T-SB-0033-4 pril 28, 204 HVC Evaporator Drain Hose Clogged Due to Insect Intrusion Service Category Vehicle Interior Section Heating/ir Conditioning Market US pplicability YER(S) MODEL(S) DDITIONL INFORMTION 200 204 4Runner, Prius 203 204 valon HV, RV4 EV 2007 204 valon, Camry, Camry HV, FJ Cruiser 2009 204 Corolla, Venza 2008 204 Highlander, Highlander HV 2009 203 Matrix 202 203 Prius C 200, 202 204 Prius PHV 202 204 Prius V 2006 204 RV4 20 204 Sienna 2007 204 Yaris Introduction Some vehicles in particular geographic areas may exhibit a condition where the HVC Evaporator Drain Hose has become obstructed with an insect nest. n insect repellent drain hose tip (RINIX Tip) is now available to help minimize future occurrences of this environmental condition. For some models, a new drain hose is required to properly fit the RINIX Tip. Follow the procedures in this bulletin for proper handling and installation of this optional service part. NOTE The RINIX Tip is NOT registered or labeled for sale or use outside the United States or Puerto Rico. 204 Toyota Motor Sales, US Page of 7
T-SB-0033-4 pril 28, 204 Page 2 of 7 Warranty Information OP CODE DESCRIPTION TIME OFP T T2 N/ Not pplicable to Warranty Parts Information MODEL MODEL YER PREVIOUS PRT NUMBER ll 2006 204 87265-3300 NEW PRT NME Connector, Water Hose (RINIX Tip) REPIR PROCEDURE QTY ll 4Runner 200 204 88539-60340 B valon 2007 204 88539-062 88539-3360 valon HV 203 204 Camry/Camry HV Corolla 2007 204 2009 203 88539-062 88539-0620 88539-33090 88539-0260 88539-0240 88539-2200 88539-3360 88539-02270 204 88539-02270 FJ Cruiser 2007 204 88539-35030 Highlander (NP) Highlander/ Highlander HV (Japan Prod) 200 204 88539-0E00 B 2008 204 88539-48040 88539-0E00 Matrix 2009 203 88539-0260 Prius 200 203 88539-2200 88539-02270 88539-2230 204 88539-2230 B Prius C 202 203 88539-52040 Prius PHV 200 202 88539-2200 88539-2230 203 88539-2230 B 204 Toyota Motor Sales, US
T-SB-0033-4 pril 28, 204 Page 3 of 7 Parts Information (Continued) MODEL Prius V RV4 MODEL YER PREVIOUS 202 203 88539-2200 PRT NUMBER NEW PRT NME REPIR PROCEDURE QTY 88539-2230 204 88539-2230 B 2006 202 88539-0R00 88539-42060 88539-4206 88539-0R0 C 203 204 88539-4206 88539-0R0 D RV4 EV 203 204 88539-0R00 88539-0R0 Sienna 20 204 88539-08070 Venza 2009 204 88539-0T00 B 2007 200 88539-52020 Yaris 20 204 88539-52040 Required Tools & Equipment TOOLS QUNTITY Chemical Resistant Gloves (Made from Waterproof Material) Safety Requirements for Handling the RINIX Tip (Connector, Water Hose) Follow the manufacturer s instructions for cleaning/maintaining Personal Protection Equipment (PPE). If no such instructions for cleaning/maintaining PPE exist, use detergent and hot water. Keep PPE separate from other laundry. Users should remove PPE immediately after handling this product. Wash the outside of the gloves before removing. Users should wash hands before eating, drinking, chewing gum, or using the toilet. 204 Toyota Motor Sales, US
T-SB-0033-4 pril 28, 204 Page 4 of 7 Safety Requirements for Handling the RINIX Tip (Connector, Water Hose) (Continued) CUTION IF SWLLOWED: Call the poison control center or doctor immediately for treatment advice. Have the person sip a glass of water if able to swallow. Do NOT induce vomiting unless instructed by the poison control center or doctor. Do NOT give anything by mouth to an unconscious person. IF ON SKIN OR CLOTHING: Take off the contaminated clothing immediately. Rinse skin immediately with plenty of water for 5 to 20 minutes. Call a poison control center or doctor for treatment advice. IF IN EYES: Hold eye open and rinse gently and slowly with water for 5 to 20 minutes. Remove contact lenses (if present) after the first 5 minutes, then continue rinsing eye. Call poison control center or doctor for treatment advice. HOTLINE NUMBER: Have the product container or label with you when calling a poison control center, doctor, or going for treatment. You may also contact 800-424-9300 for emergency medical treatment information. 204 Toyota Motor Sales, US
