Palm Beach County Fire Rescue Fleet Maintenance Asset History FL80 FIRE DEPARTMENT PUMPER NFPA COMPLIANT

Size: px
Start display at page:

Download "Palm Beach County Fire Rescue Fleet Maintenance Asset History FL80 FIRE DEPARTMENT PUMPER NFPA COMPLIANT"

Transcription

1 Workorder: V04 In Date: 0/3/005 Close Date: 0//005 Meter Reading: 3, B INSPCTION E43 See B Inspection pre-printed form SCREEN 6 IN VALVE CHECK HALE /4"" 07796DRYER KIT AD9 -NEW 07800VALVE CHECK AD TRANS FILTER ALLISON GROOVED TENSIONER OLD# WIPER BLADES ANCO SWITCH DOOR VALVE KIT SS VALVE 3 IN 5499FRE8090 REPAIR BRACKET A/C COMPRESSOR M0 HELICOIL KIT S/O HELICOIL KIT M6 HELICOIL KIT S/O 60C00FCRCLEAR BACKUP 600 SERIES SEAL DOOR 78R536078R5360M PK FILTER AIR COND PURGE VALVE KIT LIGHT MAP "" 9440BELT 9480BELT CA893AIR FILTER WIX FG87904MFG S FILTER P/S NEW STYLE FGQ79699GASKET-P/S FILTER NEW STYLE FS0FILTER FUEL WIX 334 PS8689 FRAM HPH6349AOIL FILTER 5748 K08076BELT PR WIX FILTER WATER R90PFILTER FUEL 333 WL600WLA60-A00 FOAM TANK VISION OLD FERR # 35

2 Workorder: V49 In Date: /0/005 Meter Reading: Close Date: /03/005 LIGHT IN LIGHT BAR INOP, E-43 Workorder: V707 In Date: /8/005 Meter Reading: Close Date: /30/005 HEADLIGHT BURNED, OUT RE BALLAST 4 CHANNEL LED LIGHTBAR NOT AVAIL REPAIR ONLY 400 SERIES (WHIT 9UCAPCC9UCAPCC END CAP CLEAR Workorder: V90 In Date: 0/7/006 Meter Reading: Close Date: 0/3/006 L/SIDE HEADLIGHT INOP, RE-43 Workorder: V83 In Date: 0/5/006 Meter Reading: Close Date: 0/4/006 SPOT LIGHT ON CAB INOP, R SWITCH DOOR H6054USE CV TYPE SEALED BEAM 6

3 Workorder: V343 In Date: 0/30/006 Meter Reading: Close Date: 03/0/006 NEED HYDRAULIC OIL, RE-43 80R00HURST HYD. FLUID QT 6 Workorder: V44 In Date: 0/06/006 Meter Reading: Close Date: 03/0/006 DECK GUN VALVE HARD TO OPEN, RE-43 Workorder: V843 In Date: /08/005 Meter Reading: Close Date: 03/0/006 L/SIDE LIGHTBAR LENS BROKEN, R/LEFT LED LIGHTS IN LIGHT BAR INOP, RE-43 Workorder: V605 In Date: 0/3/006 Meter Reading: Close Date: 03/0/006 TURN SIGNALS INOP, RE-43 9ULENSCCLEAR LENS FREEDOM BAR SAHSVS50STRAP UMVS6STRAP 5 5

4 Workorder: V969 In Date: 03/7/006 Meter Reading: Close Date: 03/9/006 NEED HOLES DRILLED IN BATTERY COMPT, RE-43 Workorder: V953 In Date: 03/4/006 Meter Reading: Close Date: 04/3/006 DOOR AJAR LIGHT INOP, RE-43 Workorder: V33 In Date: 04/07/006 Meter Reading: Close Date: 04/9/006 BUNGEE HOOK STRAP THAT HOLDS JAWS IS BROKEN. RE-43 Workorder: V34 In Date: 04/4/006 Meter Reading: Close Date: 04/8/006 SLOW CLOSE 3" R/REAR VALVE INOP, RE-43

5 Workorder: V463 In Date: 05/03/006 Meter Reading: Close Date: 05/08/006 DOOR AJAR LITE ON, RE-43 Workorder: V3078 In Date: 06//006 Meter Reading: Close Date: 06/3/006 We need /" replacement gaskets for E43 & T43. We used all of our reserves when we did hose testing on the tender GASKET 3.5 IN 07405GASKET 4.5 IN REDG5TGASKET.5 IN RED HEAD REDG6S403 GASKET 6 IN Workorder: V39 In Date: 06/8/006 Meter Reading: Close Date: 06/30/006 PLEASE CHECK REAR A/C DRAIN PLUG, SMALL PUDDLE NOTED ON FLOOR BOARD E43 78R536078R5360M PK FILTER AIR COND 4 Workorder: V37 In Date: 06/7/006 Meter Reading: Close Date: 07/0/006 / gallon water extinguisher for E43.

6 Workorder: V36 In Date: 06/7/006 Meter Reading: Close Date: 07/0/006 4' extension ladder missing protective cap from tip of nd extension section e43/ ground ladder. Workorder: V3866 In Date: 08/0/006 Close Date: 08/7/006 Meter Reading: 4, B INSPECTION AND REPAIRS AS NEEDED RE YLIGHT MARKER LEDAMBER 5TSMACMOUNT 500 TIR SER CHROME STUD DZ CLIP 78R536078R5360M PK FILTER AIR COND A CABLE BATT. POS. A CABLE BATT. NEG. FS0FILTER FUEL WIX 334 PS8689 FRAM HPH6349AOIL FILTER 5748 PR WIX FILTER WATER R90PFILTER FUEL 333 Workorder: V470 In Date: 08/9/006 Close Date: 08/3/006 Meter Reading: 3,88.00 hood latch broken, air horn innop E HOOD LATCH LATCH

7 Workorder: V405 In Date: 09/0/006 Close Date: 09/06/006 Meter Reading: 3,88.00 repair hurst power unit e43 BPR5ESSPARK PLUG 7734 Workorder: V3908 In Date: 08/4/006 Meter Reading: Close Date: 09/08/006 FRONT TIRES AT CALLAGHAN TIRES E43 Vendor?: VC-54 Workorder: V490 In Date: 0/6/006 Close Date: 0/5/006 Meter Reading:, CHAINSAW ON E43 STARTS UP OK, BUT AFTER IDLE WILL NOT RUN BACK UP.. WORKED ON SAW CLEANED CARB RUN AND TEST NPF Workorder: V4967 In Date: 0/9/006 Close Date: /0/006 Meter Reading:,56.00 both chain saws out of service. stop running on full throttle. added new mixed gas (50:), spark plug looks good, but still not running. E-43. TRAVELED TO STN 43. RAN BOTH CHAIN SAWS' AND FOUND NOTHING WRONG WITH THEM.

8 Workorder: V546 In Date: 0/30/006 Close Date: /06/006 Meter Reading:, fuel gauge not reading correctly on dashboard. RE43. CHECK FUEL GAGE Workorder: V550 In Date: 0/30/006 Close Date: /06/006 Meter Reading:, E43 frony suction switch inop/0-7. CHECK FRONT SUCTION VALVE MJTV5 VALVE AIR CONTROL Workorder: V577 In Date: 0/3/006 Close Date: /06/006 Meter Reading:, REPAIR CHAIN SAW REGAN SMALL EQUIP REPAIR RE43 REPAIR CHAIN SAW E43 Vendor?: REGANS MOBILE ENGIN Workorder: V635 In Date: 0/08/007 Close Date: 0/6/007 Meter Reading: 3, Foam leaking from pump area E43. Replaced foam supply hose. Adjusted tank to pump linkage 00R4FOAM HOSE AS PER SAMPLE

9 Workorder: V6348 In Date: 0/8/007 Close Date: 0/3/007 Meter Reading: 3, RE0PAIR SAW RE43 REGANS. SAW SENT OFF TO REGAN'S FOR REPAIR. Vendor?: REGAN'S MOBILE SMALL Workorder: V6380 In Date: 0/0/007 Close Date: 0/3/007 Meter Reading:,87.00 Polaroid PR camera dose not appear to be working correctly. It will not close up. Also it is out of film. E-43. TRAVELED TO STN 4. INSPECTED & TESTED POLAROID CAMERA, NO FILM ADVISE LT TO CONTACT WAREHOUSE. Workorder: V65 In Date: 0/9/007 Close Date: 0/7/007 Meter Reading:,87.00 REPLACE BACK SMALL NUMBER PLATE AND NUMBER ON E43. INSTALL SMALL NUMBER PLATE WITH NUMBER ON FRO OF T43. TRAVELED TO STN 43. INSTALLED NUMBER PLATES. Workorder: V70 In Date: 03/5/007 Close Date: 03/3/007 Meter Reading:, REPAIR SLEDGE HAMMER HOLDER IN DE COMPARTMENT. ALSO AIR HORN BUTTON ON PUMP PANEL DOES NOT WOR E43 Remounted bracket

10 Workorder: V7 In Date: 03/5/007 Close Date: 03/3/007 Meter Reading:, A HANDLIGHT FROM E43 WILL NOT HOLD A CHARGE. ALSO PLEASE CHECK BOTH BACKSEAT LIGHT BOXES. THE CHARGING LIGHTS ARE NOT COMING ON. E43 Found wire disconnected Workorder: V8476 In Date: 05/30/007 Close Date: 06/4/007 Meter Reading:,69.50 E43 FOAM SYSTEM NEEDS TO BE CHECKED OUT. SHUTS OFF BY ITSELF AND IS USING EXCESSIVE AMOUNTS OF FOA. Disassembled foam pump head and cleaned, reassembled and tested. Checked problem with hurst motor, cleaned and adjusted carb Workorder: V8577 In Date: 06/04/007 Close Date: 06/6/007 Meter Reading:, RIGHT SIDE (OFFICERS SIDE) INTAKE FEMALE SWIVEL LOCKED TIGHT. WILL NOT TURN/SWIVEL. e43. Removed swivel and cleaned and lubed Workorder: V939 In Date: 07/09/007 Close Date: 07/8/007 Meter Reading:,88.00 chain saw pull cord is not turning engine. E-43 Chkd all saw on trucks & fnd all working; fnd no problem with pull cord

11 Workorder: V89 In Date: 06/9/007 Close Date: 07/9/007 Meter Reading: 7,9.00 B INSPECTION AND REPAIRS AS NEEDED E43

12 . B INSP & ROAD TEST. T-CASE SERVICE 3. DIFFERENTIAL INPUT SEAL LEAKING. REMOVE OIL. REMOVE DRIVE LINE. REMOVEYOKE, FLANGE, & SEAL. INSTALL NEW SEAL. CLEAN PARTS. FILL DIFFERENTIAL, CHANGE OUT EMPTY GEAR OIL DRUM. 4. CHECK U-BOLTS TO TORQUE SPECS, FRONT AND REAR. 5. SERVICE AIR DRYER. 6. COOLANT SYSTEM SERV. 7. BATT.SERV REPLACEMENT SCHED. 8. BELT SERV. REPLACE PULLEY, BEARING,IDLER & TENSIONER. 9. PUMP VAC TEST-VALVES NEED UPDATING. REBUILD 4 DISCHARGE VALVES. 0. RAD LEAK. REMOVE AND DISSASSEMBLE RAD & INSTALL.. WIPER BLADES & FLUID. ADD BUG SOLVENT TO RESEVOIR.. DRIVERS DOOR AND WINDOW MOLDING AND SEAL. L- DOOR LOCK REPAIR & REPLACE AS NEEDED. 3. LIGHT FAILURE-R&R DEFECTIVE OR BROKEN LIGHTS. 4. SHOP MEETING. 5. REBUILD VALVES. R&R DISCHARGE, HOSE REEL, INTAKE RELIEF, TANK TO PUMP. REPLACED SENSING VALVE, CHECK VALVE. REPAIR PIPE NIPPLE LEAK. DRAIN TANK. REMOVED TANK TO PUMP VALVE, NIPPLE, AND RESEAL. FILL WATER TANK. PERFORM DRY VAC TEST. 6. VACATION 7. B INSP. GREASE FITTINGS. DRAIN OIL TO CORRECT LEVEL. CLEAN REAR AC FILTER. 8. SWAP OUT INTO SERVICE TRUCK FOR ON CALL. FUEL TRUCK. ADD QTS OIL, COOLANT, WASHER FLUID, CHECK TRANS FLUID & LIGHTS. 9. WEIGH VEHICLE AND TALK TO LIFT MANUFACTURER. 0. REBUILD BOTH PRIMER VALVES.. INSTALL CROSSLAY NETS. SERVICE SMALL ENG. EQUIP. 3. ON CALL PARTS. 4. REMOVE AND INSTALL LADDER DECALS. 5. REMOVE R FRONT FENDER BRACE AND RE-WORK SO BRACE DOESN'T CUT FRONT SUCTION HOSE. 6. REPLACE PUMP COMPOUND PRESSURE GAUGE. SET UP FOR NEW3 GOV GAUGE AND THROTTLE (NO MONEY IN ACCT) 7.DIAGNOSE FOAM MASTER GAUGE- TROUBLE CODE "HOT". REPLACED DISTRIBUTION BOX INJ, SWAPPED CABLE A7 CONTROL HEAD, CHECKED PIN CABLE FLOW SENSOR HALE FOAM SYS VALVE CHECK HALE /4"" CHECK VALVE INJECTOR HALE FOAM SYS O-RING FOR HALE FOAM PUMP SPRING PRIMER SPRING-VALVE QG RELIEF VALVE 00557SEAL OLD STYLE PINON 07796DRYER KIT AD9 -NEW 08-FBEADED CHAIN W/CONN NC SWITCH OK TO PUMP FOAM PUMP SENSOR KIT 03FFBEARING PULLEY SMASK LENS W/RST BUTTON VDO GROOVED TENSIONER OLD# R00FRRFLASHER RED LED FLANGED 5-4WIPER BLADES ANCO TPM/QG HALE REPAIR KIT VALVE KIT SS VALVE KIT SS VALVE / VALVE KIT SS VALVE 3 IN LENS CLEAR FOR STRIP LIGHT SEAL DOOR 75908SWITCH BATTERY MASTER 300A 8487GROUND STRAP IN 89BULB 9440BELT 9480BELT A MOLD L/H A FUEL SENDING UNIT BHT-B0CORE AND TANKS CA893AIR FILTER WIX FS0FILTER FUEL WIX 334 PS8689 FRAM HPH6349AOIL FILTER 5748 I0300PT-XE-IO300PT3-S0B 600 TRANSDUCER INT IOA00A00DISPLAY MODULE REBUILD ONLY SEND IN K08076BELT PR WIX FILTER WATER PVG-KITORING KIT R90PFILTER FUEL 333 3

13 VOLTAGE DROPS, FLOW SENSOR. 8. REPLACED R PRECONNECT NOZZLE BUCKET BRACKET. REDESIGNED FASTENER SYSTEM. 9. INSTALL LR HUBCAP AND LUG NUT COVERS. INSTALL LUG NUT COVERS ON R SIDE. 30. WORK ON HOIST. CHECK BATTERIES. 3. VACATION- JUNE 8-9, JULY -3, JULY FOAM SYSTEM DIAGNOSIS- ELEC. FAULT. CONTACT HALE TECH SUPPORT AND ENGINEER REGARDING PROBLEM. 33. FOAM SYSTEM. R&R FOAM INJ PER ED. R&R FLOW SENSOR TWICE PER ED. REPLACED FOAM SENSOR AND SCREWED ALL THE WAY IN PER ED. REMOVE PUMP AND CLEAN PUMP AND GEARS PER ED. 34. SCREW SENSOR FOR FOAM OUT PER MIKE. (OK NOW) REPLACE DISCHARGE SENSOR. FILL FOAM TANK. MEETING. 35. FUEL GAUGE PROBLEM. REPLACED SENDING UNIT PER ED. 36. REPLACED DASH BEZEL. Workorder: V9460 In Date: 07//007 Close Date: 07/4/007 Meter Reading: 7, E43 air horn spontaneously ingages when battery first turned Air horn sounds constantly; chkd unit & replc foot swtch horn; still sounding; chkd for relay in ckt-none; signal goes to node; tried to reprogram node-no good; fnd input to node grounded; will bring to shop for repair Workorder: V8945 In Date: 06//007 Close Date: 07/5/007 Meter Reading: 7,9.00 repoace two tires at shop callaghan ent e43 Replace two tires at shop - Callaghan Vendor?: CALLAGHAN

14 Workorder: V9596 In Date: 07/8/007 Close Date: 07/8/007 Meter Reading:, no reply from node. deck gun cab light illuminates when (P) break released. Pump panle lights and quartz scene lights unable to be turned on. "O.K. To Pump" light in cab not illuminating when engine placed into pumping e43 No power to pump panel; replc node # NODE HERCULES V-MUX Workorder: V9506 In Date: 07/4/007 Close Date: 08/07/007 Meter Reading: 7, repair air horns e43. rewired air horns. replaced marker light right top rear CHROME MARKER LIGHT MOUNT Workorder: V003 In Date: 08//007 Close Date: 09//007 Meter Reading: 8,45.00 VIBRATION IN DRIVELINE E43. Chkd drive line vibration; fnd pinion out loose; rem driveline, pinion yoke, drained fluid; fnd large amount of metal; reassemble & fille with new fluid. Delivered truck to Brake & Wheel Workorder: V046 In Date: 08/7/007 Close Date: 09/3/007 Meter Reading:, Repair/Replace hub caps on rearwheels of E43. One hubcap at Station. Also airhorn is still inoperative.. Rewire air horn & tested. Rem rear center chrome cap from rear wheel

15 Workorder: V0095 In Date: 08/3/007 Close Date: 09/8/007 Meter Reading: 8,45.00 rebuild rear end total truck e43 Rebuild rear end - Total Truck Vendor?: TOTAL TRUCK Workorder: V0489 In Date: 09/7/007 Close Date: 09/5/007 Meter Reading:, E43 PRIMER RELIEF LIGHT INOPERATIVE, DECK GUN WARNING LIGHT STILL BLINKING, FUEL GAUGE ON PUMP PANEL INOPERATIVE e43. Traced problem w/relief valve light & fuel gauge; fnd broken wire relay; reran new wires & tested. Adj all cab door latches Workorder: V060 In Date: 08/8/007 Close Date: 09/7/007 Meter Reading:, Air hose unaccounted for. Need vehicle air hose and air'chuck' to fill tires, pressurized water cans. e43 DC will wayne Workorder: V036 In Date: 09/0/007 Close Date: 09/7/007 Meter Reading:, PUMP PANEL LIGHTS, AND SCENE LIGHTS NOT WORKING. EXTEND-A-GUN WARNING LIGHT FLASHING INSIDE CAB. E3.Fnd bad connection in Y connector; cln; fnd bd node; R/R & downloaded node; fixed pump panel light & scene light but not extend-abar warning light; wire to switch but light didnt go off. Traced problem w/deck gun light going off; fnd bad grnd, ran new grnd wire NODE HERCULES V-MUX NISENSORNI-SENSOR SENSOR DECK GUN USE XG840-K

16 Workorder: V8399 In Date: 05/3/007 Close Date: 0/5/007 Meter Reading:,58.70 REPLACE CLEAR COVER FOR SIDE COLOR WATER LEVEL INDICATOR. (DRIVERS SIDE) e43. replaced lens for water level. Recalabrated water level guages LENS CLEAR FOR STRIP LIGHT Workorder: V65 In Date: /7/007 Close Date: //007 Meter Reading:,96.00 master pressure guage (digital) fluctuating by psi, possibly affecting pressure relief valve. E43 NO CALL REM PRESSURE RELIEF SCREEN & CLEAN. J Workorder: V684 In Date: /9/007 Close Date: /8/007 Meter Reading:, EMERGENCY SIDE LIGHTS ON OFFICERS SIDE WORKING INTERMITTENTLY. SOMETIMES THEY DON'T COME ON, THEY COME ON AND DON'T BLINK, AND MIDDLE ONE HAS SOME LEDS BURNT OUT. e43 Fnd (3) LED lights out; rem lights & install new j 50R03ZCRLIGHT LED RED TIR 6 3 Workorder: V0835 In Date: 0/04/007 Close Date: /9/007 Meter Reading: 8, mount fuel can e43. Remounted fuel can.

17 Workorder: V85 In Date: /0/007 Close Date: /06/007 Meter Reading: 30,35.00 digital master discharge gauge apears to need calabration it appears to be off by about 40psi high. For example in tank to pump a idle discharge reads 90psi were other Engines read 50psi. In pump it also is 40too high E43. Traced out problem with gauge found discharge sencer N/G removed and repaired. IOA00A00DISPLAY MODULE REBUILD ONLY SEND IN Workorder: V957 In Date: /07/007 Close Date: //007 Meter Reading: 30,35.00 front left blinker not working on engine 43 and no replacement bulbs in station. Travel to 43.. Check truck NPF has already been fixed. Workorder: V938 In Date: //007 Close Date: /9/007 Meter Reading: 30,37.50 TURN SIGNAL 0-7 E43. Repaired bad connection in light. Workorder: V80 In Date: 0//007 Close Date: 0/5/008 Meter Reading: 9,30.00 engine 43 air horn not functioning

18 Workorder: V853 In Date: /0/007 Close Date: 0/5/008 Meter Reading: 30,35.00 Pressure relief valve light dose not appear to be working properly. When relief valve is disengaged it flickers instead of stays off. When it is engaged it comes on properly. Thanks guys hope you had a good weekend. E43. Relief valve light on, Ran pump and found light working at this time QG VALVE QD REL.VALVE KIT Workorder: V405 In Date: 0/07/008 Close Date: 0/04/008 Meter Reading:, air horn on pump panel not functioning E-43 At shop for B-Inspection. j Workorder: V705 In Date: 0/0/008 Close Date: 0/04/008 Meter Reading: 3, air horn on pump panel oos, light on relief valve does not go out when setting relief valve,and ems compartment door sticks. E43 At shop for B-Inspection. j

19 Workorder: V80 In Date: 0/4/008 Close Date: 0/04/008 Meter Reading: 3, B INSPECTION AND REPAIRS AS NEEDED E43 B-Inspection. Rebuilt baypass valve; (magnet was shattered) 3. Replc wiper blades 4. Replc T/S side lenses; (both cracked) 5. Sealed condensor hsng on rear cab A/C; (lkng condensation into cabl flr) 6. Rem siren/horn; rocker swtch in dash; fab new bezel & reinstalled swtch 7. Chkd air horns going off when btry swtch is turned on; cld not reproduce concern; wired air horns back into original harness & reinstalled kick panel; test air horns repeatedly j OIL DRAIN CUMMINS ISB ISC 5W40BSYN OIL BULK QTS 5-4WIPER BLADES ANCO QG VALVE TPM/QG HALE REPAIR KIT 78R536078R5360M PK FILTER AIR COND 953AMBER LENS FS0FILTER FUEL WIX 334 PS8689 FRAM HPH6349AOIL FILTER 5748 R90PFILTER FUEL 333 Workorder: V389 In Date: 03/4/008 Close Date: 03/4/008 Meter Reading: 3,46.00 k saw belt 0-7 while cutting garage door on house fire dc3 notified. tagged and sitting in St43 bay. Unit repaired on EMS 3 ticket Workorder: V3899 In Date: 03/4/008 Close Date: 03/4/008 Meter Reading: 3,46.00 repair a/c e43. Replaced blown low pressure A/C line from compressor to expansion block, vaccum, charge, leak check system A DRYER A433074A HOSE ASSY.

