SPARE PARTS EXPLODED VIEW GAS WALL BOILERS Model E-COMBI - E-SYSTEM. Domestic Gas Boilers E-COMBI - E-SYSTEM. R EN - Edition 04-30/08/11

Transcription

1 SPARE PARTS EXPLODED VIEW GAS WALL BOILERS Model E-COMBI - E-SYSTEM R EN - Edition 04-30/08/11 Domestic Gas Boilers E-COMBI - E-SYSTEM E-COMBI 24 FF NG (UK) 04/ E-COMBI 30 FF NG (UK) 04/ E-COMBI 35 FF NG (UK) 04/ E-SYSTEM 24 NG (UK) E-SYSTEM 30 NG (UK) Reference Ind. Model type Begin End 1

2 Domestic Gas Boilers E-COMBI - E-SYSTEM / > 08/ R

3 FF FF Key N Description Manf. Pt. N Type Manf. date BURNER ASSEMBLY 0101 IGNITION ELECTRODE IONIZATION ELECTRODE INSULATION (FRONTAL) EXCHANGER 24KW /11 EXCHANGER 30KW /11 EXCHANGER 35KW /11 EXCHANGER 30KW /11 EXCHANGER 35KW /11 EXCHANGER 18/24KW / BURNER 35KW BURNER 18/24KW BURNER 30KW AIR SEPARATOR DOOR ASSY /11 DOOR ASSY / TRAP TUBE PVC D:19 L: FLEXIBLE PIPE SILICONE TUBE D: 8x1 L: 0.15M GASKET D: /11 GASKET D: / ELECTRODE GASKET DOOR GASKET GASKET / GAS SECTION 0201 GAS VALVE FAN ASSY GAS RESTRICTOR D: GPL.. GAS RESTRICTOR D: GPL.. GAS RESTRICTOR D: GPL DUCT FIRST SECTION VENTURI D: 17MM VENTURI D: VENTURI D: /11 VENTURI D: / SILENCER /11 SILENCER / UNION (3/4) UNION (1/2) GROMMET GAS TUBE GAS TUBE GAS TUBE GASKET SHEET GASKET D: O-RING D: FAN ASSEMBLY 0310 BI FLUX CONNECTION FLUE INTAKE PLUG SEALING RING 80mm GASKET GASKET SEALED CASE 0401 EXPANSION VESSEL SPRING FRONT PANEL (KIT) AIR RETURN COVER PANEL (FRONT - SEALED CHAMBER) LEFT HAND PANEL CASE PANEL (L.H. SIDE) RIGHT SIDE PANEL CASE PANEL (R.H. SIDE) CASE PANEL (FRONT) FACIA EXPANSION VESSEL SUPPORT CABLE INLET RUBBER WASHER CABLE INLET RUBBER WASHER from to E-COMBI - E-SYSTEM Domestic Gas Boilers 3

4 4 Domestic Gas Boilers E-COMBI - E-SYSTEM SYSTEM (+) R

5 FF FF Key N Description Manf. Pt. N Type Manf. date from to 0500 FLOW GROUP 0501 FLOW GROUP GRUPPO MANDATA TEMPERATURE PROBE + CLIP PRESSURE RELIEF VALVE 3 BAR OVERHEAT THERMOSTAT 100C WATER / WATER HEAT EXCHANGER WATER / WATER HEAT EXCHANGER PLUG GROMMET BY-PASS INTERFACE System Close SYST... INTERFACE System + Open SYST UNION ( 3/4-1/2) HYDRAULIC GROUP SUPPORT PIPE (SAFETY VALVE) HEATING FLOW TUBE BY-PASS PIPE PIPE SYSTEM CLIP D: CLIP D= CLIP CLIP SHEET GASKET D: O - RING (15.88X2.62) O-RING D: O - RING (15.54X2.62) O-RING 3,53X17, EXCHANGER GASKET SHEET GASKET D: RETURN GROUP 0601 RETURN GROUP LOW PRESSURE SWITCH TEMPERATURE PROBE + CLIP PUMP 6M 2V MOTOR - THREE-WAY VALVE SENSOR (REED) FLOW METER D.H.W. PLUG MOTOR + SPRING 3 WAY VALVE KIT PLUG PLUG RIDUCTORS (KIT) AUTO AIR VENT WITH O-RING KIT DRAIN SCREW WATER FILTER GROMMET CHECK VALVE CARTRIDGE PIPE (EXPANSION VESSEL) HEATING RETURN TUBE CLIP D: CLIP CLIP U-CLIP CLIP CLIP CLIP CLIP CLIP GASKET 3/ O - RING (9.19X2.62) O-RING 3,53X17, O - RING (23.47X2.62) O-RING O - RING (15.54X2.62) O RING D: O - RING (21.89X2.62) O-RING 17,17X1, O-RING D: O-RING D: E-COMBI - E-SYSTEM Domestic Gas Boilers 5

