Trailer-mounted or van-integrated

Transcription

1 Spare Parts and Accessories for PRIMAX Falling Weight Deflectometer Trailer-mounted or van-integrated Spare Parts and Accessories for PRIMAX

2 Catalogue: Spare Parts and Accessories for PRIMAX FWDs Grontmij A/S, Pavement Consultants, Kokbjerg 5, DK-6000 Kolding This edition was first published in 2010 All rights reserved; no part of this publication may be reproduced, stored in a retrieval system, or transmitted in any form or by any means, electronic, mechanical, photocopying, recording, or otherwise, without the prior written permission of the Publishers. The English version of this catalogue is the only authorised catalogue. Any other translations of this catalogue are not valid and Grontmij Carl Bro A/S cannot be held responsible for the contents of such catalogues. Printed in Denmark by Grontmij A/S Grontmij A/S, Pavement Consultants Page 1

3 Contents Part 1: Introduction Field of Application... 3 Part 2: Spare Parts Geophones, Spikes and Cable Electric Equipment Buffers and rubber for load plate Light Tools Oil Part 3: Accessories Marking Equipment Load Plate Measuring Equipment Calibration Powering Solutions Safety Equipment Electronic Hardware Software Part 4: Contact Grontmij A/S, Pavement Consultants Page 2

4 Part 1: Introduction 1.1 Field of application Spare parts and accessories included in this catalogue can be applied for the PRIMAX falling weight deflectometers as well as for earlier versions (PRI2100 ). The spare parts list contains components which through normal tear and wear should be expected to need replacements. The accessories, we have listed, are equipment which could enhance the performance of your FWD. For operation of the falling weight deflectometer we refer to our User Manual. Grontmij A/S, Pavement Consultants Page 3

5 Part 2: Spare parts 2.1 Geophones, spikes and cable Cover for geophone Yellow plastic cover for geophone Geophone spikes Long metal spike for centre geophone and short metal spike for other geophones Geophone cable 2-core cable for geophones Extension device for geophones Metal device for corrected positioning of outer geophone in case of sloping geophone beam Geophone beam cable Steel wire for beam Grontmij A/S, Pavement Consultants Page 4

6 Burndy geophone plug (male) Pins for Burndy geophone plug (male) Burndy geophone plug (female) Pins for Burndy geophone plug (female) Burndy plug tool Grontmij A/S, Pavement Consultants Page 5

7 2.2 Electric equipment Motor relay Power relay Auxiliary relay 100A fuse Non-contact control switch Grontmij A/S, Pavement Consultants Page 6

8 Non-contact control switch With cable 3-pin plug For hydraulic valve Temperature probe For manual measurement of temperature 2.3 Buffers and rubber for load plate Rubber for load plate foot Buffers Available in shore: and 75 Grontmij A/S, Pavement Consultants Page 7

9 2.4 Light Warning light Bulbs 12V 5W Bulbs 12V 5W Bulbs 12V 21W Grontmij A/S, Pavement Consultants Page 8

10 2.5 Tools Adjustable wrench Fork Wrench for control switches Set of ratchet wrenches Set of Allen keys Tool box Grontmij A/S, Pavement Consultants Page 9

11 Triflow spray can Petrol can 2.6 Oil Hydraulic oil for FWD Oil type: ZET Hydraulic Oil HLP-32 Grontmij A/S, Pavement Consultants Page 10

12 Part 3: Accessories 3.1 Marking equipment Spray marking equipment Automatic spray marking equipment for marking of each measuring point 3.2 Load plate Load plate 450 mm circular solid load plate Load plate (special 4 split version) 450 mm circular 4 split load plate Grontmij A/S, Pavement Consultants Page 11

13 3.3 Measuring equipment Rear extension beam T-beam for measurements behind and next to loading points on concrete slabs Geophone Geophone complete with cover, spike, cable and plug 3.4 Calibration Stacking tower Relative calibration verification equipment for checking of whether the sensors have drifted from initial settings Grontmij A/S, Pavement Consultants Page 12

14 3.5 Powering solutions 12/220V power inverter For power supply to the computer and the printer in the towing vehicle Generator unit 24V DC, 35 AMP generator mounted on trailer for vehicle independent powering 12/24V unit Portable power unit for use with different towing vehicles or for permanent installation on the trailer FWD to be powered by the towing vehicle 24V chargers 14A 300w Grontmij A/S, Pavement Consultants Page 13

15 3.6 Safety equipment Beam with flash lights Beam to be mounted on towing vehicle Safety signboard The safety signboard is recommended for use in general and on roads with heavy traffic in particular. It is a flip-up LED panel with high brightness and visible from long distances. The LED panel has diagonal arrow and cross function thanks to its innovative high-intensity, low consumption LED lights. The signboard is controlled from a remote control, which controls all functions such as raising/lowering of the board and the direction of indicators (lamps and sign). 3.7 Electronic hardware Video camera and monitor Video camera and monitor (black/white) to be mounted on trailer and car, for accurate location over concrete slab joints Grontmij A/S, Pavement Consultants Page 14

16 GPS guide system To be mounted on trailer and car, for accurate location e.g. airport runways and taxiways. The system needs a DGPS antenna for maximal accuracy! Video colour camera Together with the GPS guide system monitor, a camera can be connected. Shifting to camera mode, it can be used for accurate location over concrete slab joints IR temperature transmitter For automated transmission of pavement surface temperatures GPS antenna and software GPS integrated with the PRIMAX data collection software Grontmij A/S, Pavement Consultants Page 15

17 FWD camera Including one camera and integrated software in the FWD data collection program. The camera takes a picture of the spot measured by the FWD and the picture is saved together with the FWD data. 3.8 Software Rosy design road software Including a 3-day training course Rosy design airport software Including a 3-day training course Grontmij A/S, Pavement Consultants Page 16

18 Part 4: Contact For more information please contact: René Clemen Production Manager Phone: Mobile: John Kern Technician Phone: Mobile: Michael Henriksen Technician Phone: Mobile: Grontmij A/S, Pavement Consultants Page 17