20 Workorder: V3380 In Date: 0/0/008 Close Date: 03/0/008 Meter Reading: 3, repair flat at sta 43 callaghan e43 Repair flat at Stn43 - Callaghan j Vendor?: CALLAGHAN Workorder: V3868 In Date: 03/3/008 Close Date: 03/0/008 Meter Reading: 3,0.00 Front right turn single not working. Still have on going problems with fuel gauge in cab of E43.. Traced out problem with turn signal, found bad connection Workorder: V3869 In Date: 03/3/008 Close Date: 03/0/008 Meter Reading: 3,0.00 A/C unit leaking water into back floor board of E43. Tommy looked at it and informed us that the unit was "rusted out" and needs to be replaced. e43. Checked rear A/C unit leaking water, resealed unit and will monitor Workorder: V395 In Date: 03/8/008 Close Date: 04/0/008 Meter Reading: 3,08.00 Please repair/replace the cigarette lighter plug in the cab of E43. We use it for our portable spotlight.. Repaired bad connection for power plug 5645CIG. LIGHTER ACCES.

21 Workorder: V4060 In Date: 03/4/008 Close Date: 04/0/008 Meter Reading: 3,3.00 E43, B43, R43 ALL HAVE ONE OR TWO EMERGENCY LIGHTS THAT ARINOPERTATIVE.. Replaced LED light on front of Engine that was out. Workorder: V43 In Date: 04/07/008 Close Date: 04/07/008 Meter Reading: 33, AIR HORN INOP, E-43. air horn stays on/rewired air horn. Workorder: V44 In Date: 03/6/008 Close Date: 04//008 Meter Reading: 3,37.00 right front side led red warning light does not work..replaced LED lite that wasnt working. 50R03ZCRLIGHT LED RED TIR 6 Workorder: V4349 In Date: 04/08/008 Close Date: 04//008 Meter Reading: 33, REPAIR CHARGING SYSTEM E43 charging sys. on e 43 no charge

22 Workorder: V4408 In Date: 04//008 Close Date: 04/4/008 Meter Reading: 33,43.00 REPLACE ALTERNATOR E43. REPLACE ALTERNATOR. 4867JB30 UPGRADE ALTERNATOR Workorder: V509 In Date: 05/0/008 Close Date: 05/0/008 Meter Reading: 34, PIN MISSING FROM SPREADER TIPS, E-43 Pin missing gfrom spreader tips E43 - Team Equipment j Vendor?: TEAM EQUIPMENT Workorder: V55 In Date: 05/0/008 Close Date: 06/05/008 Meter Reading: 3, E43 has returned from the deployment up north and needs to be check out. Front A/C was not cooling. complete a inspection. Cab A/C; A/C filter; chkd cab, A/C & replcd filter.. Coolant leak; fnd coolant leak & rep hose clamp. 3. A-Inspection 4. Cab door hard to open; adj cab door latches. j 78R536078R5360M PK FILTER AIR COND 9879CONNECTOR 3 Workorder: V556 In Date: 05/9/008 Close Date: 06/8/008 Meter Reading: 34, ON CALL ALARM GOING OFF. alarm going off, found no alarm

23 Workorder: V5540 In Date: 06/05/008 Close Date: 07/0/008 Meter Reading: 34, REPAIR ACCESSORY PLUG E43. installed nd new volt plug in dash.. air leak traced out. air leak found at seat. repaired test = ok. 3. rear LED out repaired bad connection 50R03ZCRLIGHT LED RED TIR CIG. LIGHTER ACCES. RSR03ZCRLIGHT LED RED TIR3 SERIES Workorder: V555 In Date: 06/05/008 Close Date: 07/0/008 Meter Reading: 34, fuel gauge dose not read write. e43. FUEL GAUGE IN-OP. REPLACED DASH CLUSTER AND FUEL SENDER AND TESTED GASKET FUEL SENDER A FUEL SENDING UNIT A A CLUSTER ASSY Workorder: V556 In Date: 06/05/008 Close Date: 07/0/008 Meter Reading: 3, The air adjustment on the drivers' seat does not work. "Feels like you are driving a lowrider". E43. travel to 43. repair airline to drivers seat. 3. check air hose. Workorder: V566 In Date: 06/09/008 Close Date: 07/0/008 Meter Reading: 34, ON CALL COMP DOOR WONT OPEN E43. medical door wont open handle broken inside. drilled out opened, went to shop for parts= repaired D PADDLE HANDLE

24 Workorder: V56 In Date: 06/09/008 Close Date: 07/09/008 Meter Reading: 3,40.00 air horn on pump panel oos. r43. traced out problem with air horn, found bad ground and repaired Workorder: V5743 In Date: 06/4/008 Close Date: 07/09/008 Meter Reading: 3,47.00 siren does not come on when you press the horn button E43. checked horn button and tested ok Workorder: V5879 In Date: 06/0/008 Close Date: 07//008 Meter Reading: 3, pressure relief valve takes a long time to control pressure E43 ran pump & chkd relief valve; tested ok. j Workorder: V6397 In Date: 07/7/008 Close Date: 07/30/008 Meter Reading: 35, warning light for the doors being open does not work. e43 the air ajustment on the drivers side seat needs a air switch. it does not ajust.. found light diconnected, reconnected light and tested = ok. repaired drivers side air seat that was not working.

25 Workorder: V666 In Date: 07/8/008 Close Date: 07/3/008 Meter Reading: 3, The door ajar light in the cab of E43 is blinking again. Tommy was out today (Mon.) to check it and now it's blinking again.. Door open warning switch shows water corrosion buildup & () brkn switch; replc all defective switches. sys working normal at this time.. Opr states siren come on/off; I could not duplicate this fault; all sys working normal; chk alt output; all are operating normal. j 3. Repaired short in L- door switch. j 5-64SWITCH DOOR 5 Workorder: V6737 In Date: 07/3/008 Close Date: 08/05/008 Meter Reading: 3, Drivers side haedlight out E43 Replc headlight on right side. j Workorder: V749 In Date: 08/9/008 Close Date: 09/0/008 Meter Reading: 3,54.00 open door light is malfunctioning e43 Light works ok at this time; buzzer not coming on with light. j Workorder: V775 In Date: 08/4/008 Close Date: 09//008 Meter Reading: 3, Right side (officers side) above rear wheel, the strobe light is stuck on, does not flash/blink. E-43 Replaced LED light on right side that was not flashing. j A00 SERIES TRI RED 50R03ZCRLIGHT LED RED TIR 6

26 Workorder: V7578 In Date: 09/08/008 Close Date: 09/9/008 Meter Reading: 3, Door ajar light blinking and will not go off. E43 Traced out problem with light found bad ground. Workorder: V6738 In Date: 07/3/008 Close Date: 09/30/008 Meter Reading: 3, Thermal imager camera not charging properly E43 Repaired bad connection on TIC charger NODE MINI V-MUX Workorder: V7 In Date: 08/8/008 Close Date: 09/30/008 Meter Reading: 3,54.00 Please check TIC holder/charger on E43. The power light is coming on, but neither charging light is coming on the unit or spare battery. E43. Radio speakere mount on dash; Need base for charger; replc w/another. Need to chk on buzzer to door open; 3. Need to rep LED side marker light, rear tail board & left rear corner. j 3500-RLIGHT MARKER LED RED 3500-YLIGHT MARKER LEDAMBER 3 3 Workorder: V7437 In Date: 09/0/008 Close Date: 0/0/008 Meter Reading: 3,58.00 radio speaker bracket broken on dash. E-43. Repaired radio brack on dash. (R.T.)

27 Workorder: V83 In Date: 0/08/008 Close Date: 0/7/008 Meter Reading: 5, REPAIR SEATS AT CENTRAL Repair seats - Central Auto Trim j Vendor?: CENTRAL AUTO TRIM Workorder: V560 In Date: 06/08/008 Close Date: 0//008 Meter Reading: 3, upper left red turn signal needs to be changed R43. REPAIRED MARKER LIGHT THAT WAS NOT WORKING. Workorder: V8604 In Date: 0/6/008 Close Date: /06/008 Meter Reading: E43 has just return from a scheduled "B" maintenance. Both air systems are leaking down, front and rear. Dosen't appear to be a rapid leak, and after a few minutes it builds up and we can respond. Checked for air leaks & fnd none at this time. j

28 Workorder: V860 In Date: 0/06/008 Close Date: /07/008 Meter Reading: 37, C INSPECTION AND REPAIRS AS NEEDDED E43

29 . Road call to Stn43 to troubleshoot horn/siren sticking on; fnd faulty horn button; changed horn button out with spare unit.. Perform "C" service. 3. Performed low voltage electrical sys performance test 4. Drove Julio to upholstry shop. 5. Svc "T" case. 6. Svc air brake dryer. 7. Sec loose exh clamp & hanger. 8. Cln vac motor positive connection (corroded). 9. Replcd pinion seal (leaking). 0. Svc trans.. Replaced belts.. Chkd out Hurst tool no start cond; cld not reproduce customer concern; unit started and ran normally. 3. Replcd horn button in steering wheel (broken) 4. R/R air gov & fittings. 5. Rem oil line (supply) from air compressor & replc; go to Macko hose & have made up. 6. Insurance meeting w/rep. 7. Go to Red Wing store & get boots. 8. Replc all (4) dash defusers. 9. Lube all door & compt latches & chk opn. 0. Replace wiper blades.. Replc L/R; complete weatherstrip; replc L/F door lower weather strip & R/F door lower weatherstrip.. Replc () amber midship marker lights; replc both frnt turn signal lamp reflector lenses; replc () amber reflectors midship on each side. 3. Replc bulb in left side telescopic light. 4. Cln rear rear A/C drain; cln clogged evap core to rear unit & replc filter. 5. Rep hose reel compt light; replc node #3; reprogram new node & install; had to rem Hurst tool shelves to rem/repl nodes. 6. Rep rem, cln, repair & reinstall fuel cap. 7. Replc bulb in maplight & chk opn. 8. Replc both flag stickers on rear of unit. 9. Rem RPM cable frm T-case; make new cable & reinstall. 30. Reinstall driver/pass seats back in unit. 3. road call to Stn47; rem hubcaps for tire co. & reinstall. 3. Rem slow close valves for R/R discharge & deck gun; install new Akron valves. 33. Rem hose crosslay # & # deck plate & reattach deck gun stand pipe; reinstall deck plate for crosslay. 34. Assist w/deck gun valve & right rear discharge valve replacement. 35. Perform vac test. rem/rebuild 33 discharge & rem/rebuild intake discharge valve. 36. Replc tank to pump valve; replace # & #4 discharge valves; replc tank recirculate valve. 37. Assisted vac leak dia & repair C8COMP LIGHT WHITE LED HALE RELIEF VALVE W/ VULCANIZED SEAT SPEEDCOUNTER PUMP PANEL 00557SEAL OLD STYLE PINON IN PS FLANGE 0508FLANGE ADAPTER 3 X HALE 07796DRYER KIT AD9 -NEW 07800VALVE CHECK AD IN FLANGE ADPT W/ HOLES PS MAP LIGHT BULB 5W40BSYN OIL BULK QTS WASHER CAP WPB-FREIGHTLINER TRANS FILTER ALLISON 33864HOSE/FITTING 3500-YLIGHT MARKER LEDAMBER 5-4WIPER BLADES ANCO TPM/QG HALE REPAIR KIT VALVE KIT SS XSTRAP U-JOINT NODE HERCULES V-MUX 680-0LAMERICAN FLAG W UV CLEAR LEFT 680-0RAMERICAN FLAG W UV CLEAR RIGHT SEAL DOOR VENT A/C LH VENT A/C RH A HORN BUTTON / IN VALVE SS VALVE SS / VALVE SS 3IN NEW # R536078R5360M PK FILTER AIR COND PURGE VALVE KIT IN SS NIPPLE IN SLO-CLOZ W/R HANDLE 953AMBER LENS 9440BELT 9480BELT A CABLE BATT. POS. B480AREFLECT-AMBER BPR5ESSPARK PLUG 7734 CA893AIR FILTER WIX CD004DRAIN HOSE FS0FILTER FUEL WIX 334 PS8689 FRAM HPH6349AOIL FILTER 5748 K08076BELT LB-D30BULB QUARTZ HAL. V 50W 3 4 3

30 38.Fill task w/water & chk valves/pipes for leaks. 39. Turn in warranty valves & clnup work area. j PR WIX FILTER WATER R90PFILTER FUEL 333 Workorder: V8486 In Date: 0//008 Close Date: /0/008 Meter Reading: 5, replace hose bed cover e43 Replace hose bed co ver E43 - Central Auto j Vendor?: CENTRAL AUT TRIM Workorder: V907 In Date: /4/008 Close Date: /0/008 Meter Reading: 3,75.00 newly replaced valve on e43 is leaking, seems like its leaking from threads. Rep coated leak at R/R discharg valve; replcd lower flange & close nippled.. Rep deck gun position sensor. 3. Replc Y-connector at node #. 4. Chkd valve need to come into shop for repair. 5. Replcd park valve asy; rem dash panels, instrument panel, & air lines; R/R valve asy; reinstall fittings/switches; ran/ck for leaks; ck ok; go to Training fac IN PS FLANGE VALVE PARKING BRK IN SS NIPPLE DT043PP007DEUTSCH RECEPTACLE XG840-KITEXTENDA GUN SWITCH Workorder: V98 In Date: /9/008 Close Date: /6/008 Meter Reading: 3,76.00 air pressure leak. Air pressure have to be build up after engine shut down and sat. e43 Repaired on W/O 907 (/5/08). j

31 Workorder: V905 In Date: /0/008 Close Date: /6/008 Meter Reading: 38,38.00 DRIVERS SEAT BELT 0-7 E43 Drive to Stn; drivers seat belt lock broken; R/R seat belt. j IMMF358SEAT BELTS Workorder: V8937 In Date: /08/008 Close Date: /0/008 Meter Reading: 3, air horn is not sounding at pedal or controls E-43. Rep bad connection in rear pump panel for air horn.. Rear door cab not latching; readjust door latch. j Workorder: V9046 In Date: /3/008 Close Date: /0/008 Meter Reading: 3,75.00 The air horn on E43 is not working. Please send motor oil for E43, R43 to Station 43. Readjust air horns that were out of adjustment. j Workorder: V98 In Date: /9/008 Close Date: /0/008 Meter Reading: 3,76.00 pressure relief light not working e43 Ran pump & chkd relief valve & tested ok. j

32 Workorder: V8485 In Date: 0//008 Close Date: /05/008 Meter Reading: 5, replace tires at shop callaghan replace tires at shop Vendor?: CALLAGHAN Workorder: V9339 In Date: /5/008 Close Date: /08/008 Meter Reading: 3,74.70 REPLACE FRONT TIRES AT STA CALLAGHAN E43 Vendor?: CALLAGHAN Workorder: V944 In Date: /0/008 Close Date: /5/008 Meter Reading: 38, PUMP LEAK AT DECK GUN E-43 Deck gun leaking at pump fitting; tighten valve; will monitor valve. j Workorder: V9783 In Date: /6/008 Close Date: 0/05/009 Meter Reading: 3, The yellow pre connect (crosslay) open/close valve is leaking on E43. With it closed, you can see the pressure slowly build up on the pump panel. Preconnect # - leaking; installed new valve. j

33 Workorder: V057 In Date: 0/4/009 Close Date: 0/3/009 Meter Reading: Slow fuel leak, appears to be leaking from the bottom of the water separator... Everything appears to be tight.. The pressure relief valve is sticking consistently and not improving with continued cycling. e43. Fuel leak; rep bottom part of fuel filter.. Rel valve inop; tested rel valve & tested ok. j R90PFILTER FUEL 333 RK33FUEL BOWL KIT NON-HEATED Workorder: V804 In Date: 09/30/008 Close Date: 03/0/009 Meter Reading: 3,64.00 speaker bracket inside cab needs replacement e43 Workorder: V64 In Date: 03/08/009 Close Date: 03//009 Meter Reading: The hurst power unit located on E43 has three broken mounts. Three of the four rubber mounts which locate the power unit within the frame have completely failed... the power unit is no longer secure within its frame. E43 Replcd (4) broken Hurst tool lebgs to tool cage & clean unit. j HR MOUNT VIBRATION (NEWER POWER UNITS 4 Installed new motor mounts for Hurst unit. j Workorder: V936 In Date: 03/9/009 Close Date: 03/7/009 Meter Reading: E43's Warning compartment open light and deck gun extended light in cab flashing without cause, possible electrical issue from excessive rain E43 Travel to Stn43; chkd eng; fnd loose connection at extend gun swtch & rep door ajar not going off; chkd swtchs; ok. j

34 Workorder: V06 In Date: 03/5/009 Close Date: 04/03/009 Meter Reading: 6, generator leaks fuel e 43. Drop off oil.. Fuel leak; rep fuel leak on gen. 3. Door open light on; readj rear door swtchs. 4. Ram fan inop; clnd out carb & fuel; ran/tested ok. j 5W40BSYN OIL BULK QTS Workorder: V735 In Date: 03//009 Close Date: 04/3/009 Meter Reading: 5, REPLACE R/REAR INSIDE TIRE, E-43 Replace R/rear inside tire E43 - Callaghan j Vendor?: CALLAGHAN Workorder: V5550 In Date: 06/05/008 Close Date: 04/7/009 Meter Reading: 34, HURST POWER UNIT SPUTTERS UNDER LOAD e43 replaced spark plug & tested. j BPR6ESSPARK PLUG 73 Workorder: V383 In Date: 04/07/009 Close Date: 05/05/009 Meter Reading:,0.00 netting clip broken for preconnect on driver side. needs replacement E43. Preconnect netting brkn; replcd netting.. Air horn inop; replcd air horn foot swtch. 3. Door open light obn; fnd no lights on. 4. Hurst unit no start; installed new plug. j

35 Workorder: V698 In Date: 04/0/009 Close Date: 05/08/009 Meter Reading:, red battery cable is frayed, located by the left front wheel e43. Chkd btry cables/tested ok.. water leak; rep fitting on pump. 3. A/C belts making noise; adj belts. 4. Coolant leak; rep leak at tank. j Workorder: V3475 In Date: 05//009 Close Date: 06/0/009 Meter Reading: 7, DOOR AJAR LIGHT ON, E-43 Door open light on; fnd water in connection. j Workorder: V49 In Date: 06/5/009 Close Date: 06/9/009 Meter Reading: 8,6.00 ON CALL VISTA SCREEN 0-7 E 43 Rep screw in HUR node in console; loose & moving arnd. j

36 Workorder: V3869 In Date: 06/06/009 Close Date: 06/0/009 Meter Reading: 8,6.00 B INSPECTION AND REPAIRS AS NEEDED E43 B-Inspection. Replcd btrys - bad. 3. Brakes squeel; brake dust; rem backing plates & clnd w/soap/water. 4. Pulls to the right - tires; swapped frnt tires; road tested ok. 5. Frnt hubs leak; over full; adj oil level/cln. 6. Cant chk rear tire press; valve exts msng; installed new extensions 7. Install air horn foot swtch for officer; Stn request. 8. Several body markers dim; door grnds; rep grnds & install new lights. NOTE: Air horn foot swtch charged out on another W/O. 9. Eng oil leak; return elbow split for turbo & breather; replcd elbow. 0. Fuel leak/lift pump; replcd lift pump. j 5W40BSYN OIL BULK QTS 0A-400CLAMP 4" RLIGHT MARKER LED RED 3500-YLIGHT MARKER LEDAMBER 39357USE WASHER-SEAL PUMP ISC FUEL TRANSFER NEW # WASHER SEAL ISB HOSE DRAIN OIL VALVE CAP /8 IN VALVE EXT 50R03ZCRLIGHT LED RED TIR 6 BATTERY EPA TAXBATTERY EPA TAX $.50 PER BATTERY FS0FILTER FUEL WIX 334 PS8689 FRAM HP-3DBATTERY 950CCA HP-3D HPH6349AOIL FILTER 5748 R90PFILTER FUEL Workorder: V4345 In Date: 06/5/009 Close Date: 07/06/009 Meter Reading:,8.00 left telelight stays on.. Replcd switch for spotlight.. Water leak in cab; resealed roof. j Workorder: V4364 In Date: 06/6/009 Close Date: 07/08/009 Meter Reading: 8, SPOT LIGHTS NOT SHUTTING OFF, E-43 Spot lights inop; replcd light switch. j

37 Workorder: V458 In Date: 07/06/009 Close Date: 07/5/009 Meter Reading:,96.00 door ajar light and buzzer stays on. e43. Traced door ajar problem to junction box under truck full of water; replcd junction box; rewired & replcd door adjar switch in ladder compt. j 5-64SWITCH DOOR CB-04BOX-CIRCUT BREAK BE040 Workorder: V4980 In Date: 07//009 Close Date: 07/7/009 Meter Reading: 8, RE43 K- SAW REPAIRED BY REGAN RE43 K- saw repaired by Regan j Vendor?: REGANS SMALL ENG Workorder: V485 In Date: 07/7/009 Close Date: 07/8/009 Meter Reading:,6.00 Driver side, rear passenger seatbelt top anchor fell out. Unable to use. e43 Rep rear seat that was coming loose. j Workorder: V4864 In Date: 07/8/009 Close Date: 07/8/009 Meter Reading: 8, the k- shuts off when the throttle is pulled E43. worked on K- saw & tested.. Preconnect leaking; readj valve. 3. Rear marker lights out; ran new wire for marker lights, j

38 Workorder: V4893 In Date: 07/0/009 Close Date: 07/8/009 Meter Reading:,6.00 driver side rear passenger seat belt bolt fell out again. No seat belt on that side.r43 rep left rear seat belt; tested & tested ok. j Workorder: V354 In Date: 05/5/009 Close Date: 07/9/009 Meter Reading:,9.00 At your convenience, would you bring by some valve stem extensions for the rear inner tires. I'm unable to measure the air pressure for the rear inner tires... there are no extensions currently in place. E43 Installed new valve stem on rear tires. j A/C inop; recharged sys. Marker lights out; fnd bad grnd. j Workorder: V457 In Date: 07/0/009 Close Date: 07/9/009 Meter Reading:,88.00 Windshield wipers take several attempts to turn off. e43. Replcd wiper switch.. Door open light on; fnd switch bad; readj switch. j Workorder: V537 In Date: 08/03/009 Close Date: 08/7/009 Meter Reading: 8, E-43 oil leak. Oil leak rep leak at filter.. Air leak; chkd for air leaks; fnd none at this time. j

39 Workorder: V533 In Date: 08/05/009 Close Date: 08/4/009 Meter Reading: 9,07.40 will not idle and does not reach full rpm. k just back from shop. needs repair. E-43.Saw inop; worked on saw; will send back to shop (K saw).. Chain saw inop; rem bad fuel & clnd carb. j Workorder: V59 In Date: 08/04/009 Close Date: 08/7/009 Meter Reading: 9,07.40 Need cycle oil for Station 43. Belt making noise; adj A/C belt & rep A/C brkt. j GROOVED TENSIONER OLD#39363 K08076BELT Workorder: V553 In Date: 08/4/009 Close Date: 08/7/009 Meter Reading: fan belts still making screeching noise when truck accelerates, work request made last week and mechanic came out and stated that a part was needed and would return the following day to correct, however no one returned E-43. Belts making noise; readj belts.. Door open light on; readj all door switches. j Workorder: V5533 In Date: 08/4/009 Close Date: 08/7/009 Meter Reading: K- saw won't start, work request made previously, saw still not serviced. Worked on K saw; will send back to shop.. Ram fan inop; rem gas & put new gas in tank. j

