MATERIAL SAFETY DATA SHEET Page 01 of 05

Transcription

1 MATERIAL SAFETY DATA SHEET Page 01 of 05 Loctite(R) Plumber's Choice(TM) Sealant CHEMICAL PRODUCT AND COMPANY IDENTIFICATION Product Type: ADHESIVE 2. COMPOSITION, INFORMATION ON INGREDIENTS Ingredients CAS No. % TOLUENE* Thermoplastic rubber Proprietary Hydrocarbon resin Proprietary n-hexane* * This component is listed as a SARA Section 313 Toxic Chemical. Ingredients which have exposure limits Exposure Limits (TWA) ACGIH OSHA OTHER Ingredients (TLV) (PEL) TOLUENE 50 ppm skin 100 ppm None 188 mg/m3 skin 375mg/M3 n-hexane 50 ppm TWA 50 ppm TWA None 176mg/M3 180mg/M3 Exposure Limits (STEL) ACGIH OSHA Ingredients (TLV) (PEL) file:///c /Cub/MSDS/Permatex/25826.TXT (1 of 8)3/22/2005 1:36:15 PM

2 TOLUENE None 150 ppm 560mg/M3 3. HAZARDS IDENTIFICATION Toxicity: INHALATION: MILD IRRITANT TO THE NASAL & RESPIRATORY TRACT. INGESTION: MAY CAUSE ABDOMINAL PAIN AND NAUSEAU. OTHER SYMPTOMS PARALLEL INHALATION. ASPIRATION INTO THE LUNGS CAN PRODUCE SEVERE LUNG DAMAGE (CHEMICAL PNEUMONITIS) WHICH CAN BE FATAL. SKIN CONTACT: MAY CAUSE REDNESS & IRRITATION. EYE CONTACT: VAPORS MAY CAUSE IRRITATION. SPLASHES MAY CAUSE TEMPORARY CORNEAL DAMAGE. Primary Routes of Entry: SKIN, INHALATION, INGESTION Signs and symptoms of Exposure: OVEREXPOSURE MAY CAUSE FATIGUE, CONFUSION, HEAD_ ACHE, DIZZINESS & DROWSINESS. PECULIAR SKIN MATERIAL SAFETY DATA SHEET Page 02 of HAZARDS IDENTIFICATION (continued) SENSATIONS (I.E. PINS & NEEDLES) MAY BE PRODUCED. VERY HIGH CONCENTRATIONS MAY CAUSE UNCONCIOUSNESS AND DEATH Existing Conditions Aggravated by Exposure: PRE_EXISTING SKIN DISORDERS, EYE PROBLEMS OR IMPAIRED RESPIRATORY FUNCTION. PEOPLE WITH IMPAIRED LIVER OR KIDNEY FUNCTION MAY BE MORE file:///c /Cub/MSDS/Permatex/25826.TXT (2 of 8)3/22/2005 1:36:15 PM

3 SUSCEPTIBLE TO THE EFFECTS OF THIS SUBSTANCE Ingredients Literature Referenced Carcinogen Target Organ and Other Health Effects NTP IARC OSHA TOLUENE CAR CNS DEV IRR NO NO NO Thermoplastic rubber No Data NO NO NO Hydrocarbon resin No Data NO NO NO n-hexane DEV IRR NER REP NO NO NO Abbreviations CAR Cardiac DEV Developmental NER Nervous System CNS Central nervous system IRR Irritant REP Reproductive 4. FIRST AID MEASURES Ingestion: Inhalation: Skin Contact: Eye Contact: DO NOT INDUCE VOMITING. CALL PHYSICIAN IMMEDIATELY REMOVE TO FRESH AIR. CALL PHYSICIAN IF SYMPTOMS PERSIST. WASH THOROUGHLY WITH SOAP AND WATER FLUSH WITH WATER FOR AT LEAST 15 MINUTES. SEEK MEDICAL ATTENTION. 5. FIRE FIGHTING MEASURES Flash Point: 9 DEG F Method: Tag Closed Cup Recommended Extinguishing Agents: DRY CHEMICAL & FOAM Hazardous Products formed by Fire or Thermal Decomp IRRITATING ORGANIC VAPORS Unusual Fire or Explosion Hazards: EXTREMELY FLAMMABLE: MAY BE IGNITED BY HEAT, SPARKS OR OPEN FLAME Explosive Limits: file:///c /Cub/MSDS/Permatex/25826.TXT (3 of 8)3/22/2005 1:36:15 PM

