SAFETY DATA SHEET. Revision Date 21-Sep Identification S271-1; S271-3; S271-10; S271-10LC; S271-5; S271-50; S271-50LC; S LB; S

Transcription

1 Creation Date 22-Jun-2009 Product Name SAFETY DATA SHEET 1. Identification Sodium chloride Revision Number 2 Cat. : Synonyms Recommended Use S271-1; S271-3; S271-10; S271-10LC; S271-5; S271-50; S271-50LC; S LB; S Halite; Common salt; Rock salt Laboratory chemicals. Uses advised against Information available Details of the supplier of the safety data sheet Company Fisher Scientific One Reagent Lane Fair Lawn, NJ Tel: (201) Emergency Telephone Number CHEMTRECÒ, Inside the USA: CHEMTRECÒ, Outside the USA: Hazard(s) identification Classification Classification under 2012 OSHA Hazard Communication Standard (29 CFR ) Based on available data, the classification criteria are not met Label Elements ne required Hazards not otherwise classified (HNOC) ne identified 3. Composition / information on ingredients Component CAS- Weight % Sodium chloride >95 4. First-aid measures Eye Contact Rinse immediately with plenty of water, also under the eyelids, for at least 15 minutes. Obtain medical attention. Page 1 / 6

2 Skin Contact Inhalation Ingestion Most important symptoms/effects tes to Physician Unsuitable Extinguishing Media Flash Point Method - Wash off immediately with plenty of water for at least 15 minutes. Get medical attention immediately if symptoms occur. Move to fresh air. If breathing is difficult, give oxygen. Get medical attention immediately if symptoms occur. Do not induce vomiting. Obtain medical attention.. Treat symptomatically 5. Fire-fighting measures Autoignition Temperature Explosion Limits Upper data available Lower data available Sensitivity to Mechanical Impact Sensitivity to Static Discharge Specific Hazards Arising from the Chemical Thermal decomposition can lead to release of irritating gases and vapors. Keep product and empty container away from heat and sources of ignition. Hazardous Combustion Products Hydrogen chloride gas Sodium oxides Protective Equipment and Precautions for Firefighters As in any fire, wear self-contained breathing apparatus pressure-demand, MSHA/NIOSH (approved or equivalent) and full protective gear. NFPA Health 1 Flammability 0 Instability 1 Physical hazards N/A Personal Precautions Environmental Precautions 6. Accidental release measures Ensure adequate ventilation. Use personal protective equipment. Avoid dust formation. Should not be released into the environment. See Section 12 for additional ecological information. Methods for Containment and Clean Sweep up or vacuum up spillage and collect in suitable container for disposal. Avoid dust Up formation. Handling Storage Exposure Guidelines 7. Handling and storage Wear personal protective equipment. Ensure adequate ventilation. Avoid dust formation. Keep containers tightly closed in a dry, cool and well-ventilated place. 8. Exposure controls / personal protection This product does not contain any hazardous materials with occupational exposure limits established by the region specific regulatory bodies. Page 2 / 6

3 Engineering Measures Ensure adequate ventilation, especially in confined areas. Ensure that eyewash stations and safety showers are close to the workstation location. Personal Protective Equipment Eye/face Protection Skin and body protection Respiratory Protection Hygiene Measures Wear appropriate protective eyeglasses or chemical safety goggles as described by OSHA's eye and face protection regulations in 29 CFR or European Standard EN166. Wear appropriate protective gloves and clothing to prevent skin exposure. Follow the OSHA respirator regulations found in 29 CFR or European Standard EN 149. Use a NIOSH/MSHA or European Standard EN 149 approved respirator if exposure limits are exceeded or if irritation or other symptoms are experienced. Handle in accordance with good industrial hygiene and safety practice. 9. Physical and chemical properties Physical State Solid Appearance White Odor Odorless Odor Threshold ph 20 C; 5% aq.sol Melting Point/Range 801 C / F Boiling Point/Range 1461 C / mmhg Flash Point Evaporation Rate Flammability (solid,gas) Flammability or explosive limits Upper data available Lower data available Vapor Pressure C Vapor Density Specific Gravity Solubility Partly soluble in water Partition coefficient; n-octanol/water data available Autoignition Temperature Decomposition Temperature Viscosity Molecular Formula Cl Na Molecular Weight Stability and reactivity Reactive Hazard Stability Conditions to Avoid Incompatible Materials ne known, based on information available Hygroscopic. Incompatible products. Excess heat. Avoid dust formation. Exposure to moist air or water. Strong oxidizing agents, Metals, Strong acids Hazardous Decomposition Products Hydrogen chloride gas, Sodium oxides Hazardous Polymerization Hazardous Reactions Hazardous polymerization does not occur. ne under normal processing. 11. Toxicological information Page 3 / 6