40 Workorder: V554 In Date: 08/5/009 Close Date: 08/7/009 Meter Reading: valve for # preconnect leaks, charging the hose. E43. readj # discharge valve that was leaking.. Chain saw inop; clnd carb & tested. 3,.Air horns inop; rep connection on solenoid. j Workorder: V5565 In Date: 08/6/009 Close Date: 08/7/009 Meter Reading: 9,38.00 E43's K- needs to be checked out. If you run it at high revs the engine starts breaking up almost to a stall. Also, could you ask Tommy about the tension bar for E43. The engine is still squealing. Air leak; no air leaks at this time.. Spotlight inop; rep bad connection. j Workorder: V5969 In Date: 09/0/009 Close Date: 09/30/009 Meter Reading: 9,69.60 Valve on No. crosslay leaking, guage builds pressure while fully closed. e43. ran pump for second time & fnd no leaks.. Installed velcro strps in rear compt. j VALVE KIT / IN VALVE KIT 3 IN AKRON Workorder: V6037 In Date: 09/04/009 Close Date: 09/30/009 Meter Reading:,7.00 E43's deck gun is leaking all the time from the drain, please check.. Ran pump at 50PSI & fnd no leaks at deck gun.. Readj all valve linkages. j

41 Workorder: V663 In Date: 09/0/009 Close Date: 09/30/009 Meter Reading: 9, REPAIR DOME LTS E43 Mount tools in rear compt. j Workorder: V6530 In Date: 09/9/009 Close Date: /06/009 Meter Reading: 3.00 left siren speaker not working. e43. R/R siren speaker.. Relief valve inop; tested valve & tested ok. j SD-0RSIREN DRIVER Workorder: V663 In Date: 0/0/009 Close Date: /06/009 Meter Reading: 0,58.60 ENGINE BELTS MAKING NOISE, E-43 Installed belts & belt tensioner. j K08076BELT Workorder: V6760 In Date: 0/08/009 Close Date: //009 Meter Reading:.40 right telelight not working. E43. Rep right side spotlight.. Primer inop; cln/lubed. j

42 Workorder: V7597 In Date: //009 Close Date: /08/009 Meter Reading: The officer's side telescoping scene light quit working (all three bulbs)...repositioning and telescoping did not fix it... ***We need a 4" composite (concrete/steel) blade for our loaner K saw, please*** e43 Rep bad connection in spotlight. j Workorder: V7687 In Date: /6/009 Close Date: /0/009 Meter Reading: 0, repair vent saw (outside agency-regan's small engine service) Repair vent saw - Regans j HALF HANDLE HANDLE HALF Vendor?: REGANS SMALL ENG Workorder: V8543 In Date: //009 Close Date: /9/009 Meter Reading:, REPAIR SAW E 43REGAN Vendor?: REAGANS Workorder: V864 In Date: /8/009 Close Date: 0/08/00 Meter Reading:, ON CALL COOLANT LEAK E43 Coolant leak; rep leak & tested. j

43 Workorder: V8353 In Date: /5/009 Close Date: 0/4/00 Meter Reading: 6.00 Chainsaw, O-ring seal on bar/chain oil reservior cap missing. will not hold oil. e43 Rep oil cap & cln carb & tested. j Workorder: V8530 In Date: //009 Close Date: 0/4/00 Meter Reading: 6.00 right telelight not working. E43. Rep right side spotlight.. Water leak; rep/replc brass fitting on pump cooler. j Workorder: V8579 In Date: /5/009 Close Date: 0/4/00 Meter Reading:, Hale foam system turns itself off and reads "NoPr" on screen after approx 5 sec of being turned on. must repeatedly turn system back on in order to get foam at nozzle. E43. Ran foam sys & tested ok.. No t-signals; rep switch. j Workorder: V8585 In Date: /6/009 Close Date: 0/4/00 Meter Reading: Right side (officer's side) telelight is inoperative.e43. # crosslay continues to fill with water with the gate valve in the closed position (slow leak) 3. Master intake valve red lamp no longer illuminates. E43. Readj crosslay valve that was leaking.. Recalibrated foam & water gauges. 3. Rep master intake light that was not working. 4. Rep air leaks. j 47SOLENOID INS CONT DUTY

44 Workorder: V804 In Date: /08/009 Close Date: 0/5/00 Meter Reading: 4.00 right side telescoping scene (spot) light inoperative. Rep bad connetion in light.. Water leak; rep fitting on pump. j Workorder: V8885 In Date: 0/07/00 Close Date: 0//00 Meter Reading:, air leaks e43 Traced out air leaks. j Workorder: V8985 In Date: 0//00 Close Date: 0//00 Meter Reading: 5.30 relief valve is activating very slow. passenger side cross lay is leaking. E 43 tested relief valve & tested ok. j Workorder: V9834 In Date: 0/09/00 Close Date: 03/03/00 Meter Reading:, Charging contacts on vehicle mounted TIC charger are bent and not allowing TIC to charge correctly or not at all. e43 Rep contacts on TIC charger & tested. j

45 Workorder: V9989 In Date: 0/6/00 Close Date: 03/04/00 Meter Reading:, on call crosslay valve leaking e43 Went to Stn43; ck valve opn; valve inop; rem linkage pipe & valve; rebuilt valve; reinstalled all parts; ck opn; ck ok; return home. j VALVE KIT IN SS VALVE Workorder: V99 In Date: 0//00 Close Date: 03/0/00 Meter Reading:, during a fire call yesterday, the sawsall was being used when it broke in half. a replacement is needed for engine 43. Call Stn43; direct them to have Chief Beelsey approve & notify W. Chambers. j Workorder: V9406 In Date: 0/5/00 Close Date: 03/9/00 Meter Reading: One section (right side)of strobe lights out on E43's light bar. Rep LED light that was out in light bar. j Workorder: V30389 In Date: 03/0/00 Close Date: 03/5/00 Meter Reading: 3,8.00 Please repair light bar on E43. The right half has lights out. LED out on light bar - replcd. j LED / RED

46 Workorder: V3080 In Date: 03/7/00 Close Date: 04//00 Meter Reading: 3, Relief valve not working properly. VERY slow to close and reset when performing morning check out. e43 tested valve & tested ok. j Workorder: V38 In Date: 04/6/00 Close Date: 04/30/00 Meter Reading:, door ajar light on (on-call) E43 Door open lite on; rep ladder compt door. j Workorder: V305 In Date: 03/5/00 Close Date: 05/0/00 Meter Reading: 3, k- pull cord about to break, and wont start installed 00 inverter for tic & sys. j 3WA6POWER INVERTER 375 AMP

47 Workorder: V3047 In Date: 03/6/00 Close Date: 05/5/00 Meter Reading: 3, C INSPECTION AND REPAIRS AS NEEDED E43

48 C-Inspection. Svc rear axle. 3. Svc T-case. 4. Svc air dryer. 5. Replc frnt shocks; bottom bolts on both shocks rusted on; had to use oil/heat to remove. 6. Replc all (4) btrys; cln terms. 7. Svc P/S. 8. Torque u-bolts front/rear. 9. Rep brkn wires at connector for R/side pump panel walic waylite; replc both LED lites; replc LED lite i L- compt. 0. Rem eng fan; replc alt belt/tensioner; replc both A/C belts; reinstall fan; run eng; reajd belts.. Drain cooling sys; rem trans cooler; travel to C/S to rem fittings; install new cooler; refill coolant.. Replc L/side rear marker lite; LED's were half out on lite. 3. Replc A/C vents on rear red deot sys; cab vents were msng. 4. LED display bad on throttle cntrl on pump panel; replce display. 5. Replc switch for quartz lites;hard to turn on/off. 6. Trilock on R/side ump panel brin; 7. All (4) A/C dah vents brkn; replc all (4). 8. Replc all brkn discharge chains for caps; rplace all brkn intake chains for caps. 9. Rem leaking eng trans pump; rem L/side frnt fender & rem pump; install new trans pump; reinstall fendeer; run/chk; ok. 0. Rem intake relief valve & rep, install intake relieft valve..replc LED lite on pump panel.. Install master btry on/off switch switch was hard to turn. 3; Remove discharge side relief valve & rebuild, install new chkc valve; isntall () new hose fittings; reinstall relief valve. 4. Rem R/side rolleer for preconect & install bottom clip for net. 5. Rebuild master drain valve. 6. Replc "Batton " & Ing on" switchs on dash board; green lites wld not come on. 7. Rem master intake valve on L/side 6" Instake valve & replce lite switches for open/closed lites; lites were not coming on. j C90PSC0CDCR STRIP LIGHT STEADY WHITE STRAINER HALE RELIEF VALVE W/ VULCANIZED SEAT SPRING RELIEF VALVE HALE CAP RADIATOR 0 LB PISTON RELIEF VALVE HALE 07796DRYER KIT AD9 -NEW 07800VALVE CHECK AD9 08-FBEADED CHAIN W/CONN 40--5COOLER 403 5W40BSYN OIL BULK QTS 89BULB TRANS FILTER ALLISON PLUG THREAD 30460THREAD PLUG BATTERY ON DISPLAY IGNITION ON DISPLAY MARKER LIGHT WASHER DRAIN PLUG 39447OIL DRAIN PLUG CUMMINS PUMP ISC FUEL TRANSFER NEW # WASHER SEAL ISB WASHER SEAL GROOVED TENSIONER OLD# A/F HONDA 70-ZE TPM/QG HALE REPAIR KIT GROTE ON-OFF WEATHERPROOF USE 6H0 COPMPARTMENT LIGHT SHOCK FRONT ENGINE VENT A/C LH VENT A/C RH 7R30070 DIFFUSER A/C 3.5 IN AIR FILTER 70-ZE-55 HONDA 75908SWITCH BATTERY MASTER 300A 78R536078R5360M PK FILTER AIR COND PURGE VALVE KIT TOGGLE GUARD 9440BELT 9480BELT BATTERY EPA TAXBATTERY EPA TAX $.50 PER BATTERY BPR5ESSPARK PLUG 7734 CA893AIR FILTER WIX ELA0-ATHROTTLE EXCEL CUMMINS IS SERIES FG87904MFG S FILTER P/S NEW STYLE FGQ79699GASKET-P/S FILTER NEW STYLE

49 FS0FILTER FUEL WIX 334 PS8689 FRAM HP-3DBATTERY 950CCA HP-3D HPH6349AOIL FILTER 5748 K08076BELT PR WIX FILTER WATER R90PFILTER FUEL Workorder: V3907 In Date: 05/0/00 Close Date: 06/04/00 Meter Reading: 4,55.00 during pump testing on 4/30-B shift noticed /0 engine speed connection not working. Also digital pump discharge guage hard to read in sunlight due to LED lights broken on display. This might already be on order. E43 Chkd opn of pump & tested ok. j Workorder: V3046 In Date: 05/06/00 Close Date: 06/04/00 Meter Reading: 4,3.80 /0 engine speed port not working, this was discovered during the pump test. E43 Rep cable for pump RPMS. j Workorder: V366 In Date: 05/8/00 Close Date: 06/09/00 Meter Reading: 4, the stihl chain saw on engine 43 will not start up. Clnd carb & tested. j

50 Workorder: V3450 In Date: 05/6/00 Close Date: 06/8/00 Meter Reading: 4, K saw starter cord handle is broken. needs to be replaced to start safely. True assest number is F00758 E43 sent to shop for repair. j Workorder: V373 In Date: 06/07/00 Close Date: 06/8/00 Meter Reading: 4, T.I.C. screen is not clear and the readings seem to be incorrect.. Chkd opn of gauge & tested ok.. T-signals inop; rep connection in left rear frame rail. j Workorder: V374 In Date: 06/07/00 Close Date: 07//00 Meter Reading: 4, siren cannot be operated by utilizing the horn located on the steering wheel. E43 Replc siren head. Workorder: V33333 In Date: 07/05/00 Close Date: 07/3/00 Meter Reading: 5,3.50 pressure relief valve has a long delay while setting and doesnt seem to work correctly E43 Went to 43; FF on shift said relief valve working good; we ran pump & is reacting well within 30PSI; just a little slow releasing. j

51 Workorder: V34645 In Date: 08/3/00 Close Date: 09/9/00 Meter Reading: 9, Replace 4 rear tires (outside agency-boulevard tire) E43 Replc (4) rear tires E43 - Boulevard j Vendor?: BOULEVARD TIRE Workorder: V34875 In Date: 09//00 Close Date: 0/05/00 Meter Reading: 6, need lugnuts caps for front wheel. E43. Replc msng/brkn lugnut cvrs.. Rep brkn strut brkt on L- compt door. j BRACKET LEFT DH ACX-84534LUG NUT COVER PK0 EAA UGSS783UQ STRUT-LIFT 3 Workorder: V35043 In Date: 09/9/00 Close Date: 0/8/00 Meter Reading: 6, It appears that the front bolts to the engine intake manifold are missing and intake gasket it slipping out. E43 Will need to come to shop for repair. j Workorder: V3453 In Date: 08/6/00 Close Date: 0/0/00 Meter Reading: 6,5.00 Left side / telescoping quartz spot/scene light has one () of two () bulbs 0-7. E43. Rep bad connection in light & tested.. Air ride seat inop; rep air line; installed new one. j

52 Workorder: V34979 In Date: 09/6/00 Close Date: 0/0/00 Meter Reading: 6, for your information: while responding to a call, engine 43 shut completely down while making a right turn. after letting it sit for a few seconds with everything shut off, it started back up and was ok after that. e43 Chkd truck road tested; NFP w/truck. j RALENS SPLIT RED/AMBER 50R03ZCRLIGHT LED RED TIR RULIGHT Workorder: V35083 In Date: 09//00 Close Date: 0/0/00 Meter Reading: 6, Drivers air seat not working.. will not inflate. Rep air line on air seat. j Workorder: V36057 In Date: /0/00 Close Date: /0/00 Meter Reading: 7,85.00 Valve/plumbing on right side 3/4" preconnect (yellow) leaking allowing bottom sections of hose to partially charge with water. Almost could not get out of hosebed on fire call last night. PLEASE FIX E43 () TRAVELED TO STATION 43 TO REPAIR RIGHT SIDE PRECONNECT VALVE THAT ISN'T CLOSING OFF ALL THE WAY ON E43. REMOVED VALVE, ADJUSTED LINKAGE AND REINSTALLED VALVE AND TESTED. OK. J.W.

53 Workorder: V3603 In Date: /04/00 Close Date: /3/00 Meter Reading: 7, screw/nail in front left tire E43 () TRAVELED TO STATION 43 TO REPAIR A TIRE ON E43. REMOVED A NAIL FROM THE TIRE. WAS NOT LEAKING AIR AFTER REMOVAL OF THE NAIL. OK. () COMPARTMENT LIGHT WAS STAYING ON. CHECKED AND FOUND THE DOOR SWITCH UNPLUGGED. REPAIRED AND TESTED OK. (3) REPAIRED SLIDE OUT TRAY THAT WAS HARD TO OPEN. OK. Workorder: V36553 In Date: /8/00 Close Date: /4/00 Meter Reading: 7, Pump panel lights and telescoping scene lights 0-7. Also, right side 3/4 " preconnect still leaking and charging hose in hosebed E43 () TRAVELED TO STATION 43 TO REPAIR PUMP PANEL LIGHTS AND TELESCOPING SCENE LIGHTS ON E43 THAT WASN'T WORKING. TESTED ALL LIGHTS AND FOUND THAT THE DRIVER OPERATOR DID NOT SEEM TO KNOW HOW TO TURN THEM ON. OK. J.W. Workorder: V36448 In Date: /5/00 Close Date: /5/00 Meter Reading: 7, Left A/C compressor on engine appears to have a bolt missing on mounting bracket. Top/left rear compartment door latch is loose..needs adjusting. e43 () TRAVELED TO STATION 43 TO REPLACE A BOLT ON THE A/C COMPRESSOR OF E43 THAT WAS NOTED. INSTALLED NEW BOLT INTO THE A/C COMPRESSOR AND MOUNT. OK. J.W.

54 Workorder: V3639 In Date: /06/00 Close Date: /6/00 Meter Reading: 7, found air leaking from valve on front tank. Also front suction air valve is not working properly. The valve did not open during fire training this morning. Not sure if these are related.e43 () TRAVELED TO ST43 TO REPAIR AIR LEAK ON E43 FRONT AIR TANK AND CHECK OUT FRONT SUCTION VALVE. TESTED FRONT SUCTION VALVE AND DID NOT FIND ANYTHING NOT WORKING. J.W. Workorder: V3539 In Date: 09/8/00 Close Date: //00 Meter Reading: 6, WONT START E43 () E43 WON'T START. FOUND STARTER BAD. REPLACED WITH NEW ONE. E43 THEN STARTED. J.W STARTER S S LENS LENS CLEAR Workorder: V3540 In Date: 0/05/00 Close Date: //00 Meter Reading: 7,57.90 chain saw 0-07 e43 () CHAIN SAW WON'T RUN ON E43 UNIT WAS TAKEN TO THE COUNTY FR SHOP. J.W.

55 Workorder: V36676 In Date: /6/00 Close Date: 0/03/0 Meter Reading: 8, Engine 43 foam inductor malfuctioning. When foam is activated, the engine rpm drops. contact Dave Allen at 43B for more info E43 () TRAVELED TO ST-43 TO REPAIR FOAM RPM PROBLEM ON E43. TRACED OUT PROBLEM WITH FOAM SYSTEM. FOUND BAD WIRE GROUND. REPAIRED. () CHECKED OUT TANK FILL VALVE FOR LEAKING HO. READJUSTED VALVE AND LEAK STOPPED. J.W.

56 Workorder: V37303 In Date: /0/00 Close Date: 0/05/0 Meter Reading: 9,9.00 B INSPECTION AND REPAIRS AS NEEDED E 43. remove exhaust manifold's, remove broken bolts in head. install new manifolds, bolts, gaskets, and spacers.. B inspection 3. replace a/c compressor for cab rear a/c, replace dryer, flush out system, replace a/c compressor lines, remove engine fan replace a/c belt. evacuate and charge system. 4. driver stated rear a/c water leaking on cab floor, reseal a/c unit 5. replace water pump, replace coolant tank sight glass, tighten coolant hoses 6. check for air leak, found air ride bags leaking for cab, replace both bags, recheck for air leak, tighten numerours fittings that were leaking, and repalce 3 fittings on foot valve. 7. install battery charger, and auto-eject 0939CHARGER AUTO EJECT 0 AERO OTL395 5W40BSYN OIL BULK QTS O RING 39794SEAL O RING MANIFOLD EXHAUST EXHAUST GASKET C USE GASKET OIL EXHAUST MANIFOLD EXH. MAN. BOLT 39455SPACER EXH. MAN PUMP-WATER ISC REBUILT 45S08-693BS 90 DEGREE FEMALE W/SERVICE PORT 45S BS A/C FITTING STEEL COMPRESSOR A/C R A RED DOT DRIER 77 78R536078R5360M PK FILTER AIR COND 80L7-348 ESTER OIL E7 9440BELT FS0FILTER FUEL WIX 334 PS8689 FRAM HPH6349AOIL FILTER 5748 LML-0-003CAB AIR BAG IS4007 PR WIX FILTER WATER R90PFILTER FUEL 333 VML-T43T348 SIGHT GLASS 4 6 Workorder: V37009 In Date: /08/00 Close Date: 0//0 Meter Reading: 8, Foam inductor malfuctioning. When foam inducter is engaged, engine rpm drops. e43 Rep bad power & grnd wire; problem rep. j

57 Workorder: V37037 In Date: /09/00 Close Date: 0//0 Meter Reading: 8, The K on E-43 had the pull rope pulled out of it while trying to start it during moring check out Rep pull cord on K. j Workorder: V3770 In Date: /5/00 Close Date: 0//0 Meter Reading: 8,96.40 E43 LEAKING RADIATOR FLUID FROM TOP HOSE.. Rep hose clamps on top hose.. Wtr gauge inop; recalibrated wtr level gauge. j Workorder: V38843 In Date: 0/8/0 Close Date: 03/03/0 Meter Reading: 0,0.00 CHECK ENG STOP ENG LT ON E 43 Change out fuel filter/sensor on eng; pull off ECM plus off side of motor; chk wiring to pump throttle & rep; fnd pump throttle on pump panel bad; replc w/new; C/O code - all inactive; clear & test drive; all codes gone. j ELA0-ATHROTTLE EXCEL CUMMINS IS SERIES FS0FILTER FUEL WIX 334 PS8689 FRAM Workorder: V37844 In Date: 0/7/0 Close Date: 03/08/0 Meter Reading: 9, While pumping a dumpster fire, I engaged the Hale Foam system and the pump lost pressure and then fluctuated pressures. I the disenguaged the Foam system and my pressure returned to normal. E43 Chkd foam sys & tested ok; ran new grnd wire to computer. j

58 Workorder: V384 In Date: 0/0/0 Close Date: 03/08/0 Meter Reading: 9,83.00 deck gun swivel lock broke. not able to lock so it rotates. looks like its just the metal spring. E43 Replcd lock on swivel & tested. j X70DECK GUN ROTATION LOCK INSERT Workorder: V38543 In Date: 0/5/0 Close Date: 03/09/0 Meter Reading: 9, the backup alarm on engine 43 is not sounding. Replcd backup alarm & tested. j Workorder: V38774 In Date: 0/5/0 Close Date: 03/09/0 Meter Reading: 0,54.00 Front driver's side warning light on side of hood - led bulbs out. e43. Rep LED light out on hood.. Adj rear door latch that was hard to open. j Workorder: V38569 In Date: 0/6/0 Close Date: 03/5/0 Meter Reading: 9, digital pump discharge guage on pump panel-last digit unable to read. mechanic stated already replaced but is now not working again. E43 Replcd unit on --; tested gauge & tested ok. j IOA00A00DISPLAY MODULE REBUILD ONLY SEND IN

59 Workorder: V3863 In Date: 0/8/0 Close Date: 03/5/0 Meter Reading: 0, the number crosslay (yellow) valve leaks, which caused the crosslay to charge in its bed while the engine was pumping at a brus fire. when the drain valve is opened, a small steady stream of water keeps flowing out. E43 Chkd preconnect for valve leaking; fnd no valve leaking. j REFER TO WO AND Workorder: V38633 In Date: 0/8/0 Close Date: 03/5/0 Meter Reading: 0, when the foam pump is turned on, the engine rpm's oscillates up and down. E43 Ran pump; FNP w/pump. j Workorder: V3954 In Date: 03/6/0 Close Date: 03/8/0 Meter Reading: 0, PUMP SURGES UP TO 00 PSI WHEN FOAM SYSTEM IS ACTIVATED E43. travel to sta-43.check out surge in pump 3. travel to central shop for parts, travel back to sta replace master pump gauge 5. check foam system, called hale products spoke with sal was told it might be a bad ground. check all grounds and clean. recheck system still surges, spoke with hale and was told it might be in the FRC throttle system. 5W40QSYN OIL QT IOA00A00DISPLAY MODULE REBUILD ONLY SEND IN

60 Workorder: V38976 In Date: 03/05/0 Close Date: 04/06/0 Meter Reading: 0,389.0 lightbar mounted spotlight is not working. E43 rep spotlight that was out. j 08880ALL STEER SWITCH FREIGHTSHIPPING CHARGES 5 Workorder: V38993 In Date: 03/06/0 Close Date: 04/06/0 Meter Reading: 0, Intake pressure relief valve activates while in tank to pump, resulting in dumping tank water on the ground. E 43. Ran pump & chkd opn of pump & tested ok. j REFER TO WO37779 AND 3863 Workorder: V38994 In Date: 03/06/0 Close Date: 04/06/0 Meter Reading: 0, remote roof spot light is out E43 Rep handheld spotlight. j Workorder: V3903 In Date: 03/07/0 Close Date: 04/06/0 Meter Reading: 0, spot light on top of the engine is out. E43 rep rear spotlight. j FM CONTROL UNIT RETROFIT KIT

61 Workorder: V3909 In Date: 03/0/0 Close Date: 04/06/0 Meter Reading: 0, Thermal imaging camera is not charging tic properly and indicator light is not functioning E43 replcd TIC charger. j Workorder: V390 In Date: 03/0/0 Close Date: 04/06/0 Meter Reading: 0, pinhole is located in the soft sleve supply line on engine E 43 DC will order new hose. j Workorder: V398 In Date: 03/8/0 Close Date: 04//0 Meter Reading: 0, Intake Pressure Relief Valve opens and dumps tank water on the ground when excessive pressure is put on the pressure relief valve while exercising it. This should not happen. E 43. travel to sta-43 check relief valve, travel to s/shop for parts, travel back to sta-43. replace check valve in TPM system, still dumps water, per ED.E will bring to shop for repairs 3. Assist in t-shooting eng mgmt pump panel cntrol & foam sys. 4. install new foam sys controller in pump panel; cut to fit pump panel; wire into sys; works ok at this time. 5. Replc switch on L/side telecope light wire in new one; brkn on pump panel.

