La caldaia a letto fluido circolante per la riduzione delle emissioni di CO2
|
|
- Emil McCarthy
- 8 years ago
- Views:
Transcription
1 La caldaia a letto fluido circolante per la riduzione delle emissioni di CO2 Paolo Cotone Principal Process Engineer Silvio Arienti Process Director Power Division Foster Wheeler Italiana Tecnologie e Processi Innovativi per la Sostenibilità Ambientale degli Impianti di Combustione - 13 April 2011, Milano, Italy
2 Content of Presentation Introduction Flexi-Burn CFB power plant Framework for Reseach and Technology Development CIUDEN s Technology Development Centre (TDc) Flexi-burn OXY-CFB 300 Compostilla Summary "Flexi-Burn" is a trademark of Foster Wheeler AG, registered in the U.S., EU, Finland Tecnologie e Processi Innovativi per la Sostenibilità Ambientale degli Impianti di Combustione P. Cotone page 2
3 Introduction Present FW CFB Technology Foster Wheeler s CFB Experience Foster Wheeler Fluidized Bed Technology Basis: Over 1700 years of operating experience (>20 million operating hours) Foster Wheeler Energia Oy in Finland is the Technology Center for Fluidized Bed Boilers in Foster Wheeler Global Power Group 370 CIRCULATING FLUID BED (CFB) BOILERS SOLD Variety of fuels: coal, lignite, petroleum coke, biomass, RDF, etc. The world s largest and first SC OTU CFB with the capacity of 460 MW e at PKE s Lagisza plant in Poland is in operation. FW has developed and is offering the CFB technology in MWe scale with 600 C steam temperature. Tecnologie e Processi Innovativi per la Sostenibilità Ambientale degli Impianti di Combustione P. Cotone page 3
4 Introduction Present FW CFB Technology THINK GREEN Possibility to process Green Fuels (opportunity for CO2 emissions reduction) Low Emission SO2 (Sulhpur capture integrated in the furnace low cost limestone injection) NOx (Low Temperature Combustion) Particulate FUEL FLEXIBILITY Traditional Solid Fuels (Coal) Opportunity Fuels (Petcoke, Lignite, etc) Biomass PROVEN TECHNOLOGY (extremely high number of operating hours experienced) Tecnologie e Processi Innovativi per la Sostenibilità Ambientale degli Impianti di Combustione P. Cotone page 4
5 Flexi-Burn CFB Power Plant for CO2 capture New Flexi-Burn CFB CFB design capable for both oxy and air firing 1st generation oxy-fuel technology with flue gas recycling Fuels Flexi-Burn CFB boiler 95-97% O 2, (Ar, N 2 ) Flue gas recycle Flue gas cleaning CO 2 /H 2 O N 2, (Ar) Air separation Condensation Compression Purification Air Vent gas Oxy-readiness A plant design with certain Flexi-Burn features and space reservation for the ASU and CPU systems Steam turbine G To stack H 2 O Transport Storage CO 2 Later upgrading for CCS Tecnologie e Processi Innovativi per la Sostenibilità Ambientale degli Impianti di Combustione P. Cotone page 5
6 Framework for Reseach and Technology Development (Scale-up scheme) Air combustion: Vast experimental and modeling experience from air combustion (bench-scale Pilots >300 operating units; max. 460 MW e ) Validated design models and engineering tools Oxy-fuel combustion: Bench-scale and kw th pilot scale at VTT (2005 ) MW th pilot scale at CanmetENERGY ( ) Max. 30 MW th Oxyfuel CFB demonstration unit at the CIUDEN TDP ( ) Feasibility studies for oxy combustion plants based on the Lagisza 460 MWe OT-SC CFB boiler design Oxy-CFB-300 Project: The 300 MWe Flexi-Burn CFB demonstration project of ENDESA Generación Tecnologie e Processi Innovativi per la Sostenibilità Ambientale degli Impianti di Combustione P. Cotone page 6
7 Framework for Reseach and Technology Development FW Flexi-Burn CFB Boiler Development Activities R&D support - EU FP7 project "FLEXI BURN CFB" Design tool development toward oxy & air compatibility (combustion, heat transfer, fluid dynamics, emissions) Experiments in small and large scale pilots scale-up information Performance of materials Dynamic simulations Concept optimization, etc. Boiler design - Oxy-CFB-300: Phase 1 - Compostilla project Engineering of Flexi-Burn CFB boiler Performance and cost estimates Design verification at CIUDEN TDP Support of FEED study by ENDESA plant level l estimates t Expected operation assesment Tecnologie e Processi Innovativi per la Sostenibilità Ambientale degli Impianti di Combustione P. Cotone page 7
8 Framework for Reseach and Technology Development Pilot Testing CanmetENERGY (0.8 MWth) Test fuels and schedule: Test program completed in August 2010, analysis of results validation of design tools and process models. Test on different fuels (Spanish anthracite, petroleum coke, bituminous coal, lignite and mixtures). CFB performs very well in oxycombustion. Small differences compared to air combustion and in line with expectations. Lower emissions during oxycombustion. Tecnologie e Processi Innovativi per la Sostenibilità Ambientale degli Impianti di Combustione P. Cotone page 8