4 MATERIAL SAFETY DATA SHEET Page 03 of FIRE FIGHTING MEASURES (continued) (% by volume in air)lower 1.0% (% by volume in air)upper 7.0% 6. ACCIDENTAL RELEASE MEASURES Steps to be taken in case of spill or leak: VENTILATE AREA OF LEAK OR SPILL. REMOVE ALL SOURCES OF IGNITION. WEAR THE PROPER PROTECTIVE CLOTHING & RESPIRATOR PROTECTION. USE NON_SPARKING TOOLS & EQUIPMENT. STORE WASTE IN A CLOSED CONTAINER UNTIL DISPOSAL. KEEP AWAY FROM OXIDIZING MATERIALS 7. HANDLING AND STORAGE Safe Storage: STORE IN A COOL, DRY, WELL_VENTILATED AREA AWAY FROM DIRECT SUNLIGHT AND ANY AREA WHERE A FIRE HAZARD MAY BE ACUTE (Contact Loctite Customer Service for shelf Life information) Handling: DO NOT USE NEAR IGNITION SOURCES (I.E. HEAT, SPARKS, OPEN FLAME). DO NOT SMOKE WHEN USING THIS PRODUCT. USE IN A WELL_VENTILATED AREA. KEEP AWAY FROM CHILDREN. 8. EXPOSURE CONTROLS, PERSONAL PROTECTION Eyes: Safety glasses or goggles. file:///c /Cub/MSDS/Permatex/25826.TXT (4 of 8)3/22/2005 1:36:15 PM

5 Skin: Ventilation: WEAR IMPERMEABLE PROTECTIVE GLOVES. SUFFICIENT TO MAINTAIN VAPOR CONCENTRATION BELOW TLV See Section 2 for Exposure Limits. 9. PHYSICAL AND CHEMICAL PROPERTIES Appearance: CLEAR GEL Odor: SOLVENT Boiling Point: 151 TO 232 DEG F ph: Does not apply Solubility in Water: NEGLIGIBLE Specific Gravity Volatile Organic Compound (EPA Method 24) 48.1%; G/L Vapor Pressure: Not available Vapor Density: IS HEAVIER THAN AIR Evaporation Rate (Ether = 1) FASTER THAN BUTYL ACETATE MATERIAL SAFETY DATA SHEET Page 04 of STABILITY AND REACTIVITY Stability: Stable Hazardous Polymerization: Will not occur Incompatibility: STRONG OXIDIZERS Hazardous Decomposition file:///c /Cub/MSDS/Permatex/25826.TXT (5 of 8)3/22/2005 1:36:15 PM

6 Products (non-thermal): None 11. TOXICOLOGICAL INFORMATION See Section ECOLOGICAL INFORMATION No data available 13. DISPOSAL CONSIDERATIONS Recommended methods of disposal: INCINERATE FOLLOWING EPA FEDERAL, STATE AND LOCAL REGULATIONS. FOR FURTHER INFORMATION CONTACT YOUR STATE OR LOCAL AGENCY OR THE US EPA'S RCRA EPA Hazardous Waste Number D001/F005 - Hazardous waste per 40CFR and /Toluene 14. TRANSPORT INFORMATION DOT (49 CFR 172) Domestic Ground Transport Proper Shipping Name: Consumer Commodity (Not more than one liter); Adhesives (More than one liter) Hazard Class or Division: ORM-D (Not more than one liter); Class 3, Packing Group II (More than one liter) Identification Number: None (Not more than one liter); UN 1133 (More than one liter) Marine Pollutant: None IATA Proper Shipping Name: Adhesives Class or Division: Class III, Packing Group II UN or ID Number: UN REGULATORY INFORMATION CA Proposition 65: WARNING: This product contains a chemical known to the State of California to cause birth defects or other reproductive harm. file:///c /Cub/MSDS/Permatex/25826.TXT (6 of 8)3/22/2005 1:36:15 PM

7 Toluene MATERIAL SAFETY DATA SHEET Page 05 of OTHER INFORMATION Estimated NFPA(R) Code: Health Hazard: 2 Fire Hazard: 3 Reactivity Hazard: 1 Specific Hazard: Does not apply Estimated HMIS(R) Code: Health Hazard: 2 Flammability Hazard: 3 Reactivity Hazards: 1 Personal Protection: See Section 8. NFPA is a registered trademark of the National Fire Protection Assn. HMIS is a registered trademark of the National Paint and Coatings Assn. Prepared By: PAULA KINNEY Title: ENVIRONMENTAL HEALTH & SAFETY Company: Loctite Corp., 1001 Tr Br Cr, Rocky Hill CT (24hr.) Phone: (860) Revision Date: January 22, 1996 Revision: 0002 file:///c /Cub/MSDS/Permatex/25826.TXT (7 of 8)3/22/2005 1:36:15 PM

8 file:///c /Cub/MSDS/Permatex/25826.TXT (8 of 8)3/22/2005 1:36:15 PM