Caddy Fitting Locations No. 802 / 1 Edition Position of fuses engine compartment Overview of fuse carrier in engine compartment
|
|
- Lorraine Logan
- 7 years ago
- Views:
Transcription
1 Caddy Fitting Locations No. 802 / 1 Edition Position of fuses engine compartment Overview of fuse carrier in engine compartment 1 - Fuses on fuse holder A -SAt Location, from October 2003 chapter t Position of fuses, from October 2003 chapter t Location, from May 2005 chapter t Position of fuses, from May 2005 chapter t Position of fuses, from November 2006 chapter t Position of fuses, from May 2007 chapter t Position of fuses, from November 2007 chapter t Position of fuses, from May 2008 chapter t Position of fuses, from November 2008 chapter
2 2 - Fuses on fuse holder B -SBt Location, from October 2003 chapter t Position of fuses, from October 2003 chapter t Location, from May 2005 chapter t Position of fuses, from May 2005 chapter t Position of fuses, from November 2006 chapter t Position of fuses, from May 2007 chapter < t Position of fuses, from November 2007 chapter t Position of fuses, from May 2008 chapter t Position of fuses, from May 2009 chapter Fuses on fuse holder A -SA-, from October 2003 Torque settings Electrical system, repair Group 97, removing and installing fuse holders Fuse colours
3 A - green 25 A - white 20 A - yellow A - blue 10 A - red 7,5 A - brown 5 A - beige 3 A - purple Position of fuses on fuse holder A -SA-, from October 2003 No. Current Flow Diagram designation 1 - Fuse 1 on fuse holder A -SA1- Nominal value 0 A 200 A Function/component - Alternator -C- 90A / 110A - Alternator -C- 140A Terminal
4 2 - Fuse 2 on fuse holder A -SA2-3 - Fuse 3 on fuse holder A -SA3-4 - Fuse 4 on fuse holder A -SA4-5 - Fuse 5 on fuse holder A -SA5-6 - Fuse 6 on fuse holder A -SA6-7 - Fuse 7 on fuse holder A -SA7-80 A - Electromechanical power steering motor - V A - Radiator fan control unit -J A - Onboard supply control unit -J Vacant 100 A - Fuses on fuse holder C -SC- left dash panel SC20 - SC24, SC42 - SC56 50 A - Fuses on fuse holder C -SC- left dash panel SC39 - SC41 Fuses on fuse holder A -SA-, from May 2005 Torque settings Electrical system, repair Group 97, removing and installing fuse holders Position of fuses on fuse holder A -SA-, from May 2005
5 No. Current Flow Diagram designation 1 - Fuse 1 on fuse holder A - SA1-1 - Fuse 1 on fuse holder A - SA1-2 - Fuse 2 on fuse holder A - SA2- Nominal Function/component Terminal value 0 A - Alternator -C- 200 A - Alternator -C- 1) 80 A - Power steering control unit -J500- Electromechanical power steering motor -V A - Radiator fan control unit -J Fuse 3 on fuse holder A - SA3-3 - Fuse 3 on fuse holder A - 80 A - Radiator fan control unit -J293-2) SA3-4 - Fuse 4 on fuse holder A - 50 A - X-contact relief relay -J59-3) SA4- Onboard supply control unit -J519-3) 4 - Fuse 4 on fuse holder A - 80 A - X-contact relief relay -J59-4)
6 SA4- Onboard supply control unit -J519-4) 5 - Fuse 5 on fuse holder A Vacant - SA5-6 - Fuse 6 on fuse holder A - SA6-100 A - Fuse SC20 up to SC24 on fuse holder C -SC- Fuse SC42 up to SC48 on fuse holder C -SC- Fuse SC50 up to SC52 on fuse holder C 7 - Fuse 7 on fuse holder A - SA7- -SC- 50 A - Fuse SC39 up to SC41 on fuse holder C -SC- 5) Note t 1) only models with 140 A alternator t 2) only for models with increased blower output t 3) only models with central locking t 4) only models without central lock t 5) only models with trailer operation Position of fuses on fuse holder A -SA-, from November 2006
