SAFETY DATA SHEET SOLAR COMPOUNDS CORP.

Transcription

1 Page 1 of 5 SAFETY DATA SHEET SOLAR COMPOUNDS CORP West Blancke Street PO Box 1097 Linden, N.J Telephone Fax Hour Emergency Telephone: Chemtrec DATE OF ISSUE: 6/23/15 SECTION 1 PRODUCT INDENTIFICATION PRODUCT NAME: SOLARITE EP-5350 PART A 8200 ESD EPOXY ADHESIVE PART A CHEMICAL FAMILY: SOLVENT FREE EPOXY SECTION 2 HAZARDS IDENTIFICATION PRIMARY ROUTES OF ENTRY: Eyes, skin, and mouth. MEDICAL CONDITIONS AGGRAVATED BY EXPOSURE: None known. POTENTIAL HEALTH EFFECTS: EYE CONTACT: May cause irritation, corneal injury is unlikely. SKIN CONTACT: Prolonged or repeated exposure may cause skin irritation. May cause sensitization by skin contact. INGESTION: Single dose oral toxicity is considered to be extremely low; ingestion of a small amount is not expected to be harmful. INHALATION: Overexposure to vapors is considered unlikely due to physical properties of the material. CHRONIC: None known. CARCINOGENICITY: This product contains no ingredient above the OSHA reporting threshold listed as a carcinogen by IARC, NTP, or OSHA. This product is classified as hazardous as defined within the OSHA Hazard Communication Standard 29CFR Classification according to EC No. 1272/2008 (CLP/GHS): Skin Irritation Cat. 2 H315 Skin Sensitization Cat. 1 H317 Eye Irritation Cat. 2 H319 Aquatic Chronic 2 H411 Classification according to Directive 67/548/EEC: Xi R36/38, R43 N R51/53

2 Page 2 of 5 Label elements (EC 1272/2008): Hazard pictograms: GHS 07 GHS 09 Signal word: Warning Hazard statements: H315 Causes skin irritation. H317 May cause an allergic skin reaction. H319 Causes serious eye irritation. H411 Toxic to aquatic life with long lasting effects. EUH205 Contains epoxy constituents. May cause an allergic reaction. Precautionary statements: P264 Wash thoroughly after handling. P273 Avoid release to the environment. P280 Wear protective gloves/ protective clothing/ eye protection/ face protection. P302 + P352 IF ON SKIN: Wash with plenty of soap and water. P333 + P313 If skin irritation or rash occurs: Get medical advice/attention. Contains: Epoxy resin (reaction product: Bisphenol A/Epichlorohydrin) SECTION 3 INFORMATION ON INGREDIENTS COMPONENTS CAS EINECS No. % by weight OSHA PEL Epoxy Resin % to 45 SECTION 4 FIRST AID MEASURES EYE CONTACT: Flush with large quantities of water for at least 30 minutes. Get immediate medical attention if necessary. SKIN CONTACT: Wash with soap and large amounts of running water. INGESTION: Do not induce vomiting. Seek immediate medial advice and/or attention. INHALATION: Remove to fresh air. Get medical attention if breathing becomes difficult.

