Fluorocell PLT. Safety Data Sheet

Transcription

1 1. Identification Fluorocell PLT Safety Data Sheet According to 1907/2006/EC (REACH), 1272/2008/EC (CLP), and GHS 1.1 Product Identifier Trade Name: Article Number: 0741 CAS Number: EC Number: Index Number: Application of the Substance/Preparation: is a reagent for use with designated Sysmex Automated Hematology Analyzers. This reagent is to be handled by laboratory professionals or appropriately trained personnel. 1.3 Manufacturer or Distributor:,, Emergency Telephone Number: Contact CHEM-TEL at or Sysmex s CHEM-TEL # MIS Hazards Identification 2.1 Classification of the Substance or Mixture Classification according to Regulation (EC) No 1272/2008: GHS07 Acute Tox. 4 H302 Harmful if swallowed Classification according to Directive 67/548/EEC or Directive 1999/45/EC: Xn; Harmful R22: Harmful if swallowed Information concerning particular hazards for human and environment: Not applicable 2.2 Label Elements Labeling according to Regulation (EC) No 1272/2008: The product is classified and labeled according to the CLP Regulation Document No.: F-7052J Rev. 02 Page 1 of 11 Effective Date: 4/19/13

2 Hazard pictograms: GHS07 Signal Word: Warning Hazard-determining Components of Labeling: Ethanediol (Ethylene Glycol) Hazard Statements: H302 Harmful if swallowed Precautionary Statements: P264 Wash thoroughly after handling P270 Do not eat, drink or smoke when using this product P305+P351+P338 IF IN EYES: Rinse cautiously with water for several minutes. Remove contact lenses, if present and easy to do. Continue rinsing P501 Dispose of contents/container in accordance with local/regional/national/international regulations Hazard Description: WHMIS Symbols: D1B Toxic material causing immediate and serious toxic effects HMIS Long Term Health Hazard Substances: Substance is not listed 2.3 Other Hazards Results of PBT and vpvb assessment: PBT: Not applicable vpvb: Not applicable 3. Composition/Information on Ingredients 3.1 Substances CAS No. Description: Ethanediol (Ethylene Glycol), 99.9% Identification Number(s): EC Number: Index Number: EINECS: ; Xn R22 Index Number: ; Acute Tox. 4, H302 Document No.: F-7052J Rev. 02 Page 2 of 11 Effective Date: 4/19/13

3 Additional Information: The dye component, which is the active ingredient, is not listed here as a hazardous ingredient as it does not comprise 1% of the mixture, does not present a physical hazard, is not capable of release to exceed permissible exposure limit/threshold limit values and has not been identified as a carcinogen. For the wording of the listed risk phrases, refer to Section First Aid Measures 4.1 Description of First Aid Measures General Information: Symptoms of poisoning may even occur after several hours; therefore, medical observation for at least 48 hours after the accident Inhalation: Supply fresh air; consult doctor in case of complaints. Skin Contact: Clean with water and soap If skin irritation continues, consult a doctor Eye Contact: Protect unharmed eye Rinse opened eye for several minutes under running water Remove contact lenses if worn Rinse opened eye for several minutes under running water. If symptoms persist, consult a doctor Ingestion: Rinse out mouth and then drink plenty of water Do not induce vomiting; call for medical help immediately 4.2 Most Important Symptoms and Effects, Both Acute and Delayed Acidosis Nausea Cramp Thirst Hazards: Danger of hyperglycemia Danger of convulsion Danger of disturbed cardiac rhythm Condition may deteriorate with alcohol consumption 4.3 Indication of any Immediate Medical Attention and Special Treatment Needed: If swallowed, gastric irrigation with added, activated carbon Monitor circulation, possible shock treatment Medical supervision for at least 48 hours 5. Fire-fighting Measures Document No.: F-7052J Rev. 02 Page 3 of 11 Effective Date: 4/19/13

