Specifications for a Trailer Mounted 60 kw Three Phase Portable Generator

Transcription

1 Specifications for a Trailer Mounted 60 kw Three Phase Portable Generator The Trailer Mounted Generator covered by these specifications will be used primarily by the Northwest Wastewater Treatment Plant as back up power for City Sewage Lift Stations. If the Equipment proposed by the Bidder does not meet or exceed the specification(s) listed herein, the Bidder shall note in detail the deviations in the space(s) provided. The generator and trailer shall be equipped to comply with all applicable Federal and State OSHA requirements. Generator Features Brushless alternator for long life, low maintenance Yes No Voltage regulation ½% Yes No 60 Hertz frequency Yes No Industrial grade Tier 3 Engine Yes No Air Intake Heater Yes No Fuel/Water separator Yes No Electronic Governor Yes No Digital Controller with automatic safety shutdowns and digital readouts for: Low oil pressure Yes No High water temperature Yes No Engine over-crank Yes No Engine over-speed Yes No Low fuel level shutdown (user select) Yes No Controller disconnect switch Yes No Voltage adjust potentiometer Yes No Illuminated Instrumentation Panel Yes No Main Circuit breaker for main power connection Yes No Circuit breakers for single phase receptacles Yes No Single phase receptacles are powered during all main voltage configurations Yes No Heavy gauge steel sound attenuated enclosure with: Internally mounted muffler Yes No Durable powder coat paint finish Yes No Pad lock-able doors Yes No

2 Single point lifting eye Yes No Long run, internal, single wall XLPE fuel tank Yes No 6 bolts to remove generator from trailer Yes No Standard Premium grade DOT approved tandem axle highway trailer featuring: Torsion bar suspension Yes No Diamond plate aluminum fenders Yes No Front leveling jack Yes No Running lights Yes No Hydraulic brakes Yes No Lighted license plate bracket Yes No 2" ball hitch coupling Yes No Battery included Yes No Limited 3 year Warranty 1 year or 3,000 hours parts and labor Yes No 3 year or 3,000 hours parts Yes No Options to be included: Block Heater Yes No Battery Charger Yes No Shore power inlet for easy connection to block heater or battery charger Yes No Electric Brakes Yes No Automatic transfer switches Yes No Battery Disconnect Yes No Spark Arrestor Muffler Yes No Permanent Magnet Gen Yes No Voltage Adjustment Potentiometer Yes No Generator Specifications - Preliminary Standby Output 150 C Rise kva/kw Single 240V 45/45 Yes No 3 208V 74/59 Yes No 3 240V 80/64 Yes No 3 480V 80/64 Yes No

3 Prime Output 125 C Rise kva/kw Single 208V 41/41 Yes No 3 240V 67/54 Yes No 3 480V 73/58 Yes No Amperage (Standby Rating) Amps Single phase 240/120V 17/2X187 Yes No 3 phase 208V 205 Yes No 3 phase 240V 192 Yes No 3 phase 480V 96 Yes No Voltage - 3 phase adjustable 208/220/240/416/440/460/480 Yes No Voltage-Single phase adjustable 120/127/139/240/254/277 Yes No 3 phase Power Factor.8 Yes No Voltage Regulation ½% Yes No Frequency 60 Hertz Yes No Total Harmonic Distortion <5% Yes No Insulation Class H Yes No Engine Specifications Cylinders 4 Yes No Induction System Turbocharged, Charge Air Cooled Yes No Displacement, L (cu. in) 4.5L (275) Yes No EPA Emissions Level Tier 3 Yes No rated speed 99 Yes No RPM 1800 Yes No Bore and stroke 4.2" x 5.0" Yes No Lubrication capacity (with filter) 13.9 Qts Yes No Battery recommendation (min. cold cranking amps) 925 Yes No Battery, battery rack and cable supplied Yes No Spin on oil filter Yes No Thermostat controlled liquid cooling system Yes No 12V engine alternator Yes No

4 12V starter motor Yes No Receptacle Specifications 120 Volt 20 Amp Duplex GFCI 3 Yes No 120/240 Volt 50 Amp Twistlock 3 Yes No Two wire remote start capability Yes No Fuel System Specifications Fuel consumption Standby Rating GPH ½ load 3.1 Yes No Full load 6.3 Yes No Approximate Run Time Hours ½ load 32 Yes No Full load 16 Yes No Fuel Capacity Gallons Fuel Diesel Yes No Weights and Dimensions Weight without fuel Weight without fuel and without trailer Dimensions with trailer ( L x W x H) Dimensions without trailer (L x W x H) Sound Level Sound level db(a) 67 Yes No 7 meters, full load Yes No Other Features Start/Stop/Auto Switch Yes No Alarm Horn Yes No Controller Disconnect Switch Yes No Trailer Side Markers and Running Lights Yes No

5 Literature (Delivery is not complete without Literature): Operations - Manual of operator instructions covering operating Yes No procedures of Generator and Trailer Parts - Book with comprehensive listing of all parts for Generator and Trailer Yes No Service - Manual of proper mechanical maintenance procedures Yes No required to assure proper operation and life. Delivery Generator and Trailer - FOB Carbondale Northwest Wastewater Treatment Plant, 1699 New Era Road Yes No Delivery - Days from Award (stipulate) Days Parts and Service Service Location - Number of miles from Northwest Wastewater Treatment Plant 1699 New Era Road (stipulate) Miles