SAFETY DATA SHEET. Synonyms Part Numbers: 25605, 25615, 25631, 25636, 25641, 25641R, 35646

Transcription

1 SAFETY DATA SHEET 1. Identification Product identifier Other means of identification Product code Hercules Plumber s Caulk White, Almond/Bone, Biscuit/Linen 7354E Synonyms Part Numbers: 25605, 25615, 25631, 25636, 25641, 25641R, Recommended use Recommended restrictions Manufacturer/Importer/Supplier/Distributor information Company Name Address Caulk and sealant for use around tubs, sinks and other plumbing applications. Do not us on applications where product will be submerged under water. HCC Holdings, Inc. an Oatey Affiliate 4700 West 160th Street Cleveland, OH Telephone info@oatey.com Transport Emergency Chemtrec (Outside the US ) Emergency First Aid Contact person 2. Hazard(s) identification Physical hazards Health hazards OSHA defined hazards Label elements Hazard symbol Signal word Hazard statement Precautionary statement Prevention Response Storage Disposal Hazard(s) not otherwise classified (HNOC) MSDS Coordinator Not Classfiied. None. None. This material does not meet the criteria for classification 3. Composition/information on ingredients Mixtures Uncured product is irritating to eyes, skin and respiratory system. Chemical name CAS number % Plasticizer Polymer Additive Trade Secret* 5-10 Distillates (petroleum), hydrotreated light There are no additional ingredients present which, within the current knowledge of the supplier and in the concentrations applicable, are classified as hazardous to health or the environment and hence require reporting in this section. *Designates that a specific chemical identity and or percentage of composition has been withheld as a trade secret. 4. First-aid measures Inhalation Skin contact Remove victim to fresh air and keep at rest in a position comfortable for breathing. Get medical attention if symptoms occur. Flush contaminated skin with plenty of water. Remove contaminated clothing and shoes. Get SDS #7354E Version #: 01 Revision date: Issue date: 12-May-2015 Page 1 of 6

2 Eye contact Ingestion Most important symptoms/effects, acute and delayed Indication of immediate medical attention and special treatment needed. General information medical attention if symptoms occur. Immediately flush eyes with plenty of water, occasionally lifting the upper and lower eyelids. Check for and remove any contact lenses. Get medical attention if irritation occurs. Wash out mouth with water. Remove victim to fresh air and keep at rest in a position comfortable for breathing. If material has been swallowed and the exposed person is conscious, give small quantities of water to drink. Do not induce vomiting unless directed to do so by medical personnel. Get medical attention if symptoms occur. Skin or eye irritation. Contact poison treatment specialist immediately if large quantities have been ingested or inhaled. Note to physician, treat symptomatically. 5. Fire-fighting measures Suitable extinguishing media Unsuitable extinguishing media Specific hazards arising from the chemical Special protective equipment and precautions for firefighters Fire fighting equipment/instructions Specific methods General fire hazards Use dry chemical, CO2, alcohol-resistant foam or water spray (fog). water jet No specific fire or explosion hazard. Fire-fighters should wear appropriate protective equipment and self-contained breathing apparatus (SCBA) with a full face-piece operated in positive pressure mode. Promptly isolate the scene by removing all persons from the vicinity of the incident if there is a fire. No action shall be taken involving any personal risk or without suitable training. Use water spray to keep fire-exposed containers cool. Fire water contaminated with this material must be contained and prevented from being discharged to any waterway, sewer or drain. None None 6. Accidental release measures Personal precautions, protective equipment and emergency procedures Methods and materials for containment and cleaning up Environmental precautions Evacuate surrounding areas. Keep unnecessary and unprotected personnel from entering. Do not touch or walk through spilled material. Put on appropriate personal protective equipment. If specialized clothing is required to deal with the spillage, take note of any information in Section 8 on suitable and unsuitable materials. See also the information in "For non-emergency personnel". Large Spills: Move containers from spill area. Prevent entry into sewers, water courses, basements or confined areas. Vacuum or sweep up material and place in a designated, labeled waste container. Dispose of via a licensed waste disposal contractor. Note: see section 1 of SDS for emergency contact information and section 13 of SDS for waste disposal. Small Spills: Move containers from spill area. Vacuum or sweep up material and place in a designated, labeled waste container. Dispose of via a licensed waste disposal contractor. Note: see section 1 of SDS for emergency contact information and section 13 of SDS for waste disposal. Avoid dispersal of spilled material and runoff and contact with soil, waterways, drains and sewers. Inform the relevant authorities if the product has caused environmental pollution (sewers, waterways, soil or air). 7. Handling and storage Precautions for safe handling Conditions for safe storage, including any incompatibilities Put on appropriate personal protective equipment (see section 8 of SDS). Eating, drinking and smoking should be prohibited in areas where this material is handled, stored and processed. Workers should wash hands and face before eating, drinking and smoking. See also Section 8 for additional information on hygiene measures. Store in accordance with local regulations. Store in original container protected from direct sunlight in a dry, cool and well-ventilated area, away from incompatible materials (see section 10 of SDS) and food and drink. Keep container tightly closed and sealed until ready for use. Containers that have been opened must be carefully resealed and kept upright to prevent leakage. Do not store in unlabeled containers. Use appropriate containment to avoid environmental contamination. SDS #7354E Version #: 01 Revision date: Issue date: 12-May-2015 Page 2 of 6