62 Workorder: V39830 In Date: 04//0 Close Date: 04//0 Meter Reading:,98.00 E 43 unable to pass primer test until.5inch intake relief valve as capped. Same Intake valve now leaking after test. Pump panel trans temp guage OOS.. C/O truck; fnd slow relief valve cntrl; replc controller on pump panel bad; works ok at this time.. Fnd flow meter not ; C/O - fnd wire off - rep; reading ok at this time; C/O foam system. 3. Rebuild transfer valve under truck for water; dumping out - ok.(see W.O. 398) 4. R/R foam head on motor; C/O gear, etc. 5. C/O temp on trans gauge; looks to be ok at this time. j STRAINER CONTROL VALVE FM CONTROL UNIT RETROFIT KIT SLIDE CONTROL GROTE ON-OFF WEATHERPROOF PM CONTROL TOGGLE GUARD ELA0-ATHROTTLE EXCEL CUMMINS IS SERIES Workorder: V39303 In Date: 03/0/0 Close Date: 05/3/0 Meter Reading: 0, left telelight is not working. E43 Rep bad connection on light. j Workorder: V40579 In Date: 05//0 Close Date: 06/03/0 Meter Reading:, driver side head light is out. Sta 43.. Replc headlight & adjusted.. Rep air ride seat that was not working. j H6054USE CV TYPE SEALED BEAM 4

63 Workorder: V433 In Date: 06/06/0 Close Date: 06/07/0 Meter Reading:,84.00 Call-out. E43 rough idle, check engine light. E43 rough idle; chk eng light; code 77 & code for heating; R/R transient heatsink; still running rough; injection cntrl valve fault; swapped into spare from shop. j 39440DIODE SUPPRESSOR Workorder: V430 In Date: 06/06/0 Close Date: 06/08/0 Meter Reading:,84.00 Won't run. Towed to shop Wont run, towed to shop - Westway j Vendor?: WESTWAY Workorder: V40655 In Date: 05/7/0 Close Date: 06/09/0 Meter Reading:, Pressure relief valve is still dumping tank water on the ground from the intake pressure relief valve being ingauged just on tank water. Sta 43. Ran pump & chkd op n of pump & tested ok. j Workorder: V4080 In Date: 05/3/0 Close Date: 06/09/0 Meter Reading:, # preconnect line (crosslay/yellow nozzle) possibly has slow leak,filling hose line.line was drained earlier and hose has filled up again.confirmed valve was closed. Sta 43. Readj valve & tested. j VALVE SS IN

64 Workorder: V453 In Date: 06/06/0 Close Date: 06/3/0 Meter Reading:,84.00 injection pump. Test drove - has code ; needs ECM & poss injection cntrl valve. j Workorder: V4308 In Date: 06/5/0 Close Date: 06/3/0 Meter Reading: 3, A inspection, ear on a/c broken. A-Svc - fill wtr tank to test pump.. Fnd A/C omp bolt brkn; loosen belt & R/R bolt; ran & ck ok. 3. Fnd L/hood strobes out; R/R light asy; R/R L/marker lens/bulb; ck ok. 4. Quality check - Hines. 5. Fnd mirror brkt; mnt bolts loose - tightened bolts; ck ok. 6. R/R compt door shocks; R/R rear A/C filters. 7. Fnd # x-lay valve leaking; drained tank, rem valve; rebuilt valve; installed/greased; R/R draiin hose fitting; filled tank; ck ok. 8. Ck for coolant leaks; press test, tightened clamps; toppd off tank; ck ok. 9. Cln btry/trash line compt slides; cln, blew off & lubed slides/locks; ck opn - ck ok. 0. Ck for eng codes; test drove; ck codes; ck ok. j 94BULB 50R03ZCRLIGHT LED RED TIR 6 5-4WIPER BLADES ANCO VALVE KIT IN SS VALVE R536078R5360M PK FILTER AIR COND 953AMBER LENS EAA UGSS783UQ STRUT-LIFT 3 3 Workorder: V46 In Date: 07/9/0 Close Date: 07/9/0 Meter Reading: 3,38.00 Deliver hurst hoses to sta 43. parts only no labor HOSE HURST 6 ORANGE 353R09USE 353R403 HURST HOSE 6 GREEN

65 Workorder: V37779 In Date: 0//0 Close Date: 07/8/0 Meter Reading: 8,96.40 Intake relief valve will not reseat. Leaking. Temporarily shut with a.5" cap from brush 43. E43 REFER TO WO AND 3863 AK Workorder: V3963 In Date: 03/4/0 Close Date: 08/05/0 Meter Reading: 0, Low oil...none at station work completed Workorder: V489 In Date: 07/08/0 Close Date: 08/08/0 Meter Reading: 3,38.00 foam started flowing after 0 minutes of engagement. tested system and tested ok Workorder: V47 In Date: 07//0 Close Date: 08/5/0 Meter Reading: 4, fyi: added two quarts of motor oil to engine 43 this morning. Sta 43. Dropped off oil. j

66 Workorder: V470 In Date: 08/0/0 Close Date: 09//0 Meter Reading: 4, Inside door handle on drivers door, connected in 3 places, section has separated, stripped around bolt holding it in E 43 replaced door handle and tested repaired rear air pack that was falling out HANDLE DOOR Workorder: V430 In Date: 08/4/0 Close Date: 09/9/0 Meter Reading: 4, Fuel Gauge oos. Registering Empty although tank is Full. Sta 43. checked gauges and tested ok Workorder: V4307 In Date: 08/6/0 Close Date: 09/9/0 Meter Reading: 4, fyi: added two quarts of motor oil to engine 43 this morning. Sta 43. quarts of oil added by crew.

67 Workorder: V43474 In Date: 09/06/0 Close Date: 09/7/0 Meter Reading: 5,64.00 C INSPECTION AND REPAIRS AS NEEDED E 43. C insp.. repalce 3 a/c dash vents on dash board 3. driver stated engine uses oil, check for leak none found the hole time vehicle was in the shop. 4. replace rear cab a/c filter 5. L-3 compt.door hold open broken r&r strut 6. replace ground ladder heat sensors 7. L/S upeer and lower red LED lites / out, replace both lites 8. R/S upper and lower red LED lites / out, replace both lites 9. middle tail board marker lite inop, repair ground wire 0. L/S lower red LED lite inop, replace lite. R- compt. door hold open broken, r&r strut. r/side and l/s pump panel lites / out, replace both pump panel lites 3. RPM counter on pump panel inop, found cable broken replace cable and ends 4. no power to foam fill pump trace wiring found wire connected to node pos. in pump panel and fuse blown, run wire to solonoid for quatrz lite, then found pump frozen replace foam fill pump. 5. found FRC throttle excel on pump panel LED's / out, replace throttle excel 6. failed vacumn test, adjust all discharge valve stops, recheck and passed test 7. service air drier 8. service trans. 9. battery tray hard to open, clean tracks and lube 0. r/rear service brake chamber hose had hole in it and leaking, replace hoses on both sides.. found tail pipe separated from exhaust pipe, replace clamp and tighten bracket that hold tail pipe in place. l/side intake drain leaking, remove and replace O rings. 3. fill water tank and road test C90PSC0CDCR STRIP LIGHT STEADY WHITE 07796DRYER KIT AD9 -NEW 07800VALVE CHECK AD9 5W40BSYN OIL BULK QTS TRANS FILTER ALLISON 39898HOSE & FITTING ASSY PUMP FLOJET V 50R03ZCRLIGHT LED RED TIR 6 60R00FRR600 SERIES RED LED W/O FLANGE VENT A/C LH 78R536078R5360M PK FILTER AIR COND PURGE VALVE KIT EAA UGSS783UQ STRUT-LIFT ELA0-ATHROTTLE EXCEL CUMMINS IS SERIES FS0FILTER FUEL WIX 334 PS8689 FRAM HPH6349AOIL FILTER 5748 MSA50-A0MANSAVER COVER R90PFILTER FUEL 333 TRANSYNDALLISON TRANS FLUID GAL

68 Workorder: V44073 In Date: 0/0/0 Close Date: 0/07/0 Meter Reading: 3, Hydraulic arm broken inside medical compartment door E43 replaced arm on med compartment water leak repaired flange on deck gun Workorder: V448 In Date: 0/05/0 Close Date: 0//0 Meter Reading: 3, Air leak. low air alarm every time the truck is started. No audible leak detected. E43 checked for air leaks found none at this time Workorder: V4445 In Date: 0/09/0 Close Date: 0//0 Meter Reading: 5,54.00 The engine throttles up and down on it's own when it is in pump gear and flowing foam. E 43 ran pump and found no poblem with pump repaired rear slide out tray Workorder: V473 In Date: 06/07/0 Close Date: /0/0 Meter Reading:,84.00 Outside repair at Cummins, ECM bent. Repair Cummins j(//) Vendor?: CUMMINS

69 Workorder: V4440 In Date: 0/4/0 Meter Reading: Close Date: /07/0 TIC does not charge in holder and I would like the TIC and one box light switched (location) R REPAIRED TIC CHARGER AND TESTED Workorder: V44464 In Date: 0/8/0 Meter Reading: Close Date: /07/0 "ok to pump" light bulb is out. Sta 43. REPAIRED PUMP SWITCH AND TESTED Workorder: V4488 In Date: 0/3/0 Meter Reading: Close Date: /4/0 The K stalls when in idle. Sta 43.. Clnd carb & tested.. Rep power 0 cord for charger. j Workorder: V4490 In Date: /0/0 Meter Reading: Close Date: //0 front flasher emergency light officer's side is out, sta CFRONT SHOCKS installed new light and tested repaired ram fan and tested

70 Workorder: V4536 In Date: //0 Close Date: /9/0 Replace front tires. Meter Reading: Replace front tires.bp Vendor?: BOULEVARD Workorder: V4498 In Date: /04/0 Meter Reading: Close Date: /0/0 Bleeder valves in discharges, 3, 4 leaking while under pressure. Tried multiple attempts to lubricate/stop leak, still leaks E43 cleaned sand out of valves Workorder: V45096 In Date: //0 Meter Reading: Close Date: /0/0 Tension Rods in the medical and extrication compartment doors are broken, doors swing freely open E43 replaced pistion on door replaced spot light bulbs EAA UGSS783UQ STRUT-LIFT LB-D30BULB QUARTZ HAL. V 50W 4 Workorder: V4536 In Date: //0 Meter Reading: Close Date: //0 Discharges #,,3, & 4 bleeder valves are all leaking. Sta 43 repaired all valves that were leaking water SEAL SVS DRAIN VALVE

71 Workorder: V455 In Date: /30/0 Meter Reading: Close Date: //0 for your information: added one quart of engine oil to engine 43 this morning. jrm. Check for oil leak. Sta 43 checked for oil leak Workorder: V456 In Date: /04/0 Meter Reading: Close Date: //0 pressure relief valve stuck, not reseting. tried multiple times with no success E 43 hooked up to hydrant and cleaned out valve all tested ok Workorder: V45354 In Date: //0 Meter Reading: Close Date: /6/0 driver side front tire tread is down to wear bars, measures at a 4 on gauge. All other tires appear to have good tread left. Sta 43 CHECK TIRES WILL MONITOR Workorder: V45796 In Date: //0 Meter Reading: Close Date: 0/03/0 Captain side light box not working, Sta 43 repaired light and tested coolent leak, repaired leak and tested

72 Workorder: V45783 In Date: //0 Close Date: 0/3/0 Meter Reading: 7,0.00 circle D light bulb is out and new one is needed, also two door brackets are broken allowing compartment doors to swing out uncontrolled when opened E 43 REPLACED DOOR PISTIONS. 4 EAA UGSS783UQ STRUT-LIFT Workorder: V45838 In Date: /3/0 Close Date: 0/3/0 Meter Reading: 7,0.00 alarm sensor in truck will not shut off while in drive.tried multiple times raising- lowering and checking wires/ground.still not working alarm will not shut off, Sta 43 REPLACE MUD FLAP. B40LP-SMUD FLAP 4 X 4 Workorder: V4639 In Date: 0/07/0 Close Date: 0/3/0 Meter Reading: 7,96.00 docking station for light boxes between the driver and captian are not holding a charge. E 43 REPAIRED LIGHTS IN CAB THAT HAD BLOWN FUSE. Workorder: V46608 In Date: 0/7/0 Close Date: 0/7/0 Meter Reading: 8, box lights 0-7, Sta 43 REPAIRED LIGHT BOX THAT HAD BAD CONNECTION

73 Workorder: V46609 In Date: 0/7/0 Close Date: 0/7/0 Meter Reading: 8,40.00 system bleeds down 60psi in approx 0min not running. Sta 43 TRACED OUT AIR LEAKS AND REPAIRED TWO FITTINGS IN REAR. Workorder: V4680 In Date: 0/4/0 Close Date: 0/03/0 Meter Reading: 8, need light bulb for portable light on engine E 43 DROPPED OFF BULB. Workorder: V4697 In Date: 0/30/0 Close Date: 0/03/0 Meter Reading: 8,50.00 Need four replacement straps for flash lights and velcro straps for Irons with shoulder strap. Sta 43 REPAIRED STRAPS AND DROPPED OFF VELCRO STRAPS. Workorder: V47666 In Date: 03/0/0 Close Date: 03/3/0 Meter Reading: 9,5.70 foam system shuts down while foam is running. E 43 RAN PUMP AND CHECKED OPERATION OF PUMP, FOUND NO PROBLEM.

74 Workorder: V47735 In Date: 03/04/0 Close Date: 03/3/0 Meter Reading: 9,4.00 alot of fuel is dripping from the hurst power unit. E 43 SWAPPED OUT UNIT AND SENT UNIT FOR REPAIR. Workorder: V4775 In Date: 03/03/0 Close Date: 03/6/0 Meter Reading: 9,4.00 E 43's yellow 3/4 hose line buckle of security netting broken E 43 REPAIRED NETTING AND REMOUNTED NOZZLE HOLDER. Workorder: V4786 In Date: 03//0 Close Date: 03/6/0 Meter Reading: 9,67.00 watercooler on the engine is leaking. Sta 43 REPAIRED WATER LEAK ON PUMP PANEL Workorder: V48070 In Date: 03/0/0 Close Date: 03/7/0 Meter Reading: 9, REPLACE REAR TIRES E43 REPLACE REAR TIRES E43. Vendor?: BOULEVARD TIRE CENTE

75 Workorder: V4809 In Date: 03/7/0 Close Date: 04/0/0 Meter Reading: 9, Relief valve/drain discharge leaking E43 CHECKED FOR LEAKS RAN PUMP FOUND NO LEAKS. Workorder: V4876 In Date: 03/6/0 Close Date: 04/0/0 Meter Reading: 9, air leak/hard starting FOUND AIR LEAK AND REPAIRED REBUILT PUMP SHIFTER. HARD STARTING WAS DUE TO NOT PLUGING IN TRUCK, RECHARGED BATTERIES AND LOAD TESTED. Workorder: V489 In Date: 03/6/0 Close Date: 04/6/0 Meter Reading: 9, Discharge # pressuse relief will not seal properly. Discharge # OOS 0-7, Sta 43 REBUILT ALL DRAIN VALVES AND TESTED. Workorder: V4888 In Date: 04/5/0 Close Date: 05/07/0 Meter Reading: 30, driver side head light is not working. (FYI-- there is a new headlight in there now and it is still now functioning) CHECKED FOUND BAD CONNECTION REPAIRED CHECKED OK.

76 Workorder: V48884 In Date: 04/5/0 Close Date: 05/07/0 Meter Reading: 30, left headlight out on engine 43. the headlight had been replaced yesterday (04/4) per the offgoing shift, and the light still did not work. e43 WORK DONE ON H6054USE CV TYPE SEALED BEAM Workorder: V48945 In Date: 04/7/0 Close Date: 05/07/0 Meter Reading: 3, driver side spot light out B43 OPERATED LIGHT FOUND BAD CONNECTION AT SWITCH REPAIRED CHECKED OK. Workorder: V4899 In Date: 04/6/0 Close Date: 05/08/0 Meter Reading: 3, shelve in extracation department missing hardware to hold shelve in place. Shelve has dropped on right side. Needs the bolt and small back plate replaced.e43 REMOVED EQUIPMENT FROM SHELF STRAIGHTENED AND INSTALLED NEW HARDWARE. Workorder: V48975 In Date: 04/30/0 Close Date: 05/08/0 Meter Reading: 3, install velcro straps e 43 CHECKED OK.

77 Workorder: V48584 In Date: 04//0 Close Date: 05//0 Meter Reading: 30, PRESSURE RELIEF VALVE DOES NOT WORK PROPERLY LONG DELAY TO COME ON AND WON'T HOLD PRESSURE STEADY ALSO HAS STEADY LEAK. E43 FLUSHED OUT VALVE AND RETESTED. Workorder: V48585 In Date: 04//0 Close Date: 05//0 Meter Reading: 30, DISCHARGES AND 4 DRAINS WILL NOT SEAL ALSO DISCHARGE INTERMITTENTLY FAILS ALSO. PUMP WILL NOT HO A VACUUM UNABLE TO PASS ST PART OF PUMP TEST. E43 ALL DRAIN VALVE ARE REPAIRED. Workorder: V48587 In Date: 04//0 Close Date: 05//0 Meter Reading: 30, FOAM SYSTEM OVER RIDES PUMP THOTTLE CONTROL AND SHUTS PUMP ON AND OFF REPEATEDLY REDERING IT INOPERABLE. E43 RAN PUMP AND FOAM SYSTEM, COULD NOT GET SYSTEM TO FAIL. Workorder: V48588 In Date: 04//0 Close Date: 05//0 Meter Reading: 30, SAFETY NET ON PASSENGER SIDE CROSS LAY NEEDS TO BE REPLACED E43 REPLACED NET ON RIGHT SIDE

78 Workorder: V48589 In Date: 04//0 Close Date: 05//0 Meter Reading: 30, HOSE BED COVER NEEDS TO BE REPLACED WORN AND TORN E43 WILL HAVE MADE UP AT B Workorder: V4890 In Date: 03/6/0 Close Date: 05/4/0 Meter Reading: 9, net covering preconnect on passenger side needs placement. need two spark plugs nkg BM6A, Two Circle D replacement light bulbs, wood blades and metal cutting blades for sawsall, T handle for chain saw with flat head.sta 43. DROPPED OFF ALL SUPPLIES TO STATION.. INSTALLED NEW PRECONNECT NETS. Workorder: V48387 In Date: 04/0/0 Close Date: 05/4/0 Meter Reading: 30, Annual Vacuum test failed. Discharges & 3 leak at bleeder valve with caps on. Discharge 4 leak indicated by guage. Vacuum tes had 5 inches of drop in 45 seconds. Test discontinued until repairs are made. e43 REPAIRED ALL BLEEDER VALVES AND REPAIRED VACUUM LEAKS. Workorder: V495 In Date: 05/07/0 Close Date: 05/8/0 Meter Reading: 3,97.40 quartz warning light and buzzer coming on. e 43 READJUSTED POLE LIGHT SWITCH.

79 Workorder: V49096 In Date: 05/04/0 Close Date: 05/30/0 Meter Reading: 3,97.40 the left rear top red warning light is not working.. REPAIRED GROUND WIRE ON REAR LIGHT.. REAR A/C INOP - REPAIRED REAR A/C RELAY. Workorder: V4949 In Date: 05/7/0 Close Date: 05/30/0 Meter Reading: 3,50.0 primer pump does not even turn on - tried multiple times shutting the truck on/off. Does not even turn over.. REPAIRED BAD CONNECTION ON PRIMER MOTOR.. REAR SPOTLIGHT OUT REPAIRED BAD GROUND ON LIGHT. Workorder: V4969 In Date: 05/9/0 Close Date: 06/08/0 Meter Reading: 3, Replaced the right head light this morning and the rear upper left strobe is out. DROPPED OFF SPARE LIGHT.

80 Workorder: V49733 In Date: 05/30/0 Close Date: 06/8/0 Meter Reading: 3, While truck in pump the transmission sometime wont engage even after take pump out and repeating steps. truck is come up for PM 43. OPERATE PUMP COMPLAIN OF NOT ENGAUGE FAULT - PUMP ENGAUGE WITH NO FAULT OR UESITATION NOTICABLE. PUMP OPERATING NORMAL AT THIS TIME.. DIAGNOSE PUMP CONTROLE VALVE FAULT PUMP DERATED UNDER INSTALL POWER. REMOVE AND REBUILD TYUM CONTROLE VALVE, REMOVE AND REBUILD SV SENDING VALVE. 3. FOAM DISCHARGE EXCESIVE - FOAM DISCHARGE DISPLAY MAX FLOW A 5% REMOVE FOAM PUMP ASSEMBLEY FOAM DISTRIBUTION BOX WIRES EXPOSE - REMOVE BOX AND INSTALL NEW DISTRUBITION BOX RECALIBRATE WATER FLOW AND FOAM FLOT TO MANUFACTORY SPEC. FILL FOAM TANK. OPERATE UNIT. REPAD APART REPLACE LED SENSOR. 4. CALIBRATE WATER FLOW SENSOR FOR FOAM SYSTEM.

