Any room, space or piece of furniture where chemicals are stored for departmental, laboratory or individual use.

Save this PDF as:
 WORD  PNG  TXT  JPG

Size: px
Start display at page:

Download "Any room, space or piece of furniture where chemicals are stored for departmental, laboratory or individual use."

Transcription

1 Lakehead University Health & Safety Procedure: Chemical Storage Procedure Approved on: September 27, 2005 Revised on: February 28, 2006; March 6, 2009 Approved by: Director, Human Resources Intent: This procedure was written to provide guidance regarding safe storage of laboratory chemicals. This procedure was developed in accordance with the University s directive on health and safety and to ensure compliance with Ontario Occupational Health and Safety regulations and the Ontario Fire Code. Scope: This procedure applies to all hazardous chemicals stored on Campus and all members of the University Community, including guests, visitors and contractors, who work with hazardous chemicals. Definitions: WHMIS Workplace Hazardous Materials Information System. A Canada wide information system that deals specifically with safe management and use of hazardous materials legislated by both Federal and provincial government. MSDS Hazardous Products NFC Storage Area BSC Eye level Material Safety Data Sheet. A document required under WHMIS regulation containing specific data about hazardous material properties and safe handling procedures. Products regulated by WHMIS. National Fire Code of Canada Any room, space or piece of furniture where chemicals are stored for departmental, laboratory or individual use. Biological Safety Cabinet At the eye level of the shortest person accessing the hazardous material.

2 Applicable Legislation: Occupational Health and Safety Act, Sections 37(1) Regulation 851, R.R.O, 1990, Industrial Establishment Regulation 860, R.R.O. 1990, WHMIS Ontario Reg. 833 R.R. O. 1990, Control of Exposure to Biological and Chemical Agents Ontario Reg , R.R.O. 1990, for Designated Substances Ontario Fire Code (O. Reg. 388/97) National Fire Code of Canada Controlled Drugs and Substances Act, 1996 (c. 19) Hazardous Products Act and Regulation, R.S. 1985, C. H-3. Procedure: Storage Areas Storage areas are secured when not in use and are available to authorized personnel only. Storage areas are well illuminated. Open flames, smoking and localized heating units are not permitted near storage areas. Mixing of chemicals on surfaces used for storage is not allowed. Aisles surrounding storage areas are free from obstruction and other tripping hazards. Shelf Storage Large or heavy bottles and containers are stored on shelves no higher than waist level. Containers of chemicals are stored at or below eye level, where possible. Reagent bottles or containers do not protrude over the shelf edges. Enough storage space is allotted, ensuring that shelves are not crowded. Empty bottles are removed from the shelves. Shelves and benches are level and stable. Shelving units are securely fastened to the wall. The weight limit of the shelves is not exceeded. Shelves are clean, free from chemical contamination. Storage Containers Storage containers are inspected periodically for rust, corrosion and leakage. Damaged containers are replaced or repaired immediately. Chemicals are stored in sealed containers, not beakers or open vessels. Stoppers are easily removed from bottles or containers. Containers of mercury are well stoppered, see designated substance procedure. Eye-dropper bottles are not used for storing corrosive or water-reactive chemicals.

3 Labelling of Chemical Containers All containers are properly labelled with appropriate WHMIS supplier labels or workplace labels. All labels are readable and free from encrustation. Labels are firmly attached to the containers. Container labels include both date of receipt and anticipated disposal (necessary only for chemicals which degrade over time). Guidelines Chemicals are not exposed to direct sunlight or localized heat. It is recommended that containers of corrosive chemicals be stored in trays large enough to contain spillage or leakage. Chemicals are stored by reactive class (i.e. flammables with flammables, oxidizers with oxidizers). Incompatible chemicals are physically separated from each other. MSDS for each chemical must be consulted for proper storage instructions and should be accessible to the storage area. Current chemical inventory is accessible to the storage area and is filed yearly with the Office of Human Resources. Bottle carriers are used to transport glass bottles containing hazardous chemicals. New chemicals shall be segregated from waste chemicals. If an emergency situation occurs, Security will be notified by dialling 8911 from a safe distance, as well as, the laboratory supervisor. Requests for special consideration for non-compliance should be made to Human Resources Health and Safety. General Storage Information In all cases, the material safety data sheet (MSDS) must be consulted for specific instruction on safe storage and incompatibility information. Acids Large bottles are stored on a low shelf or in acid cabinets. Oxidizing acids are segregated from organic acids, flammable and combustible materials. Acids are separated from caustics and from reactive metals such as sodium, magnesium and potassium. Acids are segregated from chemicals which can generate toxic gases on contact such as sodium cyanide and iron sulphide. Spill control procedures and materials (neutralizers, absorbent materials) are available. Caustics Caustics are stored away from acids. Solutions of inorganic hydroxides are stored in polyethylene containers. Caustics are stored below eye level.