7 No. Current Flow Diagram designation 1 - Fuse 1 on fuse holder A - SA1-1 - Fuse 1 on fuse holder A - SA1-2 - Fuse 2 on fuse holder A - SA2- Nominal Function/component Terminal value 0 A - Alternator -C- 200 A - Alternator -C- 1) 80 A - Power steering control unit -J500- Electromechanical power steering motor -V A - Radiator fan control unit -J Fuse 3 on fuse holder A - SA3-3 - Fuse 3 on fuse holder A - 80 A - Radiator fan control unit -J293-2) SA3-4 - Fuse 4 on fuse holder A - 50 A - X-contact relief relay -J59-3) SA4- Onboard supply control unit -J519-3) 4 - Fuse 4 on fuse holder A - 80 A - X-contact relief relay -J59-4)
8 SA4- Onboard supply control unit -J519-4) 5 - Fuse 5 on fuse holder A A ---Fuse SC20 up to SC24 on fuse holder SA5- C -SC- Fuse SC42 up to SC48 on fuse holder C -SC- Fuse SC50 up to SC52 on fuse holder C -SC- 6 - Fuse 6 on fuse holder A Vacant - SA6-7 - Fuse 7 on fuse holder A - SA7-50 A - Fuse SC39 up to SC41 on fuse holder C -SC- 5) Note t 1) only models with 140 A alternator t 2) only for models with increased blower output t 3) only models with central locking t 4) only models without central lock t 5) only models with trailer operation
9 Position of fuses on fuse holder A -SA-, from May 2007 No. Current Flow Diagram designation 1 - Fuse 1 on fuse holder A - SA1-1 - Fuse 1 on fuse holder A - SA1-2 - Fuse 2 on fuse holder A - SA2-3 - Fuse 3 on fuse holder A - SA3-3 - Fuse 3 on fuse holder A - SA3- Nominal Function/component Terminal value 0 A - Alternator -C- 200 A - Alternator -C- 1) 80 A - Power steering control unit -J Electromechanical power steering motor -V A - Radiator fan control unit -J A - Radiator fan control unit -J293-2)
10 4 - Fuse 4 on fuse holder A - SA4-4 - Fuse 4 on fuse holder A - SA4-5 - Fuse 5 on fuse holder A - SA5-6 - Fuse 6 on fuse holder A - SA6-7 - Fuse 7 on fuse holder A - SA7-50 A - X-contact relief relay -J59-3) - Onboard supply control unit -J519-3) 80 A - X-contact relief relay -J59-4) - Onboard supply control unit -J519-4) 100 A -- Fuse SC20 up to SC24 on fuse holder C -SC- Fuse SC42 up to SC53 on fuse holder C -SC- - - Vacant - 50 A - Fuse SC39 up to SC41 on fuse holder C -SC- 5) Note t 1) only models with 140 A alternator t 2) only for models with increased blower output t 3) only models with central locking t 4) only models without central lock t 5) only models with trailer operation
11 Position of fuses on fuse holder A -SA-, from September 2007 No. Current Flow Diagram designation 1 - Fuse 1 on fuse holder A - SA1-1 - Fuse 1 on fuse holder A - SA1-2 - Fuse 2 on fuse holder A - SA2-3 - Fuse 3 on fuse holder A - SA3-3 - Fuse 3 on fuse holder A - SA3- Nominal Function/component Terminal value 0 A - Alternator -C- 200 A - Alternator -C- 1) 80 A - Power steering control unit -J Electromechanical power steering motor -V A - Radiator fan control unit -J A - Radiator fan control unit -J293-2)
12 4 - Fuse 4 on fuse holder A - SA4-4 - Fuse 4 on fuse holder A - SA4-5 - Fuse 5 on fuse holder A - SA5-6 - Fuse 6 on fuse holder A - SA6-7 - Fuse 7 on fuse holder A - SA7-50 A - X-contact relief relay -J59-3) - Onboard supply control unit -J519-3) 80 A - X-contact relief relay -J59-4) - Onboard supply control unit -J519-4) 100 A -- Fuse SC20 up to SC24 on fuse holder C -SC- Fuse SC42 up to SC53 on fuse holder C -SC- 100 A - Auxiliary heater element -Z35-50 A - Fuse SC39 up to SC41 on fuse holder C -SC- 5) Note t 1) only models with 140 A alternator t 2) only for models with increased blower output t 3) only models with central locking t 4) only models without central lock t 5) only models with trailer operation