3 8. Exposure controls/personal protection Occupational exposure limits US. ACGIH Threshold Limit Values Components Type Value Distillates (petroleum), hydrotreated light TWA 200 mg/m3 Biological limit values Appropriate engineering controls No Biological limits. No special ventilation requirements. Good general ventilation should be sufficient to control worker exposure to airborne contaminants. If this product contains ingredients with exposure limits, use process enclosures, local exhaust ventilation or other engineering controls to keep worker exposure below any recommended or statutory limits. Individual protection measures, such as personal protective equipment Eye/face protection Skin protection Hand Other Respiratory protection Thermal hazards General hygiene considerations 9. Physical and chemical properties Appearance Physical state Solid. Form Paste Color White or Off-White. Odor Ammonia. Odor threshold Not available. ph 7.7 Melting point/freezing point Initial boiling point and boiling Not determined range Flash point > 199 F (> 93.3 C) Upper/lower flammability or explosive limits Flammability limit lower (%) Not available Flammability limit upper (%) Not available Explosive limit - lower (%) Not available Explosive limit - upper (%) Not available Vapor pressure Not applicable Vapor density Not applicable Relative density 1.50 Solubility(ies) Solubility (water) Not available Partition coefficient (n-octanol/water) Not available Auto-ignition temperature Not applicable Decomposition temperature Not available Viscosity Not available Other information VOC (Weight %) 1.4% or 37 g/l Safety eyewear complying with an approved standard should be used when a risk assessment indicates this is necessary to avoid exposure to liquid splashes, mists, gases or dusts. Chemical-resistant, impervious gloves complying with an approved standard should be worn at all times when handling chemical products if a risk assessment indicates this is necessary. Appropriate footwear and any additional skin protection measures should be selected based on the task being performed and the risks involved and should be approved by a specialist before handling this product. Use a properly fitted, particulate filter respirator complying with an approved standard if a risk assessment indicates this is necessary. Respirator selection must be based on known or anticipated exposure levels, the hazards of the product and the safe working limits of the selected respirator. None. Wash hands, forearms and face thoroughly after handling chemical products, before eating, smoking and using the lavatory and at the end of the working period. Appropriate techniques should be used to remove potentially contaminated clothing. Contaminated work clothing should not be allowed out of the workplace. Wash contaminated clothing before reusing. Ensure that eyewash stations and safety showers are close to the workstation location. SDS #7354E Version #: 01 Revision date: Issue date: 12-May-2015 Page 3 of 6