4 Spill control procedures and materials (neutralizers, absorbent pillows) are available. Flammables All flammable liquids are stored in a NFC approved flammable liquid cabinet. All flammable liquids are kept in a flammable cabinet, except for quantities required in one day s work. Containers used for the storage of flammable or combustible liquids in a laboratory shall be of not more than 5 L capacity. Quantities of flammable and combustible liquids greater than 300L must be stored in a designated and approved chemical storage room. Flammable liquids are to be kept away from any open flames or other sources of ignition. Only approved explosion proof or flammables refrigerators should be used to store flammable liquids. Smoking is prohibited in areas where flammable substances are used and stored. Peroxide Forming Chemicals Peroxide forming chemicals must be stored in airtight containers in a dark, cool and dry place. Peroxide forming chemicals should be properly disposed prior to the date of expected peroxide formation. Suspicion of peroxide contamination is immediately evaluated by use of safe procedures. Chemicals are labelled with date received and date of disposal. Water Reactive Chemicals Water reactive chemicals are stored in a cool, dry place. In case of fire, a Class D fire extinguisher is used. Oxidizers Oxidizers are stored away from flammable, combustible and reducing agents (e.g. zinc, alkaline metals). Oxidizers should not be stored on combustible surfaces. Toxic Materials In all areas where toxic materials are in use, a written guideline, for training purposes, will be used to address personal hygiene, use of personal protective equipment, control and use of fume hoods and BSCs and appropriate disposal. When toxic gases are in use, a written code of practice will be in place for the use of air purifying respirators and other PPE required for the hazard. PPE should be inspected regularly and records kept of their inspections. Toxic materials shall be stored separately from flammable liquids.

5 Toxic materials shall be transported in public areas only with appropriate safeguards. Toxic materials shall be disposed according to Lakehead University approved methods of disposal. Toxic compounds are stored according to the nature of the chemical, with appropriate security employed where necessary. A poison control network telephone number is posted. Radioactive Compounds Contact the Health and Safety Officer or the Laboratory and Biosafety Specialist in Human Resources for guidance. Evaluation: This procedure shall be evaluated by the Health and Safety Officer and/or Lab and Biosafety Specialist in conjunction with the Joint Health and Safety every three years.

Storage of minor quantities of hazardous substances in laboratories

Storage of minor quantities of hazardous substances in laboratories Storage of minor quantities of hazardous substances in laboratories 1. Purpose To assist laboratory users in safe and compliant storage of minor quantities of chemicals (excluding explosives, radioactive

More information

Guidance sheet 1: Chemical Storage

Guidance sheet 1: Chemical Storage Guidance sheet 1: Chemical Storage This Guidance sheet describes the procedures established under the Dangerous Goods (Storage and Handling) Regulations 2000 and relevant standards for the safe storage

More information

II. DEFINITIONS Hazardous material: Any chemical which poses a hazard to health, property, or the environment.

II. DEFINITIONS Hazardous material: Any chemical which poses a hazard to health, property, or the environment. Page 1 of 5 Keywords: Acid, Base, cart, Chemical Labeling, Chemical Spill, Chemical Spill Procedure, Chemical Storage, Clean-Up, Corrosive, DHMH, Elevator, Environmental Protection Agency, EPA, evacuation,

More information

Inventory and Inspection

Inventory and Inspection Inventory and Inspection Each laboratory should maintain an inventory of the chemicals stored in the laboratory. Each chemical should have a designated storage place and should be returned to that place

More information

HAZARDOUS CHEMICAL WASTE DISPOSAL SECTION 7

HAZARDOUS CHEMICAL WASTE DISPOSAL SECTION 7 HAZARDOUS CHEMICAL WASTE DISPOSAL According to Ontario environmental legislation, generators of hazardous waste are responsible for properly packaging and labelling such wastes. The University of Toronto

More information

ISU Laboratory Safety Inspection

ISU Laboratory Safety Inspection ISU Laboratory Safety Inspection Report Number (Bldg. Abbr.-Room #-Year) Date of Lab Inspection 4/30/13 9:47 AM Lab Inspection Report Prepared by John Goodman Disclaimer The assessors believe the information

More information

3.2 The Department of Environmental Health and Safety is responsible for;

3.2 The Department of Environmental Health and Safety is responsible for; 1 Introduction The have been developed in order to minimize the risk of accidental chemical reactions and exposure resulting from the improper storage of hazardous chemicals. The chemical storage procedures

More information

General Safety & Health Standards Published by the Division of Building Safety In Cooperation with the Idaho Industrial Commission

General Safety & Health Standards Published by the Division of Building Safety In Cooperation with the Idaho Industrial Commission General Safety & Health Standards Published by the Division of Building Safety In Cooperation with the Idaho Industrial Commission Laboratories and Chemical Storage Safety Rules 111 111. LABORATORIES AND

More information

Principal Investigator: Department: Building: Room Number: Person completing form: Phone Number:

Principal Investigator: Department: Building: Room Number: Person completing form: Phone Number: Risk Management & Safety Main Office, Wyoming Hall Room 102 Phone: (307) 766-3277 Fax: (307)766-6116 Regulated Materials Management Center Phone: (307)766-3696 Fax: (307)766-3699 Web: www.uwyo.edu/ehs

More information

Hazardous Waste Management Procedures

Hazardous Waste Management Procedures Hazardous Waste Management Procedures For information and guidance on handling and removal of hazardous waste contact the CSUCI office of Environment, Safety and Risk Management (X 8847). Campus Hazardous

More information

Laboratory Inspection

Laboratory Inspection Laboratory Inspection Conducted By: Date: Location (room # & building): I. Lab Work Practices No smoking, food & beverages rules are observed. Food and beverages are not stored in the laboratory areas,

More information

Compressed Gas Cylinder Safety

Compressed Gas Cylinder Safety Labeling Compressed Gas Cylinder Safety Cylinders should be labeled with the name of the gas or gas mixture and the primary hazard associated with that chemical (flammable, oxidizer, etc.) Do not accept