13 Position of fuses on fuse holder A -SA-, from May 2008 No. Current Flow Diagram designation 1 - Fuse 1 on fuse holder A -SA1-1 - Fuse 1 on fuse holder A -SA1-2 - Fuse 2 on fuse holder A -SA2-3 - Fuse 3 on fuse holder A -SA3-4 - Fuse 4 on fuse holder A -SA4- Nominal Function/component Terminal value 0 A - Alternator -C- 200 A - Alternator -C- 1) 80 A - Power steering control unit -J Electromechanical power steering motor - V A - Radiator fan thermal switch -F18- Radiator fan control unit -J293-5) 50 A - X-contact relief relay -J59-3) Onboard supply control unit -J519-3)
14 4 - Fuse 4 on fuse holder A -SA4-5 - Fuse 5 on fuse holder A -SA5-6 - Fuse 6 on fuse holder A -SA6-7 - Fuse 7 on fuse holder A -SA7-80 A - X-contact relief relay -J59-4) - Onboard supply control unit -J519-4) 100 A - Fuse SC20 up to SC24 on fuse holder C -SC- - Fuse SC42 up to SC52 on fuse holder C -SC- (applicable up to May 2009) Fuse SC43 up to SC53 on fuse holder C -SC- (applicable from May 2009) 50 A - Low heat output relay -J359-2) 100 A - High heat output relay -J360-2) Note t 1) only models with 140 A alternator t 2) only models with auxiliary air heater t 3) only models with central locking t 4) only models without central lock t 5) only models with variable radiator fan
15 Position of fuses on fuse holder A -SA-, from November 2008 No. Current Flow Diagram designation 1 - Fuse 1 on fuse holder A -SA1-1 - Fuse 1 on fuse holder A -SA1-2 - Fuse 2 on fuse holder A -SA2-3 - Fuse 3 on fuse holder A -SA3-4 - Fuse 4 on fuse holder A -SA4- Nominal Function/component Terminal value 0 A - Alternator -C- 200 A - Alternator -C- 1) 80 A - Power steering control unit -J500- Electromechanical power steering motor - V A - Radiator fan thermal switch -F18- Radiator fan control unit -J293-3) 80 A - X-contact relief relay -J59- Onboard supply control unit -J519-
16 5 - Fuse 5 on fuse holder A -SA5-6 - Fuse 6 on fuse holder A -SA6-7 - Fuse 7 on fuse holder A -SA7-80 A - Fuse SC20 up to SC24 on fuse holder C -SC- Fuse SC42 up to SC52 on fuse holder C -SC- (applicable up to May 2009) Fuse SC43 up to SC53 on fuse holder C -SC- (applicable from May 2009) 40 A - Low heat output relay -J359-2) 80 A - High heat output relay -J360-2) Note t 1) only models with 140 A alternator t 2) only models with auxiliary air heater t 3) only models with variable radiator fan Fuse holder B -SB- on electronics box, on left of engine compartment, from November 2003 Fuse colours
17 A - green 25 A - white 20 A - yellow A - blue 10 A - red 7,5 A - brown 5 A - beige 3 A - purple Fuse locations on fuse holder B -SB-, from October 2003 No. Current Flow Diagram designation 1 - Fuse 1 on fuse holder B -SB1-2 - Fuse 2 on fuse holder B -SB2-3 - Fuse 3 on fuse holder B -SB3-4 - Fuse 4 on fuse holder B -SB4-5 - Fuse 5 on fuse holder B -SB5-6 - Fuse 6 on fuse holder B -SB6-7 - Fuse 7 on fuse holder B -SB7-8 - Fuse 8 on fuse holder B -SB8- Nominal value Function/component Terminal A - ABS control unit -J104- A - ABS control unit -J Vacant 5 A - Onboard supply control unit -J A ---Treble tone horn -H2- Bass tone horn -H7- Dual tone horn relay -J4-20 A A - - Ignition coil 1 with output stage -N70- Ignition coil 2 with output stage -N127- Ignition coil 3 with output stage -N291- Ignition coil 4 with output stage -N292- Ignition transformer -N2- Brake pedal switch -F47- J... - Engine control units Clutch position sender -G A - Exhaust gas recirculation valve -N Activated charcoal filter system solenoid valve 1 - N80- Radiator fan control unit -J293- Intake manifold flap motor -V A - Fuel pump relay -J17- (BDJ, BJB) Fuse 9 on fuse holder B -SB Fuse 10 on fuse 10 A - Exhaust gas recirculation valve -N18-87