4 Acute Toxicity Product Information See actual entry in RTECS for complete information. Component Information Component LD50 Oral LD50 Dermal LC50 Inhalation Sodium chloride LD50 = 3 g/kg ( Rat ) LD50 > 10 g/kg ( Rabbit ) LC50 > 42 g/m 3 ( Rat ) 1 h Toxicologically Synergistic Products Delayed and immediate effects as well as chronic effects from short and long-term exposure Irritation Sensitization Carcinogenicity The table below indicates whether each agency has listed any ingredient as a carcinogen. Component CAS- IARC NTP ACGIH OSHA Mexico Sodium chloride t listed t listed t listed t listed t listed Mutagenic Effects t mutagenic in AMES Test Reproductive Effects Developmental Effects Teratogenicity STOT - single exposure STOT - repeated exposure Aspiration hazard Symptoms / effects,both acute and delayed Endocrine Disruptor Information Other Adverse Effects Ecotoxicity Do not empty into drains.... ne known ne known The toxicological properties have not been fully investigated. 12. Ecological information Component Freshwater Algae Freshwater Fish Microtox Water Flea Sodium chloride t listed Pimephals prome: LC50: 7650 mg/l/96h t listed EC50: 1000 mg/l/48h Persistence and Degradability Soluble in water Persistence is unlikely based on information available. Bioaccumulation/ Accumulation. Mobility Waste Disposal Methods DOT TDG IATA Will likely be mobile in the environment due to its water solubility. 13. Disposal considerations Chemical waste generators must determine whether a discarded chemical is classified as a hazardous waste. Chemical waste generators must also consult local, regional, and national hazardous waste regulations to ensure complete and accurate classification. 14. Transport information t regulated t regulated t regulated Page 4 / 6

5 IMDG/IMO t regulated 15. Regulatory information International Inventories Component TSCA DSL NDSL EINECS ELINCS NLP PICCS ENCS AICS IECSC KECL Sodium chloride X X X X X X X Legend: X - Listed E - Indicates a substance that is the subject of a Section 5(e) Consent order under TSCA. F - Indicates a substance that is the subject of a Section 5(f) Rule under TSCA. N - Indicates a polymeric substance containing no free-radical initiator in its inventory name but is considered to cover the designated polymer made with any free-radical initiator regardless of the amount used. P - Indicates a commenced PMN substance R - Indicates a substance that is the subject of a Section 6 risk management rule under TSCA. S - Indicates a substance that is identified in a proposed or final Significant New Use Rule T - Indicates a substance that is the subject of a Section 4 test rule under TSCA. XU - Indicates a substance exempt from reporting under the Inventory Update Rule, i.e. Partial Updating of the TSCA Inventory Data Base Production and Site Reports (40 CFR 710(B). Y1 - Indicates an exempt polymer that has a number-average molecular weight of 1,000 or greater. Y2 - Indicates an exempt polymer that is a polyester and is made only from reactants included in a specified list of low concern reactants that comprises one of the eligibility criteria for the exemption rule. U.S. Federal Regulations TSCA 12(b) SARA 313 SARA 311/312 Hazard Categories Acute Health Hazard Chronic Health Hazard Fire Hazard Sudden Release of Pressure Hazard Reactive Hazard CWA (Clean Water Act) Clean Air Act OSHA Occupational Safety and Health Administration CERCLA California Proposition 65 U.S. State Right-to-Know Regulations This product does not contain any Proposition 65 chemicals U.S. Department of Transportation Reportable Quantity (RQ): DOT Marine Pollutant DOT Severe Marine Pollutant N N N U.S. Department of Homeland Security This product does not contain any DHS chemicals. Other International Regulations Page 5 / 6

6 Mexico - Grade Severe risk, Grade 4 Canada This product has been classified in accordance with the hazard criteria of the Controlled Products Regulations (CPR) and the MSDS contains all the information required by the CPR WHMIS Hazard Class Prepared By n-controlled 16. Other information Regulatory Affairs Thermo Fisher Scientific EMSDS.RA@thermofisher.com Creation Date Revision Date Print Date Revision Summary 22-Jun Sep Sep-2015 This document has been updated to comply with the US OSHA HazCom 2012 Standard replacing the current legislation under 29 CFR to align with the Globally Harmonized System of Classification and Labeling of Chemicals (GHS) Disclaimer The information provided on this Safety Data Sheet is correct to the best of our knowledge, information and belief at the date of its publication. The information given is designed only as a guide for safe handling, use, processing, storage, transportation, disposal and release and is not to be considered as a warranty or quality specification. The information relates only to the specific material designated and may not be valid for such material used in combination with any other material or in any process, unless specified in the text. End of SDS Page 6 / 6