Safety data sheet according to 1907/2006/EC, Article 31

Transcription

1 Page 1/8 1 Identification of the substance/mixture and of the company/undertaking Date of issue: Product identifier Trade name: Formengips PRIMODUR 25, -48, -52, -54, -56, -58, -P, -R, -S rot, PRIMOSUPRA 60, -62, - 64, - Relevant identified uses of the substance or mixture and uses advised against not determined Application of the substance / the preparation: Construction chemicals Building material Filler / Extender Details of the supplier of the safety data sheet Manufacturer / Supplier: Overlack GmbH +49(+2161)3560 Aachener Straße Mönchengladbach - Niederlassung Arnsperger Tel.: +49(+2234) Toyota-Allee Köln - Niederlassung Ost Tel.: +49(+341) Gutberletstraße Leipzig - Niederlassung Süd Tel.:+49(+8234) Max-Fischer-Straße Bobingen - Niederlassung Nord Tel.: +49(+40) Colonnaden Hamburg - Niederlassung Mitte Tel.: +49(+621) Turmstraße Ludwigshafen Overlack Global/Chemical GmbH Tel.: +49(+211) Paul-Thomas-Str Düsseldorf-Reisholz Overlack B.V. Tel.: +31(+499) Ekkersrijt 1301 NL-5692 AJ Son/Eindhoven address of the competent person responsible for the Safety Data Sheet: [email protected] Informing department: Legal Compliance Only during office hours: 8:00-17:00 Emergency telephone number: Emergency Call: Poison Control Center Mainz - 24 hour Emergency service - Phone: +49 (0) 6131/19240 (Contd. on page 2)

2 Page 2/8 (Contd. of page 1) 2 Hazards identification Classification of the substance or mixture Classification according to Regulation (EC) No 1272/2008 The product is not classified according to the CLP regulation. Classification according to Directive 67/548/EEC or Directive 1999/45/EC Void Information concerning particular hazards for human and environment: void Classification system: The product does not have to be labelled due to the calculation procedure of the "General Classification guideline for preparations of the EU" in the latest valid version. Label elements Labelling according to Regulation (EC) No 1272/2008 Void Hazard pictograms Void Signal word Void Hazard statements Void Other hazards Results of PBT and vpvb assessment PBT: Not applicable. vpvb: Not applicable. 3 Composition/information on ingredients Chemical characterization: Mixtures Description: Mixture of the substances listed below with nonhazardous additions. Dangerous components: Void 4 First aid measures Description of first aid measures General information: No special measures required. After inhalation: Supply fresh air; consult doctor in case of symptoms. After skin contact: The product is not skin irritating. Rinse with plenty of water. After eye contact: Rinse opened eye for several minutes under running water. If symptoms persist, consult doctor. After swallowing: Rinse out mouth and then drink plenty of water. In case of persistent symptoms consult doctor. Information for doctor: Most important symptoms and effects, both acute and delayed No further relevant information available. Indication of any immediate medical attention and special treatment needed No further relevant information available. (Contd. on page 3)

3 Page 3/8 (Contd. of page 2) 5 Firefighting measures Extinguishing media Suitable extinguishing agents Product does not burn - take extinguishing measures according to fire conditions. For safety reasons unsuitable extinguishing agents none Special hazards arising from the substance or mixture Can be released in case of fire: Sulphur oxides (SOx) Calcium oxide Advice for firefighters Protective equipment: Wear self-contained breathing apparatus. Additional information Dispose of fire debris and contaminated fire fighting water in accordance with official regulations. 6 Accidental release measures Personal precautions, protective equipment and emergency procedures Ensure adequate ventilation. Avoid causing dust. Danger of slipping on leaked/spilled product. Environmental precautions: Do not allow to enter drainage system, surface or ground water. Methods and material for containment and cleaning up: Ensure adequate ventilation. Collect mechanically. Send for recovery or disposal in suitable containers. Dispose of the material collected according to regulations. Reference to other sections See Section 7 for information on safe handling See Section 8 for information on personal protection equipment. See Section 13 for information on disposal. 7 Handling and storage Handling Precautions for safe handling Ensure good ventilation/exhaustion at the workplace. Prevent formation of dust. Do not breathe dust. Make sure that all applicable workplace limits are observed. Avoid contact with eyes. Avoid prolonged or repeated skin contact. Information about protection against explosions and fires: The product is not flammable. (Contd. on page 4)

4 Page 4/8 Conditions for safe storage, including any incompatibilities Storage Requirements to be met by storerooms and containers: Store in the original container. Observe all local and national regulations for storage of water polluting products. Information about storage in one common storage facility: Store away from foodstuffs. Further information about storage conditions: Keep container tightly sealed. Store under dry conditions. Protect from humidity and keep away from water. Specific end use(s) No further relevant information available. (Contd. of page 3) 8 Exposure controls/personal protection Additional information about design of technical systems: No further data; see item 7. Control parameters Components with critical values that require monitoring at the workplace: Observe all workplace limits for dust. Additional information: The lists that were valid during the compilation were used as basis. Exposure controls Personal protective equipment General protective and hygienic measures Keep away from foodstuffs, beverages and food. Instantly remove any contaminated garments. Wash hands during breaks and at the end of the work. Avoid contact with the eyes. Avoid close or long term contact with the skin. Do not eat or drink while working. Breathing equipment: Use breathing protection in case of dust formation. If all workplace limits are observed and good ventilation is ensured, no special precautions necessary. Protection of hands: Protective gloves To avoid skin problems reduce the wearing of gloves to the required minimum. Check the permeability prior to each renewed use of the glove. The glove material has to be impermeable and resistant to the product/ the substance/ the preparation. Due to missing tests no recommendation to the glove material can be given for the product/ the preparation/ the chemical mixture. Selection of the glove material on consideration of the penetration times, rates of diffusion and the degradation. Material of gloves The selection of the suitable gloves does not only depend on the material, but also on further marks of quality and varies from manufacturer to manufacturer. As the product is a preparation of several substances, the resistance of the glove material can not be calculated in advance and has therefore to be checked prior to the application. (Contd. on page 5)