18 holder B -SB Fuse 11 on fuse holder B -SB Fuse 12 on fuse holder B -SB Fuse 13 on fuse holder B -SB Fuse 14 on fuse holder B -SB14- - Fuse on fuse holder B -SB Fuse 16 on fuse holder B -SB Fuse 17 on fuse holder B -SB Fuse 18 on fuse holder B -SB Fuse 19 on fuse holder B -SB Fuse 20 on fuse holder B -SB Fuse 21 on fuse holder B -SB Fuse 22 on fuse holder B -SB Fuse 23 on fuse holder B -SB Fuse 24 on fuse holder B -SB Fuse 25 on fuse holder B -SB Fuse 26 on fuse holder B -SB26-25 A A -- Altitude correction solenoid valve -N78- Exhaust gas recirculation cooler change-over valve -N A - - Motronic control unit -J220- (BCA, BGU) Diesel direct injection system control unit -J248- (BDJ, BJB) Lambda probe -G39- (BCA) Lambda probe after catalytic converter -G1- (BCA) - - Vacant - - Vacant 40 A - Starter -B- (Terminal 50) 50 A - Steering column electronics control unit -J A - Control unit in dash panel insert -J Vacant A -- Radio -R- Control unit with display for radio and navigation system -J A - Mobile telephone operating electronics control unit -J Vacant - - Vacant - - Vacant 10 A - Data bus diagnostic interface -J Vacant 10 A 5 A - - Motronic control unit -J220- (BCA) Terminal voltage supply relay -J317- (BCA, BDJ, BJB ) 27 - Fuse 27 on fuse 10 A - Heater element for crankcase breather -N79- holder B -SB Fuse 28 on fuse - - Vacant holder B -SB Fuse 29 on fuse 20 A - Injector, cylinder 1 -N- (BCA) 87 87
19 holder B -SB29- - Fuse on fuse holder B -SB Fuse 31 on fuse holder B -SB Fuse 32 on fuse holder B -SB Fuse 33 on fuse holder B -SB Fuse 34 on fuse holder B -SB Fuse 35 on fuse holder B -SB Fuse 36 on fuse holder B -SB Fuse 37 on fuse holder B -SB Fuse 38 on fuse holder B -SB Fuse 39 on fuse holder B -SB Fuse 40 on fuse holder B -SB Fuse 41 on fuse holder B -SB Fuse 42 on fuse holder B -SB Fuse 43 on fuse holder B -SB Fuse 44 on fuse holder B -SB Fuse 45 on fuse holder B -SB45- Injector, cylinder 2 -N31- (BCA) Injector, cylinder 3 -N32- (BCA) Injector, cylinder 4 -N33- (BCA) 20 A - Auxiliary heater control unit -J364- A - Windscreen wiper motor -V- 40 A -- Glow plug 1 -Q10- (BDJ) Glow plug 2 -Q11- (BDJ) A - Glow plug 3 -Q12- (BDJ) Glow plug 4 -Q13- (BDJ) A Fuel system pressurisation pump -G6- (BCA, BGU) - - Vacant Vacant Vacant Vacant - 10 A - Headlight range control regulator -E Left headlight range control motor -V48- Right headlight range control motor -V49-5 A - Oil level and oil temperature sender -G Control unit in dash panel insert -J A - - SC1, SC2, SC3, SC4, SC5, SC6, SC9, SC10, SC11, SC12, SC13, SC14, SC, SC16, SC25, SC26, SC27 on fuse holder C -SC- - - Vacant 5 A 10 A - Fuel pump relay -J17- (BCA, BGU) -- Glow plug relay -J52- (BDJ) Air mass meter -G70- (BJB) - - Vacant - - Vacant 87a A - - Lambda probe -G39- (BGU) Lambda probe after catalytic converter -G1- (BGU) 46 - Fuse 46 on fuse - - Vacant 87a holder B -SB Fuse 47 on fuse 40 A - Onboard supply control unit -J519-, left headlight 87a
20 holder B -SB Fuse 48 on fuse holder B -SB Fuse 49 on fuse holder B -SB Fuse 50 on fuse holder B -SB Fuse 51 on fuse holder B -SB Fuse 52 on fuse holder B -SB Fuse 53 on fuse holder B -SB Fuse 54 on fuse holder B -SB54- (models with central locking) 40 A - Onboard supply control unit -J519-, right headlight (models with central locking) - - Vacant - - Vacant 50 A 40 A Automatic glow period control unit -J179- (BJB) Glow plug 1 -Q10- (BJB) Glow plug 2 -Q11- (BJB) Glow plug 3 -Q12- (BJB) Glow plug 4 -Q13- (BJB) Secondary air pump relay -J299- (BGU) Secondary air pump motor -V101- (BGU) - - Vacant 25 A -- Driver door control unit -J386- Front passenger door control unit -J A - Radiator fan control unit -J293- Fuse holder B -SB- on electronics box, on left of engine compartment, from May 2005 Fuse colours