More information

RMM 501 Hazardous Materials Management Systems Including WHMIS Program Page 2 November 2014

RMM 501 Hazardous Materials Management Systems Including WHMIS Program Page 2 November 2014 RMM 501 Hazardous Materials Management Systems Including WHMIS Program Page 2 3.4 McMaster University RMM #300 Safety Orientation and Training Program 3.5 McMaster University RMM #301 Standard Operating

More information

LABORATORY SAFETY INSPECTION CHECKLIST

LABORATORY SAFETY INSPECTION CHECKLIST LABORATORY SAFETY INSPECTION CHECKLIST As part of EH&S's laboratory safety survey program, we have compiled a list of the most common safety problems. This is not a list of every possible hazard, but can

More information

POLICY FOR THE MANAGEMENT OF HAZARDOUS MATERIALS. Supersedes /Amends: VRS-47/October 20, 2004

POLICY FOR THE MANAGEMENT OF HAZARDOUS MATERIALS. Supersedes /Amends: VRS-47/October 20, 2004 Effective Date: February 15, 2010 Supersedes /Amends: VRS-47/October 20, 2004 Originating Office: Office of the Vice-President, Services Policy Number: VPS-47 SCOPE This Policy applies to all persons (including

More information

DANGEROUS GOODS DEPOTS

DANGEROUS GOODS DEPOTS DANGEROUS GOODS DEPOTS CONTENTS Contents... 1 1. Introduction... 2 2. Purpose... 2 3. What is a dangerous goods depot?... 2 4. Classification of dangerous goods... 2 4.1 Packing groups... 5 4.2 Primary

More information

Safety and Health Office WORKPLACE SAFETY CHECKLIST

Safety and Health Office WORKPLACE SAFETY CHECKLIST Location: Date: Inspected by: Safety and Health Office WORKPLACE SAFETY CHECKLIST WORK ENVIRONMENT Ventilation Removal of fumes and dust Temperature and humidity control Noise levels Vibration Lighting

More information

Hazardous Substances UHSP/15/HS/03 Schedule 5/04

Hazardous Substances UHSP/15/HS/03 Schedule 5/04 Health and Safety Policy Hazardous Substances UHSP/15/HS/03 Schedule 5/04 Hazardous Substances Policy Identification and Storage Arrangements for Keeping and Storage of Hazardous Substances This document

More information

Particularly Hazardous Substances (PHS) Standard Operating Procedure (SOP)

Particularly Hazardous Substances (PHS) Standard Operating Procedure (SOP) Particularly Hazardous Substances (PHS) Standard Operating Procedure (SOP) Formaldehyde, formalin, paraformaldehyde solutions, and paraformaldehyde solids Principal Investigator: Room & Building #: Department:

More information

Chemical Safety and Material Safety Data Sheets Lab worksheet

Chemical Safety and Material Safety Data Sheets Lab worksheet Honors Introductory Chemistry Spring 2011 Assignment #4 Chemical Safety and Material Safety Data Sheets Lab worksheet Discussion: Chemicals and other hazardous materials are an integral component of the

More information

Laboratory Hazardous Waste Disposal Guidelines

Laboratory Hazardous Waste Disposal Guidelines Satellite Accumulation Area (SAA) For safety and environmental reasons, hazardous waste must be stored in a designated "Satellite Accumulation Area." These areas must be inspected weekly for container

More information

Hazardous Waste Generator Training

Hazardous Waste Generator Training presented by Facilities Management and the office of Hazardous Waste Generator Training Environmental Health & Safety RCRA..."It's The Law!" Hazardous Waste is: Spent material that is: READY TO BE THROWN

More information

IX. EMERGENCY PLANNING

IX. EMERGENCY PLANNING IX. EMERGENCY PLANNING EMERGENCY PLANNING, SPILL RESPONSE & REPORTING Any unexpected event or accident situation that occurs during the transport, storage or use of hazardous materials constitutes a potential

More information

WHMIS: GENERAL INFORMATION & TRAINING REQUIREMENTS

WHMIS: GENERAL INFORMATION & TRAINING REQUIREMENTS WHMIS: GENERAL INFORMATION & TRAINING REQUIREMENTS What is WHMIS? WHMIS stands for the Workplace Hazardous Materials Information System. It is a national hazardous materials classification system designed

More information

SPILLS & SPILL KITS. Spills -General Guidelines:

SPILLS & SPILL KITS. Spills -General Guidelines: Spills -General Guidelines: If handled properly, a spill may be nothing more than a nuisance. If handled improperly, a spill can seriously disrupt your activities and the work of your colleagues. At worst,

More information

Workplace Hazardous Materials Information System (WHMIS)

Workplace Hazardous Materials Information System (WHMIS) Workplace Hazardous Materials Information System (WHMIS) Latest revised date: October 26, 2011 Page 1 of 12 1.0 Introduction 2.0 Scope Memorial University shall keep under constant review the use or presence

More information

Laboratory Audit Sheet Auditor s Name: Date of Inspection: / / Building Name: Room# Principal Investigator:

Laboratory Audit Sheet Auditor s Name: Date of Inspection: / / Building Name: Room# Principal Investigator: Laboratory Audit Sheet Auditor s Name: Date of Inspection: / / Building Name: Room# Principal Investigator: 1. 0 GENERAL HOUSKEEPING PRACTICES Y/N N/A C REGULATORY GUIDANCE COMMENTS 1.1 Walkways in and