4 10. Stability and reactivity Reactivity Chemical stability Possibility of hazardous reaction Conditions to avoid Incompatible materials Hazardous decomposition products 11. Toxicological information Stable under normal conditions. The product is stable. Under normal conditions of storage and use, hazardous reactions will not occur. No specific data. No specific data. Under normal conditions of storage and use, hazardous decomposition products should not be produced. Information on likely routes of exposure Inhalation Skin contact Eye contact Ingestion Symptoms related to the physical, chemical and toxicological characteristics Information on likely routes of exposure Acute Toxicity No specific data. Components Species Results Skin corrosion/irritation Serious eye damage/eye irritation Respiratory or skin sensitization Respiratory sensitization Skin sensitization Germ cell mutagenicity Carcinogenicity Reproductive toxicity Specific target organ toxicity Single exposure Repeated exposure Aspiration Hazard Chronic effects Further information 12. Ecological information Ecotoxicity Not determined. Not determined. Not considered a respiratory irritant This product is not expected to cause skin irritation. No specific data Contains Distillates (petroleum), hydrotreated Which is a category 1 Aspiration Hazard. The likely hood of aspirating the product in this form is very low due to the high viscosity. Product/ingredient name Results Species Exposure Distillates (petroleum), hydrotreated light Acute LC50 2,900 μg/l Fresh water Fish - Rainbow trout,donaldson trout 96 h Acute LC50 2,200 μg/l Fresh water Fish - Bluegill 96 h Persistence and degradability Bio accumulative potential Mobility in soil Other adverse effects Not Available. Not Available. Not available. No known significant effects of critical hazards. SDS #7354E Version #: 01 Revision date: Issue date: 12-May-2015 Page 4 of 6

5 13. Disposal considerations Disposal instructions Local disposal regulations Hazardous waste code Not Applicable 14. Transportation information DOT IATA IMDG UN number UN Proper Shipping Name Transportation Hazard classes Packing group UN number UN Proper Shipping Name Transportation Hazard classes Packing group UN number UN Proper Shipping Name Transportation Hazard classes Packing group Environmental hazards Marine polluntant 15. Regulatory information The generation of waste should be avoided or minimized wherever possible. Disposal of this product, solutions and any by-products should at all times comply with the requirements of environmental protection and waste disposal legislation and any regional local authority requirements. Dispose of surplus and non-recyclable products via a licensed waste disposal contractor. Waste should not be disposed of untreated to the sewer unless fully compliant with the requirements of all authorities with jurisdiction. Waste packaging should be recycled. Incineration or landfill should only be considered when recycling is not feasible. This material and its container must be disposed of in a safe way. Empty containers or liners may retain some product residues. Avoid dispersal of spilled material and runoff and contact with soil, waterways, drains and sewers. Not Applicable Not Regulated Not Regulated Not Regulated U.S. Federal regulations SARA 311/312 Classification US state regulations California Prop 65 Canada WHMIS (Canada) International regulations TSCA 12(b) - Chemical export notification: None required. TSCA 5(a)2 - Final significant new use rules: Not listed TSCA 5(a)2 - Proposed significant new use rules: Not listed TSCA 5(e) - Substances consent order: Not listed Not applicable This product contains a chemical known to the State of California to cause cancer, birth defects, or other reproductive harm. Class D-2A: Material causing other toxic effects (Very toxic). Country(s) or region Inventory Name On inventory list (yes/no)* Canada At least one component not listed in DSL, but all such Yes components are listed in NDSLDomestic Substance List Australia Australian Inventory of Chemical Substances (AICS) Not Determined China Inventory of Existing Chemical Substances in China (IECSC) Not Determined United States & Puerto Rico Toxic Substances Control Act (TSCA 8b) Yes SDS #7354E Version #: 01 Revision date: Issue date: 12-May-2015 Page 5 of 6

6 16. Other information, including date of preparation or last revision Issue Date Revision Date - Version # May-2015 HMIS Rating Health: 1 Flammability: 1 Physical Hazards: 0 Disclaimer HCC Holdings Inc. an Oatey Affiliate cannot anticipate all conditions under which this information and its product, or the products of other manufacturers in combination with its product, may be used. It is the user s responsibility to ensure safe conditions for handling, storage and disposal of the product, and to assume liability for loss, injury, damage or expense due to improper use. The information in the sheet was written based on the best knowledge and experience currently available. SDS #7354E Version #: 01 Revision date: Issue date: 12-May-2015 Page 6 of 6