Safety Data Sheet according to the Hazard Communication Standard (CFR ) HazCom 2012.

Transcription

1 SECTION 1: Identification of the substance/mixture and of the company/undertaking 1.1. Product identifier Product name Product code : : ML Relevant identified uses of the substance or mixture and uses advised against Use of the substance/mixture 1.3. Details of the supplier of the safety data sheet Medivators Inc th Avenue North Minneapolis, MN USA T (800) Emergency telephone number : High-level disinfectant for professional medical use Emergency number : CHEMTREC (800) CHEMTREC International +1 (703) hr SECTION 2: Hazards identification 2.1. Classification of the substance or mixture GHS-US classification Eye irritation 2A Skin sensitization Label elements GHS-US labelling Hazard pictograms (GHS-US) : Signal word (GHS-US) Hazard statements (GHS-US) Precautionary statements (GHS-US) GHS07 : Warning : Causes serious eye irritation. May cause an allergic skin reaction. : Wash hands thoroughly after handling. Wear eye protection/face protection/protective gloves. Avoid breathing dust/fume/gas/mist/vapors/spray. Contaminated work clothing must not be allowed out of the workplace. If in eyes: Rinse cautiously with water for several minutes. Remove contact lenses, if present and easy to do. Continue rinsing. If eye irritation persists: Get medical advice/attention. If on skin: Wash with plenty of water. If skin irritation or rash occurs: Get medical advice/attention. Wash contaminated clothing before reuse. Dispose of contents/ container in accordance with local/regional/national/international regulation Other hazards SECTION 3: Composition/information on ingredients 3.1. Substance Not applicable Mixture Name Product identifier % GHS-US classification Alcohols, C9-11, ethoxylated (CAS No) Acute Tox. 4 (Oral) Eye Dam. 1 ortho-phthalaldehyde (CAS No) Acute Tox. 3 (Oral) Skin Corr. 1B Skin Sens. 1 * The exact percentage (concentration) of composition has been withheld as a trade secret in accordance with paragraph (i) of EN Rev A Page 1 of 5

2 SECTION 4: First aid measures 4.1. Description of first aid measures First-aid measures after inhalation First-aid measures after skin contact First-aid measures after eye contact First-aid measures after ingestion : If breathing is difficult, remove victim to fresh air and keep at rest in a position comfortable for breathing. Get medical advice/attention if you feel unwell. : In case of contact, immediately flush skin with plenty of water. Remove contaminated clothing and shoes. Wash clothing before reuse. Call a physician if irritation develops and persists. : In case of contact, immediately flush eyes with plenty of water for at least 15 minutes. If easy to do, remove contact lenses, if worn. If irritation persists, get medical attention. : If swallowed, do NOT induce vomiting unless directed to do so by medical personnel. Never give anything by mouth to an unconscious person. Get medical advice/attention if you feel unwell Most important symptoms and effects, both acute and delayed Symptoms/injuries after inhalation Symptoms/injuries after skin contact Symptoms/injuries after eye contact Symptoms/injuries after ingestion : May cause respiratory tract irritation. : May cause skin irritation. Symptoms may include redness, drying, defatting and cracking of the skin. May cause sensitization by skin contact. : Causes serious eye irritation. Symptoms may include discomfort or pain, excess blinking and tear production, with marked redness and swelling of the conjunctiva. : May be harmful if swallowed. May cause stomach distress, nausea or vomiting Indication of any immediate medical attention and special treatment needed Symptoms may not appear immediately. In case of accident or if you feel unwell, seek medical advice immediately (show the label or SDS where possible). SECTION 5: Firefighting measures 5.1. Extinguishing media Suitable extinguishing media Unsuitable extinguishing media : Treat for surrounding material. : None known Special hazards arising from the substance or mixture Fire hazard : Products of combustion may include, and are not limited to: oxides of carbon Advice for firefighters Protection during firefighting : Keep upwind of fire. Wear full fire fighting turn-out gear (full Bunker gear) and respiratory protection (SCBA). SECTION 6: Accidental release measures 6.1. Personal precautions, protective equipment and emergency procedures General measures 6.2. Methods and material for containment and cleaning up For containment Methods for cleaning up 6.3. Reference to other sections : Use personal protection recommended in Section 8. Isolate the hazard area and deny entry to unnecessary and unprotected personnel. : Contain and/or absorb spill with inert material (e.g. sand, vermiculite), then place in a suitable container. Use appropriate Personal Protective Equipment (PPE). : Scoop up material and place in a disposal container. See section 8 for further information on protective clothing and equipment and section 13 for advice on waste disposal. SECTION 7: Handling and storage 7.1. Precautions for safe handling Precautions for safe handling Hygiene measures 7.2. Conditions for safe storage, including any incompatibilities Storage conditions 7.3. Specific end use(s) Not available. : Avoid contact with skin and eyes. Avoid breathing dust/fume/gas/mist/vapors/spray. Do not swallow. Handle and open container with care. When using do not eat, drink or smoke. : Launder contaminated clothing before reuse. Wash hands before eating, drinking, or smoking. : Keep out of the reach of children. Keep container tightly closed.