81 Workorder: V4970 In Date: 05/9/0 Close Date: 06//0 Meter Reading: 3, B INSPECTION E 43. B-Inspection; windshield wipe blade and fluid; rear a/c filter; right front turn signal and macke lense; replace blown tray bulb.. Remove hose bed cover and l/rear seat for repair. Install new hose bed cover and reupholstered seat. 3. Battery and trash line tray slider and lock seazed up - clean latching mechanism and sliders, lubricate and operate. 4. Rear indicator light inop - remove blown bulb install new bulb - system still inop - trace wire harness to chassie support strap found power cable short to ground - repair fault. 5. Cab door seals torn remove seals and install new door seals. 6. Window moldings damage or broken - remove moldings and install new moldings. 7. Diagnosing L/rear light bar failure - found led assembly bad - replace LED, found micro ballast one side malfunction. no parts - parts on order - reassemble. 8. Power steering service. 9. Engine and a/c belt service, replace tensioner and idler tensioner pully bearing. 0. Hologen light l/side inop - found bulbs in good condition, no power to assembly - found pinched line. correct fault. Repair pinched line.. L- comp tool holders loose - remove retap hold down holes and reinstall tool holders.. Rear a/c cool - diagnose fault - found unit low on freon - vacuum system check for leak none found - charge system operate unit cooling to 35 degree. 3. Hose bed cover hold down snaps broken - remove old damage snap and install new snaps. 4. Cab dimond plate cover loose - screws holes worn - retap several holes and secure plate to cab. 5. Air leak - replace leaking fittings and secure loose air lines. 6. Q.A D0LIGHT BALLEST MINI BAR CONTROL VALVE WASHER DIAPRAGM SUPPORT (PMD VALVE) WASHER DISTRIBUTION BOX 03FFBEARING PULLEY GROOVED TENSIONER OLD# WIPER BLADES ANCO VALVE SENSING SV HALE LIGHT KIT HALE SEAL DOOR 78R536078R5360M PK FILTER AIR COND LENS AMBER 953AMBER LENS 9440BELT 9480BELT A MOLD L/H A MOLD R/H AMH-AMH- VALVE EXTENSION FG87904MFG S FILTER P/S NEW STYLE FGQ79699GASKET-P/S FILTER NEW STYLE FS0FILTER FUEL WIX 334 PS8689 FRAM HPH6349AOIL FILTER 5748 K08076BELT R90PFILTER FUEL 333

82 Workorder: V50389 In Date: 06/6/0 Close Date: 07/09/0 Meter Reading: 3, Transmission retarder leaks air when brake is applied lightly and stops when applied fully. E43 TRAVEL TO STATION REMOVE AIR CONTROL VALVE ON TRANSMISSION INSTALL NEW VALVE VALVE ASSY.ACCUM Workorder: V50597 In Date: 07/04/0 Close Date: 07/0/0 Meter Reading: 3,46.00 air pressure will not build up AIR PRESSURE COONT BUILD UP/TRANS RETARDER VALVE SOLENOID LEAKING AT EXHAUST/REPLACED VALVE VALVE ASSY.ACCUM PURGE VALVE KIT Workorder: V50664 In Date: 07/07/0 Close Date: 07/3/0 Meter Reading: 3,49.30 T.I.C. Charger does not charge T.I.C. only charges the spare and needs to be moved to top of center compartment. E43 REPAIRED TIC CHARGER. Workorder: V50665 In Date: 07/07/0 Close Date: 07/3/0 Meter Reading: 3,49.30 E43 needs PVC styrofoam cup holder. AIR LEAK, REPAIRED LEAK AT DRIVER'S SEAT.. STATION WILL MAKE CUP HOLDER.

83 Workorder: V50668 In Date: 07/07/0 Close Date: 07/3/0 Meter Reading: 3,49.30 E43 missing Dynablade for K DC WILL ORDER BLADE. Workorder: V50695 In Date: 07/09/0 Close Date: 07/5/0 Meter Reading: 3,49.30 K will start. Will not stay running. Does not accelerate to high RPM. e 43 CLEANED CARB AND RAN UNIT. Workorder: V50736 In Date: 07/0/0 Close Date: 07/5/0 Meter Reading: 3,49.30 need case of oil DROPPED OFF OIL AT STATION. Workorder: V5367 In Date: 08/05/0 Meter Reading: Close Date: 09/3/0 QUARTZ ALARM IN CAB HAS ASHORT IN IT COMES ON AND GOES OFF WITH THE LIGHTS DOWN. E43. RGT SIDE QUARTZ LIGHT OUT REPAIRED LIGHT.. QUARTZ LIGHT ALARM GOING OFF READING SWITCH. 3. DROPPED OFF OIL AT STATION.

84 Workorder: V574 In Date: 08/0/0 Meter Reading: Close Date: 09/3/0 the air horn blast when I hit a small bump in the road. E43. REPLACED AIR HORN BOTTON THAT WAS LOADED W/ WATER AND TESTED.. REPAIRED 0 CORD THAT WAS SHORTOUT. Workorder: V5390 In Date: 08/06/0 Meter Reading: Close Date: 09/4/0 tower light on passenger side light bulb burned out SWITCH FOOT SIREN QUARTZ LIGHT BULB OUT REPLACED BULB AND TESTED. QUARTZ LIGHT ALARM GOING OFF ADJUSTED SWITCH. LB-D30BULB QUARTZ HAL. V 50W Workorder: V5569 In Date: 08/3/0 Meter Reading: Close Date: 09/7/0 PUMP THROTTLE FINIKY. WOULD NOT THROTTLE UP AT A CALL. SHUT DOWN, PULLED ENGINE FORWARD 6' AND RETRIED. THROTTLE WORKED. REALLY???? E43. RAN PUMP CHKD ALL CONNECTIONS ALL TESTED OK. Workorder: V566 In Date: 08/7/0 Meter Reading: Close Date: 09/7/0 SIDE WATER LIGHt GADGES ARE NOT WORKER ON EITHER SIDE. PASSWAY LEVEL GADGE IS WORKING. RECHARGED WATER LEVEL LIGHTS AND TESTED

85 Workorder: V5673 In Date: 08/7/0 Close Date: 09/7/0 Meter Reading: 33, primer pump sticking FINE ON PRIME PUMP REPAIR WIRES AND REPLACE WIRES REPLACE PRIME PUMP AND SOLIOD PRIME VALVE SWITCH. Workorder: V5577 In Date: 09/3/0 Meter Reading: Close Date: 0/0/0 We need some cycle oil for equipment. Sta NC SWITCH OK TO PUMP PRIMER PUMP MOTOR DROPPED OFF OIL AT STATION. Workorder: V5753 In Date: 0/0/0 Meter Reading: Close Date: 0/6/0 E 43 left rear emergency light bracket broken off. Mechanic already by station. E43 REINSTALLED NEW BRACKET AND REWIRED. Workorder: V5777 In Date: 0/0/0 Close Date: 0/6/0 Meter Reading: 34, repair rear light e 43 REPAIRED SHORTED WIRES IN REAR LIGHT.

86 Workorder: V590 In Date: 0/07/0 Meter Reading: Close Date: /09/0 Bi-lat (Right) side of each telelight bulb is burned out. E 43 REPLACED LIGHT. Workorder: V5364 In Date: 0/3/0 Meter Reading: Close Date: /09/0 box light charger left rear passenger seat broken and needs to be replaced. We also need a case of motor oil for E43 and B43 INSTALLED NEW CHARGED FOR HANDLIGHTS AND NEW FUSE HOLDER. AIR LEAK-REPAIRED AIR LEAKS. 5W40BSYN OIL BULK QTS Workorder: V49057 In Date: 05/0/0 Close Date: /0/0 Meter Reading: 3,9.00 while drafting, the master pressure relief drain had to be capped, as it was sucking in a large amount of air, preventing a vacuum. E43 CORRECTED RELIEF VALVE TPM/QG HALE REPAIR KIT Workorder: V5336 In Date: 0/9/0 Meter Reading: Close Date: /8/0 E 43 losing air pressure. Mechanic contacted AIR LEAK, REPLACED PARKING BRAKE VALVE VALVE PARKING BRK.

87 Workorder: V53566 In Date: /06/0 Meter Reading: Close Date: /8/0 for your information: two quarts of motor oil was added to engine 43 this morning. jrm/9573. REPAIRED OIL LEAK AT DRAIN PLUG. Workorder: V53559 In Date: /06/0 Meter Reading: Close Date: /30/0 Air leak. goes down to 50 psi. after about -hours. E43 CHECKED FOR AIR LEAKS AND REPAIRED. Workorder: V53597 In Date: /07/0 Meter Reading: Close Date: /30/0 both tower lights need bulbs replaced E43 REPLACED BULBS. Workorder: V53633 In Date: /08/0 Meter Reading: Close Date: /30/0 LEFT TELE LIGHT() OF THE () BULBS IN THE HOUSING IS BLOWN E43 REPAIRED ALL SPOT LIGHTS THAT WERE OUT.

88 Workorder: V53595 In Date: /07/0 Close Date: /07/0 Need cycle oil e43 Meter Reading: DROPPED OFF OIL. Workorder: V53646 In Date: /09/0 Meter Reading: Close Date: /07/0 The remote controlled top mounted spotlight does not light up. REPAIRED SPOT LIGHT GROUND THAT WAS OUT. Workorder: V5376 In Date: /3/0 Meter Reading: Close Date: /07/0 tower lights not working properly one bulb one each work intermittenly REPAIRED SHORTED WIRE IN POLE. Workorder: V5377 In Date: /3/0 Meter Reading: Close Date: /07/0 top mounted spot light is out E43 REPAIRED SPOTLIGHT.

89 Workorder: V5378 In Date: /3/0 Meter Reading: Close Date: /07/0 all step work lights are out E43 REPAIRED STEP LIGHTS FOR REAR AND SIDE OF TRUCK. Workorder: V5398 In Date: /6/0 Close Date: /6/0 Meter Reading: 35,800.0 S.C.B.A. Bracket right rear is missing mounting bolt and has come lose E43. AIR LEAK - REPAIRED AIR LEAK.. REPAIRED BRACKET IN REAR OF SEAT. Workorder: V54435 In Date: /4/0 Meter Reading: Close Date: 0/4/03 air bags under passenger cab not working cab bottoms out while driving CHECKED FOR LEAKS FOUND NO LEAKS ROAD TESTED STROBE LINEAR REFLECTOR 6ELTUBE Workorder: V54480 In Date: /8/0 Meter Reading: Close Date: 0/4/03 The left front turn signal, and the top mounted remote controlled spotlight are both not working. REPAIRED SPOT LIGHT AND TURN LIGHT.

90 Workorder: V54550 In Date: //0 Meter Reading: Close Date: 0/4/03 both the left front turn signal and the top mounted remote controlled spotlight are not working. INSTALLED NEW HEADLIGHT AND WIRED. AIR LEAKS CHECKED FOR AIR LEAKS FOUND NONE AT THIS TIME. Workorder: V54779 In Date: 0/03/03 Meter Reading: Close Date: 0/4/03 Strobe light out on rear driver side light by hose bed r43 REPAIRED LIGHT AND REPAIRED STROBE IN BACK. Workorder: V5487 In Date: 0/06/03 Meter Reading: Close Date: 0/4/03 primer (switch) sticks in the on position from the pump panel. primer on the officer side next to steamer valve functions properly. Problem is evidently with teh panel switch. E43 TESTED PRIMER VALVE AND TESTED OK. CHECKED FOR AIR LEAKS FOUND NONE AT THIS TIME. Workorder: V5493 In Date: 0/07/03 Close Date: 0/5/03 Meter Reading: 36, Pressure gauge for preconnect # non- operational. E43. REMOVED AND REPLACED PRESSURE GAUGE.. AIR LEAK - TRACED OUT AIR LEAKS GUAGE

91 Workorder: V54996 In Date: 0//03 Close Date: 0/5/03 Meter Reading: 36, # preconnect pressure gauge not working.. REMOVED AND REPLACED NO # GAUGE.. AIR LEAK, CHECKED FOR AIR LEAKS. Workorder: V55688 In Date: 0//03 Close Date: 0//03 Meter Reading: 38, no power, running rough ENGINE LOW ON POWER - FOUND BLACK FUEL - CONTAMINATED WITH OIL. SWAPPED INTO BATTALION 3 SPARE. Workorder: V5535 In Date: 0/8/03 Close Date: 0//03 Meter Reading: 37, air pressure low when starting the engine. air leak.. TRACED OUT AIR LEAKS AND REPAIRED. Workorder: V55466 In Date: 0/0/03 Close Date: 0//03 Meter Reading: 37,50.00 leak in the air system of the engine delaying response. E-43 TRACED OUT AIR LEAKS AND REPAIRED.

92 Workorder: V55508 In Date: 0/04/03 Close Date: 0//03 Meter Reading: 37, air leak causing delay in response.. CAB AIR BAGS, CHECKED NO LEAKS.. REPAIRED RAM FAN, INSTALLED RUBBER FEET. FZ-K90-MOTOR MOUNT RAM FAN GF65 LML-0-003CAB AIR BAG IS Workorder: V55594 In Date: 0/07/03 Close Date: 0//03 Meter Reading: 38, drivers side headlight not working. e43 REPLACED HEADLIGHTS. 4 H6054USE CV TYPE SEALED BEAM Workorder: V5655 In Date: 03/08/03 Close Date: 03//03 Meter Reading: 38,48.00 constantly has a vibration/shutter while driving WENT TO 43 CHECK ORIVELINE - CHECK OK - STARTED AND RAN ENGINE - CHECK FOR CODES - NO CODES - RAN CYLINDER - CUT - OUT TEST - CHECK OK - RAN CONTROL VALVE TEST - CHECK OK - TEST DROVE WITH DRIVER FOUND SMALL ENG MISS FROM RPM UNDER LOAD.

93 Workorder: V5576 In Date: 0//03 Close Date: 03/8/03 Meter Reading: 38, C inspection - injectors and tubes need to be replaced, oil in fuel. Fuel tank needs to be drained and refilled with fresh fuel.

94 . C-INSPECTION.. C-INSPECTION CONTINUE. 3. SERVICE PUMP TRANSMISSION. 4. SERVICE REAR AXLE. 5. R&R WIPER BLADES. 6. INFLATE FRONT RIRES TO 05 INFLATE REAR TIRES TO R&R CAB AUX A/C FILTER. 8. R&R FRONT HUB OIL FIL CAPS. 9. R&R RAD CAP AND TOP OFF COOLANT. 0. MAKE AND INSTALL ASSETT STICKER FOR WINDSHIELD.. TIGHTEN ALL HOLD OPEN HARDWARE ON BOTH COMPT L-3 DOORS.. R&R LOWER PIVOT BOLT ON CAB A/C COMPRESOR AND ADJ FANBELT. ALSO ADJ FANBELT ON CAB AUX A/C COMPRESSOR. 3. ROMOVE OLD PAINT. CLEAN AND PRIME CAP. LET DRY PAINT FUEL CAP YELLOW. 4. R&R AIR FILTER. 5. FORCE OPEN BATTERY TRAY DRAWER. CLEAN AND LUBE SLIDES AND LATCHES AND LATCH HANDLE ASSY. 6. R&R TAIL PIPE SUPPORT BRACKET. INSTALL NEW HARDWARE AND TIGHTEN. 7. R&R DRYER FROM VEHICLE (AD-9) OVERHAUL DRYER AND R&R CHECK VALVE ASSY. 8. R&R 4 BATTERIES. ALSO REPLACED POSITIVE MULTI. CABLE ASSY AND REPAIRED 3 POS, WIRES THAT TERMINALS TORE OFF WHEN REMOVING ATTACHMENT NUT. 9. R&R TOP HALF OF CAB AUX A/C UNIT IN ORDER TO R&R AIR DIFFUSER. 0. DIAGNOSE WHY RPM COUNTER ON PUM PANEL DOESN'T WORK. PUMP PANEL COUNTER ON PUMP PANEL BAD INNER AND OUTER CABLE BAD. FABRICATE NEW INNER OUTER CABLE ASSY AND REPLACE PANEL COUNTER ASSY.. R&R AND REBUILD PRIMER VALVE.. START VEHICLE WON'T PASS DRY VAC TEST DIAGNOSIS. 3. DRY VACUUM TEST DIAGNOSIS AND REPAIRS. 4. DRY VACUUM TEST DIAGNOSIS AND REPAIRS CONTINUED. 5. REMOVE BUCKLE AND STRAP FOR REAR OF HOSE BED COVER TO USE FOR SAMPLE AT CENTRAL AUTO TRIM. THEN REINSTALL BUCKLES ONTO REAR CROSSBAR. 6. R&R 3 DASH PANELS IN ORDER TO DIAGNOSE AND REPAIR WHY DEFROSTER DUCTS HAVE TAPE ON THEM. R&R ONE CABLE. R&R ONE BULB ADJ ANOTHER CABLE UNTIL CORRECT. REMOVE DUCT TAPE FROM TOP OF DASH. 7. START R&R INJECTORS AND TUBES ANODE ONLY VALVE CHECK HALE /4"" SPEEDCOUNTER PUMP PANEL MOUNTING ORING INJ TUBE VALVE GASKET COVER RXINJECTOR WASHER SEAL RACK GASKET 40530FUEL PRESS SENSOR VALVE EXT. 5-4WIPER BLADES ANCO VALVE KIT SS VALVE KIT SS VALVE / SEAL AIR DUCT CABLE ASSY HEATER 7R VENT A/C NEW # AKRON 3 IN VALVE 78R A/C FILTER VALVE KIT 3 IN AKRON A CABLE BATT. POS. BATTERY EPA TAXBATTERY EPA TAX $.50 PER BATTERY FS0FILTER FUEL WIX 334 PS8689 FRAM HP-3DBATTERY 950CCA HP-3D HPH6349AOIL FILTER 5748 PR WIX FILTER WATER PVG-KITORING KIT R90PFILTER FUEL 333 SPR-W58-TEE PLASTIC

95 8. REMOVE LINES, TUBES, VALVE COVER. A/C LINES, AND INJECTORS. 9. CONTINUE TROUBLESHOOT, REPLACE FUEL PRESSURE SENSOR AND FUEL TEMP SENDER, TEST DRIVE, STILL SAME????? 30. REPLACE BAJO SEALING WASHERS ON LIFT PUMP RE-TEST DRIVE-STILL SAME. 3. START REMOVE INJECTORS, CHECK WHERE TUBES MOUNTS, FOR POSSIBLE CRUSHING OR CRACKS. 3. REINSTALL INJECTORS OK. RETEST DRIVE STILL NOT RIGHT. 33. FINISH INSTALL TUBES AND INJECTORS. 34. TAKE TRUCK FOR LONG TEST DRIVE, RUNNING BATTER BUT STILL NOT RIGHT, ENGINE VIBRATION AND LONG CRANKS, START TROUBLESHOOT. 35. CONTINUE TROUBLESHOOT, RE-TORQUE ALL TUBES. 36. TRY TO BLEED FUEL SYSTEM, CHECK TUBES. 37. REMOVE INJECTOR PUMP FROM PART'S ENGINE. 38. REMOVE INJECTOR PUMP FROME-43 TO SWAP PUMPS WITH PARTS ENGINE. 39. FINISH REMOVE PUMP FROM E-43, START TO INSTALL PUMP FRAME PARTS ENGINE IN FINISH PUMP INSTALL IN E-43 TAKE ON TEST DRIVE OK. LET SIT OVERNIGHT CHEC IN A.M. 4. TEST START UP AFTER SITTING OVER NIGHT TEST DRIVE. 4. START INSTALL INJECTOR PUMP OFF OF E-43 ON PARTS TRUCK FINISH INSTALL INJECTOR PUMP ON PART'S TRUCK. 44. BLEED FUEL SYSTEM, REPAIR LEAKING LINES ON PART'S TRUCK. Workorder: V56497 In Date: 03/9/03 Close Date: 03/9/03 Meter Reading: 38,85.00 Hurst unit wont start E-43 HURST PUMP INOP. SPARK PLUG BROKE/REPLACED SPARK PLUG AND EXTRACTED BROKEN TIP FROM PLUG WIRE CONNECTOR. FSC749907NO SWITCH LOW AIR PRESSURE FSC74934NC SW PARK BK SPADE TYPE CONNECTOR

96 Workorder: V5648 In Date: 03/5/03 Close Date: 03//03 Meter Reading: 38,85.00 E 43 roof top spot light damaged and had to be removed. A bay door damaged the light. CHECKED SPOT LIGHT NEEDS NEW ONE ORDERED.. INSTALLED NEW SPOT LIGHT. 60SPOT LIGHT REMOTE 770LIGHT Workorder: V56408 In Date: 03/4/03 Close Date: 04/05/03 Meter Reading: 38,6.00 engine slow to start. REPAIRED CONNECTION ON STARTER. Workorder: V5038 In Date: 06/4/0 Meter Reading: Close Date: 04/08/03 Power pug broken and falling out and wont charge the Thermo Cam. Workorder: V5037 In Date: 06/5/0 Close Date: 04//03 Meter Reading: 3, air brakes leaking while applied 830GDIAPHRAM BRAKE

97 Workorder: V50393 In Date: 06/6/0 Close Date: 04//03 Meter Reading: 3, air leak Workorder: V56870 In Date: 04/07/03 Close Date: 04/6/03 Meter Reading: 38, Door sensors in D/O compartment not showing door closed, setting off alarms in cab. REPAIRED DOOR ALARM GOING OFF. Workorder: V57363 In Date: 04/30/03 Close Date: 05/0/03 Meter Reading: 39, HARD START COLD SIREN WORKS INTERMITTENT COMES ON BY ITSELF e 43 REMOVE AND INSTALL NEW LIFT PUMP ON ENGINE FUEL SYSTEM WASHER SEAL PUMP ISC FUEL TRANSFER NEW # WASHER SEAL ISB FS0FILTER FUEL WIX 334 PS8689 FRAM R90PFILTER FUEL 333 Workorder: V57644 In Date: 05/0/03 Close Date: 05/7/03 primer motor not working... Meter Reading: REPALCED PRIMER MOTOR PRIMER PUMP MOTOR

98 Workorder: V57688 In Date: 05/3/03 Meter Reading: Close Date: 05/7/03 Prime motor not working. E43. REPLACED PRIMER HANDLE THAT WAS HARD TO PULL.. SPOT LIGHT REPAIRED BAD CONNECTION. Workorder: V57690 In Date: 05/3/03 Meter Reading: Close Date: 05/7/03 Spot light on roof of the engine not working.e43. REPAIRED BAD CONNECTION.. READJUSTED TANK TO PUMP VALVE LINKAGE. Workorder: V5769 In Date: 05/3/03 Meter Reading: Close Date: 05/7/03 Water level lights on side of the engine not working.e43. REPAIRED BAD CONNECTION ON WATER LEVEL LIGHTS.. REPAIRED REAR GRAB RAIL FOR REAR OF TRUCK. Workorder: V5769 In Date: 05/3/03 Meter Reading: Close Date: 05/7/03 E43 is getting a bubbling rust line on the top of the engine.. RESEALED TOP OF ROOF.. REPAIRED DECK GUN VALVE THAT WAS LEAKING.

99 Workorder: V585 In Date: 06/8/03 Close Date: 06/4/03 Meter Reading: 40,65.00 extenda gun light on again, which hinders the ability to drive at night. E43 CHECKED CONNECTION ON TRUCK FOR EXTENDA GUN LIGHT AND ALL CHECKED OK - ROAD TESTED AND LIGHT IS NOT ON AT THIS TIME. Workorder: V5858 In Date: 06/0/03 Close Date: 06/4/03 Meter Reading: 40,65.00 Roof rotating white spot light is not working. In addition, the rear driver side compartment rollout drawer appears to be difficult to ro back into the compartment. SPOT LIGHT IS NOT WORKING DUE TO NEED TO REPLACE CABLE, WILL DO AT LATER TIME. Workorder: V57349 In Date: 04/9/03 Meter Reading: Close Date: 07/9/03 E 43 hesitates when starting. May be the starter. E43 repaired on Workorder: V5935 In Date: 07/5/03 Close Date: 07/9/03 Meter Reading: 4,55.40 FYI: Added two quarts of engine oil to Engine 43 this morning. NO ACTION AT THIS TIME.