9 CIUDEN s Technology Development Centre (TDC) General information Fundación Ciudad de la Energía (CIUDEN): non-profit, collaborative research organization for technology development established by three Ministries of the Spanish Government. TDC located in North Western Spain (El Bierzo). It allows collaborative research for international cooperation with industry, universities and research institutions TDC located close to the Endesa s Compostilla II Power Plant Tecnologie e Processi Innovativi per la Sostenibilità Ambientale degli Impianti di Combustione P. Cotone page 9
10 CIUDEN s Technology Development Centre (TDC) Technology: Oxyfuel Carbon Capture FUEL PREPARATION PC BOILER FLUEGAS RECIRCULATION AND MIXING GASIFIER FLUEGAS CLEANING CFB BOILER CO 2 PURIFICATION The main systems at the TDC: Coal and limestone preparation and feeding Pulverized Coal (20 MWth) and Circulating Fluidized Bed boilers (30 MWth) Flue gas recirculation, preheating TECHNICAL and oxygen mixing devices BUILDINGS & Flue gas cleaning Test unit for CO 2 purification and compression (shared with oxy- PC) DCS system CONTROL SYSTEM FW designs and supplies the CFB boiler for the TDC commissioning i i in 2011 Tecnologie e Processi Innovativi per la Sostenibilità Ambientale degli Impianti di Combustione P. Cotone page 10
11 CIUDEN s Technology Development Centre (TDC) Technology: Oxyfuel Carbon Capture Furnace Dimensions i (m) 20x2.9x MW th max oxycombustion 30 O 2 consumption (kg/h) 8775 Flue gas recycle (kg/h) Flue gas (kg/h) Coal consumption (kg/h) 5469 Limestone feed (kg/h) 720 Steam (t/h) 47.5 P(bar) / T ( C) 30 / 250 Tecnologie e Processi Innovativi per la Sostenibilità Ambientale degli Impianti di Combustione P. Cotone page 11
12 CIUDEN s Technology Development Centre (TDC) Technology: Oxyfuel Carbon Capture Tecnologie e Processi Innovativi per la Sostenibilità Ambientale degli Impianti di Combustione P. Cotone page 12
13 Flexi-burn OXYCFB300 Compostilla European Energy Program for Recovery (EEPR) The origin of the European Energy Programme for Recovery (EEPR) is the global 200 billion European Economic Recovery Plan presented by the Commission on 26 November On 9 December 2009, the European Commission announced details of the six CO 2 capture and storage (CCS) projects which will receive funding ( 1 billion in total) under the EEPR to develop the projects initial stages. Each project received 180 M funding (except Porto Tolle 100 M ) Tecnologie e Processi Innovativi per la Sostenibilità Ambientale degli Impianti di Combustione P. Cotone page 13
14 Flexi-burn OXYCFB300 Compostilla Project description The future OXYCFB300 Project is devoted to demonstrate the CCS value chain (Capture + Transport + Storage) as one of the expected 12 commercial size demo projects to be finally within the EU SET (Strategic Energy Technology) Plan. The Project has been selected in the EEPR Program to complete, during the period, all the studies, pilot size test, and engineering (FEED) to allow by mid-2012 the Investment Decision (FID) for the final construction phase by the final project promoters. As beneficiaries of the EEPR a consortium between ENDESA GENERACIÓN, CIUDEN and FWEOy has been created to develop the initial phase. Tecnologie e Processi Innovativi per la Sostenibilità Ambientale degli Impianti di Combustione P. Cotone page 14
15 ENDESA GENERACION Flexi-burn OXYCFB300 Compostilla EEPR Organization & Roles in the CCS Value Chain Utility yp promoter (capture, transport and storage) General coordination and project management Engineering g (FEED, studies, etc) Permitting Knowledge sharing CIUDEN CCS Technology Development Plants (TDP) promoter Capture (OXY-CFB and OXY-PC) Transport (Test loop) Storage Public perception FOSTER WHEELER ENERGIA Oy Flexi-Burn CFB Technology developer and provider CAPTURE TECHNOLOGY OXY-CFB supercritical boiler (about 330 Mwe); wide design fuel range (domestic and imported), including biomass. CO 2 TRANSPORT 12 /16 underground pipeline; approx 150 km. 5,500 ton/day; ~ 120 bar CO 2 STORAGE Deep saline formation Duero basin (optional: Ebro basin) Tecnologie e Processi Innovativi per la Sostenibilità Ambientale degli Impianti di Combustione P. Cotone page 15
16 Flexi-burn OXYCFB300 Compostilla Schedule PHASE I PHASE II Tecnologie e Processi Innovativi per la Sostenibilità Ambientale degli Impianti di Combustione P. Cotone page 16
17 Flexi-burn OXYCFB300 Compostilla Future Capture Plant 3D Model Tecnologie e Processi Innovativi per la Sostenibilità Ambientale degli Impianti di Combustione P. Cotone page 17
18 Summary FW Flexi-burn CFB derives from the green, flexible and commercially well proven technology of air fired CFB FW Flexi-burn CFB technology allows CO2 capture Flexy-burn CFB technology capable to process biomass for further additional CO2 emissions reduction FW Flexi-Burn technology has been succesfully demonstrated for carbon capture in small pilot scale The piloting of Flexi-Burn technology in 30 MW th scale will start t in 2011 in the CIUDEN Technology Development Centre Tecnologie e Processi Innovativi per la Sostenibilità Ambientale degli Impianti di Combustione P. Cotone page 18