21 50 A - red 40 A - orange A - green 25 A - white 20 A - yellow A - blue 10 A - red 7,5 A - brown 5 A - beige 3 A - purple Fuse locations on fuse holder B -SB-, from May 2005 No. Current Flow Nominal Function/component Terminal
22 Diagram designation 1 - Fuse 1 on fuse holder B -SB1-2 - Fuse 2 on fuse holder B -SB2-3 - Fuse 3 on fuse holder B -SB3-4 - Fuse 4 on fuse holder B -SB4-5 - Fuse 5 on fuse holder B -SB5-6 - Fuse 6 on fuse holder B -SB6-7 - Fuse 7 on fuse holder B -SB7-8 - Fuse 8 on fuse holder B -SB8-9 - Fuse 9 on fuse holder B -SB Fuse 10 on fuse holder B -SB Fuse 11 on fuse holder B -SB Fuse 12 on fuse holder B -SB Fuse 13 on fuse holder B -SB Fuse 14 on fuse holder B -SB14- value - - Vacant - A - Steering column electronics control unit - J527-5 A - Onboard supply control unit -J519- A - ABS control unit -J104- A - Mechatronic unit for dual clutch gearbox - J743- (only models with direct shift gearbox) 5 A - Control unit in dash panel insert -J Vacant - A -- Control unit with display for radio and navigation system -J503- Radio -R- 10 A - Mobile telephone operating electronics control unit -J412- (only models with telephone) 5 A --- Motronic current supply relay -J271- (BSX) Terminal voltage supply relay -J329- (BDJ, BST, BLS, BSU, BJB, BCA, BUD) Engine control unit -J623- BCA, BUD, BSX) 20 A - Auxiliary heater control unit -J364-5 A - Data bus diagnostic interface -J533- A - Engine control unit -J A ---- Ignition coil 1 with output stage -N70- (BCA, BSX, BUD) Ignition coil 2 with output stage -N127- (BCA, BSX, BUD) Ignition coil 3 with output stage -N291- (BCA, BSX, BUD) Ignition coil 4 with output stage -N292- (BCA, BSX, BUD) Ignition transformer -N2- (BGU, BSE, BSF)
23 - Fuse on fuse holder B -SB- - Fuse on fuse holder B -SB Fuse 16 on fuse holder B -SB Fuse 17 on fuse holder B -SB Fuse 18 on fuse holder B -SB Fuse 19 on fuse holder B -SB Fuse 20 on fuse holder B -SB Fuse 21 on fuse holder B -SB Fuse 21 on fuse holder B -SB Fuse 22 on fuse holder B -SB Fuse 23 on fuse holder B -SB23-5 A --- Fuel pump relay -J17- (BDJ, BST, BLS, BSU, BJB) Glow plug relay -J52- (BDJ, BST) Automatic glow period control unit -J179- (BLS, BSU, BJB) 10 A Fuel pump switch-off relay -J333- (BSX) Injector, cylinder 1 -N- (BUD) Injector, cylinder 2 -N31- (BUD) Injector, cylinder 3 -N32- (BUD) Injector, cylinder 4 -N33- (BUD) Gas injection valve 1 -N366- (BSX) Gas injection valve 2 -N367- (BSX) Gas injection valve 3 -N368- (BSX) Gas injection valve 4 -N369- (BSX) A - ABS control unit -J A - Onboard supply control unit -J519- A - Special vehicle control unit -J608- A - Windscreen wiper motor -V- 40 A -- Glow plug 3 -Q12- (BDJ, BST) Glow plug 4 -Q13- (BDJ, BST) 10 A - Lambda probe -G39- (BLS with particulate filter/preparation for particulate filter) A -- Lambda probe -G39- (BGU, BSE, BSF, BCA, BSX, BUD) Lambda probe after catalytic converter - G1- (BGU, BSE, BSF, BCA, BSX, BUD) 5 A -- Brake pedal switch -F47- (applicable up to May 2006) Clutch position sender -G476- (only models with manual gearbox) 5 A ---- Secondary air pump relay -J299- (BGU, BSE) Exhaust gas recirculation valve -N18- (BDJ, BST, BJB) Charge pressure control solenoid valve - N75- (BJB) Exhaust gas recirculation cooler changeover valve -N345- (BJB, BLS, BSU) Exhaust gas recirculation cooler changeover valves 2 -N381- (BLS, BSU) 87
