SAFETY DATA SHEET. Section 1: IDENTIFICATION. Proxy C+

Transcription

1 SAFETY DATA SHEET Section 1: IDENTIFICATION Proxy C+ Recommended Use: Detergent for use in suitable automated endoscope reprocessors Product Code: (2x5L) Whiteley Medical A division of Whiteley Corporation Pty Ltd (A.C.N ) Postal Address: P. O. Box 1076 North Sydney NSW 2059 Telephone Number: (02) Facsimile: (02) Web: Emergency Telephone Number: Poisons Information Centre (National) Distributed in New Zealand by: Whiteley Corporation NZ Limited Address: 36 Neales Road, East Tamaki, Auckland, New Zealand 2013 Telephone Number: , Emergency Telephone Number: New Zealand Poisons Centre 0800 POISON or Section 2: HAZARDS GHS Classification Skin Corrosion (Category 1) Signal Word DANGER Hazard Statements H314 Causes severe skin burns and eye damage Precautionary Statements P260 Do not breathe dusts or mists P264 Wash hands thoroughly after using P280 Wear protective gloves/protective clothing and eye protection Response Statements P301 + IF SWALLOWED: Rinse mouth. Do NOT induce vomiting. P330 + P331 P303 + IF ON SKIN: Take off immediately all contaminated clothing. Rinse skin with water. P361 + P353 P304 + IF INHALED: Remove victim to fresh air and keep at rest in a position comfortable for P340 breathing. P305 + IF IN EYES: Rinse cautiously with water for several minutes. Remove contact lenses, if P351 + present and easy to do. Continue rinsing. Issue No. 1 GHS Page 1 of 6

2 P338 P310 P363 Immediately call a POISON CENTRE or doctor/physician. Wash contaminated clothing before reuse Storage Statements P405 Store locked up Disposal Statements P501 Dispose of container as per local regulations HSNO Classifications 8.2C Substances that are corrosive to dermal tissue 8.3A Substances that are corrosive to ocular tissue Section 3: COMPOSITION INFORMATION Ingredient CAS No Proportion Glycolic Acid <10% Didecyldimethylammonium Chloride <10% Ingredients deemed not to be hazardous Not applicable To 100% Section 4: FIRST AID Eye (Contact) Skin (Contact) Inhalation(Breathing) Ingestion (Swallowing) Advice to Doctor First Aid Facilities Additional Information Hold eyelids apart and flush the eye continuously with running water. Immediately call a Poison Centre or doctor/physician. Remove contaminated clothing and flush skin and hair with running water. If skin irritation occurs seek medical advice. Wash contaminated clothing before reuse. Remove to fresh air. DO NOT induce vomiting. Give water to drink if conscious. For advice, contact a Poisons Information Centre (Phone ) or a doctor/physician. Treat symptomatically for highly acidic detergent. Ensure an eye wash is available and ready for use. No aggravated medical conditions are known to be caused by exposure to this product. Section 5: FIREFIGHTING MEASURE Suitable Extinguishing Media Not flammable. Use appropriate extinguisher for burning substance, such as dry chemical powder, foam, water spray or fog. Hazards From Combustion Toxic and/or irritating fumes including carbon monoxide and carbon Products dioxide may be emitted. Precautions For Fire Fighters Keep containers cool by spraying with water. and Special Protective Equipment Additional Information Hazchem Code Not applicable. Section 6: ACCIDENTAL RELEASE MEASURES Emergency Procedure SAA/SNZ HB76: Dangerous Goods Initial Emergency Response Guide Not applicable. Issue No. 1 GHS Page 2 of 6