More information

Guide on the Segregation, Packaging, Labelling and Storage of Laboratory Chemical Wastes for Schools

Guide on the Segregation, Packaging, Labelling and Storage of Laboratory Chemical Wastes for Schools APPENDIX II Guide on the Segregation, Packaging, Labelling and Storage of Laboratory Chemical Wastes for Schools (Prepared by Environmental Protection Department) 1. Introduction The Waste Disposal (Chemical

More information

Flammables & Explosives

Flammables & Explosives M3055 Flammables & Explosives Leader s Guide Marcom Group Ltd. INTRODUCTION TO THE PROGRAM Structure and Organization Information in this program is presented in a definite order, so that employees will

More information

Grade 9 Applied Science Unit 1 Lesson 2 Safety in the Lab

Grade 9 Applied Science Unit 1 Lesson 2 Safety in the Lab Grade 9 Applied Science Unit 1 Lesson 2 Safety in the Lab Safety is paramount in a science lab. Safety includes safe chemical storage, safe chemical use, proper use of equipment, safety equipment and partner

More information

Laboratory Safety and Environmental Health Assessment Program

Laboratory Safety and Environmental Health Assessment Program Laboratory Safety and Environmental Health Assessment Program Principal Investigators and Faculty are vital to the success of safety and environmental compliance programs in Colorado School of Mines research

More information

Hazardous Waste Management Document No. LAB

Hazardous Waste Management Document No. LAB Hazardous Waste Management 1. INTENT This Standard Operating Procedure (SOP) applies to all faculty, staff and students at Wilfrid Laurier University. It was developed by the Environmental/Occupational

More information

Ventilation of Dangerous Goods Chemical Storage Cabinets.

Ventilation of Dangerous Goods Chemical Storage Cabinets. Doc Ref: PPD 04.16 Release Date: 24 January 2013 Ventilation of Dangerous Goods Chemical Storage Cabinets. Information and Guidelines. The various Australian Standards for The Storage and Handling of Chemicals

More information

HAZARDOUS SUBSTANCES AUDIT CHECKLIST

HAZARDOUS SUBSTANCES AUDIT CHECKLIST Not all sections will be applicable to all laboratories and workplaces in the Division of ICS. Answering no to any of the questions indicates a need for corrective action to be identified and undertaken.

More information

Hazardous Waste Procedures. Faculty of Science University of Ottawa

Hazardous Waste Procedures. Faculty of Science University of Ottawa Hazardous Waste Procedures University of Ottawa Contents Hazardous Materials Waste Overview:... 3 Regulations:... 3 General requirements related to packaging waste:... 4 Table 1: List of Appropriate Waste

More information

WHMIS. ...your right to know. Workplace Hazardous Materials Information System

WHMIS. ...your right to know. Workplace Hazardous Materials Information System WHMIS...your right to know. Workplace Hazardous Materials Information System Disclaimer of Liability: With respect to documents and training available from this server, Dunk and Associates nor any of its

More information

FDNY C14 Certificate of Fitness Quiz

FDNY C14 Certificate of Fitness Quiz FDNY C14 Certificate of Fitness Quiz Name: Date: 1. Who issues a New York City laboratory permit? a) Department of Environmental Protection (DEP) b) Department of Environmental Conservation (DEC) c) Occupational

More information

Oxidizer(s) Management and Use Guidelines

Oxidizer(s) Management and Use Guidelines Facilities and Campus Services EHS/RMS 3101 Science Circle CPISB Room 102B Anchorage, AK 99508 Oxidizer(s) Management and Use Guidelines This document provides information concerning the handling, storage,

More information

Hazardous Materials Move Guide. Transportation Procedures for Chemical and Biological Materials

Hazardous Materials Move Guide. Transportation Procedures for Chemical and Biological Materials Hazardous Materials Move Guide Transportation Procedures for Chemical and Biological Materials April 2015 SECTION 1 Introduction This Guide has been developed as a supplement to the Indiana University

More information

Safe Storage of Hazardous Chemicals

Safe Storage of Hazardous Chemicals 1. PURPOSE: To provide a guideline on the safe storage requirements of hazardous chemicals in the VCU community. 2. SCOPE/APPLICABILITY: This guideline is applicable to all users of hazardous chemicals

More information

N/A = Not Applicable in your workspace. Yes = No violation of the code listed. Comments = Any Comments you would like us to take into consideration.

N/A = Not Applicable in your workspace. Yes = No violation of the code listed. Comments = Any Comments you would like us to take into consideration. Date: Conducted By: Bldg: Room: Dept: Room Supervisor (PI if applicable): Safety and Risk Management recommends that an official Self-Inspection is conducted Annually for each space. SRM also recommends

More information

TARLETON STATE UNIVERSITY HAZARD COMMUNICATION PROGRAM

TARLETON STATE UNIVERSITY HAZARD COMMUNICATION PROGRAM TARLETON STATE UNIVERSITY HAZARD COMMUNICATION PROGRAM Office of Risk Management and Safety August 2009 1. GENERAL The 69 th Legislature of the State of Texas, in 1985, enacted the Texas Hazard Communication