19 Summary EEPR funding has accelerated the expected future commercialization of CCS by funding the initial development of six CCS demonstration projects in Europe. ENDESA GENERACIÓN, CIUDEN and Foster Wheeler, under the EEPR program, have signed an agreement for the OXY-CFB-300 Phase 1 Demonstration Project to develop the engineering and feasibility of a future 300 MWe Flexi-Burn CFB power plant with complete CCS chain. Tecnologie e Processi Innovativi per la Sostenibilità Ambientale degli Impianti di Combustione P. Cotone page 19
20 Acknowledgements Arto Hotta, Timo Eriksson and Reijo Kuivalainen, Foster Wheeler Energia Oy, Finland Andrés Sánchez-Biezma Sacristán, Jorge Martínez Jubitero and Juan Carlos Ballesteros, ENDESA Generación S.A., Spain Monica Lupion and Vicente Cortes, Fundación Ciudad de la Energía (CIUDEN), Spain Ben Anthony, Lufei Jia, David McCalden, Yewen Tan, Ian He, Yinghai Wu and Robert Symonds, CanmetENERGY Ottawa, Canada Tecnologie e Processi Innovativi per la Sostenibilità Ambientale degli Impianti di Combustione P. Cotone page 20
21 Thank You! paolo _ cotone@fwceu.com silvio_arienti@fwceu.com Tecnologie e Processi Innovativi per la Sostenibilità Ambientale degli Impianti di Combustione P. Cotone page 21
Oxycombustion in Coal Power Generation. M Lupion*, B Navarrete, P Otero, V Cortes
CIUDEN CCS Technological Development elopment Plant on Oxycombustion in Coal Power Generation M Lupion*, B Navarrete, P Otero, V Cortes 1 st Oxyfuel Combustion Conference 8-11 September 2009. Cottbus,
More informationSpanish Situation on FBC
Spanish Situation on FBC Juan Otero Department of Energy 58 Th IEA FBC IA Xi an May 17, 2009 Industrial Facilities Sogama Escatrón La Pereda CLOSED Tirmadrid Vetejar La Pereda Location: Mieres (Asturias)
More informationAlstom Development of Oxyfuel PC and CFB Power Plants
Alstom Development of Oxyfuel PC and CFB Power Plants Frank Kluger & John Marion 3 rd Oxy-Combustion Workshop Yokohama, Japan March 06, 2008 Improvement Measures for Fossil Power Plants Regarding CO2 Mitigation
More informationTutkimuksen merkitys menestyvässä liiketoiminnassa- Innovaatiosta tuotteeksi
Tutkimuksen merkitys menestyvässä liiketoiminnassa- Innovaatiosta tuotteeksi Matti Rautanen Manager, External Networks, Power-wide R&D Tutkimuksella tulevaisuuteen- seminaari Kaukolämpöpäivät, Kuopio 29.8.2013
More informationThe Future of Coal-Based Power Generation With CCS UN CCS Summit James Katzer MIT Energy Initiative web.mit.edu/coal/
The Future of Coal-Based Power Generation With CCS UN CCS Summit James Katzer MIT Energy Initiative web.mit.edu/coal/ 1 Times Are Changing As Yogi Berra said: The Future Ain t What It Used to Be 2 Overview
More informationFluidized Bed Based CO 2 Capture by Carbonate Looping
Fluidized Bed Based CO 2 Capture by Carbonate Looping Prof. Dr.-Ing. Bernd Epple bernd.epple@est.tu-darmstadt.de www.est.tu-darmstadt.de Tel. +49 6151 16 4717 1 Carbonator: T 450 750 C CaO + CO 2 CaCO
More informationCIUDEN experiences in CO2 capture by oxycombustion CIUDEN experiencias en captura de CO2 por oxicombustón
CIUDEN experiences in CO2 capture by oxycombustion CIUDEN experiencias en captura de CO2 por oxicombustón P. Otero 1, I. Alvarez 1, J.A. Gutierrez *1 1 Fundacion Ciudad de la Energia, Ciuden, II Avda.
More informationTechnology comparison of CFB versus pulverized-fuel firing for utility power generation
IFSA 2011, Industrial Fluidization South Africa: 91 99. Edited by A. Luckos & P. den Hoed Johannesburg: Southern African Institute of Mining and Metallurgy, 2011 Technology comparison of CFB versus pulverized-fuel
More informationCarbon Capture. Investment for the Future
Carbon Capture Investment for the Future Doosan Carbon Capture Technologies Oxyfuel 160KWt at Doosan ERTF* ERTF Oxyfuel Conversion 40MWt OxyCoal TM Burner at Doosan CCTF Full Power Plant Demo Expected
More informationApplication of the Biomass, OxyFuel, and Flameless Combustion for the utilisation of pulverised coals for electricity generation
Application of the Biomass, OxyFuel, and Flameless Combustion for the utilisation of pulverised coals for electricity generation Acronym : BOFCom Research Area: Coal Type of project: Research Project duration:
More informationSewage sludge treatment with oxygen enrichement and oxyfuel combustion in CFBC - new pilot plant results
Sewage sludge treatment with oxygen enrichement and oxyfuel combustion in CFBC - new pilot plant results 64 TH IEA FLUIDIZED BED CONVERSION MEETING Naples 3 rd of June, 2012 Authors: David Wöß, Gregor
More informationProcess Integration of Chemical Looping Combustion with Oxygen Uncoupling in a Coal-Fired Power Plant