3 Page 3 of 5 SECTION 5 FIRE FIGHTING MEASURES FLASH POINT: >465 o F LOWER FLAMMABLE LIMIT: NA UPPER FLAMMABLE LIMIT: NA FIRE-FIGHTING INSTRUCTIONS: Clear fire area of all non-emergency personnel. Do not enter confined fire space without bunker gear including positive pressure, NIOSH approved, self-contained breathing apparatus. EXTINGUISHING MEDIA: Foam, dry chemical foam, or carbon dioxide. DECOMPOSITION PRODUCTS: Carbon monoxide, carbon dioxide, hydrocarbons, aldehydes, and acids from incomplete combustion, which may be potentially hazardous. Appropriate precautions should be taken. SECTION 6 ACCIDENTAL RELEASE MEASURES STEPS TO BE TAKEN IF MATERIAL IS RELEASED OR SPILLED: Keep people away. Recover free product. Add sand, earth, or other suitable absorbent to spill area. Minimize breathing vapors. Minimize skin contact. Ventilate confined spaces. Open all windows and doors. Keep product out of sewers and watercourses by diking or impounding. Advise authorities if product has entered or may enter sewers, watercourses or extensive land areas. Assure conformity with applicable local, state, and federal regulations in disposing of waste. SECTION 7 HANDLING AND STORAGE HANDLING: Avoid prolonged or repeated contact with skin. Remove contaminated clothing. Launder or dry clean before reuse. Cleanse skin thoroughly after contact, before breaks and meals, and at the end of the work period. STORAGE: Keep containers closed when not in use. Store in a cool, dry place with adequate ventilation SECTION 8 EXPOSURE CONTROLS/PERSONAL PROTECTION PERSONAL PROTECTIVE EQUIPMENT: EYE/FACE PROTECTION: Wear safety glasses with side shields or splash goggles if contact with material is likely. SKIN PROTECTION: Wear chemical-resistant gloves, if needed to avoid prolonged or repeated skin contact. RESPIRATORY PROTECTION: Not normally needed. ENGINEERING CONTROLS: Use normal room ventilation. SECTION 9 PHYSCIAL AND CHEMICAL PROPERTIES BOILING POINT: NA SPECIFIC GRAVITY (water =1) Refer to technical data sheet. APPEARANCE AND ODOR: Gray paste with a characteristic epoxy odor.

4 Page 4 of 5 VOC: 9 grams/liter SECTION 10 COMBINED VOC; 14.3 grams/liter STABILITY AND REACTIVITY CHEMICAL STABILITY: Stable. POLYMERIZATION: Will not occur. CONDITIONS TO AVOID: None known. HAZARDOUS DECOMPOSITION PRODUCTS: Carbon monoxide, carbon dioxide, aldehydes and acids from incomplete combustion. SECTION 11 TOXICOLOGICAL INFORMATION No information available. SECTION 12 GHS09 Environment ECOLOGICAL INFORMATION Aquatic Chronic 2 H411 Toxic to aquatic life with long lasting effects. SECTION 13 DISPOSAL CONSIDERATIONS Dispose of in an environmentally safe manner and in accordance with local, state and federal regulations. SECTION 14 TRANSPORT INFORMATION DOT: This product does not contain any hazardous/corrosive ingredients. It is not regulated by the U.S. Department of Transportation.

5 Page 5 of 5 ADR, IMDG, IATA: UN3082, ENVIRONMENTALLY HAZARDOUS SUBSTANCE, LIQUID, N.O.S. (Reaction product of epichlorhydrine and phenol-formaldehyde), 9 III EMERGENCY RESPONSE GUIDE NUMBER: 171 SECTION 15 REGULATORY INFORMATION TSCA: All components of this product are on the TSCA inventory or are exempt from TSCA inventory requirements under 40 CFR SARA TITLE III: Section 311 and 312 Health and Physical Hazards: Immediate Delayed Fire Pressure Reactivity [ ] [ ] [ ] [ ] [ ] Section 313: Contains no components at or above EPA reporting thresholds. SECTION 16 OTHER INFORMATION HMIS RATINGS: Health = 1 Flammability = 2 Reactivity = 0 Person Protective Equipment = C Hazard rating scale: 0 = Minimal, 1 = Slight, 2 = Moderate, 3 = Serious, 4 = Severe The information and recommendations contained herein are, to the best of Solar Compounds knowledge and belief, accurate and reliable as of the date issued. Solar Compounds does not warrant or guarantee their accuracy or reliability, and Solar Compounds shall not be liable for any loss or damage arising out of the use thereof. The information and recommendations are offered for the user s consideration and examination, and it is the user s responsibility to satisfy itself that they are suitable and complete for its particular use. REVISIONS REASONS 11/15/14 original written 5/23/15 product name changed