More information

Potassium Nitrate Prilled Fertiliser Recommended Fertiliser

Potassium Nitrate Prilled Fertiliser Recommended Fertiliser 1. IDENTIFICATION OF THE SUBSTANCE / MIXTURE AND SUPPLIER Product name: Potassium Nitrate Prilled Fertiliser Recommended Fertiliser use: Supplier: Campbells Fertilisers Australasia Address: 18 Raymond

More information

Waste Management Log Book

Waste Management Log Book Waste Management Log Book Web address: www.ehs.psu.edu Designated Accumulation Area: Building & Room Number Location in Room Supervisor: E-mail Individual designated to ensure procedures are followed:

More information

Safe Storage of Hazardous Substances

Safe Storage of Hazardous Substances Safe Storage of Hazardous Substances Introduction Improper storage of hazardous substances may create serious risk, not only to University staff and students, but also to emergency services personnel,

More information

GEORGIA INSTITUTE OF TECHNOLOGY ENVIRONMENTAL HEALTH AND SAFETY PERSONAL PROTECTIVE EQUIPMENT

GEORGIA INSTITUTE OF TECHNOLOGY ENVIRONMENTAL HEALTH AND SAFETY PERSONAL PROTECTIVE EQUIPMENT PURPOSE To protect the health and welfare of GEORGIA TECH employees in areas where there may be a risk of injury or exposure to hazardous substances or conditions employees who work in areas where physical

More information

Color Coded Labeling System for Storing Chemicals in your Laboratory

Color Coded Labeling System for Storing Chemicals in your Laboratory Color Coded Labeling System for Storing Chemicals in your Laboratory Hazard Color Code Company Storage Flammables Red Store in flammable storage cabinet or flammable storage area. Separate flammable solids

More information

CHEMICAL SPILL MANAGEMENT GUIDELINES

CHEMICAL SPILL MANAGEMENT GUIDELINES WHS Unit CHEMICAL SPILL MANAGEMENT GUIDELINES Contents 1 Purpose... 2 2 Scope... 2 3 Definitions... 2 4 Roles and Responsibilities... 2 5 General... 2 6 Defining Major or Minor Spill... 3 7 Major Spill

More information

WHMIS Test and Answer Key. Choose the correct "class" for the following symbol:

WHMIS Test and Answer Key. Choose the correct class for the following symbol: Question 1 a) Dangerously Reactive Materials b) Corrosive Materials c) Flammable / Combustible Materials d) Oxidizing Materials Question 2 WHMIS "hazard symbols" are easily identifiable due to their shape.

More information

Laboratory Safety Inspection Checklist

Laboratory Safety Inspection Checklist Laboratory Safety Inspection Checklist Conducted By: Date of Inspection: Location: Principal Investigator/Supervisor: General Lab Housekeeping A M S NO NA Comments Laboratory surfaces appear to be cleaned;

More information

Safety Inspection Checklist

Safety Inspection Checklist Inspector(s): Building: Room Number (s): Department/Unit: Date Inspected: Supervisor: To customize your local inspection checklist, delete or add as required. Inspection Headings: 1. Administrative 8.

More information

Mechanical Systems Competency 1.20

Mechanical Systems Competency 1.20 Competency 1.20 Mechanical systems personnel shall demonstrate a working level knowledge of the safety and health fundamentals of mechanical systems and/or components. 1. Supporting Knowledge and Skills

More information

ST. CLOUD TECHNICAL AND COMMUNITY COLLEGE HAZARDOUS WASTE PROCEDURE

ST. CLOUD TECHNICAL AND COMMUNITY COLLEGE HAZARDOUS WASTE PROCEDURE APPLICABILITY This procedure is applicable to all St. Cloud Technical & Community College faculty, staff and students. GENERAL Federal, state and local governments impose strict regulations concerning

More information

ALUMINUM METAL (WIRE, FOIL, SHOT)

ALUMINUM METAL (WIRE, FOIL, SHOT) MSDS Number: A2705 * * * * * Effective Date: 02/03/09 * * * * * Supercedes: 05/17/07 1. Product Identification ALUMINUM METAL (WIRE, FOIL, SHOT) Synonyms: Aluminum wire; Aluminum foil; Aluminum shot; Aluminum

More information

Material Safety Data Sheet

Material Safety Data Sheet 1 1 0 Material Safety Data Sheet Magnesium Amino Acid Chelate MSDS He a lt h Fire Re a c t iv it y Pe rs o n a l Pro t e c t io n 1 1 0 E Section 1: Chemical Product and Company Identification Product

More information

EL DORADO UNION HIGH SCHOOL DISTRICT ADMINISTRATIVE REGULATION. Operations AR

EL DORADO UNION HIGH SCHOOL DISTRICT ADMINISTRATIVE REGULATION. Operations AR EL DORADO UNION HIGH SCHOOL DISTRICT ADMINISTRATIVE REGULATION Business and Noninstructional HAZARDOUS SUBSTANCES Operations AR 3514.1 Cautionary Notice 2010-13: AB 1610 (Ch. 724, Statutes of 2010) amended

More information

SECTION FC 2706 NON-PRODUCTION CHEMICAL LABORATORIES

SECTION FC 2706 NON-PRODUCTION CHEMICAL LABORATORIES New York City Administrative Code - Title 29 New York City Fire Code SECTION FC 2706 NON-PRODUCTION CHEMICAL LABORATORIES 2706.1 Scope. This section shall govern the storage, handling and use of laboratory

More information

Laboratory Safety Inspection Checklist (Biology and Biochemistry)

Laboratory Safety Inspection Checklist (Biology and Biochemistry) EOSMS 201-1A Date: 11/15/14 Page 1 of 9 Building Room Inspection Date Department Principal Investigator(s) Inspector(s) Instructions: This form is to be completed for laboratory self-inspection. Complete

More information

Queen's University Environmental Health and Safety

Queen's University Environmental Health and Safety April, 2009 1 SOP-Chem-08 1.0 Introduction This document is intended as a guide to the Queen s University requirements for handling and storing flammable and combustible material in non-laboratories areas.