Process Integration of Chemical Looping Combustion with Oxygen Uncoupling in a Coal-Fired Power Plant Petteri Peltola 1, Maurizio Spinelli 2, Aldo Bischi 2, Michele Villani 2, Matteo C. Romano 2, Jouni
More information2nd IEA Oxyfuel Combustion Conference
2nd IEA Oxyfuel Combustion Conference Oxyfuel Combustion with Hitachi's DST - Burner at Vattenfall's 30Wth Pilot Plant at Schwarze Pumpe S. Rehfeldt, F.-P. Schiffer, P. Weckes, C. Bergins, K.-D. Tigges
More informationMHI s Energy Efficient Flue Gas CO 2 Capture Technology and Large Scale CCS Demonstration Test at Coal-fired Power Plants in USA
MHI s Energy Efficient Flue Gas CO 2 Capture Technology and Large Scale CCS Demonstration Test at Coal-fired Power Plants in USA 26 MASAKI IIJIMA *1 TATSUTO NAGAYASU *2 TAKASHI KAMIJYO *3 SHINSUKE NAKATANI
More informationStora Enso Fors Ltd Sweden
THE ANALYSIS REPORT OF PLANT NO. 3 Cofiring of biomass - evaluation of fuel procurement and handling in selected existing plants and exchange of information (COFIRING) - Part 2 Stora Enso Fors Ltd Sweden
More informationGENERATION TECHNOLOGY ASSESSMENT
SPO PLANNING ANALYSIS GENERATION TECHNOLOGY ASSESSMENT Technology Cost & Performance Milestone 2 Public Technical Conference OCTOBER 30, 2014 NOTE: ALL IRP MATERIALS ARE PRELIMINARY & SUBJECT TO CHANGE
More informationBIOMASS LOOKING FOR EFFICIENT UTILIZATION THE REHEAT CONCEPT. Jaroslav Lahoda Olaf Arndt Walter Hanstein. Siemens Power Generation (PG)
BIOMASS LOOKING FOR EFFICIENT UTILIZATION THE REHEAT CONCEPT Jaroslav Lahoda Olaf Arndt Walter Hanstein Siemens Power Generation (PG) Brno, Czech Republic & Görlitz, Germany BIOMASS LOOKING FOR EFFICIENT
More informationC S L Forum. 2nd Ministerial Meeting. ITALIAN ROADMAP: Project s Proposal for CSLF
C S L Forum 2nd Ministerial Meeting ITALIAN ROADMAP: Project s Proposal for CSLF SEPCA: Advanced Technologies for CO 2 Separation and Capture for Existing and Innovative Fossil Fired Power Plants CO 2
More informationM.Sc. Matti Kivelä Power Plant Manager R&D Lahti Energia Oy P.O. Box 93 FIN-15141 Lahti Finland Tel. 358 3 823 3240 matti.kivela@lahtienergia.
LAHTI ENERGIA OY M.Sc. Matti Kivelä Power Plant Manager R&D Lahti Energia Oy P.O. Box 93 FIN-15141 Lahti Finland Tel. 358 3 823 3240 matti.kivela@lahtienergia.fi Contact LAHTI ENERGIA OY Founded. 1907
More informationPERFORMANCE EVALUATION OF NGCC AND COAL-FIRED STEAM POWER PLANTS WITH INTEGRATED CCS AND ORC SYSTEMS
ASME ORC 2015 3rd International Seminar on ORC Power Systems 12-14 October 2015, Brussels, Belgium PERFORMANCE EVALUATION OF NGCC AND COAL-FIRED STEAM POWER PLANTS WITH INTEGRATED CCS AND ORC SYSTEMS Vittorio
More informationBest Choice BENSON BOILER. Excellent performance features make the Benson boiler the most widely used type of once-through boiler
BENSON BOILER Best Choice Excellent performance features make the Benson boiler the most widely used type of once-through boiler by JOACHIM FRANKE and RUDOLF KRAL Power for generations BENSON BOILER Best
More informationSixth Annual Conference on Carbon Capture & Sequestration
Sixth Annual Conference on Carbon Capture & Sequestration Expediting Deployment of Industrial Scale Systems Geologic Storage - EOR An Opportunity for Enhanced Oil Recovery in Texas Using CO 2 from IGCC
More informationClean Energy Systems, Inc.
Clean Energy Systems, Inc. Clean Energy Systems (CES) technology is a zero emission, oxy-fuel combustion power plant. CES approach has been to apply gas generators and high-temperature, high-pressure,
More informationPutting a chill on global warming
Carbon capture and storage Putting a chill on global warming SABINE SULZER SULZER PUMPS MARKUS DUSS SULZER CHEMTECH Whenever fuel is burned, carbon dioxide (CO ) is emitted into the atmosphere. The subsequent
More informationWell Positioned for the Future
Dominion Generation Virginia City Hybrid Energy Center Well Positioned for the Future The Coal Institute July 13, 2015 Rick Boyd Manager of Fuel Origination & Operations 1 Dominion Profile Operating Segments
More informationCommitted to make a better world
Committed to make a better world 1. Higher Availability & Reliability 2. Highest Plant efficiency 3. Lower Heat Rate 4. Minimum Auxiliary Power Consumption 5. Minimum Emission of Pollutants Committed to
More informationItaly - Porto Tolle: storage in offshore saline aquifer
Italy - Porto Tolle: storage in offshore saline aquifer Monia Politi Enel - Engineering & Innovation Division - Research CO2GeoNet Open Forum 9-11 May 2011, San Servolo Island, Venice High level overview
More informationClean coal from a Vattenfall perspective
Clean coal from a Vattenfall perspective 14 April 2010 Torbjörn Wahlborg, Senior Executive Vice President Head of Business Group Nordic Vattenfall in brief Europe s fifth largest generator of electricity
More informationVALIDATION, MODELING, AND SCALE-UP OF CHEMICAL LOOPING COMBUSTION WITH OXYGEN UNCOUPLING