6 Page 1 of 5 SAFETY DATA SHEET SOLAR COMPOUNDS CORP West Blancke Street PO Box 1097 Linden, N.J Telephone Fax Hour Emergency Telephone: Chemtrec DATE OF ISSUE: 6/23/15 SECTION 1 PRODUCT INDENTIFICATION PRODUCT NAME: SOLARITE EP-5350 PART B 8200 ESD EPOXY ADHESIVE PART B CHEMICAL FAMILY: SOLVENT FREE EPOXY SECTION 2 HAZARDS IDENTIFICATION PRIMARY ROUTES OF ENTRY: Eyes, skin, and mouth. MEDICAL CONDITIONS AGGRAVATED BY EXPOSURE: None known. POTENTIAL HEALTH EFFECTS: EYE CONTACT: May cause irritation, corneal injury is unlikely. SKIN CONTACT: Prolonged or repeated exposure may cause skin irritation. May cause sensitization by skin contact. INGESTION: Single dose oral toxicity is considered to be extremely low; ingestion of a small amount is not expected to be harmful. INHALATION: Overexposure to vapors is considered unlikely due to physical properties of the material. CHRONIC: None known. CARCINOGENICITY: This product contains no ingredient above the OSHA reporting threshold listed as a carcinogen by IARC, NTP, or OSHA. This product is classified as hazardous as defined within the OSHA Hazard Communication Standard 29CFR Classification according to EC No. 1272/2008 (CLP/GHS): Skin Irritation Cat. 2 H315 Skin Sensitization Cat. 1 H317 Eye Irritation Cat. 2 H319 Aquatic Chronic 2 H411 Classification according to Directive 67/548/EEC: Xi R36/38, R43 N R51/53

7 Page 2 of 5 Label elements (EC 1272/2008): Hazard pictograms: GHS 07 GHS 09 Signal word: Warning Hazard statements: H315 Causes skin irritation. H317 May cause an allergic skin reaction. H319 Causes serious eye irritation. H411 Toxic to aquatic life with long lasting effects. EUH205 Contains epoxy constituents. May cause an allergic reaction. Precautionary statements: P264 Wash thoroughly after handling. P273 Avoid release to the environment. P280 Wear protective gloves/ protective clothing/ eye protection/ face protection. P302 + P352 IF ON SKIN: Wash with plenty of soap and water. P333 + P313 If skin irritation or rash occurs: Get medical advice/attention. Contains: Liquid polyamide resin. SECTION 3 INFORMATION ON INGREDIENTS COMPONENTS CAS EINECS No. % by weight OSHA PEL Polyamide Resin % to 75% SECTION 4 FIRST AID MEASURES EYE CONTACT: Flush with large quantities of water for at least 30 minutes. Get immediate medical attention if necessary. SKIN CONTACT: Wash with soap and large amounts of running water.