3 SECTION 8: Exposure controls/personal protection 8.1. Control parameters Alcohols, C9-11, ethoxylated ( ) USA ACGIH ACGIH TWA Not available. USA OSHA OSHA PEL (TWA) Not available. ortho-phthalaldehyde ( ) USA ACGIH ACGIH TWA Not available. USA OSHA OSHA PEL (TWA) Not available Exposure controls Appropriate engineering controls Hand protection Eye protection Skin and body protection Respiratory protection Environmental exposure controls : Use ventilation adequate to keep exposures (airborne levels of dust, fume, vapor, etc.) below recommended exposure limits. : Wear chemically resistant protective gloves. : Wear eye protection. : Wear suitable protective clothing. : In case of insufficient ventilation, wear suitable respiratory equipment. Respirator selection must be based on known or anticipated exposure levels, the hazards of the product and the safe working limits of the selected respirator. : Maintain levels below Community environmental protection thresholds. : Do not eat, smoke or drink where material is handled, processed or stored. Wash hands carefully before eating or smoking. Handle according to established industrial hygiene and safety practices. SECTION 9: Physical and chemical properties 9.1. Information on basic physical and chemical properties Physical state : Liquid Appearance : Clear Colour : Colourless Odour : Mild but distinctive Odour threshold ph : Relative evaporation rate (butylacetate=1) Melting point Freezing point Boiling point : > 100 C (212 F) Flash point Auto-ignition temperature Decomposition temperature Flammability (solid, gas) : Not flammable Vapour pressure Relative vapour density at 20 C Relative density : Solubility Log Pow Log Kow Viscosity, kinematic Viscosity, dynamic Explosive properties Oxidising properties Explosive limits 9.2.

4 SECTION 10: Stability and reactivity Reactivity No dangerous reaction known under conditions of normal use Chemical stability Stable under normal storage conditions Possibility of hazardous reactions No dangerous reaction known under conditions of normal use Conditions to avoid Heat Incompatible materials None known Hazardous decomposition products May include, and are not limited to: oxides of carbon. SECTION 11: Toxicological information Information on toxicological effects Acute toxicity : Not classified. LD50 dermal rabbit LC50 inhalation rat Alcohols, C9-11, ethoxylated ( ) LD50 dermal rabbit ortho-phthalaldehyde ( ) > 2000 mg/kg > 2000 mg/kg > 20 mg/l/4h 1400 mg/kg 1378 mg/kg >2 g/kg 120 mg/kg Skin corrosion/irritation Serious eye damage/irritation : Causes serious eye irritation. Respiratory or skin sensitization : May cause an allergic skin reaction. Germ cell mutagenicity Carcinogenicity Reproductive toxicity Specific target organ toxicity (single exposure) Specific target organ toxicity (repeated exposure) Aspiration hazard Symptoms/injuries after inhalation Symptoms/injuries after skin contact Symptoms/injuries after eye contact Symptoms/injuries after ingestion SECTION 12: Ecological information Toxicity Ecology - general : May cause respiratory tract irritation. : May cause skin irritation. Symptoms may include redness, drying, defatting and cracking of the skin. May cause sensitization by skin contact. : Causes serious eye irritation. Symptoms may include discomfort or pain, excess blinking and tear production, with marked redness and swelling of the conjunctiva. : May be harmful if swallowed. May cause stomach distress, nausea or vomiting. : May cause long-term adverse effects in the aquatic environment Persistence and degradability Persistence and degradability Not established.

5 12.3. Bioaccumulative potential Bioaccumulative potential Not established Mobility in soil Other adverse effects Effect on ozone layer Effect on the global warming : : No known ecological damage caused by this product. SECTION 13: Disposal considerations Waste treatment methods Waste disposal recommendations SECTION 14: Transport information In accordance with DOT UN number Not regulated for transport UN proper shipping name Not applicable. : This material must be disposed of in accordance with all local, state, provincial, and federal regulations. The generation of waste should be avoided or minimized wherever possible Additional information Special transport precautions : No supplementary information available. : Do not handle until all safety precautions have been read and understood. SECTION 15: Regulatory information US Federal regulations All components of this product are listed, or excluded from listing, on the United States Environmental Protection Agency Toxic Substances Control Act (TSCA) inventory US State regulations Rapicide OPA 28 State or local regulations SECTION 16: Indication of changes Date of issue : None. : 16Oct14 : None. This product does not contain a chemical known to the State of California to cause cancer, birth defects or other reproductive harm.