VALIDATION, MODELING, AND SCALE-UP OF CHEMICAL LOOPING COMBUSTION WITH OXYGEN UNCOUPLING A research program funded by the University of Wyoming School of Energy Resources Executive Summary Principal Investigator:
More informationSixth Annual Conference on Carbon Capture & Sequestration
Sixth Annual Conference on Carbon Capture & Sequestration Session Title: Retrofitting of Existing Coal-Fired Plants MHI s Post Combustion CO 2 Recovery Process for Coal Fired Power Stations: Requirement
More informationThe Effect of EPA s Proposed NSPS on. Carbon Capture and Storage Technology
The Effect of EPA s Proposed NSPS on Carbon Capture and Storage Technology Executive Summary Carbon capture and storage (CCS) is expected to require two generations of technology development to be commercially
More informationINTEGRATED CCS CHAIN ON OXYCOMBUSTION. Dominique Copin Coordinator CCS
LACQ PROJECT: MAIN RESULTS OF AN INTEGRATED CCS CHAIN ON OXYCOMBUSTION Dominique Copin Coordinator CCS CCS PILOT, LACQ, FRANCE CONTENTS Pilot project overview Surface operational feedback Transport and
More informationOutlook on Integrated Gasification Combined Cycle (IGCC) Technology
The IGCC Process: From Coal To Clean Electric Power Outlook on Integrated Gasification Combined Cycle (IGCC) Technology Testimony of Edward Lowe Gas Turbine-Combined Cycle Product Line Manager General
More informationClean Coal Seminar 2014
Clean Coal Seminar 2014 Using lignite in the modern low-emission power plants Waldemar Szulc Vice President of the Board PGE GiEK S.A. Warsaw, 2 June 2014 Agenda Organisational structure Basic information
More informationEOR/CCS 360-DEGREE LEGAL REVIEW
November 2012 EOR/CCS 360-DEGREE LEGAL REVIEW INDEX 1 Introduction 1 2 Executive Summary 1 3 Project description and stakeholders 3 3.1 Overview of the combined EOR and CCS project 3 3.2 Stakeholders 4
More informationFlameless Technology for Particulate Emissions Suppression
Flameless Technology for Particulate Emissions Suppression M. Malavasi, C. Allouis, A. D'Anna Report RSE/2009/108 Ente per le Nuove tecnologie, l Energia e l Ambiente RICERCA SISTEMA ELETTRICO Flameless
More informationUusiutuvien teknologioiden kehittäminen yhteistyössä partnereiden kanssa
Uusiutuvien teknologioiden kehittäminen yhteistyössä partnereiden kanssa Jussi Mäntyniemi Technology and R&D Director Valmet Valmet s technology and services offering Transforming renewable raw materials
More informationA Review of Biomass Boiler Technologies. Fernando Preto CanmetENERGY, Natural Resources Canada
A Review of Biomass Boiler Technologies Fernando Preto CanmetENERGY, Natural Resources Canada Agricultural Biomass for Combustion Energy April 14 2011, Guelph About CanmetENERGY CanmetENERGY is a science
More informationPGE - Polish Energy Group. Nuclear power development in Poland - we need decision today. Organisation of the Polish Power Sector After Consolidation
Nuclear power development in Poland - we need decision today Hanna Trojanowska Director of International Affairs and New Technologies Department PGE Polska Grupa Energetyczna S.A. Organisation of the Polish
More informationPraxair, Inc. Ray Roberge Sr. VP and Chief Technology Officer
Praxair, Inc. Ray Roberge Sr. VP and Chief Technology Officer Oxygen Opportunities From Increasing Use of Coal Jefferies Investor Seminar November 11, 2009 Making our planet more productive SM www.praxair.com
More informationHow To Run A Power Plant
CO 2 Capture at the Kemper County IGCC Project 2011 NETL CO 2 Capture Technology Meeting Kemper County IGCC Overview 2x1 Integrated Gasification Combined Cycle (IGCC) 2 TRansport Integrated Gasifiers (TRIG
More informationA - 2564 Weissenbach AUSTRIA Tel. +43/2672/890-0, Fax: 890-13 Internet: www.polytechnik.com E-Mail: office@polytechnik.at
A - 2564 Weissenbach AUSTRIA Tel. +43/2672/890-0, Fax: 890-13 Internet: www.polytechnik.com E-Mail: office@polytechnik.at 1 Biomass heat and energy production Ing. Herbert Brenner Polytechnik Luft-und
More informationCO2 enhanced coal gasification and BlueCoal new Clean Coal Technologies proposals from Poland
European Union Side Event Paris, Le Bourget, 9th December 2015 CO2 enhanced coal gasification and BlueCoal new Clean Coal Technologies proposals from Poland Aleksander Sobolewski INSTITUTE FOR CHEMICAL
More informationOPPORTUNITIES FOR HEAT RATE REDUCTIONS IN EXISTING COAL- FIRED POWER PLANTS: A STRATEGY TO REDUCE CARBON CAPTURE COSTS
CONFERENCE PROCEEDINGS OPPORTUNITIES FOR HEAT RATE REDUCTIONS IN EXISTING COAL- FIRED POWER PLANTS: A STRATEGY TO REDUCE CARBON CAPTURE COSTS by Edward K. Levy, Nenad Sarunac, and Carlos Romero Energy
More informationSaskPower CCS Global Consortium Bringing Boundary Dam to the World. Mike Monea, President Carbon Capture and Storage Initiatives
SaskPower CCS Global Consortium Bringing Boundary Dam to the World Mike Monea, President Carbon Capture and Storage Initiatives 1 Purpose of Today A. CCS around the world B. What SaskPower is doing C.