8 Page 3 of 5 INGESTION: Not harmful if swallowed in small amounts. Seek immediate medical advice and/or attention if necessary. INHALATION: Remove to fresh air. Get medical attention if breathing becomes difficult. SECTION 5 FIRE FIGHTING MEASURES FLASH POINT: >485 o F LOWER FLAMMABLE LIMIT: NA UPPER FLAMMABLE LIMIT: NA FIRE-FIGHTING INSTRUCTIONS: Clear fire area of all non-emergency personnel. Do not enter confined fire space without bunker gear including positive pressure, NIOSH approved, self-contained breathing apparatus. EXTINGUISHING MEDIA: Foam, dry chemical foam, or carbon dioxide. DECOMPOSITION PRODUCTS: Carbon monoxide, carbon dioxide, hydrocarbons, aldehydes, and acids from incomplete combustion, which may be potentially hazardous. Appropriate precautions should be taken. SECTION 6 ACCIDENTAL RELEASE MEASURES STEPS TO BE TAKEN IF MATERIAL IS RELEASED OR SPILLED: Keep people away. Recover free product. Add sand, earth, or other suitable absorbent to spill area. Minimize breathing vapors. Minimize skin contact. Ventilate confined spaces. Open all windows and doors. Keep product out of sewers and watercourses by diking or impounding. Advise authorities if product has entered or may enter sewers, watercourses or extensive land areas. Assure conformity with applicable local, state, and federal regulations in disposing of waste. SECTION 7 HANDLING AND STORAGE HANDLING: Avoid prolonged or repeated contact with skin. Remove contaminated clothing. Launder or dry clean before reuse. Cleanse skin thoroughly after contact, before breaks and meals, and at the end of the work period. STORAGE: Keep containers closed when not in use. Store in a cool, dry place with adequate ventilation SECTION 8 EXPOSURE CONTROLS/PERSONAL PROTECTION PERSONAL PROTECTIVE EQUIPMENT: EYE/FACE PROTECTION: Wear safety glasses with side shields or splash goggles if contact with material is likely. SKIN PROTECTION: Wear chemical-resistant gloves, if needed to avoid prolonged or repeated skin contact. RESPIRATORY PROTECTION: Not normally needed. ENGINEERING CONTROLS: Use normal room ventilation.

9 Page 4 of 5 SECTION 9 PHYSCIAL AND CHEMICAL PROPERTIES BOILING POINT: NA SPECIFIC GRAVITY (water =1) Refer to technical data sheet. APPEARANCE AND ODOR: Black paste with a characteristic epoxy odor. VOC: 20 grams/liter COMBINED VOC; 14.3 grams/liter SECTION 10 STABILITY AND REACTIVITY CHEMICAL STABILITY: Stable. POLYMERIZATION: Will not occur. CONDITIONS TO AVOID: None known. HAZARDOUS DECOMPOSITION PRODUCTS: Carbon monoxide, carbon dioxide, aldehydes and acids from incomplete combustion. SECTION 11 TOXICOLOGICAL INFORMATION No information available. SECTION 12 GHS09 Environment ECOLOGICAL INFORMATION Aquatic Chronic 2 H411 Toxic to aquatic life with long lasting effects. SECTION 13 DISPOSAL CONSIDERATIONS Dispose of in an environmentally safe manner and in accordance with local, state and federal regulations. SECTION 14 TRANSPORT INFORMATION

10 Page 5 of 5 DOT: This product does not contain any hazardous/corrosive ingredients. It is not regulated by the U.S. Department of Transportation. ADR, IMDG, IATA: UN3082, ENVIRONMENTALLY HAZARDOUS SUBSTANCE, LIQUID, N.O.S. (Reaction product of epichlorhydrine and phenol-formaldehyde), 9 III EMERGENCY RESPONSE GUIDE NUMBER: 171 SECTION 15 REGULATORY INFORMATION TSCA: All components of this product are on the TSCA inventory or are exempt from TSCA inventory requirements under 40 CFR SARA TITLE III: Section 311 and 312 Health and Physical Hazards: Immediate Delayed Fire Pressure Reactivity [ ] [ ] [ ] [ ] [ ] Section 313: Contains no components at or above EPA reporting thresholds. SECTION 16 OTHER INFORMATION HMIS RATINGS: Health = 1 Flammability = 1 Reactivity = 0 Person Protective Equipment = C Hazard rating scale: 0 = Minimal, 1 = Slight, 2 = Moderate, 3 = Serious, 4 = Severe The information and recommendations contained herein are, to the best of Solar Compounds knowledge and belief, accurate and reliable as of the date issued. Solar Compounds does not warrant or guarantee their accuracy or reliability, and Solar Compounds shall not be liable for any loss or damage arising out of the use thereof. The information and recommendations are offered for the user s consideration and examination, and it is the user s responsibility to satisfy itself that they are suitable and complete for its particular use. REVISIONS REASONS 11/15/14 original written 5/23/15 product name changed