5 Page 5/8 (Contd. of page 4) Penetration time of glove material The exact break through time has to be found out by the manufacturer of the protective gloves and has to be observed. Eye protection: Safety glasses recommended during refilling. 9 Physical and chemical properties Information on basic physical and chemical properties General Information Appearance: Form: crystalline powder Colour: white Smell: weak, characteristic Odour threshold: not determined ph-value (6.7 g/l) at 20 C: Change in condition Melting point/melting range: 1450 C Boiling point/boiling range: not determined Flash point: not applicable Inflammability (solid, gaseous) Not determined. Ignition temperature: Decomposition temperature: Not determined. Self-inflammability: Product is not selfigniting. Danger of explosion: Product is not explosive. Critical values for explosion: Lower: Upper: Not determined. Not determined. Vapor pressure: Not applicable. Density at 20 C: 2.75 g/cm³ Bulk density at 20 C: kg/m³ Relative density Not determined. Vapour density (AIR = 1): Not applicable. Evaporation rate Not applicable. Solubility in / Miscibility with Water at 20 C: 6.7 g/l Segregation coefficient (n-octanol/water): Not determined. Viscosity: dynamic: kinematic: Not applicable. Not applicable. (Contd. on page 6)

6 Page 6/8 Organic solvents: 0.0 % Other information No further relevant information available. (Contd. of page 5) 10 Stability and reactivity Reactivity Chemical stability Thermal decomposition / conditions to be avoided: No decomposition if used according to specifications. Possibility of hazardous reactions No dangerous reactions known. Conditions to avoid No further relevant information available. Incompatible materials: No further relevant information available. Hazardous decomposition products: Sulphur oxides (SOx) Calcium oxide 11 Toxicological information Information on toxicological effects Acute toxicity: Primary irritant effect: on the skin: No irritant effect. on the eye: No irritant effect Sensitization: No sensitizing effect known. Additional toxicological information: When used and handled according to specifications, the product does not have any harmful effects according to our experience and the information provided to us. 12 Ecological information Toxicity Aquatic toxicity: EC50/48 h > 79 mg/l (water flea (daphnia magna)) (OECD 202, Limit-Test) EC50/72 h > 79 mg/l (algae (selenastrum capricornutum)) (OECD 201, Limit-Test) LC50/96 h > 79 mg/l (red killifish (Oryzias latipes)) (OECD 203, Limit-Test) Persistence and degradability No further relevant information available. Behaviour in environmental systems: Bioaccumulative potential No further relevant information available. Mobility in soil No further relevant information available. Additional ecological information: General notes: Do not allow product to reach ground water, water bodies or sewage system. Water hazard class 1 (Self-assessment): slightly hazardous for water (Contd. on page 7)

7 Page 7/8 Results of PBT and vpvb assessment PBT: Not applicable. vpvb: Not applicable. Other adverse effects No further relevant information available. (Contd. of page 6) 13 Disposal considerations Waste treatment methods Recommendation Disposal must be made according to official regulations. Waste disposal key number: According to local/national regulations. European waste catalogue: Waste disposal key numbers from EWC have to be assigned depending on origin and processing. Uncleaned packagings: Recommendation: Disposal must be made according to official regulations. Recommended cleaning agent: Water, if necessary with cleaning agent. 14 Transport information UN-Number ADR, ADN, IMDG, IATA Void UN proper shipping name ADR, ADN, IMDG, IATA Void Transport hazard class(es) ADR, ADN, IMDG, IATA Class Void Packing group ADR, IMDG, IATA Void Special precautions for user Not applicable. Transport in bulk according to Annex II of MARPOL73/78 and the IBC Code Not applicable. Transport/Additional information: Not dangerous according to the above specifications. UN "Model Regulation": - 15 Regulatory information Safety, health and environmental regulations/legislation specific for the substance or mixture Labelling according to Regulation (EC) No 1272/2008 Void Hazard pictograms Void Signal word Void (Contd. on page 8)

8 Page 8/8 Hazard statements Void National regulations Decree to be applied in case of technical fault: Directive 96/82/EC does not apply. Water hazard class: Water hazard class 1 (Self-assessment): slightly hazardous for water Chemical safety assessment: A Chemical Safety Assessment has not been carried out. (Contd. of page 7) 16 Other information These data are based on our present knowledge. However, they shall not constitute a guarantee for any specific product features and shall not establish a legally valid contractual relationship. Department issuing MSDS: C.S.B. GmbH Phone: Parkstraße 29 Fax: D Krefeld Germany Abbreviations and acronyms: ADR: Accord européen sur le transport des marchandises dangereuses par Route (European Agreement concerning the International Carriage of Dangerous Goods by Road) RID: Règlement international concernant le transport des marchandises dangereuses par chemin de fer (Regulations Concerning the International Transport of Dangerous Goods by Rail) IMDG: International Maritime Code for Dangerous Goods IATA: International Air Transport Association ICAO: International Civil Aviation Organization GHS: Globally Harmonized System of Classification and Labelling of Chemicals Sources: These data are based on information submitted by pre-suppliers.