6 Domestic Gas Boilers E-COMBI - E-SYSTEM E-SYSTEM E-COMBI Transf. gaz > GPL Conv. gas > GPL Trasf. gas > GPL Transf. gas > GPL 5002 Transf. gaz > Nat Conv. gas >Nat Trasf. gas > Met Transf. gas > Met 5020 Options Accessories Opzioni Accessorio 6 R

7 FF FF Key N Description Manf. Pt. N Type Manf. date from to 0800 ELECTRICAL BOX 0801 FUSE 250V 2A P.C.B (CLIP-IN) E-BUS PUSH IGNITER INSPECTION COVER HOLE PLATE MECHANICAL CLOCK CONTROL PANEL P.C.B. (MAIN) PRINTED CIRCUIT BOARD (DISPLAY) PUSH BUTTON ON/OFF KNOB PLUG CONTROL PANEL COVER (REAR) PRESSURE GAUGE SERIGRAPHED STRIP KIT SERIGRAPHED STRIP KIT CABLE CLAMP CABLE CLAMP ELECTRODE IGNITION CABLE TIMECLOCK CABLE EARTH WIRE DISPLAY WIRING / CN02... IGNITOR - GAS VALVE CABLE / CN03... NTC - OVERHEAT - PRESSURE SENSOR CABLE / CN04... IONIZATION ELECTRODE CABLE / CN05... THREE WAY VALVE CABLE / CN09... PUMP 2V CABLE 6M / CN10... CLIP-IN E-BUS WIRING / CN11... FLOW METER CABLE / CN14... SOLAR SENSOR CABLE / CN17... FEEDER 240V / CN20... NTC PROBE - NTC EXCHANGER - FAN / CN22... ROOM THERMOSTAT CABLE / CN JIG PLATE & PIPE FITTING 0902 WATER FLOW SERVICE TAP HOT WATER CONNECTION GAS SERVICE TAP GAS SERVICE TAP COLD WATER TAP WATER RETURN SERVICE TAP THERMOSTATIC MIXING VALVE WALL HOOK WALL HOOK SHEET GASKET D: TEMPERATURE PROBE + CLIP FILTER SHEET GASKET D: SHEET GASKET D: NON-RETURN VALVE SHEET GASKET D: FLEXIBLE PIPE ACCESSORIES 5001 BURNER JET FULL KIT (LPG) BURNER JET FULL KIT (LPG) CONVERSION KIT > GPL ROD PLATE CLEANING KIT CONDENSATION AIR RETURN MANIFOLD E-COMBI - E-SYSTEM Domestic Gas Boilers 7

8 Domestic Gas Boilers E-COMBI - E-SYSTEM LIST OF THE ABBREVATIONS HW... : Hot water. CW... : Cold water. C... : Ceramic resistance (normal heating). Ca... : Ceramic resistance (accelerated heating) TP... : Immersion heater. 1F... : With fittings. 2F... : Without fittings. 3F... : With fittings and another outlet connection. AMI... : With mixing valve. SMI... : Without mixing valve. PUISS... : Power of th appliance. PN... : Appliance with normal pression. LP... : Appliance with low pression. PV... : Appliance with variable power. PF... : Appliance with fixed power.. IDENTIFICATION PLATE SERIAL NUMBER 11 Characters : Month of manucfacture : from 1 to 9 Jan. to Sep., O Oct., N Nov., D Dec. 19 Characters : Year of manufacture Month of manucfacture Product reference Millenium of manufacture Characters : XX Characters : XX Product reference Year of manufacture Technical number of the appliance Sequencial number Year of manufacture Product reference Sequencial number Sequencial number Manufacturing day Year of manufacture Sequencial number Manufacturing day The indications mentionned on the prices, commercial or technical literature and the scheme are written for your guidance and are available at a given time. The CONSTRUCTOR retains the power to modify the presentation, the form, the size, the conception or the material of the products. 8