4 5.1 Extinguishing Media Suitable extinguishing agents: Use fire extinguishing methods suitable to surrounding conditions For safety reasons, unsuitable extinguishing agents: None 5.2 Special Hazards Arising from the Substance or Mixture: In case of fire, the following can be released: Carbon monoxide Under certain fire conditions, traces of other toxic gases cannot be excluded 5.3 Advice for Firefighters Protective equipment: Wear self-contained respiratory protective device Wear fully protective suit 6. Accidental Release Measures 6.1 Personal Precautions, Protective Equipment and Emergency Procedures: Ensure adequate ventilation Product forms slippery surface when combined with water Wear protective clothing 6.2 Environmental Precautions: Dilute with plenty of water 6.3 Methods and Material for Containment and Cleaning Up: Absorb with liquid-binding material (sand, diatomite, acid binders, universal binders, sawdust) Dispose contaminated material as waste according to Section 13 Clean the affected area carefully; suitable cleaners are: warm water and cleansing agent 6.4 Reference to Other Sections See Section 7 for information on safe handling See Section 8 for information on personal protection equipment See Section 13 for disposal information 7. Handling and Storage 7.1 Precautions for Safe Handling: Ensure good ventilation/exhaust at the workplace Prevent formation of aerosols Keep receptacles tightly sealed Information about Fire and Explosion Protection: No special measures required 7.2 Conditions for Safe Storage, Including any Incompatibilities Document No.: F-7052J Rev. 02 Page 4 of 11 Effective Date: 4/19/13

5 Storage: Keep away from dust and direct sunlight. Store at 2-35 C. Do not freeze. Keep away from source of ignition. Keep away from incompatible substances, strong oxidant and strong acid. Requirements to be met by storerooms and receptacles: Protect from humidity and water Avoid storage near extreme heat, ignition sources or open flame Information about storage in one common storage facility: Store away from foodstuffs Do not store together with oxidizing and acidic materials Further information about storage conditions: Store in cool, dry conditions in well sealed receptacles This product is hygroscopic Protect from humidity and water 7.3 Specific end use(s): No further relevant information available 8. Exposure Controls/Personal Protection Additional information about design of technical facilities: No further data; see Section Control parameters Ingredients with limit values that require monitoring at the workplace: Ethanediol (Ethylene Glycol); TLV (USA) Short-term Value: C 100 mg/m 3, H IOELV (EU) Short-term Value: 104 mg/m 3, 40 ppm IOELV (EU) Long-term Value: 52 mg/m 3, 20 ppm Skin EL (Canada) Short-term Value: C 100* 20** mg/m 3, C 50*** ppm EL (Canada) Long-term Value: 10** mg/m 3 (*Aerosol; **Particulate; ***Vapor) DNELs: No further relevant information available PNECs: No further relevant information available Additional Information: The lists valid during the making were used as basis 8.2 Exposure Controls Personal protective equipment: General protective and hygienic measures: Keep away from foodstuffs, beverages and feed Wash hands before breaks and at the end of work Avoid contact with the eyes Avoid close or long term contact with the skin Do not inhale gases/fumes/aerosols Document No.: F-7052J Rev. 02 Page 5 of 11 Effective Date: 4/19/13

6 Avoid alcohol consumption while working with the product Respiratory protection: Not necessary if room is well-ventilated Use suitable respiratory protective device in case of insufficient ventilation Use suitable respiratory protective device when aerosol or mist is formed Protection of hands: Protective gloves The glove material has to be impermeable and resistant to the product/the substance/the preparation. Due to missing tests, no recommendation to the glove material can be given for the product/the preparation/the chemical mixture. Selection of the glove material on consideration of the penetration times, rates of diffusion and the degradation Material of gloves: Sensibilization by the components in the glove materials is possible The selection of suitable gloves does not only depend on the material, but also on further marks of quality and varies from manufacturer to manufacturer. As the product is a preparation of several substances, the resistance of the glove material cannot be calculated in advance and therefore has to be checked prior to the application. Penetration time of glove material: The exact break through time has to be found out by the manufacturer of the protective gloves and has to be observed For the permanent, contact gloves made of the following materials are suitable: Butyl rubber, BR Nitrile rubber, NBR Rubber Eye protection: Safety Glasses Body protection: Not required Limitation and supervision of exposure to the environment: No special requirements Risk management measures: See Section 7 for additional information No special requirements 9. Physical and Chemical Properties Document No.: F-7052J Rev. 02 Page 6 of 11 Effective Date: 4/19/13