24 23 - Fuse 23 on fuse holder B -SB Fuse 24 on fuse holder B -SB Fuse 25 on fuse holder B -SB Fuse 26 on fuse holder B -SB Fuse 27 on fuse holder B -SB Fuse 27 on fuse holder B -SB Fuse 28 on fuse holder B -SB Fuse 29 on fuse holder B -SB29- - Fuse on fuse holder B -SB- 10 A Fuel tank shut-off valve 1 -N361- (BSX) Fuel tank shut-off valve 2 -N362- (BSX) Fuel tank shut-off valve 3 -N363- (BSX) High pressure valve for gas mode -N372- (BSX) Fuel tank shut-off valve 4 -N429- (BSX) 10 A Exhaust gas recirculation valve -N18- - (BCA) Injector, cylinder 1 -N- (BSX) Injector, cylinder 2 -N31- (BSX) Injector, cylinder 3 -N32- (BSX) Injector, cylinder 4 -N33- (BSX) Activated charcoal filter system solenoid valve 1 -N80- (BCA, BGU, BSE, BSF, BUD) Variable intake manifold change-over valve -N6- (BGU, BSE, BSF) Intake manifold flap motor -V7- (BDJ, BST) radiator fan connection 40 A - Onboard supply control unit -J A - Onboard supply control unit -J A --- Glow plug 1 -Q10- (BDJ, BST) Glow plug 2 -Q11- (BDJ, BST) Secondary air pump motor -V101- (BGU, BSE) A - Automatic glow period control unit -J179- (BJB, BLS, BSU) 40 A - Terminal voltage supply relay 2 -J681- A -- Driver door control unit -J386- (only for model with electric window regulator) Front passenger door control unit -J387- (only for model with electric window regulator) A -- - Fuse SC18 - SC19 on fuse holder C -SC- (applies to special vehicle only) - Fuse SC53 - SC56 on fuse holder C -SC- (applies to special vehicle only)
25 Fuse locations on fuse holder B - SB-, from November 2006 No. Current Flow Diagram designation 1 - Fuse 1 on fuse holder B -SB1-2 - Fuse 2 on fuse holder B -SB2-3 - Fuse 3 on fuse holder B -SB3-4 - Fuse 4 on fuse holder B -SB4-5 - Fuse 5 on fuse holder B -SB5- Nominal value Function/component Terminal - - Vacant - A - Steering column electronics control unit - J527-5 A - Onboard supply control unit -J519- A - ABS control unit -J104- A - Mechatronic unit for dual clutch gearbox - J743- (only models with direct shift
26 6 - Fuse 6 on fuse holder B -SB6-7 - Fuse 7 on fuse holder B -SB7-8 - Fuse 8 on fuse holder B -SB8-9 - Fuse 9 on fuse holder B -SB Fuse 10 on fuse holder B -SB Fuse 11 on fuse holder B -SB Fuse 12 on fuse holder B -SB Fuse 13 on fuse holder B -SB Fuse 14 on fuse holder B -SB14- - Fuse on fuse holder B -SB- - Fuse on fuse holder B -SB- gearbox) 5 A - Control unit in dash panel insert -J Vacant - A -- Control unit with display for radio and navigation system -J503- Radio -R- 10 A - Mobile telephone operating electronics control unit -J412- (only models with telephone) 5 A --- Motronic current supply relay -J271- (BSX) Terminal voltage supply relay -J329- (BDJ, BST, BLS, BSU, BJB, BUD) Engine control unit -J623- (BUD, BSX) 20 A - Auxiliary heater control unit -J364-5 A - Data bus diagnostic interface -J533- A - Engine control unit -J A ---- Ignition coil 1 with output stage -N70- (BSX, BUD) Ignition coil 2 with output stage -N127- (BSX, BUD) Ignition coil 3 with output stage -N291- (BSX, BUD) Ignition coil 4 with output stage -N292- (BSX, BUD) Ignition transformer -N2- (BSE, BSF) 5 A --- Fuel pump relay -J17- (BDJ, BST, BLS, BSU, BJB) Glow plug relay -J52- (BDJ, BST) Automatic glow period control unit -J179- (BLS, BSU, BJB) 10 A Fuel pump switch-off relay -J333- (BSX) Injector, cylinder 1 -N- (BUD) Injector, cylinder 2 -N31- (BUD) Injector, cylinder 3 -N32- (BUD) Injector, cylinder 4 -N33- (BUD) Gas injection valve 1 -N366- (BSX) Gas injection valve 2 -N367- (BSX) Gas injection valve 3 -N368- (BSX) Gas injection valve 4 -N369- (BSX)