More informationPulverized Coal Oxycombustion Power Plants Final Results
Pulverized Coal Oxycombustion Power Plants Final Results Revised August 2008 Original Publication Date: August 2007 Jared Ciferno Disclaimer This presentation was prepared as an account of work sponsored
More informationValmet biotechnologies and pyrolysis status update. Joakim Autio Product manager, Pyrolysis systems Valmet
Valmet biotechnologies and pyrolysis status update Joakim Autio Product manager, Pyrolysis systems Valmet Presentation outline 1 2 3 Valmet biotechnologies Pyrolysis development background Demonstration
More informationSECARB 10 th Annual Stakeholders' Briefing. Southern Company CCS R&D: Plant Barry CCS Demo. Dr. Richard A. Esposito Southern Company.
SECARB 10 th Annual Stakeholders' Briefing Southern Company CCS R&D: Plant Barry CCS Demo Dr. Richard A. Esposito Southern Company March 12, 2015 Introduction to Southern Company Regulated Utility Franchises
More informationOverview of Integrated Coal Gasification Combined-cycle Technology Using Low-rank Coal
19 Overview of Integrated Coal Gasification Combined-cycle Technology Using Low-rank Coal TAKAO HASHIMOTO *1 KOICHI SAKAMOTO *2 YOSHIKI YAMAGUCHI *3 KOJI OURA *4 KENICHI ARIMA *5 TAKESHI SUZUKI *6 Mitsubishi
More informationProgress on High Efficiency Coal Power Plants
CoalFleet for Tomorrow Progress on High Efficiency Coal Power Plants Dr. Jeff Phillips Sr. Program Manager, Generation McIlvaine Webcast March 1, 2012 CoalFleet for Tomorrow is a registered service mark
More informationMaking Coal Use Compatible with Measures to Counter Global Warming
Making Use Compatible with Measures to Counter Global Warming The J-POWER Group is one of the biggest coal users in Japan, consuming approximately 2 million tons of coal per year at eight coal-fired power
More informationBIOMASS RESEARCH at ECN. Bram van der Drift
BIOMASS RESEARCH at ECN Bram van der Drift ECN-BIOMASS ~50 persons, ~8 M /y, organized in three groups: power and heat biomass upgrading (torrefaction) waste to energy co-firing CHP (combustion, gasification)
More informationB0401 Abstract 029 Oral Presentation Session B04 Innovative Applications and Designs - Tuesday, July 1, 2008 16:00 h
Reference System for a Power Plant Based on Biomass Gasification and SOFC Richard Toonssen, Nico Woudstra, Adrian H.M. Verkooijen Delft University of Technology Energy Technology, Process & Energy department
More informationSimulation of a base case for future IGCC concepts with CO 2 capture
Simulation of a base case for future IGCC concepts with CO 2 capture Christian Kunze, Hartmut Spliethoff Institute for Energy Systems TU München for 4 th Clean Coal Technology Conference 2009 18 20 May,
More informationCOAL GASIFICATION AND CO 2 CAPTURE
COAL GASIFICATION AND CO 2 CAPTURE an overview of some process options and their consequences Use this area for cover image (height 6.5cm, width 8cm) Evert Wesker Shell Global Solutions International B.V.
More informationA MAJOR STEP FORWARD---THE SUPERCRITICAL CFB BOILER
A MAJOR STEP FORWARD---THE SUPERCRITICAL CFB BOILER Ragnar Lundqvist, Foster Wheeler Energia Oy Andre Schrief, Siemens Power Generation Pertti Kinnunen Foster Wheeler Energia Oy Kari Myöhänen, Foster Wheeler
More informationHigh Efficiency Low Emissions: The first way forward for clean coal technology. Dr Andrew Minchener OBE General Manager IEA Clean Coal Centre
High Efficiency Low Emissions: The first way forward for clean coal technology Dr Andrew Minchener OBE General Manager IEA Clean Coal Centre IEA Clean Coal Centre mission statement The IEA CCC will disseminate
More informationGasification as a Strategic Energy and Environmental Option
Gasification as a Strategic Energy and Environmental Option William G. Rosenberg 79 John F. Kennedy Street Center for Business & Government Belfer Center for Science & International Affairs Kennedy School
More informationT@W Good Practice Form
T@W Good Practice Form Setting Title: Public-private Partnership Leading to a New CHP Plant Utilising Fibre Sludge and Biomass Country: Location: Sweden Mariestad in West Sweden Region Start date: 1999
More informationSKI Coal Gasification Technology. Feb. 23, 2012
SKI Coal Gasification Technology Feb. 23, 2012 1 Contents Overview of SK Organization Coal SKI Coal Gasification Technology 2 SK Group [ Sales ] Unit: USD Billion SK Telecom SK C&C SK Broadband SK Telesys
More informationFeasibility Study on Carbonate Looping Process for Post Combustion CO 2 -Capture from Coal fired Power Plants
Feasibility Study on Carbonate Looping Process for Post Combustion CO 2 -Capture from Coal fired Power Plants B. Epple und J. Ströhle Removal London, 7-9 July 2008 www.est.tu-darmstadt.de Technische Universität
More informationFinanzierung von Erneuerbaren Energie und Energieeffizienz Projekten in Asien. INTEC Engineering GmbH Berlin, 08.03.2016
Finanzierung von Erneuerbaren Energie und Energieeffizienz Projekten in Asien INTEC Engineering GmbH Berlin, 08.03.2016 Energy efficiency projects in Asia, The 8 th March INTEC 2016, GROUP Berlin INTEC
More informationLarge Combustion Plant (LCP) Directive Flexibility Mechanisms