More information

Princeton University Lab Specific Safety Training

Princeton University Lab Specific Safety Training Princeton University Lab Specific Safety Training Per University policy, all individuals conducting work in Princeton University laboratories, paid or unpaid, including faculty, staff, students and visitors,

More information

Procedure 7: Warning Signs and Labels

Procedure 7: Warning Signs and Labels Procedure 7: Warning Signs and Labels General Considerations 1. A copy of the poster Radioisotope Safety Basic Laboratories or Radioisotope Safety Intermediate Laboratories, as appropriate, shall be posted

More information

Guidance. for. Purchasing, Storage & Disposal of Hazardous Substances

Guidance. for. Purchasing, Storage & Disposal of Hazardous Substances Health & Safety, Edinburgh Napier University Guidance for Purchasing, Storage & Disposal of Hazardous Substances v1 February 2007 Edinburgh Napier University, Health & Safety Team, Sighthill Campus, Edinburgh

More information

FLAMMABLE LIQUIDS COMPLIANCE NOTE

FLAMMABLE LIQUIDS COMPLIANCE NOTE Issued by: Heather Rice Page: 1 of 7 COMPLIANCE NOTE INTRODUCTION This document provides additional guidance to support the Arrangement on Flammable Liquids (Ref No. CYC/HS/A27) CONTENTS Section Topic

More information

UNH SAFETY AUDIT Office of Environmental Health and Safety

UNH SAFETY AUDIT Office of Environmental Health and Safety UNH SAFETY AUDIT Office of Environmental Health and Safety Administrative Information Customized for each location. Ensure contact information on door caution signs is up to date. Doors YES NO N/A 1. The

More information

HAZARDS RATE HAZARD NOTES/COMMENTS: EXTERIOR / PARKING LOT

HAZARDS RATE HAZARD NOTES/COMMENTS: EXTERIOR / PARKING LOT MONTHLY INSPECTION REPORT Date of Inspection: Persons Participating in Inspection: Are all parking spots and walkways well lit at night? Are parking spots safe? Are employees encouraged to use a buddy

More information

Any other time call the SFASU Police at Emergencies 911 Non-emergencies 468-2608

Any other time call the SFASU Police at Emergencies 911 Non-emergencies 468-2608 Emergency Response to Waste Spills There are numerous different chemical, biological, and radioactive hazardous materials used throughout Stephen F. Austin State University on a daily basis. These chemicals

More information

Environmental Health & Safety Policy Manual

Environmental Health & Safety Policy Manual Environmental Health & Safety Policy Manual Issue Date: 04/09/2010 Policy # EHS-200.05 Chemical Ordering and Storage Procedures 1.0 PURPOSE: The improper storage and handling of chemicals can result in

More information

LABORATORY SPECIFIC SAFETY TRAINING

LABORATORY SPECIFIC SAFETY TRAINING LABORATORY SPECIFIC SAFETY TRAINING Principal Investigators/Laboratory supervisors shall ensure that all workers in their laboratories receive health & safety training specific to the hazards present in

More information

NFPA HMIS PPE Transport Symbol. Issuing Date 21-Aug-2006 Revision Date NOT AUTHORIZED Revision Number NOT AUTHORIZED

NFPA HMIS PPE Transport Symbol. Issuing Date 21-Aug-2006 Revision Date NOT AUTHORIZED Revision Number NOT AUTHORIZED Material Safety Data Sheet # 310 Hercules Chemical Company Inc. 111 South Street Passaic NJ 07055-7398 Information Telephone: 1-800 221-9330 Internet: www.herchem.com NFPA HMIS PPE Transport Symbol Issuing

More information

Environmental Release Prevention, Control & Reporting Standard

Environmental Release Prevention, Control & Reporting Standard Environmental Release Prevention, Control & Reporting Standard Section: SCOPE This standard applies to all research, teaching, operational activities and persons handling, transporting, using, disposing

More information

JOINT HEALTH & SC AND INTERNAL RESPONSIBILITY SYSTEM. Location Frequency What to Inspect

JOINT HEALTH & SC AND INTERNAL RESPONSIBILITY SYSTEM. Location Frequency What to Inspect Section: Policy # MI\LS\35\v02 Page 1 of 6 Subject Title: Workplace Health and Safety Inspection Procedures Issued by: LABORATORY MANAGER Original Date: April 20, 2001 Approved by: Laboratory Director

More information

Dangerous Goods Guidelines

Dangerous Goods Guidelines Dangerous Goods Guidelines 1. Recommended Compliance Procedure 2. Types of Dangerous Goods 3. ChemWatch 4. Labelling 5. Statutory Quantities 6. Laboratory Quantities (AS 2243.10) 7. Hierarchy of Controls