7 9.1 Information on basic physical and chemical properties General Information Appearance: Form: Liquid Color: Blue Odor: None Odor Threshold: Not determined ph value: Not determined Change in Condition Melting Point/Melting Range: 9.7 F / C Boiling Point/Boiling Range: Undetermined Flash Point: 264 F / 129 C (Cleveland Open Cup) Flammability (solid, gaseous): Not applicable Ignition Temperature: 770 F / 410 C Decomposition Temperature: Not determined Self-igniting: Not determined Danger of explosion: Consider a combustible liquid. Do not expose to open flame. Combustion gases produced are carbon monoxide and carbon dioxide Explosion limits: Lower: 3.2 Vol % Upper: 53 Vol % Vapor Pressure at 20 C: 0.08 hpa Density at 20 C: 1.11 g/cm 3 Relative Density: Not determined Vapor Density: Not determined Evaporation Rate: Not determined Solubility in/miscibility with Water: Fully miscible Partition Coefficient (n-octanol/water): Not determined Viscosity: Dynamic: Not determined Kinematic: Not determined Solvent Content: Water: <1.0% (as impurity) 9.2 Other information: No further relevant information available 10. Stability and Reactivity 10.1 Reactivity: No further relevant information available Document No.: F-7052J Rev. 02 Page 7 of 11 Effective Date: 4/19/13

8 10.2 Chemical Stability Thermal decomposition/conditions to be avoided: No decomposition if used and stored according to specifications 10.3 Possibility of Hazardous Reactions: Ethanediol (Ethylene Glycol) reacts with strong oxidizing agents, strong acids and polymerization catalysts Reacts with peroxides and other radical forming substances 10.4 Conditions to Avoid: Keep ignition sources away Do not smoke Store away from oxidizing agents Moisture 10.5 Incompatible Materials: No further relevant information available 10.6 Hazardous Decomposition Products: Irritant gases/vapors Carbon monoxide and carbon dioxide 11. Toxilogical Information 11.1 Information on Toxilogical Effects Acute Toxicity: LD/LC50 values relevant for classification: Ethanediol (Ethylene Glycol) Oral LD mg/kg (rat) Dermal LD mg/kg (rabbit) Primary Irritant Effect: Inhalation/Ingestion: Moderate health hazard rating reflects unusual exposures via ingestion. This reagent is relatively safe when handled using good chemical hygiene by laboratory professionals and when enclosed in the analyzer hydraulic system. On the Skin: Contact will cause skin discoloration and possible irritation. Absorption may occur through skin, prolonged and repeated skin contact may be harmful On the Eye: Slight irritant effect on the eyes Sensitization: No sensitizing effects known Additional Toxilogical Information: Harmful Toxic and/or corrosive effects may be delayed up to 24 hours Repeated Dose Toxicity: May cause damage to organs through prolonged or repeated exposure 12. Ecological Information Document No.: F-7052J Rev. 02 Page 8 of 11 Effective Date: 4/19/13

9 12.1 Toxicity Aquatic Toxicity: No further relevant information is available 12.2 Persistence and Degradability: Biodegradable 12.3 Bioaccumulative Potential: Does not accumulate in organisms 12.4 Mobility in Soil: No further relevant information available Additional Ecological Information: General Notes: The declarations are valid for the component with the highest Toxilogical risk Avoid transfer into the environment Due to available data on eliminability/decomposition and bioaccumulation, potential prolonged damage of the environment is unlikely Water Hazard Class (self-classification) in the concentrate Water Hazard Class 1 (German Regulation) (Assessment by list): Slightly hazardous for water 12.5 Results of PBT and vpvb assessment PBT: Not applicable vpvb: Not applicable 12.6 Other Adverse Effects: No further relevant information available 13. Disposal Considerations 13.1 Waste Treatment Methods Recommendation: Disposal must be made according to official regulations Recommended Cleansing Agents: Water, if necessary together with cleansing agents 14. Transport Information 14.1 UN-Number DOT, ADN, IMDG, IATA: N/A 14.2 UN Proper Shipping Name DOT, ADR, ADN, IMDG, IATA: N/A 14.3 Transport Hazard Classes DOT, ADR, AND, IMDG, IATA: N/A Class: N/A 14.4 Packing Group DOT, ADR, IMDG, IATA: N/A 14.5 Environmental Hazards: Marine Pollutant: No Document No.: F-7052J Rev. 02 Page 9 of 11 Effective Date: 4/19/13

