSHA PEL ACGIH TLV None Product Name: Clog Buster Pro Chem, Inc. Product Number: 3415 Revision Date: 5/14/2014 Page 1 of 2

2 9. Physical & Chemical Properties APPEARANCE: Green Powder MELTING POINT/ FREEZING POINT: N/A ODOR: None INITIAL BOILING POINT AND RANGE: N/A ph: N/A FLASH POINT: None METHOD: N/A EVAPORATION RATE: Not established FLAMMABLE LIMITS: N/A CONDITIONS of FLAMMABILITY: Non-flammable EXPLOSIVE Not established VAPOR PRESSURE: N/A PROPERTIES: VAPOR DENSITY: Not established RELATIVE DENSITY: (H 20=1):0.697 SOLUBILITY in WATER: Soluble VOC (g/l): Stability & Reactivity Information GENERAL: This is a stable material CONDITIONS OF REACTIVITY: INCOMPATIBLE MATERIALS: CONDITIONS TO AVOID: Excessive heat or flame. HAZARDOUS DECOMPOSITION: Not established. HAZARDOUS POLYMERIZATION: Will not occur. Reacts with sodium hypochlorite or calcium hypochlorite. Strong oxidants 11. Toxicological Information LD50: Not established. LC50: Not established. CARCINOGENICITY: IRAC: None NATIONAL TOXICOLOGY PROGRAM: None OSHA: None CALIFORNIA PROP 65: No listed ingredient REPRODUCTION TOXICITY: NOT AVAILABLE MUTAGENICITY: NOT AVAILABLE 12. Ecological Information NO DATA AVAILABLE 13. Disposal Consideration TERATOGENICITY: NOT AVAILABLE SYNERGISTIC PRODUCTS: NOT AVAILABLE Waste Disposal Method: Observe all federal, state and local regulations. 14. Transportation Information D.O.T. (DEPARTMENT OF TRANSPORTATION): PROPER SHIPPING NAME: Non-hazardous powder HAZARD CLASS: Not regulated IDENTIFICATION NUMBER: Not applicable 15. Regulatory Information CERCLA (COMPREHENSIVE ENVIRONMENTAL RESPONSE COMPENSATION AND LIABILITY ACT): No Reportable Quantity OSHA HAZARD COMMUNICATION STANDARD, 28 CFR : No hazardous ingredient. SARA TITLE III (SUPERFUND AMENDMENTS AND REAUTHORIZATION ACT): No listed ingredient. TSCA (TOXIC SUBSTANCES CONTROL ACT): All ingredients are listed. 16. Other Information NFPA Hazard Rating: Health 1 None Extreme Fire Reactivity 0 PPE B Reason for Issue: GHS changes to Sections 2 & 3. Prepared by: J. Pickett Approved by: C. Matthews Approval Date of Issue: 1/31/2014 Approval Date: 1/31/2014 The information provided in this MSDS is believed to be reliable and accurate. However, the information is provided without any warranty or guarantee, express or implied, regarding its correctness. We do not assume responsibility and expressly disclaim liability for loss, damage or expense arising out of the use of this information. The buyer assumes all responsibility of using and handling the product in accordance with the federal, state and local regulations. Product Name: Clog Buster Pro Chem, Inc. Product Number: 3415 Revision Date: 5/14/2014 Page 2 of 2