More information

Chapter 13: Compressed Gas Safety

Chapter 13: Compressed Gas Safety Chapter 13: Compressed Gas Safety Guidelines for Compressed Gas Cylinders The University of Illinois at Chicago (UIC) wants to ensure the safety of employees who handle compressed gases on campus. In order

More information

Chemical storage guidance

Chemical storage guidance Document control information Chemical storage guidance Published document name: chem-storage-gn.pdf Date issued: November 2015 Version: 2.3 Previous review dates: 2010 Next review date: January 2019 Related

More information

Hazardous Substances and Dangerous Goods Procedures

Hazardous Substances and Dangerous Goods Procedures Hazardous Substances and Dangerous Goods Procedures 1. Preamble 1.1 Western Sydney University acknowledges its responsibility to identify, evaluate and control the risks associated with the handling and

More information

Decommissioning of Laboratory Space Prior To Relocation, Demolition or Renovation

Decommissioning of Laboratory Space Prior To Relocation, Demolition or Renovation Decommissioning of Laboratory Space Prior To Relocation, Demolition or Renovation Document Number: EHS Effective Date: 3-1-2005 Revision Date: 12-28- 2011 1.0 Purpose and Applicability 1.1 The purpose

More information

Wide range of chemicals are used in research laboratories of the Institute, each with its own inherent hazards.

Wide range of chemicals are used in research laboratories of the Institute, each with its own inherent hazards. CHEMICAL SAFETY Introduction Wide range of chemicals are used in research laboratories of the Institute, each with its own inherent hazards. An understanding of the potential hazards and precautions required

More information

Using ChemTracker with Life Safety Boxes

Using ChemTracker with Life Safety Boxes Using ChemTracker with Life Safety Boxes Overview ChemTracker produces reports used as part of a Life Safety Box (LSB) program intended to quickly provide detailed hazardous materials information to emergency

More information

Standard Operating Procedures for Hazardous Chemicals

Standard Operating Procedures for Hazardous Chemicals Standard Operating Procedures for Hazardous Chemicals Title of Procedure: Nitric Acid Dilutions for Flame AA Date: 3/29/2012 Date of Last Review: Principal Investigator: Benny Freeman Lab Location: PRC

More information

SPILL RESPONSE PROCEDURE

SPILL RESPONSE PROCEDURE SPILL RESPONSE PROCEDURE Queen's University Spill Response Procedure May 2000 1 SOP-HAZMAT-01 1.0 Preamble This document outlines emergency spill response procedures as part of the overall Queen's University

More information

Yale Environmental Health & Safety. Pyrophoric. Handling Policy

Yale Environmental Health & Safety. Pyrophoric. Handling Policy Pyrophoric Yale Environmental Health & Safety Handling Policy Yale Environmental Health & Safety 135 College Street, Suite 100 New Haven, CT 06510 T 203-785-3550 / F 203-785-7588 www.yale.edu/ehs TABLE

More information

The Storage of Flammable Liquids in School Laboratories

The Storage of Flammable Liquids in School Laboratories The Storage of Flammable Liquids in School Laboratories From June 1993 issue of Crucible Volume 24.3 INTRODUCTION This article provides some recommendations for: storing flammable liquids; the quantities

More information

University of Tennessee Safety Guidelines

University of Tennessee Safety Guidelines University of Tennessee Safety Guidelines Guideline Subject: Compressed Gases and Cryogenics Safety Guidelines Approval Date: 10/1/15 (Rev. 1) Next Scheduled Review: 10/1/19 Date Effective: 1/01/09 Contact

More information

Hazardous Waste Management & Waste Minimization Training

Hazardous Waste Management & Waste Minimization Training Hazardous Waste Management & Waste Minimization Training Environmental Health and Safety Safety Training Building Inspections Accident Investigations Fire Safety Hazardous Materials Management Laboratory

More information

Material Safety Data Sheet

Material Safety Data Sheet Material Safety Data Sheet Aloe Vera MSDS 0 Section : Chemical Product and Company Identification He a lt h Fire Re a c t iv it y Pe rs o n a l Pro t e c t io n 0 A Product Name: Aloe Vera Catalog Codes:

More information

RESPIRATORY PROTECTION PROGRAM

RESPIRATORY PROTECTION PROGRAM RESPIRATORY PROTECTION PROGRAM OFFICE of ENVIRONMENTAL HEALTH & SAFETY Campus Location: Physical Plant 521 S. Razorback Road Telephone: 479 575 5448 Web site: http://www.phpl.uark.edu Applies to all UofA

More information

Embedded Battery Safety

Embedded Battery Safety Battery Handling and Safety Handle the battery or top case assembly with battery by the edges, with two hands at all times. Do not lift or hold the battery or top case assembly with battery using the cable

More information

Proper chemical storage is required to minimize the hazards associated leaks, spills, and accidental mixing of incompatible chemicals.

Proper chemical storage is required to minimize the hazards associated leaks, spills, and accidental mixing of incompatible chemicals. CHEMICAL STORAGE Proper chemical storage is required to minimize the hazards associated leaks, spills, and accidental mixing of incompatible chemicals. General Storage Guidelines Observe the following

More information

Safety Data Sheet. Product #: 300178. Aspira Scientific 521 Cottonwood Dr. Milpitas, CA 95035 408.571.1100 techsupport@aspirasci.com www.aspirasci.