100 Workorder: V5884 In Date: 07/03/03 Close Date: 08/0/03 Meter Reading: 4, top emergency light bar above the cab driver side, One light not working. Pressure relief valve not working properly. door adjar audible sound is not working E43 REMOVED AND REBUILT RELIEF VALVE SPRING-VALVE QG RELIEF VALVE TPM/QG HALE REPAIR KIT Workorder: V58880 In Date: 07/05/03 Close Date: 08/0/03 Meter Reading: 4, Spot light is not working. In addition, red flashing light on front roof light bar on the driver side is not working. REPAIRED LEFT REAR SPOTLIGHT THAT HAD BAD GOUND. Workorder: V58890 In Date: 07/06/03 Close Date: 08/0/03 Meter Reading: 4,40.0 Rubber Hook that holds the Spreaders/ Hurst tool down is very loose. It looks like it needs a replacement to help hold the spreade down. In addition, the chainsaw needs a chainsaw wrench.e 43 READJUSTED TOOL BRACKETS AND REPAIRED HOLDER. Workorder: V5936 In Date: 07/4/03 Close Date: 08/0/03 Meter Reading: 4,55.40 top left emergency strobe, right bulb is out. also, relief valve continues to not function properly, as it will activate but is slow deactivate. i excercised it for 0 min. with no improvement RAN PUMP TESTED RELIEF VALVE AND TESTED OK

101 Workorder: V5864 In Date: 06/4/03 Close Date: 08/07/03 Meter Reading: 40,65.00 One of our two circled lights is not working. 40 RA. REPAIRED CIRCLE D-LIGHT.. REPAIRED REAR STEP LIGHTS THAT WERE OUT. Workorder: V59078 In Date: 07/5/03 Close Date: 08/07/03 Meter Reading: 4,95.00 Pressure relief valve stuck in open position. E43. RAN PUMP AND TESTED RELIEF VALVE AND REBUILT VALVE.. REPAIRED AIR LEAK AT REAR OF TRUCK AT AIR TANK. Workorder: V5940 In Date: 07/9/03 Meter Reading: Close Date: 08//03 emergency lights on front bar and driver side rear top corner continue to be only partially operative. Each needs at least one bulb replaced. Air leak is also becoming increasingly more severe. repaired on w/o5949

102 Workorder: V5949 In Date: 07/9/03 Meter Reading: Close Date: 08//03 near catastrophic brake failure while responding to call. D/O was not driving hard on brakes and had not applied brakes in over a mile, approx. 90 seconds before failure. E43. travel to sta-43, check brakes, driver and officer did not feel the truck was safe to drive, drove to c/shop pick up spare and bring to sta-43. check brakes, found front brake chambers inop, remove front wheels and rear wheels, repalce front brakes, brake chambers, slack adjusters, hardware, brake drums, front rotors, wheel bearings, oil seals. set up slack adjusters and adjust brakes, replace brake foot valve 3. replace rear brakes, brake hardware, drums, brake chambers, slack adjusters, set up slack adjusters, adjust brakes. install wheels 4. rust on roof of cab, also cracked, remove all rust and seal roof seam with marine grade sealer 5. check for spotlight inop, found wires under lite bar broken, remove headliner and spotlight assy. install new comunition cable, reinstall headliner 6. front and rear lites out in lite bars, replace lites and control boards 7. found air leak will not hold over night, check with soap and water found multiple air leaks fixed all. air system now hold over night 8. relief valve inop, remove and rebuild intake and discharge valves, replace TPM control valve, replace sensor valve, adjust lite switch, 9. door ajar lite inop, found complete door ajar system disconnected, wires cut for lites and alarm, trace out wiring for complete system found deck gun switch inop, replace switch, found quartz lites sensor out of adjustment, also found L- compt. door switch bad, rewire ajar lites and alarm 0. water leaks inside cab from rear red dot a/c, remove filter and clean out drains. vehicle hard starting, hook up laptop, found code for fuel pressure sensor, replace sensor, still hard starting, and still had codes for sensor, trace out wiring, check fuel system, could not find problem, sent to cummins. pump intake and discharge pressure gauges inop, replace FRC led gauge display and transducers ***** these were problems reported to me by the officer and never repaired***** 0-06B807-50LINAER CORNER HALE RELIEF VALVE W/ VULCANIZED SEAT SPRING-VALVE QG RELIEF VALVE SPRING RELIEF VALVE HALE HUB FRONT WHEEL CON MET 0400BRAKE CHAMBER SWITCH-PROXIMITY QG VALVE 867BRAKE VALVE E-6 NEW HUB COVER GASKET 3576REAR BRAKE DRUMS 37000ASEAL FRONT DRUM M ENGINE SLACK ADJ WAB SLACK ADJUSTER WAB FUEL PRESS SENSOR 49497SENSOR PRESSURE 56TIRE INFLATOR QG VALVE VALVE SENSING SV HALE QD REL.VALVE KIT TPM/QG HALE REPAIR KIT ACX-84534LUG NUT COVER PK0 CM03596BEARING INNER EAA UGSS783UQ STRUT-LIFT FP4000PT-TRANSDUCER DISCHARGE DIG. MASTER PUM FREIGHTSHIPPING CHARGES I0300PT-XE-IO300PT3-S0B 600 TRANSDUCER INT IOA00A00DISPLAY MODULE REBUILD ONLY SEND IN KSR30470QPBRAKE SHOES FRONT M MF39063NUT WHEELBRG TORQUE TITE S690AIR CHUCK SBN NP06773TRBBEARING CUP SBN NP435398TRBBEARING CUP SBN NP874005TRBBEARING CONE XG840-KITEXTENDA GUN SWITCH XK QPMHD SHOE KIT 3/8 BEAM 0

103 Workorder: V59756 In Date: 08/3/03 Close Date: 09/0/03 Meter Reading: 4,64.00 B inspection E43. B inspection, repairs made on w/o#5949. repalce broken # 4 discharge gauge 3. replace discharge transducer for FRC pump panel gauge, that was inop, GUAGE FS0FILTER FUEL WIX 334 PS8689 FRAM HPH6349AOIL FILTER 5748 R90PFILTER FUEL 333 Workorder: V60453 In Date: 09//03 Close Date: 0/09/03 Meter Reading: 4,64.00 need either a new chain saw chain or sharpen the spare chain on E43 DROPPED OFF NEW CHAIN AND INSTALLED ON SAW. Workorder: V6630 In Date: 0/9/03 Close Date: /06/03 Meter Reading: 4,64.00 QA and replace rear tailboard. START REMOVING REAR TAIL BOARD FROM TRUCK.. REMOVED TAIL BOARD FROM PARTS TRUCK CLEANED UP INSTALLED HARNESS FROM TAILBOARD ON E-43 INSTALLED TAILBOARD ON TRUCK RLIGHT MARKER LED RED C634C VENT ACTUATOR EAA UGSS783UQ STRUT-LIFT 3

104 Workorder: V676 In Date: //03 Close Date: /6/03 Meter Reading: 4,64.00 E43 air stuck on AIR HORN STOCK OK. CHECK FOUND LOOSE CONNECTION NEAR LINE REPAIR CONNECTION AND SECURE WIRES TEST FOR OPERATION IS GOOD NOW. Workorder: V646 In Date: /0/03 Close Date: /03/03 Meter Reading: 4,64.00 replace injectors E43 REPLACE INJECTORS E43. Vendor?: CUMMINS POWER SOUTH Workorder: V683 In Date: /6/03 Close Date: /04/03 Meter Reading: 4,64.00 air horn staying on when battery switch turned, air line disconnected at solenoid also do a quality check. CHECK AIR HORN - REMOVED DASH PANEL AND CHECK SWITCH - CHECK OK. CHECK V-MOR NODES ON AIR HORN CIRCUIT - CHECK OK - AIR HORN CHECK OK.. FOUND VARIOUS NODES LOAD SHEADING - REPROGRAMMED ALL NODES CHECK OK. 3. Q.C. - TEST DROVE PUMPED CHECK OK.

105 Workorder: V6506 In Date: /05/03 Meter Reading: Close Date: /3/03 Needs constant power point put in, shuts off with Engine REWIRED VOLT TO CONSTRUCT POWER. Workorder: V654 In Date: /05/03 Meter Reading: Close Date: /3/03 need placards for E43 rear doors, they have been removed and need to be replaced( black mounting brackets) INSTALLED NEW NUMBER PLATES AND REMOVED OLD ONES. Workorder: V6605 In Date: /09/03 Meter Reading: Close Date: /3/03 Emergency light on officer side grille not working. E43 S PLACARDFRONT AND BACK PLACARD. REMOVED LIGHT AND INSTALLED NEW LIGHT AND REWIRED UNIT.. TRACED OUT AIR LEAKS FOUND NONE AT THIS TIME. Workorder: V6606 In Date: /09/03 Meter Reading: Close Date: /3/03 Door shock on medical compartment broken. E43 60R00FRR600 SERIES RED LED W/O FLANGE INSTALLED NEW BRACKET AND PISTON IN MED COMPARTMENT. 575BACKUP ALARM ECCO 07 DEC

106 Workorder: V6607 In Date: /09/03 Meter Reading: Close Date: /3/03 Relocate the microphone holder on the officers side... e43 MOVED MIKE HOLDER TO OFFICERS SIDE AND REWIRED VOLT CHARGER. Workorder: V6685 In Date: /3/03 Close Date: 0/7/04 Meter Reading: 4, Right front turn signal is not working. E43 REPAIRED BAD CONNECTION IN LIGHT. Workorder: V674 In Date: /4/03 Close Date: 0/7/04 Meter Reading: 4, Right front turn signal not working. E43 REPAIRED ALL AIR LEAKS THAT WERE FOUND. Workorder: V675 In Date: /4/03 Close Date: 0/7/04 Meter Reading: 4, Door strut on generator compartment broken. E43 REPAIRED COMPARTMENT DOOR THAT WOULD NOT CLOSE - REPAIRED HINGE.

107 Workorder: V6750 In Date: /6/03 Close Date: 0/7/04 Meter Reading: 4,6.50 Right front turn signal out. E43 REPAIRED RIGHT TURN SIGNAL THAT WAS OUT DUE TO BROKEN WIRES. Workorder: V6867 In Date: //03 Meter Reading: Close Date: 0/06/04 Door strut on generator compartment broken RA E43 REMOVED AND REPLAECD DOOR PISTON. Workorder: V63393 In Date: 0/4/04 Meter Reading: Close Date: 0/06/04 Drivers compartment door warning light going off intermittently while driving with door closed RA REPAIRED REAR DOOR SWITCH THAT WAS SHORTING OUT. Workorder: V6404 In Date: 0/06/04 Close Date: 0/06/04 Meter Reading: 43, replace hurst hoses and need a case oil DELIVERED OIL. 5W40QSYN OIL QT HOSE HURST 6 ORANGE 353R09USE 353R403 HURST HOSE 6 GREEN

108 Workorder: V6407 In Date: 0/0/04 Meter Reading: Close Date: 0/0/04 Need hurst hydraulic fluid - qts PARTS DELIVERED. 80R00HURST HYD. FLUID QT Workorder: V640 In Date: 0/0/04 Close Date: 0//04 Meter Reading: 43, No air presure. TRACED OUT LEAK AND REPAIRED. Workorder: V6436 In Date: 0/4/04 Close Date: 0/4/04 Meter Reading: 43, Mount brackets for new hose installation MOVE HOSE BED DIVIDER. MOUNT 5" TOOL HOLDER BRACKETS AT VARIOUS PLACES ON TRUCK. ATTACH 5 TO RT CAP RETAINER. Workorder: V64587 In Date: 0/7/04 Close Date: 0/8/04 Meter Reading: 44, no crank NO CARNK. FOUND FAULTY STARTER REPLACE ALSO SOLENOID ON FIREWALL ORIGINAL SOLENOID MT T STARTER ESX005STARTER RELAY ESX-0-05

109 Workorder: V64453 In Date: 0//04 Meter Reading: Close Date: 03//04 The ignition doen not turn the motor intrmittently before turning over... Possibly low cranking amps... E43 CHECKED ALL CONNECTION STARTED TRUCK SEVERAL TIMES AND STARTED OK, Workorder: V64454 In Date: 0//04 Meter Reading: Close Date: 03//04 Front bumper suction valve not opening... E43 REPAIRED TANK FILL LINE THAT WAS INOP- LINKAGE WAS OFF VALVE. Workorder: V64455 In Date: 0//04 Meter Reading: Close Date: 03//04 Is it possible to have a third set of large diameter spanners mounted on the right side panel... E43 DC WILL NEED TO ORDER. Workorder: V663 In Date: 0/9/03 Close Date: 03/8/04 Meter Reading: 4,64.00 engine hard starting REPAIRES COMPLETED.

110 Workorder: V64609 In Date: 03/0/04 Meter Reading: Close Date: 03/8/04 Still having the intermittent delay in cranking. E 43 TRACED OUT PROBLEM, TESTED WIRES AND CHECKED ALL CONNECTION WILL MONITOR. Workorder: V6463 In Date: 03/0/04 Meter Reading: Close Date: 03/8/04 When attempting to start Engine 43 this morning, there was a click when the ignition was turned on, then nothing. The engine started on the second attempt. E43 REMOVED AND INSTALLED NEW KEY SWITCH. Workorder: V6478 In Date: 03/05/04 Meter Reading: Close Date: 03/8/04 E43 WILL NOT START WHEN IGNITION SWITCH IS TURN AT TIMES. HAVE TO TURN IGNITION SWITCH MORE THEN ONCE DOES NOT ALWAYS WORK CORRECTLY. FRONT INTAKE DOES NOT WORK AND AIR SWITCH LEAKS AIR WHEN USED.. TRACED OUT WITH INTERMITTENT STARTING.. VALVE HANDLE BROKEN, REMOVED AND REPAIRED. Workorder: V65757 In Date: 04/6/04 Meter Reading: Close Date: 04//04 right rear outside tire worn to wear bars on outerside of tire 0AKRON SHORT ARM RC-4 0AKRON LONG ARM RC-4 right rear outside tire worn to wear bars on outerside of tire Vendor?: ELPEX

111 Workorder: V6544 In Date: 04/04/04 Meter Reading: Close Date: 04/5/04 Throttle fluctuated wildly while pumping a fire.. CHECKED ALL CONNECTION AND RAN PUMP AND FOUND NO PROBLEM.. DROPPED OFF HURST OIL. 80R00HURST HYD. FLUID QT 3 Workorder: V6449 In Date: 0/4/04 Meter Reading: Close Date: 05//04 front intake valve needs to be replaced and E43 needs 5" spanners with mount to be mounted on passenger side of engine. Than you. REMOUNTED TOOLS IN L- COMPARTMENT.. CHECK ENGINE LIGHT ON-FOUND LOW ON COOLANT, PRESSURE TEST MOTOR. ALA EXTENDED LIFE COOLANT GAL 6 Workorder: V6575 In Date: 04/6/04 Meter Reading: Close Date: 05/3/04 The strap that holds the spreader in place is broken and the spreaders fall out of holder when door is opened and is unable to be closed, also hose bag for the extracation hose needs to be replaced it has two large hole E43. REMOVED AND REPLACED STRAP FOR HURST CUTTERS.. CLEANED CARB ON HURST UNIT AND TESTED. Workorder: V6643 In Date: 05/05/04 Meter Reading: Close Date: 05/3/04 Foam tank level light flucuating from full to / tank when tank is full. CLEANED GROUND WIRE ON SENDING UNIT AND TESTED GUAGE.

112 Workorder: V66680 In Date: 05/3/04 Meter Reading: Close Date: 06/09/04 quartz tower light alarm will not go off read justed switch for quartz lights. Workorder: V6703 In Date: 06/3/04 Meter Reading: Close Date: 07/03/04 Lock on 5in hose broken on stortz coupling E43. AIR LEAK REPAIRED AND RECHECKED FOR LEAKS.. DOOR ALARM TRACED OUT ALARM FOUND BAD GROUND ON REAR DOORS. Workorder: V676 In Date: 06/0/04 Meter Reading: Close Date: 07/09/04 CHAIN SAW WILL NOT START.. shop pick up saw. Workorder: V674 In Date: 06/4/04 Meter Reading: Close Date: 07/6/04 Section of 5 inch hose in need of repair. Red coupling lock broken. E43 repairs complete on ticket v6703

113 Workorder: V69059 In Date: 08/9/04 Close Date: /03/04 Meter Reading: 47,06.00 C inspection SE7

114 . a & b - C Inspection.. C Inspection. 3. C Inspection. 4. Performed pump tests after dry vacuum tests to determine location of leaks. Large leaks at tank to pump and tank fill/recirculation valves. 5. Batteries failed load tests after recharge. Replaced 4 batteries. 6. Replaced intake air filter and rear cab A/C filter. 7. Serviced air dryer. 8. Found foam system, pump to valve hose severely degraded and cracked. Replaced hose and tested system. 9. Replaced failed compartment door hold open props on R/rear R3/both, rear lower/both. R & I rear grab rail to replace failed hose bed cover straps. 0. R & I tank to pump valve and overhauled. Recalculated valve arm geometry. Cut and welded arm to correct. Installed correct length shift rod and adjusted.. Removed tank fill/recirc. valve and replaced with revised Arkon valve. Removed Arkon valve flanges and piping from parts truck and installed. Adjusted shift rod geometry and adjusted.. Retested for pump leaks by performing dry vacuum test and pressure tests. Secondary leaks found at # discharge and trash line Hale valves. 3. Removed and overhauled # discharge and trashline Hale pump valves. Performed dry vacuum and pressure tests to verify repairs. 4. Found pump panel transmission temperature gauge holding water. Replaced failed gauge and fabricated wiring. 5. Performed cooling system flush and replaced filter. Pressure tested and replaced failed radiator cap. 6. Remove campaign sign brackets. Cleaned adhesive. 7. a & b - Replaced front and rear compressor belts and adjusted. Replaced worn and noisy engine serp. belt and failed tensioner. Replaced sheared compressor mounting bolt. 8. Removed rusting, corroded crosslay nozzle holders. Assembled new holders and fabricated mounts. 9. Removed damaged glove holder in rear of cab and remove adhesive. Installed new glove holders. Removed decals from windshield. 0. Rear upper grab bar loose. Drilled and tapped new mounting holes. Secured with new fasteners.. Walk thru pump panel. Upper inspection panel, cam lock missing and all fasteners loose. Removed cam locks from parts truck. Installed cam lock. Drilled out and installed new rivets on all panel locks.. a & b - R & I middle and rear headliner sections. R & I L/R seat for upper cushion and cover repairs. Sent headliners and seat to trim shop. 3. Removed duct tape from defrost vents and cleaned SCREEN 6 IN CAP RADIATOR 0 LB 07796DRYER KIT AD9 -NEW 07800VALVE CHECK AD9 08-FBEADED CHAIN W/CONN 5W40BSYN OIL BULK QTS 94BULB TRANS TEMP GAUGE GROOVED TENSIONER OLD# VALVE CORE 48074HOSE & FITTINGS 5-4WIPER BLADES ANCO VALVE KIT IN SS VALVE VALVE KIT SS VALVE / CIG. LIGHTER ACCES BULB TAG LIGHT SWITCH TURN SIGNAL A HORN BUTTON 700-5EG50T SEAL 78R536078R5360M PK FILTER AIR COND PURGE VALVE KIT VALVE KIT 3 IN AKRON 9440BELT 9480BELT PINION GEAR ANTICOOLANT ANTIFREEZE GAL BATTERY EPA TAXBATTERY EPA TAX $.50 PER BATTERY CA893AIR FILTER WIX EAA UGSS783UQ STRUT-LIFT FS0FILTER FUEL WIX 334 PS8689 FRAM HP-3DBATTERY 950CCA HP-3D HPH6349AOIL FILTER 5748 K08076BELT LF8TS-LEDMAP LIGHT LED 8 IN PR WIX FILTER WATER PSTANKWATER LEVEL LED LIGHT R90PFILTER FUEL 333 RGTTAS6505ASTEERING GEAR BOX FRTLNR. ENG. S337INNER POLE SWITCH MAGNET TRANSYNDALLISON TRANS FLUID GAL WAT6403STRAINER 6 IN

115 adhesive from dash panel. Adjusted defrost/vent cable. 4. Found horn pad broken and turn signal switch bent and sticking. Replaced horn pad and turn signal switch assembly. 5. a & b - Found all warning buzzers and lamps inoperable. Repaired cut wiring and disconnected buzzers and lamps. Removed left quartz pole lamp and disassembled. Replaced warning sensor magnet. Adjusted sensor. 6. a & b -75% of green LEDs on right side tank level indicator inoperable. No access to wiring behind indicator. Drilled hole in body to access wiring. Fabricated wiring and installed new indicator. 7. Found front intake valve not opening. air switch working properly. Removed valve motor assembly and disassembled valve seized due to debris. Cleaned and lubricated valve. Reinstalled. 8. Found L/ handlight charger inoperable and map lamp missing. Removed corroded connector and repaired wiring on charger. Installed map lamp. CONTINUED ON WORK ORDER # 7067

116 Workorder: V7067 In Date: 08/9/04 Close Date: /03/04 Meter Reading: 47,06.00 additional work order for C inspection SE7 CONTINUED FROM W/O # a & b - Removed booster reel and disassembled. Found failed brake/manual pinion gear. Replaced gear. Reinstalled. 30. Installed wiper blades. Cleaned garbage and debris from cab and body. Installed right pump panel # discharge cap and cap chains. 3. Power steering noise diagnostics and complete system flush. 3. Polish, attempt, replacement wheels. 33. R & I front wheels for tire replacement. 34. a & b - Performed power steering diagnostics using pressure/flow gauge. Installed new gear and bled system. Test drove. Removed steering wheel to position straight. Test drove again. Verified repair. 35. Replaced failed bulb in left front clearance lamp. 36. Quality & Assessment. Workorder: V7070 In Date: /04/04 Close Date: /07/04 Meter Reading: 47,06.00 replace fronts WORK REPAIRS REQUESTED. Vendor?: BLVD TIRE CENTER

117 Workorder: V7 In Date: /6/04 Close Date: /04/04 Meter Reading: 47,06.00 A inspection SE7. "A" Inspection air tires to proepr PSI. L seat belt cover torn, trim loose cover away 3. Diangose driver step light inop-found wires pulled from connector. Repair connection and pulled slack from harness and tie strap to secure. 4. Left and right fender markers inop-found both bulbs burnt out, replaced bulbs. 5. Cab light box charger broken and loose. Replaced charger, splice wires. Install lock nuts on bottom slide test charger (ok) protect wiring 6. Center rear right tail board marker dim-found bad light assembly and cut pinched wire, repaired wire and replaced light assy 7. L- shock missing-install new shock on L- door 8. Loosen and adjusted R air horn sound 3500-RLIGHT MARKER LED RED EAA UGSS783UQ STRUT-LIFT Workorder: V76 In Date: /3/04 Meter Reading: Close Date: /8/04 pressure alarm sounding, no rpm, no temp reading, no oil pressure on panel, pressure relief light lit when in drive, discharge gaug giving reading when in drive E4. Travel to 4, driver complaint no oil pressure or temp or tach. Throttle working traced wiring back as far as possible could not locate EDM connection-replaced throttle head.. Driver complaint of check engine light, checked system found new throttle 0-7, repaired system-ok. ELA0-ATHROTTLE EXCEL CUMMINS IS SERIES Workorder: V7809 In Date: //04 Close Date: /30/04 Meter Reading: 47, Pump trottle on panel not working. Panel show's no RPM, but display code E0. Checked truck found no problem with throttle