27 16 - Fuse 16 on fuse holder B -SB Fuse 17 on fuse holder B -SB Fuse 18 on fuse holder B -SB Fuse 19 on fuse holder B -SB Fuse 20 on fuse holder B -SB Fuse 21 on fuse holder B -SB Fuse 21 on fuse holder B -SB Fuse 22 on fuse holder B -SB Fuse 23 on fuse holder B -SB Fuse 23 on fuse holder B -SB Fuse 24 on fuse holder B -SB24- A - ABS control unit -J A - Onboard supply control unit -J519- A - Special vehicle control unit -J608- A - Windscreen wiper motor -V- 40 A -- Glow plug 3 -Q12- (BDJ, BST) Glow plug 4 -Q13- (BDJ, BST) 10 A - Lambda probe -G39- (BLS with particulate filter/preparation for particulate filter) A -- Lambda probe heater -Z19- (BSE, BSF, BSX, BUD) Lambda probe 1 heater after catalytic converter -Z29- (BSE, BSF, BSX, BUD) 5 A -- Clutch position sender -G476- (only models with manual gearbox) 5 A ---- Secondary air pump relay -J299- (BSE, BSF) Exhaust gas recirculation valve -N18- (BDJ, BST, BJB) Charge pressure control solenoid valve - N75- (BJB) Exhaust gas recirculation cooler changeover valve -N345- (BJB, BLS, BSU) Exhaust gas recirculation cooler changeover valves 2 -N381- (BJB, BLS, BSU) 10 A Fuel tank shut-off valve 1 -N361- (BSX) Fuel tank shut-off valve 2 -N362- (BSX) Fuel tank shut-off valve 3 -N363- (BSX) High pressure valve for gas mode -N372- (BSX) Fuel tank shut-off valve 4 -N429- (BSX) 10 A Injector, cylinder 1 -N- (BSX) Injector, cylinder 2 -N31- (BSX) Injector, cylinder 3 -N32- (BSX) Injector, cylinder 4 -N33- (BSX) Activated charcoal filter system solenoid valve 1 -N80- (BSE, BSF, BUD) Variable intake manifold change-over valve -N6- (BSE, BSF) Intake manifold flap motor -V7- (BDJ, BST) Radiator fan connection (T4x connector) 87
28 25 - Fuse 25 on fuse holder B -SB Fuse 26 on fuse holder B -SB Fuse 27 on fuse holder B -SB Fuse 27 on fuse holder B -SB Fuse 28 on fuse holder B -SB Fuse 29 on fuse holder B -SB29- - Fuse on fuse holder B -SB- 40 A - Onboard supply control unit -J A - Onboard supply control unit -J A --- Glow plug 1 -Q10- (BDJ, BST) Glow plug 2 -Q11- (BDJ, BST) Secondary air pump motor -V101- (BSE, BSF) A - Automatic glow period control unit -J179- (BJB, BLS, BSU) 40 A - Terminal voltage supply relay 2 -J681- A -- Driver door control unit -J386- (only for model with electric window regulator) Front passenger door control unit -J387- (only for model with electric window regulator) A -- Fuse SC18 - SC19 on fuse holder C -SC- (applies to special vehicle only) Fuse SC53 - SC56 on fuse holder C -SC- (applies to special vehicle only)
29 Fuse locations on fuse holder B - SB-, from May 2007 No. Current Flow Diagram designation 1 - Fuse 1 on fuse holder B -SB1-2 - Fuse 2 on fuse holder B -SB2-3 - Fuse 3 on fuse holder B -SB3-4 - Fuse 4 on fuse holder B -SB4-5 - Fuse 5 on fuse holder B -SB5- Nominal value Function/component Terminal - - Vacant - 5 A - Steering column electronics control unit - J527-5 A - Onboard supply control unit -J519- A - ABS control unit -J104- A - Mechatronic unit for dual clutch gearbox - J743- (only models with direct shift gearbox)
30 6 - Fuse 6 on fuse holder B -SB6-7 - Fuse 7 on fuse holder B -SB7-8 - Fuse 8 on fuse holder B -SB8-9 - Fuse 9 on fuse holder B -SB Fuse 10 on fuse holder B -SB Fuse 11 on fuse holder B -SB Fuse 12 on fuse holder B -SB Fuse 13 on fuse holder B -SB Fuse 13 on fuse holder B -SB Fuse 14 on fuse holder B -SB14- - Fuse on fuse holder B -SB- - Fuse on fuse holder B -SB- 5 A - Control unit in dash panel insert -J Vacant - A - Control unit with display for radio and navigation system -J503- Radio -R- 5 A - Mobile telephone operating electronics control unit -J412- (only models