10 14.6 Special Precautions for User: Not applicable 14.7 Transport in Bulk According to Annex II of MARPOL73/78 and the IBC Code: Not applicable 14.8 UN Model Regulation : Regulatory Information 15.1 Safety, Health and Environmental Regulations/Legislation Specific for the Substance or Mixture United States (USA) SARA Section 355 (Extremely Hazardous Substances): Substance is not listed Section 313 (Specific Toxic Chemical Listings): Ethanediol (Ethylene Glycol) TSCA (Toxic Substances Control Act): Substance is listed Proposition 65 (California): Chemicals Known to Cause Cancer: Substance is not listed Chemicals Known to Cause Reproductive Toxicity for Females: Substance is not listed Chemicals Known to Cause Reproductive Toxicity for Males: Substance is not listed Chemicals Known to Cause Developmental Toxicity: Substance is not listed Carcinogenic Categories: EPA (Environmental Protection Agency): Substance is not listed IARC (International Agency for Research on Cancer): Substance is not listed TLV (Threshold Limit Value Established by ACGIH): Ethanediol (Ethylene Glycol) MAK (German Maximum Workplace Concentration): Substance is not listed NIOSH-Ca (National Institute for Occupational Safety and Health): Substance is not listed OSHA-Ca (Occupational Safety and Health Administration): Substance is not listed Canada Canadian Domestic Substances List (DSL): Substance is listed Canadian Ingredient Disclosure List (limit 0.1%): Substance is not listed Canadian Ingredient Disclosure List (limit 1%): Ethanediol (Ethylene Glycol) This product has been classified in accordance with the hazard criteria of the Controlled Products Regulations (CPS) and the SDS contains all the information required by CPR Chemical Safety Assessment: A chemical safety assessment has not been carried out 16. Other Information Document No.: F-7052J Rev. 02 Page 10 of 11 Effective Date: 4/19/13

11 provides the information contained herein in good faith, but makes no representative claim or warranty as to its completeness or accuracy. This document is intended only as a guide for appropriate handling of the material described by properly trained persons using the product according to its intended purposes. Individuals receiving this information retain the responsibility for determining the suitability of the information for any specific purpose. Users should consider these data only as supplement to other information gathered by themselves and must make independent determinations of the suitability and completeness of information from all sources to ensure proper use and disposal of these materials and for the safety and health of employees and customers. No warranty, expressed or implied, is made with regard to such information. Permission is granted to make unlimited paper copies of this SDS for internal purposes only. Relevant Phrases: H302 Harmful if swallowed R22 Harmful if swallowed Abbreviations and Acronyms: ADR: Accord européen sur le transport des marchandises dangereuses par Route (European Agreement concerning the International Carriage of Dangerous Goods by Road) IMDG: International Maritime Code for Dangerous Goods DOT: US Department of Transportation DOT: US Department of Transportation IATA: International Air Transport Association GHS: Globally Harmonized System of Classification and Labeling of Chemicals ACGIH: American Conference of Governmental Industrial Hygienists European Inventory of Existing Commercial Chemical Substance CAS: Chemical Abstracts Service (division of the American Chemical Society) NFPA: National Fire Protection Association (USA) HMIS: Hazardous Materials Identification System (USA) DNEL: Derived No-Effect Level (REACH) PNEC: Predicted No-Effect Concentration (REACH) LC50: Lethal concentration, 50 percent LD50: Lethal dose, 50 percent Sources: This document was authored and reviewed by the technical and scientific staff at Chem- Tel Inc. Descriptions, classifications and calculations are based upon data provided by manufacturer and augmented by published data in conjunction with expert analysis by degreed scientists. Document No.: F-7052J Rev. 02 Page 11 of 11 Effective Date: 4/19/13