118 Workorder: V69959 In Date: 0/06/04 Close Date: 0/0/05 Meter Reading: 47, pump panel display shows error e0, no rpm, oil pressure, or temperature readouts Pump panel display shows error eol no rpm oil pressure or temp. Checked system ok Workorder: V7889 In Date: /8/04 Meter Reading: Close Date: 0/05/05 TIC (asset # 0739) is not getting any charge when place or attach it on base charger E4 Check out tire on truck not charging tic R/R and rewire new base Workorder: V73009 In Date: 0/09/05 Close Date: 0/3/05 Meter Reading: 48, A INSPECTION. A Inspection.. R & R compartment L-3 hold open. 3. R & R lens and bulb on cab roof marker light. 4. A/C compressor bolt broken. Loosen all adjacent bolts. R & R pivot bolt, washers and nut. Adjust belt tension. EAA UGSS783UQ STRUT-LIFT Workorder: V73750 In Date: 03/09/05 Meter Reading: Close Date: 03/09/05 K fuel cap is partially chipped so it does not have a complete seal, therefor leaking fuel. Asset # for saw is 067. Light duty delivered 50536FUEL CAP PARDNERS

119 Workorder: V73698 In Date: 03/06/05 Meter Reading: Close Date: 03/9/05 (Spare Ferrara), toggle switch for front intake not working. Not opening valve for front intake. -Tom Parker (56) Travel to station 37. Check out front intake valve inop. Try to free up valve cylinder bad. Needs to go to shop for replacement on next P.M. Workorder: V7440 In Date: 03/7/05 Close Date: 05/06/05 Meter Reading: 49, A-inspection. A-Inspection.. L/rear and R/rear window molding broken- remove and install new molding. A MOLD L/H A MOLD R/H Workorder: V697 In Date: 09/03/04 Meter Reading: Close Date: 06/08/05 Will not hold vacuum Tank to pump valve or tank fill valve not closing completely. Tank level gauges on the side of the truck not working when in pump gear

120 Asset: () FERRARA FL80 50 Gpm Pumper CSHOP Comments: E7 THROTTLE PROBLEM Date Opened: Date Finished: TASKS PERFORMED Q PARTS Meter Reading: 49,590 FIRE APPARATUS THROTTLE; THROTTLE EXCEL CUMMINS IS SERIES CSHOP Comments: E7 RELIEF VALVE INOP Date Opened: Date Finished: Meter Reading: 49,690 TASKS PERFORMED TRAVEL TO BE CHARGED TO WORK ORDER FIRE APPARATUS CSHOP-05-5 Comments: THROTTLE NOT FUNCTIONING PROPERLY ON PUMP PANEL SPARE ENGINE AT 7 Date Opened: Date Finished: Meter Reading: TASKS PERFORMED 50,000 TRAVEL TO BE CHARGED TO WORK ORDER FIRE PUMP CSHOP-05-0 Comments: SAFETY ALARM FOR DECK GUN STUCK ON Date Opened: Date Finished: TASKS PERFORMED Q PARTS Meter Reading: 50,000 A INSPECTION AIR SYSTEM STROBE LIGHTS AIR HORN SAFTEY-EMERGENCY EQUIPMENT HVAC SYSTEM LIGHT; 600 SERIES RED LED W/O FLANGE 3 SWITCH; EXTENDA GUN SWITCH CSHOP Comments: NEED V POWER FROM BATTERY WHEN IGN OFF FOR SAFETY PAD Date Opened: Date Finished: Meter Reading: TASKS PERFORMED 50,000 BATTERY

Palm Beach County Fleet Management Asset Maintenance History

Palm Beach County Fleet Management Asset Maintenance History Workorder: 557575 Meter Reading: 62 In Date: 11/02/2005 Close Date: 11/18/2005 REPAIR GLASS FROM HURRICANE WILMA Set Up Glass Repair And Prep Vehicle 2.00 Make And Apply Asset # Decals To Vehicle Charge:

More information

356 CHECKLIST ELECTRICAL: CHASSIS:

356 CHECKLIST ELECTRICAL: CHASSIS: 356 CHECKLIST ELECTRICAL: Headlights hi/lo beam Taillights Running lights Turn signals Brake lights License light(s) Fog lights Reverse light Horn Dome lights Dash lights Temp guage Tank level guage Tachometer

More information

Palm Beach County Fleet Management Asset Maintenance History

Palm Beach County Fleet Management Asset Maintenance History Workorder: 34963 Meter Reading: 582 In Date: 02/18/2000 Close Date: 02/25/2000 R&R Seat Road And Bridge And Back. Charge: REPLACE SEAT 1.50 SEAT ASSY. HE1300 1.00 216.42 Charge: 67.50 Workorder: 39566

More information

Work Order History Report

Work Order History Report Work Order History Report Asset WL307 Asset: WL307, Including Children, Active: True Loader, Wheel (IT) W/O No Description Finished Hours 179 WL307 R&R transfilter tested ok 3/12/2009 Hours 103 CAT WL

More information

Volkswagen Jetta, Golf, GTI 1999, 2000 Brake System 47 Brakes - Hydraulic Components (Page GR-47)

Volkswagen Jetta, Golf, GTI 1999, 2000 Brake System 47 Brakes - Hydraulic Components (Page GR-47) 47 Brakes - Hydraulic Components (Page GR-47) FS III front brake calipers, servicing Front brake caliper piston, removing and installing FN 3 front brake calipers, servicing Front caliper piston, removing

More information

46431x92A Garden Tractor (1998) Page 1 of 16 Body Chassis

46431x92A Garden Tractor (1998) Page 1 of 16 Body Chassis 46431x92A Garden Tractor (1998) Page 1 of 16 Body Chassis 46431x92A Garden Tractor (1998) Page 2 of 16 Body Chassis 1 092546E701 Bracket, Seat 2 091963 Z Plate Assembly, Switch 3 164X26 Spring, Compression

More information

Heavy Duty Equipment Mechanic (Class Code 3743) Task List. Inspection and Diagnosis

Heavy Duty Equipment Mechanic (Class Code 3743) Task List. Inspection and Diagnosis Heavy Duty Equipment Mechanic (Class Code 3743) Task List Inspection and Diagnosis In order to verify complaints and determine malfunctions a Heavy Duty Mechanic: 1. Reads operators written trouble reports,

More information

Range Road RR Series Semi-Automatic Firewood Processor. Crated Unit Assembly Manual

Range Road RR Series Semi-Automatic Firewood Processor. Crated Unit Assembly Manual Range Road RR Series Semi-Automatic Firewood Processor Crated Unit Assembly Manual 1 1) Undo 8-18mm x 19mm Nuts and bolts, 2 on each leg of top frame 2) Lift top of Metal crate off and move out of work

More information

CDS TROUBLESHOOTING SECTION I. VACUUM. 1.0. Weak vacuum at wand. Gauge reads normal (10hg to 14hg)

CDS TROUBLESHOOTING SECTION I. VACUUM. 1.0. Weak vacuum at wand. Gauge reads normal (10hg to 14hg) CDS TROUBLESHOOTING SECTION I. VACUUM 1.0. Weak vacuum at wand. Gauge reads normal (10hg to 14hg) 1.1. Clogged hoses or wand tube. Disconnect hoses and carefully check for an obstruction. 1.2. Excessive

More information

Customer Owned Certified

Customer Owned Certified TEREX BENFORD TA30 Customer Owned Certified OFF HIGHWAY TRUCKS Inspection Number: 751979 Serial #: A7991472 Date Created: 07/27/2011 07:46:05 AM CDT Engine Serial #: N/A Last Updated: 08/02/2011 07:10:48

More information

BR150 Pmi Baja Reaction 150cc Go Kart (VIN PREFIX L4VM)

BR150 Pmi Baja Reaction 150cc Go Kart (VIN PREFIX L4VM) Page 1 of 21 Product Information Baja Web > Product Information > Parts Lists > GOKART > BR150 Pmi Baja Reaction 150cc Go Kart (VIN PREFIX L4VM) BR150 Pmi Baja Reaction 150cc Go Kart (VIN PREFIX L4VM)

More information

Lebanon Fire Department Lebanon Engine 512 Check Sheet

Lebanon Fire Department Lebanon Engine 512 Check Sheet Page 1 of 8 Initials Engine Oil Transmission Fluid Windshield washer fluid Radiator level Power Steering Fluid Mileage (All digits) Brakes/Air Tanks Fuel Level Windshield Wipers Brake Lights Interior Lights

More information

Cooling system components, removing and installing

Cooling system components, removing and installing Page 1 of 34 19-1 Cooling system components, removing and installing WARNING! The cooling system is pressurized when the engine is warm. When opening the expansion tank, wear gloves and other appropriate

More information

Before installation it is important to know what parts you have and what the capabilities of these parts are.

Before installation it is important to know what parts you have and what the capabilities of these parts are. INSTALLATION GUIDE Before installation it is important to know what parts you have and what the capabilities of these parts are. The Recon XZT is the smallest and most powerful gauge of its kind. With

More information

ELECTRICAL WIRING (R.H. DRIVE VEHICLES)

ELECTRICAL WIRING (R.H. DRIVE VEHICLES) C-1 ELECTRICAL WIRING (R.H. DRIVE VEHICLES) CONTENTS GENERAL.......................... 3 WIRING HARNESS CONFIGURATION DIAGRAMS......................... 4 ENGINE COMPARTMENT................ 4 DASH PANEL...........................

More information

MAN - MERCEDES - BENZ

MAN - MERCEDES - BENZ SAYFA: 1 10100 10102 10103 355 353 06 15 355 353 03 15 346 353 08 15 AXLE GEAR AXLE GEAR AXLE (WITH BUSHING TYPE) (WITH BUSHING TYPE) (WITH BUSHING TYPE) 2521 2517-2521-2622 10104 10105 10106 308 350 00

More information

1/29/2008 DR50. Baja Motorsports Inc. P.O. Box 61150 Phoenix, AZ 85082 Toll Free: 888-863-2252 PART NUMBERS PRICES ARE SUBJECT TO CHANGE 1 of 45

1/29/2008 DR50. Baja Motorsports Inc. P.O. Box 61150 Phoenix, AZ 85082 Toll Free: 888-863-2252 PART NUMBERS PRICES ARE SUBJECT TO CHANGE 1 of 45 DR50 Toll Free: 888-863-2252 PART NUMBERS PRICES ARE SUBJECT TO CHANGE 1 of 45 CYLINDER & CYLINDER HEAD Part UPC Number Description Baja Description 1 DR50-001 842645074424 CYLINDER 1 1 2 DR50-002 842645074431

More information

INSTALLATION INSTRUCTIONS

INSTALLATION INSTRUCTIONS INSTALLATION INSTRUCTIONS Accessory Application Publications No. AII23628 2003 PILOT Issue Date MAY 2002 PARTS LIST Security System Kit (sold separately): P/N 08E51-S84-100 2 Remote controls Attachment

More information

Palm Beach County Fleet Management Asset Maintenance History

Palm Beach County Fleet Management Asset Maintenance History Workorder: 835552 In Date: 03/13/2008 Close Date: 03/14/2008 SISTERS TOWING & TRANSPORTATON TOW FROM 980 CRESTW Sisters Towing & Transportaton Tow From 980 Crestwood Blvd, Rpb Tow To Sr Fleet Charge: 0.00

More information

PUMP MAINTENANCE SCHEDULE AND CHECKLISTS

PUMP MAINTENANCE SCHEDULE AND CHECKLISTS PUMP MAINTENANCE SCHEDULE AND CHECKLISTS Providing a maintenance schedule defined specifically by run hours or yardage pumped serves only as a general guideline given the large amount of variables a unit

More information

REMOVAL AND INSTALLATION

REMOVAL AND INSTALLATION 303-01C-1 REMOVAL AND INSTALLATION Engine Body On Special Tool(s) Adapter For 303-D043 303-D043-02 or equivalent Special Tool(s) 303-01C-1 Turbocharger Lifting Bracket 303-1266 Wrench, Fan Clutch Nut 303-214

More information

CLASS B PRE-TRIP INSPECTION STUDY GUIDE

CLASS B PRE-TRIP INSPECTION STUDY GUIDE Miami School 3790 NW 11 th St. Miami, Fl 33126 305-649-5344 La Belle School 250 E. Cowboy Way La Belle, Fl 33935 863-675-0755 STRAIGHT TRUCK FRONT OF VEHICLE CLASS B PRE-TRIP INSPECTION STUDY GUIDE Chock

More information

Duramax Maintenance Info

Duramax Maintenance Info The following maintenance schedule was arranged using information from GM, OEM manufacturers and personal experience. It does not represent the standard and should only be used as reference, you may choose

More information

Volkswagen Jetta, Golf, GTI 1999, 2000 2.8 Liter VR6 2V Engine Mechanical, Engine Code(s): AFP 17 Engine-Lubrication (Page GR-17)

Volkswagen Jetta, Golf, GTI 1999, 2000 2.8 Liter VR6 2V Engine Mechanical, Engine Code(s): AFP 17 Engine-Lubrication (Page GR-17) 17 Engine-Lubrication (Page GR-17) Lubrication system components, removing and installing Oil filter housing, disassembling and assembling Oil pan, removing and installing Oil pressure and oil pressure

More information

GENUINE PARTS INSTALLATION INSTRUCTIONS

GENUINE PARTS INSTALLATION INSTRUCTIONS GENUINE PARTS INSTALLATION INSTRUCTIONS DESCRIPTION: Illuminated Kick Plate APPLICATION: Rogue (2011) PART NUMBER: 999G6 GX010 KIT CONTENTS: Item A B C G H QTY 1 1 1 D 1 E 1 F 3 15 6 Description Kick Plate,

More information

6-years/75,000 miles Comprehensive coverage Subsequent Owner Warranty $100 Deductible

6-years/75,000 miles Comprehensive coverage Subsequent Owner Warranty $100 Deductible LINCOLN PREMIER LIMITED WARRANTY 6-years/75,000 miles Comprehensive coverage Subsequent Owner Warranty $100 Deductible Comprehensive Coverage Because Lincoln has always been a brand you can trust and respect,

More information

DESTROKED. Circuits that will be run through the Ford PCM and Ford Engine Harness

DESTROKED. Circuits that will be run through the Ford PCM and Ford Engine Harness DESTROKED Thank you for your interest in Destroked. Please read through this overview to get a good idea of what is involved in your Cummins conversion project. Circuits that will be run through the Ford

More information

Turbocharger system components, servicing

Turbocharger system components, servicing 21-1 Turbocharger system components, servicing Engine codes: AAZ, 1Z, AHU Observe rules of cleanliness Page 21-10 Turbocharger hoses and lines, connecting Page 21-11 WARNING! Do not re-use any fasteners

More information

DR90. Baja Motorsports Inc. P.O. Box 61150 Phoenix, AZ 85082 Toll Free: 888-863-2252 PART NUMBERS AND PRICES ARE SUBJECT TO CHANGE 1 of 51

DR90. Baja Motorsports Inc. P.O. Box 61150 Phoenix, AZ 85082 Toll Free: 888-863-2252 PART NUMBERS AND PRICES ARE SUBJECT TO CHANGE 1 of 51 DR90 Toll Free: 888-863-2252 PART NUMBERS AND PRICES ARE SUBJECT TO CHANGE 1 of 51 CYLINDER & CYLINDER HEAD 1 DR90-001 842645048166 CYLINDER 1 1 2 DR90-002 842645048173 GASKET, CYLINDER 1 1 3 DR90-003

More information

1/29/2008 DR125 / DR150. Baja Motorsports Inc. P.O. Box 61150 Phoenix, AZ 85082 Toll Free: 888-863-2252 PARTS AND PRICES ARE SUBJECT TO CHANGE 1 of 55

1/29/2008 DR125 / DR150. Baja Motorsports Inc. P.O. Box 61150 Phoenix, AZ 85082 Toll Free: 888-863-2252 PARTS AND PRICES ARE SUBJECT TO CHANGE 1 of 55 DR125 / DR150 Toll Free: 888-863-2252 PARTS AND PRICES ARE SUBJECT TO CHANGE 1 of 55 CYLINDER HEAD ASSY. 1 125-001 883099006937 CYLINDER HEAD COVER 1 1 2 125-002 883099006944 BOLT M6X28 2 3 3 125-003 883099006951

More information

UDOT RPMS VEHICLE RECORDS, PREVENTIVE MAINTENANCE & SURVEILLANCE

UDOT RPMS VEHICLE RECORDS, PREVENTIVE MAINTENANCE & SURVEILLANCE UDOT RPMS VEHICLE RECORDS, PREVENTIVE MAINTENANCE & SURVEILLANCE VEHICLE RECORDS AND PREVENTIVE MAINTENANCE Prepared by: UTAH DEPARTMENT OF TRANSPORTATION OFFICE OF PLANNING AND PROGRAMMING IN COOPERATION

More information

2017 Audi Maintenance Schedule - All Models

2017 Audi Maintenance Schedule - All Models 2017 Audi Maintenance Schedule - All Models MY 2017 Maintenance Intervals - USA Service Intervals If you are not sure when you should bring your Audi in for service or which services are to be performed

More information

INSTALLATION MANUAL 3RP / 5RP 4-BUTTON SERIES VEHICLE SECURITY SYSTEMS

INSTALLATION MANUAL 3RP / 5RP 4-BUTTON SERIES VEHICLE SECURITY SYSTEMS 3RP / 5RP 4-BUTTON SERIES VEHICLE SECURITY SYSTEMS INSTALLATION MANUAL Before you begin the installation Read the INSTRUCTIONS! Always use a multi-meter when verifying vehicle wiring. Before mounting the

More information

Rail 001 112 2 Canvas, folding top 001 101 3 Rear panel 001 102 4 Stip in window, left 001 106 dto. right 001 107

Rail 001 112 2 Canvas, folding top 001 101 3 Rear panel 001 102 4 Stip in window, left 001 106 dto. right 001 107 U 411 1 Rear view mirror, round, metall 13cm Ø 002 045 2 Raised airintake 002 060 3 Side panelling, front, left 002 030 Side panelling, front, right 002 031 4 Panelling left 002 051 dto. right 002 052

More information

Volkswagen New Beetle 2.0 Liter 4-cyl General, Engine (Engine Code AEG) 17 Engine-Lubrication system (Page GR-17)

Volkswagen New Beetle 2.0 Liter 4-cyl General, Engine (Engine Code AEG) 17 Engine-Lubrication system (Page GR-17) 17 Engine-Lubrication system (Page GR-17) Lubrication system components, removing and installing Oil pan, removing and installing Oil pressure and oil pressure switch, checking Dynamic oil pressure warning

More information

Figure 2 The fan and shroud also needs to be removed for access to the four a/c compressor bolts and removal of the compressor from the top.

Figure 2 The fan and shroud also needs to be removed for access to the four a/c compressor bolts and removal of the compressor from the top. Here are some pictures to show what s required when replacing the A/C compressor, expansion valve and receiver/drier on a 2001 Volvo V70. Even if you don t replace these A/C parts these pictures can help

More information

DR50 Hensim Dirt Runner 49cc Dirt Bike (VIN PREFIX LLCH or LUAH)

DR50 Hensim Dirt Runner 49cc Dirt Bike (VIN PREFIX LLCH or LUAH) Page 1 of 21 Product Information Baja Web > Product Information > Parts Lists > DIRTBIKE > DR50 Hensim Dirt Runner 49cc Dirt Bike (VIN PREFIX LLCH or LUAH) DR50 Hensim Dirt Runner 49cc Dirt Bike (VIN PREFIX

More information

Cooling system components, removing and installing

Cooling system components, removing and installing Engine BHW Cooling system components, removing and installing Page 1 / 24 19-1 Cooling system components, removing and installing Warning! When doing any repair work, especially in the engine compartment,

More information

AUTOMOBILE MECHANIC STUDENT INTERNSHIP SKILLS LIST Provo School District

AUTOMOBILE MECHANIC STUDENT INTERNSHIP SKILLS LIST Provo School District AUTOMOBILE MECHANIC STUDENT INTERNSHIP SKILLS LIST Provo School District Repairs and overhauls automobiles, buses, trucks, and other automotive vehicles: Examines vehicle and discusses with customer or

More information

Southern Columbia Area School District Bus/Automotive Parts for Sale. PartNo Description Vendor Amount 1 583966C91 EXHAUST CLAMP 1 2 905-09 PIPE 1

Southern Columbia Area School District Bus/Automotive Parts for Sale. PartNo Description Vendor Amount 1 583966C91 EXHAUST CLAMP 1 2 905-09 PIPE 1 Southern Columbia Area School District Bus/Automotive Parts for Sale PartNo Description Vendor Amount 1 583966C91 EXHAUST CLAMP 1 2 905-09 PIPE 1 3 00025296 BACK UP LIGHTS 1 4 00109869 HARNESS Bus Parts

More information

ENGINE Dinli 904 D1033-011

ENGINE Dinli 904 D1033-011 ENGINE Dinli 904 D1033-011 ENGINE Model Item Part no Description Specification Quantity 01 E140000-01 E14 ENGINE 450C.C. 1 FENDER SEAT D1033-021 FENDER SEAT Model Item Part no Description Specification

More information

2003 ACCORD - Automatic Transmission Removal

2003 ACCORD - Automatic Transmission Removal 2003 ACCORD - Automatic Transmission Removal Special Tools Required Engine support hanger, A and Reds AAR-T-12566 Engine hanger balancer bar VSB02C000019 Front subframe adapter VSB02C000016 These special

More information

INSTALLATION INSTRUCTIONS. 6111 Air Spring Kit 2011+ Ford F250/F-350 Single Wheel 2WD 2011+ Ford F350 Dually 2WD IMPORTANT NOTES

INSTALLATION INSTRUCTIONS. 6111 Air Spring Kit 2011+ Ford F250/F-350 Single Wheel 2WD 2011+ Ford F350 Dually 2WD IMPORTANT NOTES INSTALLATION INSTRUCTIONS 6111 Air Spring Kit 2011+ Ford F250/F-350 Single Wheel 2WD 2011+ Ford F350 Dually 2WD Thank you for purchasing a quality Hellwig Product. PLEASE READ THIS INSTRUCTION SHEET COMPLETELY

More information

Work Order History Report

Work Order History Report Work Order History Report Asset MG304 Asset: MG304, Including Children, Active: True Grader, motor W/O No Description Finished Done 1570 MG304 - Perform Plant Audit and Mobile Plant Mechanical Check List.

More information

TABLE OF CONTENTS. Section 1 - Assembling your new pit bike.

TABLE OF CONTENTS. Section 1 - Assembling your new pit bike. Orion Pit Bike Sales Owners Manual (All information and content is the property of Orion Pit Bike Sales. Any attempt to copy or resell is a direct violation of our copyright. All violators will be prosecuted)

More information

Palm Beach County Fleet Management Asset Maintenance History

Palm Beach County Fleet Management Asset Maintenance History Workorder: 463074 Meter Reading: 1 In Date: 11/30/2004 Close Date: 11/30/2004 Install Trailer Plug Charge: INSTALL TRAILER PLUG 1.50 7555046 MALE CONNECTOR 1.00 6.96 Charge: 75.00 Workorder: 463116 In

More information

Preventative Maintenance Policies and Plan

Preventative Maintenance Policies and Plan Preventative Maintenance Policies and Plan The objectives of the NECTD Preventative Maintenance Policies and Plan are: Ensure that assets are protected and maintained so that they reach their maximum useful

More information

Air Vantage 500 Kubota

Air Vantage 500 Kubota Illustration of Sub Assemblies Illustration of Sub Assemblies Illustration of Sub Assemblies Illustration of Sub Assemblies P-625 P-625 RETURN TO MAIN INDEX PARTS LIST FOR Air Vantage 500 Kubota P-625-A

More information

COMMERCIAL GAS DRYER

COMMERCIAL GAS DRYER COMMERCIAL GAS DRYER MODELS CGD8990XW0 4 12 Litho In U.S.A. (CMS) (psw) c 2012 WHIRLPOOL CORPORATION Part No. Rev. B TOP AND CONSOLE PARTS 2 TOP AND CONSOLE PARTS 1 Literature Parts W10184516 Installation

More information

ILLUSTRATED PARTS LIST

ILLUSTRATED PARTS LIST CW11 / TW11 / TW11R WITH 340cc HONDA ENGINE 800-643-7332 amsportworks.com NOTE: Some part numbers vary by serial number. The serial number is located on a brass tag beneath the dump bed on the driver side.