Large Combustion Plant (LCP) Directive Flexibility Mechanisms By Pat Swords Oct 2014 Content of the Presentation What are the Flexibility Mechanisms for existing LCPs What advantages have been found by
More informationSiemens Power Generation Innovationstrends bei Anlagen und Komponenten in der Energieerzeugung
Siemens Power Generation 2006. All Rights Reserved Siemens Power Generation Innovationstrends bei Anlagen und Komponenten in der Energieerzeugung Nicolas Vortmeyer CTO, Siemens Power Generation Key Drivers
More informationEIGHTH ANNUAL CONFERENCE ON CARBON CAPTURE & SEQUESTRATION
EIGHTH ANNUAL CONFERENCE ON CARBON CAPTURE & SEQUESTRATION Session: Retrofitting Coal Fired Plants for CCS Mitsubishi Heavy Industries Approach to Commercialization of Post Combustion CO2 Capture Technology
More informationDevelopment of Coal Gasification System for Producing Chemical Synthesis Source Gas
27 Development of Coal Gasification System for Producing Chemical Synthesis Source Gas TAKAO HASHIMOTO *1 KOICHI SAKAMOTO *1 KATSUHIRO OTA *2 TAKASHI IWAHASHI *3 YUUICHIROU KITAGAWA *4 KATSUHIKO YOKOHAMA
More informationAdvanced gas turbine cycles: new solutions for the near future needs
Accordo di Programma MiSE-ENEA Advanced gas turbine cycles: new solutions for the near future needs Giuseppe Messina ENEA, Sustainable Combustion Processes Laboratory Roma, 24 June 2015 Sustainable Combustion
More informationDrying of Woody Biomass. Process Engineering / GEA Barr-Rosin
Drying of Woody Biomass BioPro Expo & Marketplace / Atlanta, GA / March 14-16, 2011 Drying of Woody Biomass Conventional Direct Fired Dryer Technology Proprietary work of the Copyright Owner Issues with
More informationWaste a source of energy. Regional Solid Waste Management Plan Review: Engaging solutions for tomorrow. Incineration. Incineration
Waste a source of energy Regional Solid Waste Management Plan Review: Engaging solutions for tomorrow Garbage School 301: Waste to Energy All organic materials contains energy Plant or animal based Plastics
More informationJASE-world Waste to Energy Sub WG Masanori Tsukahara Hitachi Zosen Corporation 2012.11.14
Presentation of Japanese technology of waste to energy JASE-world Waste to Energy Sub WG Masanori Tsukahara Hitachi Zosen Corporation 2012.11.14 1 JASE-W established in Oct 2008 Introduction of JASE-world
More informationTHE INTERNATIONAL CCS TEST CENTRE NETWORK
THE INTERNATIONAL CCS TEST CENTRE NETWORK Presentation at CSLF technical Group Meeting, Regina, 16 July 2015 Lars Ingolf Eide, Norway 08/07/2015 1 Launched in 2012 to accelerate CCS technology development,
More informationFrom solid fuels to substitute natural gas (SNG) using TREMP
From solid fuels to substitute natural gas (SNG) using TREMP Topsøe Recycle Energy-efficient Methanation Process Introduction Natural gas is a clean, environmentally friendly energy source and is expected
More informationWeiss A/S Presentation. by Bo Johansen
Weiss A/S Presentation by Bo Johansen The history Weiss GmbH founded in Germany by the Weiss brothers as a producer of combustion systems Weiss delivers its first District Heating plant Nordfab A/S, a
More informationBy K.K.Parthiban / Boiler specialist / Venus Energy Audit System
FINE TUNING EXPERIENCE OF A CFBC BOILER By K.K.Parthiban / Boiler specialist / Venus Energy Audit System Introduction The Industrial boilers have been seeing a growth in capacity in the recent years. Current
More informationIt s time for H.E.R.O. Energy Saving Strategy for. Tunnel & Shuttle Kilns
Energy Saving Strategy for Tunnel & Shuttle Kilns SANITARY WARE 1 Introduction The application of the Kyoto protocol and the effects of the recent energy crisis, have highlighted just how important it
More informationHow To Make A Carbon Capture Plant Workable
IEA MOST Workshop: Advances in deployment of fossil fuel technology Beijing June 25, 2014 US DOE National Carbon Capture Center Power Systems Development Facility (PSDF) started combustion testing June
More informationCoal waste slurries as a fuel for integrated gasification combined cycle plants
Coal waste slurries as a fuel for integrated gasification combined cycle plants Marcin A. Lutynski 1,a, and Aleksander Lutynski 2 1 Silesian University of Technology, Faculty of Mining and Geology, ul.
More informationCommercial Scale Fast Pyrolysis Oil Production and Utilisation. Bert van de Beld, IEA conference - Berlin
Commercial Scale Fast Pyrolysis Oil Production and Utilisation Bert van de Beld, IEA conference - Berlin 1 Content Organisation Fast Pyrolysis activities Commercial Demonstration Plant: EMPYRO Pyrolysis
More informationFebruary 9, 2011 Peter Kling, ÅF Consult Ltd Vice President, Bio and WtE Consulting
International WtE projects Project development and implementation February 9, 2011 Peter Kling, ÅF Consult Ltd Vice President, Bio and WtE Consulting 1 ÅF in Energy and Environment World class renown expertise
More informationUniversity of Iowa Power Plant
University of Iowa Power Plant Contents Purpose... 2 History... 3 Cogeneration... 6 Boilers... 7 Environmental Impact... 10 Steam Turbine Generators... 12 Modernization... 14 Biomass Fuel Initiative...