Safety Data Sheet. Product #: 300178. Aspira Scientific 521 Cottonwood Dr. Milpitas, CA 95035 408.571.1100 techsupport@aspirasci.com www.aspirasci. Safety Data Sheet Aspira Scientific 521 Cottonwood Dr. Milpitas, CA 95035 408.571.1100 techsupport@aspirasci.com www.aspirasci.com Section 1: Product Identification Product Identifiers Product Name: L-

More information

Combustible liquid: Any liquid having a flashpoint at or above 100 F (e.g. kerosene, fuel oil)

Combustible liquid: Any liquid having a flashpoint at or above 100 F (e.g. kerosene, fuel oil) HOSPITAL NAME INSTITUTIONAL POLICY AND PROCEDURE (IPP) Department: Manual: Section: TITLE/DESCRIPTION POLICY NUMBER Handling of Flammable Material EFFECTIVE DATE REVIEW DUE REPLACES NUMBER NO. OF PAGES

More information

CHEMICAL SAFETY TRAINING STUDENT WORKBOOK. Chemical Safety Training Student Workbook 1

CHEMICAL SAFETY TRAINING STUDENT WORKBOOK. Chemical Safety Training Student Workbook 1 CHEMICAL SAFETY TRAINING STUDENT WORKBOOK Chemical Safety Training Student Workbook 1 TABLE OF CONTENTS CHEMICAL SAFETY TRAINING Chemical Safety Training Student Workbook 2 PROGRAM OVERVIEW Welcome to

More information

CHECKLIST FERTILIZER STORAGE. Store fertilizers separate from other chemicals in dry conditions.

CHECKLIST FERTILIZER STORAGE. Store fertilizers separate from other chemicals in dry conditions. CHECKLIST FERTILIZER STORAGE Store fertilizers separate from other chemicals in dry conditions. Extra care needs to be given to concentrate stock solutions. Secondary containment should be used. Provide

More information

ALVERNIA UNIVERSITY OSHA REGULATION: 29 CFR 1910.1200 HAZARD COMMUNICATION SECTION: 1700 REVISION DATE: 2/3/2012 REVISION: 4 NUMBER:

ALVERNIA UNIVERSITY OSHA REGULATION: 29 CFR 1910.1200 HAZARD COMMUNICATION SECTION: 1700 REVISION DATE: 2/3/2012 REVISION: 4 NUMBER: OSHA REGULATION: 29 CFR 90.200 HAZARD COMMUNICATION 700 : DATE: /3/200 DATE: 2/3/202 A. POLICY. This procedure follows requirements set forth in 29 CFR 90.200. 2. It is the policy of Alvernia University

More information

Wolfson Campus Natural Science Department. Chemical Laboratory. What did I spill? Student Safety Contract

Wolfson Campus Natural Science Department. Chemical Laboratory. What did I spill? Student Safety Contract Wolfson Campus Natural Science Department Chemical Laboratory What did I spill? Student Safety Contract April 2000 Wolfson Campus Student Safety Contract-Chemistry Laboratory The Chemistry Laboratory courses

More information

ADMINISTRATIVE SERVICES MANUAL

ADMINISTRATIVE SERVICES MANUAL Purpose Responsibilities Proper Storage and use of flammable liquids can significantly reduce the possibility of accidental fires and injuries. To minimize risk to life and properly, the requirements of

More information

INCOMPATIBILITY OF COMMON LABORATORY CHEMICALS

INCOMPATIBILITY OF COMMON LABORATORY CHEMICALS INCOMPATIBILITY OF COMMON LABORATORY CHEMICALS When certain hazardous chemicals are stored or mixed together, violent reactions may occur because the chemicals are unsuitable for mixing, or are incompatible.

More information

Palm Beach State College Florida s First Public Community College CHEMICAL SPILL RESPONSE PLAN

Palm Beach State College Florida s First Public Community College CHEMICAL SPILL RESPONSE PLAN Palm Beach State College Florida s First Public Community College CHEMICAL SPILL RESPONSE PLAN PALM BEACH STATE COLLEGE CHEMICAL SPILL RESPONSE PLAN 1. Introduction Despite the best efforts of faculty

More information

Chapter 4: HAZARD COMMUNICATION: Signs, Labels, Material Safety Data Sheets, Safety Data Sheets

Chapter 4: HAZARD COMMUNICATION: Signs, Labels, Material Safety Data Sheets, Safety Data Sheets Chapter 4: HAZARD COMMUNICATION: Signs, Labels, Material Safety Data Sheets, Safety Data Sheets Signs All employees must be alerted to hazards in an area. The employer shall post signs at prominent locations,

More information

Safety Data Sheet. Nitrate Standard, 3 ppm NO₃ R A, R A. Company: Ricca Chemical Company

Safety Data Sheet. Nitrate Standard, 3 ppm NO₃ R A, R A. Company: Ricca Chemical Company SECTION 1: Identification 1.1. Product Identifier Trade Name or Designation: Nitrate Standard, 3 ppm NO₃ Product Number: R5307003 Other Identifying Product Numbers: R5307003-100A, R5307003-500A 1.2. Recommended

More information

North Carolina State University Emergency Facilities Closure Checklist- Part I

North Carolina State University Emergency Facilities Closure Checklist- Part I North Carolina State University Emergency Facilities Closure Checklist- Part I Unplanned or spontaneous events often disrupt daily operations on campus. In the event that an incident may interrupt your

More information