T-SB-0033-4 pril 28, 204 Page 5 of 7 Directions for Use on LL Repair Procedures The RINIX Tip contains permethrin, a pesticide, as the active ingredient. Please note, it is a violation of Federal law to use this product in a manner inconsistent with its labeling. Repair Procedure. Follow the instructions provided in the Safety Requirements for Handling the RINIX Tip 2. Locate the HVC Evaporator Drain Hose. 3. Following the vehicle specific Repair Manual, remove the HVC Evaporator Drain Hose. 4. Put on all necessary PPE and install the RINIX Tip (Connector, Water Hose) into the NEW HVC Evaporator Drain Hose listed in the Parts Information section of this bulletin. 5. When installing the RINIX Tip, verify it is fully seated in the HVC Evaporator Drain Hose as shown in Figure. 6. Following the vehicle specific Repair Manual, install the HVC Evaporator Drain Hose. Figure.. 204 Toyota Motor Sales, US
T-SB-0033-4 pril 28, 204 Page 6 of 7 Repair Procedure B. Follow the instructions provided in the Safety Requirements for Handling the RINIX Tip 2. Locate the HVC Evaporator Drain Hose. 3. Following the vehicle specific Repair Manual, remove the HVC Evaporator Drain Hose. 4. Put on all necessary PPE and install the RINIX Tip into the original HVC Evaporator Drain Hose listed in the Parts Information section of this bulletin. 5. When installing the RINIX Tip, verify it is fully seated in the HVC Evaporator Drain Hose as shown in Figure. 6. Following the vehicle specific Repair Manual, install the HVC Evaporator Drain Hose. Repair Procedure C. Follow the instructions provided in the Safety Requirements for Handling the RINIX Tip 2. Locate the HVC Evaporator Drain Hose. 3. Following the vehicle specific Repair Manual, remove the HVC Evaporator Drain Hose. 4. Before installing the RINIX Tip (Connector, Water Hose) into the NEW HVC Evaporator Drain Hose, the end of the hose needs to be cut perpendicular as shown in Figure 2. Figure 2.. 5. Put on all necessary PPE and install the RINIX Tip into the NEW HVC Evaporator Drain Hose listed in the Parts Information section of this bulletin. 204 Toyota Motor Sales, US
T-SB-0033-4 pril 28, 204 Page 7 of 7 Repair Procedure C (Continued) 6. When installing the RINIX Tip, verify it is fully seated in the HVC Evaporator Drain Hose as shown in Figure. 7. Following the vehicle specific Repair Manual, install the HVC Evaporator Drain Hose. Repair Procedure D. Follow the instructions provided in the Safety Requirements for Handling the RINIX Tip 2. Locate the HVC Evaporator Drain Hose 3. Following the vehicle specific Repair Manual, remove the HVC Evaporator Drain Hose. 4. Before installing the RINIX Tip (Connector, Water Hose) into the original HVC Evaporator Drain Hose, the end of the hose needs to be cut perpendicular as shown in Figure 2. 5. Put on all necessary PPE and install the RINIX Tip into the original HVC Evaporator Drain Hose listed in the Parts Information section of this bulletin. 6. When installing the RINIX Tip, verify it is fully seated in the HVC Evaporator Drain Hose as shown in Figure. 7. Following the vehicle specific Repair Manual, install the HVC Evaporator Drain Hose. 204 Toyota Motor Sales, US