More informationImpact of coal quality and gasifier technology on IGCC performance
Impact of coal quality and gasifier technology on IGCC performance Ola Maurstad 1 *, Howard Herzog**, Olav Bolland*, János Beér** *The Norwegian University of Science and Technology (NTNU), N-7491 Trondheim,
More informationVattenfall and CCS activities
Vattenfall and CCS activities UNECE Ad hoc Group of Experts on Cleaner Electricity Production from Coal and other Fossil Fuels Meeting 17-18 November, 2008 Leif Brandels, Vattenfall AB, Group R&D This
More informationSteam and hot water boiler systems for industrial and municipal power generation Dr.-Ing. Wolfgang Sobbe VKK Standardkessel Köthen GmbH
Steam and hot water boiler systems for industrial and municipal power generation Dr.-Ing. Wolfgang Sobbe VKK Standardkessel Köthen GmbH German-Vietnamese Bio Energy Day Ho Chi Minh City, 16. September
More informationAlberta Research Council (ARC) Enhanced Coalbed Methane (ECBM) Recovery Project in Alberta, Canada
Alberta Research Council (ARC) Enhanced Coalbed Methane (ECBM) Recovery Project in Alberta, Canada Bill Gunter Alberta Research Council (ARC) Inc. Edmonton, Alberta, Canada CBM Resources of Western Canada
More informationThe Technology and Business of Power Andrew Valencia, P.E. Lower Colorado River Authority
The Technology and Business of Power Andrew Valencia, P.E. Lower Colorado River Authority 1 2 What is Efficiency? Efficiency: What you get divided by what you pay for Heatrate is a measure of plant efficiency
More informationSULFUR RECOVERY UNIT. Thermal Oxidizer
SULFUR RECOVERY UNIT Thermal Oxidizer BURNERS FLARES INCINERATORS PARTS & SERVICE SULFUR RECOVERY UNIT Thermal Oxidizer Tail Gas Thermal Oxidizer designed and built to GOST-R requirements. Zeeco can meet
More informationUpgrading of Heavy Oils with FLEXICOKING. ExxonMobil Research & Engineering Company Tim Hilbert
Upgrading of Heavy Oils with FLEXICOKING ExxonMobil Research & Engineering Company Tim Hilbert FLEXICOKING: Integrated Coking and Gasification FLEXICOKING TM Integrated Coke Gasification Key features of
More informationKsawery Kuligowski Pomeranian Center for Environmental Research and Technology POMCERT University of Gdansk Poland
Alternative manure energy solutions: Incineration and thermal gasification A greener agriculture for a bluer Baltic Sea Conference 2011 Seminar C Ksawery Kuligowski Pomeranian Center for Environmental
More informationNITROGEN OXIDES FORMATION in combustion processes COMBUSTION AND FUELS
NITROGEN OXIDES FORMATION in combustion processes NITROGEN OXIDES FORMED DURING COMBUSTION N 2 O - nitrous oxide NO - nitric oxide NO 2 - nitrogen dioxide N = 14, O 2 =16, NO = 30, NO 2 = 46 CONTRIBUTION
More informationSTATE OF CFB TECHNOLOGY IN POLAND
STATE OF CFB TECHNOLOGY IN POLAND Prof. NOWAK Wojciech Czestochowa University of Technology IEA FBC Meeting, X ian May 17, China 1 OWNER/LOCATION Commercial CFB boilers in Poland YEAR TYPE CAPACITY FUELS
More informationCarbon Capture and Storage (CCS) in Canada. CCS Technical Experts Meeting UNFCCC Bonn, Germany October 21, 2014
1 Carbon Capture and Storage (CCS) in Canada CCS Technical Experts Meeting UNFCCC Bonn, Germany October 21, 2014 2 Canada s Approach on CCS Recognizing the potential of CCS to reduce GHG emissions from
More informationLow grade thermal energy sources and uses from the process industry in the UK
Low grade thermal energy sources and uses from the process industry in the UK Yasmine Ammar, Sharon Joyce, Rose Norman, Yaodong Wang, Anthony P. Roskilly Sustainable Thermal Energy Management in the Process
More information4 th EU Sout Africa Clean Coal Working Group Meeting
4 th EU Sout Africa Clean Coal Working Group Meeting Hybrid Concentrated Solar Power (CSP) Concept Case Study for the Medupi Power Stationy Falk Hoffmeister Head of Sales and Business Development. Dr.
More informationESBI Carbon Solutions. Partnering with Countries to Achieve their Full Carbon Credit Potential
ESBI Carbon Solutions Partnering with Countries to Achieve their Full Carbon Credit Potential ESB International ESB International (ESBI) is a growing international energy company and one of Europe s leading
More informationBiomass Boiler House Best Practices. Irene Coyle & Fernando Preto CanmetENERGY
Biomass Boiler House Best Practices Irene Coyle & Fernando Preto CanmetENERGY Growing the Margins London, Ontario March 2010 The Biomass & Renewables Group of Industrial Innovation Group (IIG) of CanmetENERGY
More informationVägar mot ett uthålligt energisystem i Europa
Vägar mot ett uthålligt energisystem i Europa Filip Johnsson Institutionen för Energi och Miljö Chalmers 412 96 Göteborg, Sweden Energisessionen 2008, 7/2, 2008 I = P A T P Population Impact on Environment
More information