More information

PREVENTION MAINTENANCE CHECKLIST FOR TRACTORS, TRUCKS, AND AUTOMOBILES

PREVENTION MAINTENANCE CHECKLIST FOR TRACTORS, TRUCKS, AND AUTOMOBILES PREVENTION MAINTENANCE CHECKLIST FOR TRACTORS, TRUCKS, AND AUTOMOBILES Farm Machinery Fact Sheet FM-21 By Dr. Von H. Jarrett, Extension Agricultural Engineer Systematic sequence for inspection GASOLINE

More information

ENGINE FUEL FUEL FILTER... FUEL HEATER... INJECTOR... SUPPLY PUMP... COMMON RAIL... FUEL PRESSURE LIMITTER...

ENGINE FUEL FUEL FILTER... FUEL HEATER... INJECTOR... SUPPLY PUMP... COMMON RAIL... FUEL PRESSURE LIMITTER... FUEL FILTER............................ FUEL HEATER.......................... INJECTOR.............................. SUPPLY PUMP.......................... COMMON RAIL.......................... FUEL PRESSURE

More information

DR90. Baja Motorsports Inc. P.O. Box 61150 Phoenix, AZ 85082 Toll Free: 888-863-2252 PART NUMBERS AND PRICES ARE SUBJECT TO CHANGE 1 of 51

DR90. Baja Motorsports Inc. P.O. Box 61150 Phoenix, AZ 85082 Toll Free: 888-863-2252 PART NUMBERS AND PRICES ARE SUBJECT TO CHANGE 1 of 51 DR90 Toll Free: 888-863-2252 PART NUMBERS AND PRICES ARE SUBJECT TO CHANGE 1 of 51 CYLINDER & CYLINDER HEAD Part UPC Number Description Baja Description 1 DR90-001 842645048166 CYLINDER 1 1 2 DR90-002

More information

1/29/2008 DR70. Baja Motorsports Inc. P.O. Box 61150 Phoenix, AZ 85082 Toll Free: 888-863-2252 PART NUMBERS PRICES ARE SUBJECT TO CHANGE 1 of 43

1/29/2008 DR70. Baja Motorsports Inc. P.O. Box 61150 Phoenix, AZ 85082 Toll Free: 888-863-2252 PART NUMBERS PRICES ARE SUBJECT TO CHANGE 1 of 43 DR70 Toll Free: 888-863-2252 PART NUMBERS PRICES ARE SUBJECT TO CHANGE 1 of 43 CYLINDER & CYLINDER HEAD 1 DR70-001 883099044472 CYLINDER 1 1 2 DR70-002 883099044489 GASKET, CYLINDER 1 1 3 DR70-003 883099044496

More information

specializing in AIR CONDITIONING, PARTS AND SYSTEMS for your classic vehicle PERFECT FIT IN-DASH HEAT/ COOL/ DEFROST 1967-72 CHEVROLET PICKUP

specializing in AIR CONDITIONING, PARTS AND SYSTEMS for your classic vehicle PERFECT FIT IN-DASH HEAT/ COOL/ DEFROST 1967-72 CHEVROLET PICKUP specializing in AIR CONDITIONING, PARTS AND SYSTEMS for your classic vehicle PERFECT FIT IN-DASH HEAT/ COOL/ DEFROST 1967-72 CHEVROLET PICKUP CONTROL & OPERATING INSTRUCTIONS The controls on your new Perfect

More information

Trouble Shooting. Pump

Trouble Shooting. Pump Trouble Shooting Pump Trouble Possible Cause Remedy Oil leaking in the area of water pump crankshaft Worn crankshaft seal, bad bearing, grooved shaft, or failure of retainer o-ring. Excessive play on crankshaft

More information

Not required for most applications Not required for most applications High pressure (12-803 provided) High pressure (12-803 provided)

Not required for most applications Not required for most applications High pressure (12-803 provided) High pressure (12-803 provided) ELECTRIC FUEL PUMPS P/N 12-801-1, 712-801-1, 12-802-1, 712-802-1, 12-815-1, & 712-815-1 FUEL PRESSURE REGULATORS P/N 12-803, 12-501, 12-804, 12-500, & 15812NOS Installation Instructions THESE INSTRUCTIONS

More information

Technical Guide 08/15/14

Technical Guide 08/15/14 Technical Guide 08/15/14 1 Table of Contents Contact information.3 Identifying your system..4-8 Model Number Serial number location Parts of your fuel system..9-14 Fuel pump diagram Wire harness schematics

More information

CPL SYSTEMS / GROENEVELD AUTOMATIC GREASING SYSTEM COMPLETE SYSTEM CHECK PNEUMATIC PUMP

CPL SYSTEMS / GROENEVELD AUTOMATIC GREASING SYSTEM COMPLETE SYSTEM CHECK PNEUMATIC PUMP CPL SYSTEMS / GROENEVELD AUTOMATIC GREASING SYSTEM COMPLETE SYSTEM CHECK PNEUMATIC PUMP Feb 5, 2003 1 CPL SYSTEMS / GROENEVELD AUTOMATIC GREASING COMPLETE SYSTEM CHECK - PNEUMATIC PUMP THE SYSTEM DOES

More information

INSTALLATION INSTRUCTIONS. 6108 Air Spring Kit 2011+ Ford F250 Single Wheel 4WD 2011+ Ford F350 Dually 4WD (2011 F350 Single Wheel 4WD use p/n 6113)

INSTALLATION INSTRUCTIONS. 6108 Air Spring Kit 2011+ Ford F250 Single Wheel 4WD 2011+ Ford F350 Dually 4WD (2011 F350 Single Wheel 4WD use p/n 6113) INSTALLATION INSTRUCTIONS 6108 Air Spring Kit 2011+ Ford F250 Single Wheel 4WD 2011+ Ford F350 Dually 4WD (2011 F350 Single Wheel 4WD use p/n 6113) Thank you for purchasing a quality Hellwig Product. PLEASE

More information

Katana Supercharger Installation Instructions Rev. E Page 1 of 23

Katana Supercharger Installation Instructions Rev. E Page 1 of 23 Katana Supercharger Installation Instructions Rev. E Page 1 of 23 READ FITTING INSTRUCTIONS IN FULL BEFORE INSTALLATION This article is sold without warranty expressed or implied. No warranty or representation

More information

ILLUSTRATED PARTS LIST

ILLUSTRATED PARTS LIST TW400 WITH 390cc HONDA ENGINE 390cc 2 WHEEL DRIVE UTILITY VEHICLE ILLUSTRATED S LIST 390cc 2WD B O D Y D I A G R A M 390cc 2WD F R A M E D I A G R A M 390cc 2WD D R I V E T R A I N D I A G R A M DESCRIPTION

More information

2009 QUICK REFERENCE GUIDE GET INFORMED. ROLL.

2009 QUICK REFERENCE GUIDE GET INFORMED. ROLL. xb 2009 QUICK REFERENCE GUIDE GET INFORMED. ROLL. 2009 Scion xb This Quick Reference Guide is a summary of basic vehicle operations. It contains brief descriptions of fundamental operations so you can

More information

DR125 and DR150 Hensim Dirt Runner 125cc and 150cc Dirt Bike (VIN PREFIX LLCH or LUAH)

DR125 and DR150 Hensim Dirt Runner 125cc and 150cc Dirt Bike (VIN PREFIX LLCH or LUAH) Parts Lists - DR125 and DR150 Hensim Dirt Runner 125cc and 150cc Dirt Bike (VIN PR... Page 1 of 25 Product Information Baja Web > Product Information > Parts Lists > DIRTBIKE > DR125 and DR150 Hensim Dirt

More information

COOLING SYSTEM Section Page

COOLING SYSTEM Section Page 5 COOLING SYSTEM Section Page 5.1 COOLANT PRE-HEATER... 5-3 5.2 COOLANT PUMP NON-EGR ENGINE... 5-7 5.3 COOLANT PUMP EGR ENGINE... 5-13 5.4 FRONT CONNECTOR HOUSING NON-EGR ENGINE... 5-17 5.5 FRONT CONNECTOR

More information

ADDING AN ELECTRIC AUXILIARY FAN TO RADIATOR STACK ON 03 ALPINE COACH

ADDING AN ELECTRIC AUXILIARY FAN TO RADIATOR STACK ON 03 ALPINE COACH ADDING AN ELECTRIC AUXILIARY FAN TO RADIATOR STACK ON 03 ALPINE COACH The original design of the 03 Alpine Coaches (and perhaps other years as well) did not include any kind of engine fan engage mechanism

More information

ACCUMULATOR INSTALLATION

ACCUMULATOR INSTALLATION 7001-7 ACCUMULATOR INSTALLATION BRAKE ACCUMULATORS I 308L93 Rae 7-59710 Issued 6-93 Printed in U.S.A 7001-8 Removal ACCUMULATOR VALVE 1. Park the machine on a level surface and lower the. loader bucket

More information

Third Edition. 1970-72 Corvette Technical Information Manual & Judging Guide Index

Third Edition. 1970-72 Corvette Technical Information Manual & Judging Guide Index Third Edition 1970-72 Corvette Technical Information Manual & Judging Guide Index Index INTERIOR Page 3 1. Upholstery and Seat Belts Page 5 1.1. Vinyl Upholstery Page 5 1.2. Custom (Leather) Upholstery

More information

Sample G1 ASE-type Certification Test. Sample ASE Maintenance and Light Repair (G1)-Type Certification Test

Sample G1 ASE-type Certification Test. Sample ASE Maintenance and Light Repair (G1)-Type Certification Test Sample G1 ASE-type Certification Test Sample ASE Maintenance and Light Repair (G1)-Type Certification Test Content Area Questions In Test Percentage Of Test A. Engine Systems 9 16% B. Automatic 4 7% Transmissions

More information

MOTOR VEHICLE MECHANIC REPAIR CATEGORIES

MOTOR VEHICLE MECHANIC REPAIR CATEGORIES Chapter 8: Motor Vehicle Mechanic Repair Categories Page 1 CHAPTER 8 MOTOR VEHICLE MECHANIC REPAIR CATEGORIES Section 8-1 REQUIREMENT Section 10 of the Motor Vehicle Service and Repair Act (MCL 257.1310)

More information

INSIDE ENGINE COMPARTMENT TOYOTA AIR CONDITIONING ENGLISH EUROPE,GENERAL,AUSTRALIA

INSIDE ENGINE COMPARTMENT TOYOTA AIR CONDITIONING ENGLISH EUROPE,GENERAL,AUSTRALIA INSIDE ENGINE COMPARTMENT TOYOTA AIR CONDITIONING ENGLISH EUROPE,GENERAL,AUSTRALIA INTRODUCTION IMPORTANT NOTICE This manual has been designed for technicians who are qualified and educated in the proper

More information

VOYAGER 570G. 744A Sprayer Control

VOYAGER 570G. 744A Sprayer Control VOYAGER 570G 744A Sprayer Control U S E R M A N U A L U S E R M A N U A L Table of Contents CHAPTER 1 - INTRODUCTION...1 SYSTEM CONFIGURATIONS...1 KIT CONTENTS...3 CONTROL HOUSING ASSEMBLY...5 CHAPTER

More information

Cooling system components, removing and installing

Cooling system components, removing and installing Page 1 of 30 19-1 Cooling system components, removing and installing Notes: When the engine is warm the cooling system is under pressure. If necessary release pressure before commencing repair work. Secure

More information

SERVICE GUIDE For WARN PULLZALL 120v AC &100v AC P/N 685000 & 685001

SERVICE GUIDE For WARN PULLZALL 120v AC &100v AC P/N 685000 & 685001 SERVICE GUIDE For WARN PULLZALL 120v AC &100v AC P/N 685000 & 685001 REPAIR / REPLACEMENT INSTRUCTIONS TROUBLE SHOOTING GUIDE 986765A2.doc Page 1 of 50 WARNING This guide identifies potential hazards and

More information

1998½-2007 Dodge Ram 5.9L Cummins

1998½-2007 Dodge Ram 5.9L Cummins 9 January 2014 1081130-33 Dodge Cummins Low Fuel Pressure Alarm Light Kit (I-00143) 1 1998½-2007 Dodge Ram 5.9L Cummins LOW FUEL PRESSURE ALARM LIGHT - Installation Manual - Part Number Sequence: 1081130

More information

OVEN PARTS For Models:GSC308PJB05, GSC308PJQ05, GSC308PJT05, GSC308PJS05 (Black) (White) (Biscuit) (Black Stainless)

OVEN PARTS For Models:GSC308PJB05, GSC308PJQ05, GSC308PJT05, GSC308PJS05 (Black) (White) (Biscuit) (Black Stainless) OVEN PARTS 30" BUILT IN ELECTRIC COMBO SENSOR/SC (GOLD LINE) 3 05 Litho In U.S.A. (cre) 1 Part No. Rev.A OVEN PARTS 1 Literature Parts 4455994 Installation Instructions Use & Care Guide 8300346 Microwave

More information

Gas Oven Repair Guide

Gas Oven Repair Guide - /6 - Gas Oven Repair Guide [ FX70*, FX50*] Ver. Aug-0 Ignition Failure Cooktop ignition Oven ignition Heating defect Oven Cooktop Abnormal Flame Button, Motors Lamp Others Smell, Smoke, Noise No Display,

More information

G PART NUMBER OF CONNECTORS

G PART NUMBER OF CONNECTORS A 1 A/C Ambient Temp. Sensor 90980 11070 Buckle SW RH (w/ Power Seat) A/C Condenser Fan Motor (1G FE) 90980 10928 B 9 Buckle SW RH (w/o Power Seat) 90980 11212 A 2 A/C Condenser Fan Motor (2JZ GE) 90980

More information

Cooling system components, servicing

Cooling system components, servicing 19-1 Cooling system components, servicing WARNING! The cooling system is pressurized when the engine is warm. When opening the expansion tank, wear gloves and other appropriate protection, cover the cap

More information

P150SC15. Designed for 2015 Ford F150 Super-Cab and Super-Crew vehicles without Sony System. 2015 Stillwater Designs P150SC15-A2-20150813

P150SC15. Designed for 2015 Ford F150 Super-Cab and Super-Crew vehicles without Sony System. 2015 Stillwater Designs P150SC15-A2-20150813 P150SC15 Designed for 2015 Ford F150 Super-Cab and Super-Crew vehicles without Sony System Subwoofer Assembly Amplifier Assembly Amplifier Harness 2015 Stillwater Designs P150SC15-A2-20150813 M6 Bolt M6

More information

Intake Manifold: Service and Repair

Intake Manifold: Service and Repair 2000 Chevy Truck S10/T10 P/U 2WD L4-2.2L VIN 4 Copyright 2008, ALLDATA 9.90 Page 1 Intake Manifold: Service and Repair Removal Procedure 1. Disconnect the battery negative cable. Refer to Battery Replacement.

More information

Important: Please read these instructions carefully and completely before starting the installation. TITAN Fuel Tanks

Important: Please read these instructions carefully and completely before starting the installation. TITAN Fuel Tanks TITAN pt. no.: 03 0000 0120 Important: Please read these instructions carefully and completely before starting the installation. TITAN Fuel Tanks INSTALLATION INSTRUCTIONS G e n e r a t i o n V Extended

More information

Power Door Locks Cruise Control System. Cigarette Lighter. Blower. Fan. Windshield Wiper System. See Note. High Wiper. Med. Low.

Power Door Locks Cruise Control System. Cigarette Lighter. Blower. Fan. Windshield Wiper System. See Note. High Wiper. Med. Low. + + Power Door Locks Cruise Control System Cigarette Lighter Power Windows Blower Fan Windshield Wiper System Clock Radio Rev. Light Switch See Note HVAC Side Marker Light Park/Turn Signal Low/High Beam

More information

Companion Service Guide

Companion Service Guide Companion Service Guide This Service Guide contains: Troubleshooting Replacement Instructions Contact Information Golden Technologies 401 Bridge Street Old Forge, PA 18518 Toll-free: 800-624-6374 Fax:

More information

13. REAR WHEEL/BRAKE/SUSPENSION

13. REAR WHEEL/BRAKE/SUSPENSION 13. REAR WHEEL/BRAKE/SUSPENSION 13 3.5~4.5kg-m 8.0~10.0kg-m 0.8~1.2kg-m 3.0~4.0kg-m 2.4~3.0kg-m 3.5~4.5kg-m 6.0~8.0kg-m 13-0 13. REAR WHEEL/BRAKE/SUSPENSION 13 REAR WHEEL/BRAKE/SUSPENSION SERVICE INFORMATION...

More information

MERCEDES FIRST EDITION - 2013

MERCEDES FIRST EDITION - 2013 FIRST EDITION - 2013 CONTENTS Accessories... 1 Hydraulic Jacks Air Intake... 2 Air Filter Charger Charging System Intake Charger Hose Intake Manifold Intake Pipe Air Filter Intercooler Charger Aircondition...

More information

BUGGY SETUP GUIDE. Volume GOKARTSUSA GY6 150, CN250. Buggy Setup Guide

BUGGY SETUP GUIDE. Volume GOKARTSUSA GY6 150, CN250. Buggy Setup Guide BUGGY SETUP GUIDE Volume 1 GOKARTSUSA GY6 150, CN250 Buggy Setup Guide GY6 150, CN250 DUNE BUGGY Buggy Setup Guide GOKARTSUSA.COM 2000 Highway 50 S. Lake Tahoe, CA 96150 Phone 800.603.1437 2 Table of Contents

More information

Neptune. replace. Owners Manual

Neptune. replace. Owners Manual Neptune replace Owners Manual Training with the Neptune Rower 1. As with any piece of fitness equipment, consult a physician before beginning your Neptune Rower exercise program. 2. Follow instructions

More information

Power Cube Open Source Ecology Page 1. Power Cube. Version 4

Power Cube Open Source Ecology Page 1. Power Cube. Version 4 Power Cube Open Source Ecology Page 1 Power Cube Version 4 Power Cube Open Source Ecology Page 2 Contents Table of Contents Power Cube... 1 Contents...2 Introduction... 3 Bill Of Materials...4 Discrete

More information

Subaru Reference. This reference contains the following information: connector pinouts. connector pinouts

Subaru Reference. This reference contains the following information: connector pinouts. connector pinouts Subject: Source: 1993 2010 Impreza, WRX, and Sti and 2002 07 Outback Sport ABS wiring diagrams, harness routing, and connector locations and pinouts Subaru service manuals This reference contains the following

More information

Lancair Legacy Annual Condition Inspection Checklist

Lancair Legacy Annual Condition Inspection Checklist Lancair Legacy Annual Condition Inspection Checklist Performed by: Completion Date: Complete Maintenance/Inspection Item Comments Pre-Inspection Research AD and Service bulletins Inspect entire airframe

More information

INSTRUMENT PANEL. 1995 Volvo 850 DESCRIPTION & OPERATION. 1995-96 ACCESSORIES & EQUIPMENT Volvo Instrument Panels

INSTRUMENT PANEL. 1995 Volvo 850 DESCRIPTION & OPERATION. 1995-96 ACCESSORIES & EQUIPMENT Volvo Instrument Panels INSTRUMENT PANEL 1995 Volvo 850 1995-96 ACCESSORIES & EQUIPMENT Volvo Instrument Panels 850 WARNING: When working around steering column and before performing repairs, disconnect and shield battery ground

More information

KEYLESS ENTRY UPGRADE SECURITY SYSTEM for 2004 TOYOTA HIGHLANDER

KEYLESS ENTRY UPGRADE SECURITY SYSTEM for 2004 TOYOTA HIGHLANDER KEYLESS ENTRY UPGRADE SECURITY SYSTEM for 2004 TOYOTA HIGHLANDER DEALER SERVICE AND INSTALLATION MANUAL KIT NO. 00016-30915 Contents PARTS LIST... 2 PARTS ILLUSTRATIONS... 2 VEHICLE PREPARATION... 3 INSTALLING

More information

JANUS INTERNATIONAL CORPORATION INSTALLATION INSTRUCTIONS Pantheon Mini Operator

JANUS INTERNATIONAL CORPORATION INSTALLATION INSTRUCTIONS Pantheon Mini Operator JANUS INTERNATIONAL CORPORATION INSTALLATION INSTRUCTIONS Pantheon Mini Operator The Janus Pantheon mini operator does not typically require the provision of any additional site requirements other than

More information

123 Industrial Loop Road Paynesville, MN 56362 Phone: 1-800-864-1649 www.master-mfg.com

123 Industrial Loop Road Paynesville, MN 56362 Phone: 1-800-864-1649 www.master-mfg.com 123 Industrial Loop Road Paynesville, MN 56362 Phone: 1-800-864-1649 www.master-mfg.com INTRODUCTION The purpose of this manual is to assist you in the assembly, operation and maintenance of your sprayer

More information

Railgates By THIEMAN IMPORTANT! KEEP IN VEHICLE! PLEASE READ AND UNDERSTAND THE CONTENTS OF THIS MANUAL BEFORE OPERATING THE EQUIPMENT.

Railgates By THIEMAN IMPORTANT! KEEP IN VEHICLE! PLEASE READ AND UNDERSTAND THE CONTENTS OF THIS MANUAL BEFORE OPERATING THE EQUIPMENT. TVL SERIES Railgates By THIEMAN TVL 20, TVL 30, TVL 20A, TVL 30A OWNERS MANUAL/PARTS LIST! IMPORTANT! KEEP IN VEHICLE! PLEASE READ AND UNDERSTAND THE CONTENTS OF THIS MANUAL BEFORE OPERATING THE EQUIPMENT.

More information

Cooling system components

Cooling system components Page 1 / 33 19-1 Cooling system components Caution! When doing any repair work, especially in the engine compartment, pay attention to the following due to clearance issues: Route lines of all types (e.g.

More information

Solstice/Sky Water Pump Replacement

Solstice/Sky Water Pump Replacement Solstice/Sky Water Pump Replacement The water pump on the Solstice/Sky is starting to need replacement on some vehicles. This guide will help in replacing the water pump while the engine is still in the

More information

Volkswagen Golf 5 2004-> VW Rabbit GTI 2006->

Volkswagen Golf 5 2004-> VW Rabbit GTI 2006-> Стр. 1 из 24 Volkswagen Golf 5 2004-> VW Rabbit GTI 2006-> 19-1 Cooling system components Warning! Hot steam may escape when opening expansion tank. Wear protective goggles and protective clothing to prevent

More information

WARNING! REQUIRED TOOLS & SUPPLIES: HIGH VOLTAGE

WARNING! REQUIRED TOOLS & SUPPLIES: HIGH VOLTAGE INSTRUCTIONS Product: GEM Electric Motorcars Models: All Subject: Instructions for installing Stereo Accessory Estimated Completion Time:.75 Hours Parts: See Page # 7 REQUIRED TOOLS & SUPPLIES: (1) 3/8

More information