3 PRO CHEM, INC BLUEGRASS LAKES PKWY. ALPHARETTA, GA EMERGENCY/INFO # (800) ADDITIONAL EMERGENCY # INFO TRAC MATERIAL SAFETY DATA SHEET CLOG BUSTER / 3415 NOVEMBER 2009 PAGE 1 HEALTH 0 FIRE 0 REACTIVITY 0 P.P.E. A SECTION 1 Chemical and Company Identification COMMON NAME: GENERIC NAME: CHEMICAL: Cleaning Compound Cleaner Mixture SECTION 2 Composition on Ingredients INGREDIENTS CAS % OSHA PEL ACGIH TLV Does not contain any hazardous ingredients. SECTION 3 Hazards Information ROUTES AND INDICATIONS OF EXPOSURE: EYES: May cause irritation to eyes. SKIN: Good industrial hygiene recommended. INHALATION: N/A INGESTION: May cause irritation. TOXICITY DATA: None as listed by OSHA, NTP, IARC, or EPA. SECTION 4 First Aid Measures EMERGENCY FIRST AID: EYES: Flush eyes for fifteen minutes with water. SKIN: Wash exposed areas with soap and water. INHALATION: Move victim to fresh air or oxygen supply. INGESTION: Drink one glass of water to dilute ingested material. Do not induce vomiting. SECTION 5 Fire Fighting Measures FLASH POINT: DEGREES LEL: UEL: AUTOIGNITION TEMPERATURE: EXTINGUISHING MEDIA: Product will not support flames. UNUSUAL FIRE/EXPLOSION HAZARDS: None HAZARDOUS DECOMPOSITION PRODUCTS: None known SECTION 6 Accidental Release Measures MATERIAL SPILLAGE: Contain and retrieve spilled materials (absorb, pump, vacuum). SECTION 7 Handling and Storage Keep closed when not in use. Store at room temperature. Prevent product from freezing. Follow MSDS and Label warnings even after package is empty. SECTION 8 Exposure Controls/Personal Protection PROTECTIVE EQUIPMENT: RESPIRATORY PROTECTION: ENGINEERING CONTROLS: PERSONAL HYGIENE: Wear safety glasses and gloves. General ventilation recommended. Keep containers closed when not in use. Do not handle or store near strong oxidants. Cleanse skin thoroughly after contact. Complies With USDL Safety and Health Regulations, (29 CFR ) SECTION 9 Physical and Chemical Properties BOILING POINT: APPEARANCE: Green SPECIFIC GRAVITY: FORM: Pellet MELTING POINT: ODOR: Mild EVAPORATION RATE: VAPOR DENSITY: SOLUBILITY (H 2 0, 25C): Soluble ph: N/A VOLATIZES CONTENT: VOC (g/l): SECTION 10 Stability and Reactivity STABILITY: CONDITIONS TO AVOID: Stable None known. SECTION 11 Toxicological Information No Data Available. SECTION 12 Ecological Information No Data Available. SECTION 13 Disposal Consideration WASTE DISPOSAL: This material is NOT defined as hazardous by the Resource Conservation and Recovery Act. It is the product user s responsibility to determine at the time of disposal, whether a material containing the product or derived from the product should be classified as a hazardous waste. (40 FR ). Spill and releases of this material are not reportable under S.A.R.A. (III) Sec SECTION 14 Transport Information D.O.T. SHIPPING NAME: D.O.T. HAZARD CLASSIFICATION: NON-REGULATED N/A SECTION 15 Regulatory Information S.A.R.A. III Sec. 311 & 312: N/A S.A.R.A. III Sec. 313: NOT covered under Sara 313 R.C.R.A.: NO TSCA Registry: YES SECTION 16 Other Information The information provided in this MSDS is believed to be reliable and accurate. However, the information is provided without any warranty or guarantee, express or implied, regarding its correctness. The conditions or methods of handling, storage, use and disposal of the product are beyond our control. We do not assume responsibility and expressly disclaim liability for loss, damage or expense arising out of the use of this information. The buyer assumes all responsibility of using and handling the product in accordance with the federal, state and local regulations. THIS INFORMATION MUST BE ON ALL MSDS S COPIED AND DISTRIBUTED FOR THIS MATERIAL. NO WARRANTY IS EXPRESSED/IMPLIED REGARDING THE ACCURACY OF THIS DATA OR RESULTS OBTAINED FROM USE. PROCHEM ASSUMES NO RESPONSIBILITY FOR PERSONAL INJURY OR PROPERTY DAMAGE TO USER. VENDEE/USER ASSUMES ALL RISKS ASSOCIATED WITH USE.

4 Clog Buster #3415 Powdered Drain Opener Packets Features Creates a two-way foam that coats the drain line up to 12 feet of the drain sink Contains NO acids or caustics No VOC s, biodegradable, non-toxic and non-corrosive Odors are not just masked but eliminated at the source Microbes and enzymes are completely safe because they are non-pathogenic and salmonella free Description B CLOG BUSTER is a combination of all-natural microbes and enzymes that consumes fats, oils, and greases ( FOG ), as well as food wastes. The all-natural microbes and enzymes consume clogs in drains and pipes and digest them into carbon dioxide and water. CLOG BUSTER eliminates clogs and keeps pipes free-flowing and clog-free. Food waste and FOG adhere to pipes, causing slow, sluggish drains. Slow, sluggish drains also create putrid odors and attract insects. CLOG BUSTER creates a foam that acts as a delivery system that embeds the microbes and enzymes into the waste clinging to the side of the pipes. CLOG BUSTER eliminates slow drains by consuming the waste that accumulates in drains and pipes. It does not contain any acids, caustics, detergents, surfactants, or emulsifiers. Applications Food service facilities Restrooms Kitchens Supermarkets Food processing plants Hotels Athletic facilities Prisons Schools Health 0 Flammability 0 Reactivity 0 Personal Protection A Directions Apply 4 oz. of CLOG BUSTER to clogged or slow drain. Pour 8 oz. of water into drain to activate CLOG BUSTER. Allow to settle in drain for at least 4 hours before using again. Recommended once a week for continuous drain line maintenance. Product Specifications Appearance Green pellets Odor Mild Boiling Point Specific Gravity Melting Point Evaporation Rate Solubility (H20, 25 C) Soluble Volatizes Content Vapor Density ph N/A Voc (g/l) Flash Point Degrees Storage Keep closed when not in use. Store at room temperature. Prevent product from freezing. Transportation Information Class Code: 55 NMFC #: Proper Shipping Name Compound Cleaning Liquid 1475 Bluegrass Lakes Parkway Alpharetta, GA

5