Material Safety Data Sheet Aquaox Anolyte EPA Reg #

Transcription

1 EPA Reg # HMIS H a z a r d R a t i n g : Health = 1 Flammabitity = 0 Physical = 0 Reactivity = 0 0 = Minimal Hazard 1 = Slight Hazard 2 = Moderate Hazard 3 = Serious Hazard 4 = Severe Hazard Section I General Information Product Name: AQUAOX ANOLYTE Product Description: Hypochlorous Acid Solution Generated Electro-Chemically from Diluted Brine CAS #: None (Mixture) Manufacturer: Aquaox Industries Inc Address: Sierra Lakes Parkway, Suite Fontana, CA For Information on Health Hazards Call: (909) Chemtrec Emergency Number: (800) Preparation Date of Latest Revision: June 26, 2014 Section II Composition and Information on Ingredients Component(s) CAS # Water Hypochlorous Acid The Product contains > 500 ppm Free Available Chlorine (FAC). This product is not a "Hazardous Chemical" as defined by the OSHA Hazard Communication Standard, 29 CFR Aquaox Industries Inc Page 1 of 6

2 Section III Physical and Chemical Properties Physical State Liquid Appearance / Color Clear Odor Slight Chlorine Odor Corrosive Characteristics Mildly Corrosive Boiling Point ( C) 100 Melting Point ( C) N/A Flammability / Flash Point ( C) N/A Explodability N/A Vapor Pressure (mmhg at 20 C) N/A Density (g/ml) Viscosity (cps) 1.00 ph Section I V Health Effects Information Route of Entry / Exposure: SKIN CONTACT EYE CONTACT INHALATION INGESTION Potential Acute Health Effects: SKIN CONTACT: EYE CONTACT: INHALATION: INGESTION: Depending on the degree of unprotected contact and individual sensitivity with the product, skin contact may cause mild irritation, redness, rash and itchiness. Depending on duration and individual sensitivity with the product, unprotected eye contact may cause moderate eye irritation, pain, redness, watering and itchiness. Excessive, prolonged or repeated inhalation may cause irritation to mucous membranes and upper respiratory tract. This product may be harmful if ingested. Depending on the amount swallowed, ingestion may cause mild irritation to mouth, throat, stomach and gastrointestinal tract. Potential Chronic Health Effects: CARCINOGENIC EFFECTS: MUTAGENIC EFFECTS: TERATOGENIC EFFECTS: DEVELOPMENTAL: Aquaox Industries Inc Page 2 of 6

3 No components of this product are present at levels identified as a carcinogen or potential carcinogen by OSHA. Section V First Aid Measures Skin Contact: In case of contact, wash off with soap and plenty of water. In case of irritation, cover the irritated skin with an emollient. Cold water may be used. Wash clothing before reuse. Seek medical attention if skin irritation continues. Eye Contact: Check for and remove any contact lenses. Immediately flush eyes with running water for at least 15 minutes, keeping eyelids open. Cold water may be used. Seek medical attention if eye irritation occurs. Inhalation: If inhaled, remove to fresh air. If not breathing, give artificial respiration. If breathing is difficult, give oxygen and call physician. Ingestion: If swallowed, do not induce vomiting unless directed to do so by medical personnel. Never give anything by mouth to an unconscious person. Rinse mouth with water and drink plenty of fluids. Seek medical attention if discomfort occurs. Section VI Storage, Disposal, Spill and Leak Procedures Storage: Disposal: Spill / Leak: Keep container tightly closed in a dry and well-ventilated place at room temperature. AVOID FREEZING. Dispose of unused product. Offer surplus and non-recyclable solutions to a licensed disposal company. Dike spill with inert absorbent materials (sand, oil-dry or other commercially spill absorbents) to contain and soak up liquid. Place wastes into an appropriate waste disposal container. Section VII Fire and Explosive Hazard Information Non Flammable and Non Explosive. Hazardous decomposition products may form under fire conditions; nature of decomposition products is unknown. Aquaox Industries Inc Page 3 of 6

4 Section VIII Stability and Reactivity Data Chemical Stability: Stable under recommended storage conditions. Conditions to Avoid: Avoid freezing. Materials to Avoid: Strong oxidizing agents, Strong acids, Organic materials. Hazardous Polymerization: Will not occur. Section IX Control Measures and Personal Protective Equipment Protective Clothing: Wear proper personal protective equipment and clothing to care for spill situation. Hand Protection: Eye Protection: Ventilation: Handle with gloves. Use rubber, neoprene, or other chemically impervious gloves when handling this product. Wear safety glasses when handling this product. Open air or good room ventilation is adequate for the safe use of this product. Avoid breathing any vapors or fumes resulting from acid ventilation. Section X Transportation Information DOT: OSHA: Not DOT Regulated. No DOT label required. No Label Required. Aquaox Industries Inc Page 4 of 6

5 Section XI Regulatory Information TSC A No: All chemicals in this product are listed on the EPA TSCA Inventory list. CERCLA / SARA: This product has been reviewed according to the EPA "Hazard Categories" promulgated under Sections 311 and 312 of SARA. It does not fall under any listed category and poses no risk of immediate (acute) health hazard, delayed (chronic) health hazard, fire hazard or sudden release of pressure, and is not reactive (see 29 CFR ). OSHA Hazard Communication Standard: This product is not a "Hazardous Chemical" as defined by the OSHA Hazard Communication Standard, 29 CFR Clean Air Act: NA Product Label Hazard Information: Avoid Contact with Eyes and Skin Wash Hands after Handling Product Prevent Ingestion and Inhalation KEEP OUT OF THE REACH OF CHILDREN Product Barcode: Aquaox Industries Inc Page 5 of 6

6 Section XII - Disclaimer This (MSDS) was prepared in accordance with the provisions and requirements of 29 CFR (g) and discloses the physical and health hazards of all hazardous chemicals contained in the Product described in this MSDS, but unless otherwise noted, does NOT describe or disclose ALL of the chemicals/components in the Product, some of which may be Trade Secrets. The information included in this MSDS is based on data developed or compiled by Aquaox from open literature, independent laboratory studies, and other available scientific evidence, and is believed to be accurate and complete. However, Aquaox makes no warranty with respect thereto. Anyone intending to use the Product described in this MSDS should satisfy himself that the Product (1) is suitable for their particular purposes and intended uses, and (2) meets any safety and health standards applicable thereto. It is the obligation of each user of the Product described in this MSDS to determine and comply with the requirements of all statutes local, state and federal applicable to its use, storage and disposal. Section XIII Abbreviations and Symbols CAS # = Chemical Abstracts Service Register number CERCLA = Comprehensive Environmental Response Compensation and Liability Act DOT = Department of Transportation EPA = Evironmental Protection Agency HMIS = Hazardous Materials Identification System NA = Not Applicable Information ND = Not Determined OSHA = Occupational Safety and Health Administration OSHA, TWA = Occupational Safety and Health Administration, Time Weighted Average SARA = Superfund Amendment and Reauthorization Act of 1986 TSCA = Toxic Substances Control Act of 1976 Aquaox Industries Inc Page 6 of 6