3 Spills / Clean up Slippery when spilled. Personal protective equipment should be worn when cleaning up spills. Restrict access to area until completion of cleanup. Stop leak if safe to do so. Contain spill with absorbent material, such as sand, vermiculite or other inert material. Prevent spill entering sewers or waterways. Collect and dispose of spilled material according to local regulations. Wash away remnants with copious amounts of cold water. Clean area by working from the periphery to the centre of spill or from the edge of the room to the centre. Section 7: HANDLING AND STORAGE Precautions for Safe Handling Conditions for Safe Storage Use only as directed on the product label. Any non-intended or non-authorised use of this product may result in personal injury or damage to equipment. Store product in original container. Do not mix with detergents or other chemicals. Wash hands and face thoroughly after handling and before work breaks, eating, drinking, smoking and using toilet facilities. Store in a cool, dry, well ventilated area away from incompatible materials. Keep container tightly sealed. Section 8: EXPOSURE CONTROL/PERSONAL PROTECTION National Exposure Standards Source: National Exposure Standards for Atmospheric Contaminants in the Occupational Environment [NOHSC:1003] & New Zealand Workplace Exposure Standards Ingredient CAS No ES-TWA ES-STEL None Available Biological Limit Values Engineering Controls Personal Protective Equipment Use only in a well ventilated area. Eye/face protection Safety glasses / face shield / chemical resistant goggles should be worn to prevent eye contact. Skin protection Use Nitrile gloves or similar to prevent skin contact. Respiratory protection Respirator is not usually necessary but if required use a half face filter respirator suitable for organic vapours. Issue No. 1 GHS Page 3 of 6

4 Section 9: PHYSICAL AND CHEMICAL PROPERTIES Appearance Clear pale liquid Odour Mild Odour Threshold ph Freezing Point Approx. 0⁰C Initial Boiling Point Approx. 100⁰C Boiling Range Flash point Evaporation Rate Flammability Upper flammability limit Lower flammability limit Vapour Pressure Vapour Density Relative Density Solubility Completely miscible with water Partition Coefficient: n-octanol/water Autoignition temperature Decomposition temperature Viscosity Approx. 20 cps Section 10: STABILITY AND REACTIVITY Chemical Stability Conditions to avoid Incompatible materials Hazardous decomposition products Hazardous reactions Acute toxicity Skin corrosion/ irritation Serious eye damage/ irritation Respiratory or skin sensitisation Product is stable and will not undergo any hazardous reactions under normal conditions of use and storage. Avoid high temperatures (store below 25 o C). Protect against physical damage. Incompatible with oxidising agents. None known. Contact with metals may produce flammable hydrogen gas. Section 11: TOXICOLOGICAL INFORMATION Glycolic Acid: LD mg/kg (oral, rat) RTECS MC Product causes irritation, pain and reddening on skin contact. Serious burns may result if the affected area if product is not removed immediately by thorough washing with water. Product causes irritation, pain and reddening on eye contact. Serious, permanent eye damage may result if not treated immediately. Issue No. 1 GHS Page 4 of 6

5 Germ Cell Mutagenicity Carcinogenicity Reproductive toxicity Specific Target Organ Toxicity Single Exposure Specific Target Organ Toxicity Repeated Exposure Aspiration Hazard Section 12: ECOLOGICAL INFORMATION Ecotoxicity Persistence and degradability Bioaccumulative potential Mobility in soil Other adverse effects Section 13: DISPOSAL CONSIDERATIONS Disposal method Special precautions Disposal to sewer is normally recommended with copious amounts of water. Refer to State/Territory Land Waste Management Authorities if applicable. Containers are recyclable and can be disposed of by a licensed waste contractor. Containers can be disposed of to general waste or rinsed thoroughly and recycled. Suitable for incineration by approved agent. Section 14: TRANSPORT INFORMATION Not classified as Dangerous Goods by the criteria of the Australian Dangerous Goods Code (ADG Code). UN Number Not applicable. UN Proper Shipping Name Not applicable. Class and subsidiary risk Not applicable. Packing Group Not applicable. Special precautions for user Not applicable. Hazchem Code Not applicable. Section 15: REGULATORY INFORMATION Poisons Schedule (SUSDP): None allocated. All ingredients are listed in the Australia Inventory of Chemical Substances (AICS). HSNO Approval Code: HSR This document has been produced in accordance with the requirements of the Globally Harmonised System of Classification and Labelling. Issue No. 1 GHS Page 5 of 6

6 Section 16: OTHER INFORMATION Date of preparation: This document remains property of Whiteley Corporation Pty Ltd. Alterations are not permitted without prior written authorisation from Whiteley Corporation Pty Ltd. Issue No. 1 GHS Page 6 of 6