with telephone) 5 A --- Motronic current supply relay -J271- (BSX) Terminal voltage supply relay -J329- (BDJ, BST, BLS, BSU, BJB, BUD) Engine control unit -J623- (BUD, BSX) 20 A - Auxiliary heater control unit -J364-5 A - Data bus diagnostic interface -J533- A - Engine control unit -J623- (BDJ, BST, BLS, BSU, BJB, BMM) A - Engine control unit -J623- (BSE, BSF, BSX, BUD) 20 A ---- Ignition coil 1 with output stage -N70- (BSX, BUD) Ignition coil 2 with output stage -N127- (BSX, BUD) Ignition coil 3 with output stage -N291- (BSX, BUD) Ignition coil 4 with output stage -N292- (BSX, BUD) Ignition transformer -N2- (BSE, BSF, BSX) 5 A --- Fuel pump relay -J17- (BDJ, BST, BLS, BSU, BJB, BMM) Glow plug relay -J52- (BDJ, BST) Automatic glow period control unit -J179- (BLS, BSU, BJB, BMM) 10 A Fuel pump switch-off relay -J333- (BSX) Injector, cylinder 1 -N- (BUD) Injector, cylinder 2 -N31- (BUD) Injector, cylinder 3 -N32- (BUD) Injector, cylinder 4 -N33- (BUD) Gas injection valve 1 -N366- (BSX) Gas injection valve 2 -N367- (BSX) Gas injection valve 3 -N368- (BSX)
31 16 - Fuse 16 on fuse holder B -SB Fuse 17 on fuse holder B -SB Fuse 18 on fuse holder B -SB Fuse 19 on fuse holder B -SB Fuse 20 on fuse holder B -SB Fuse 21 on fuse holder B -SB Fuse 21 on fuse holder B -SB Fuse 22 on fuse holder B -SB Fuse 23 on fuse holder B -SB Fuse 23 on fuse holder B -SB Fuse 24 on fuse holder B -SB24- Gas injection valve 4 -N369- (BSX) A - ABS control unit -J104- A - Treble tone horn -H2- Bass tone horn -H7- A - Special vehicle control unit -J608- A - Windscreen wiper motor -V- 40 A -- Glow plug 3 -Q12- (BDJ, BST) Glow plug 4 -Q13- (BDJ, BST) 10 A - Lambda probe heater -Z19- (BLS with particulate filter/preparation for particulate filter) A -- Lambda probe heater -Z19- (BSE, BSF, BSX, BUD) Lambda probe 1 heater after catalytic converter -Z29- (BSE, BSF, BSX, BUD) 5 A -- Clutch position sender -G476- (only models with manual gearbox) 5 A ---- Secondary air pump relay -J299- (BSE, BSF) Exhaust gas recirculation valve -N18- (BDJ, BST, BJB) Charge pressure control solenoid valve -N75- (BJB) Exhaust gas recirculation cooler change-over valve -N345- (BJB, BLS, BSU) Exhaust gas recirculation cooler change-over valves 2 -N381- (BJB, BLS, BSU) 10 A Fuel tank shut-off valve 1 -N361- (BSX) Fuel tank shut-off valve 2 -N362- (BSX) Fuel tank shut-off valve 3 -N363- (BSX) High pressure valve for gas mode -N372- (BSX) Fuel tank shut-off valve 4 -N429- (BSX) 10 A Injector, cylinder 1 -N- (BSX) Injector, cylinder 2 -N31- (BSX) Injector, cylinder 3 -N32- (BSX) Injector, cylinder 4 -N33- (BSX) Activated charcoal filter system solenoid valve 1 -N80- (BSE, BSF, BUD) Variable intake manifold change-over valve - N6- (BSE, BSF) Intake manifold flap motor -V7- (BDJ, BST) 87
32 25 - Fuse 25 on fuse holder B -SB Fuse 26 on fuse holder B -SB Fuse 27 on fuse holder B -SB Fuse 27 on fuse holder B -SB Fuse 28 on fuse holder B -SB Fuse 29 on fuse holder B -SB29- - Fuse on fuse holder B -SB- Radiator fan connection (T4x connector) 40 A - Onboard supply control unit -J A - Onboard supply control unit -J A --- Glow plug 1 -Q10- (BDJ, BST) Glow plug 2 -Q11- (BDJ, BST) Secondary air pump motor -V101- (BSE, BSF) A - Automatic glow period control unit -J179- (BJB, BLS, BSU) 40 A - Terminal voltage supply relay 2 -J681- A -- Driver door control unit -J386- (only for model with electric window regulator) Front passenger door control unit -J387- (only for model with electric window regulator) A -- Fuse SC18 - SC19 on fuse holder C -SC- (applies to special vehicle only) Fuse SC36 - SC38 on fuse holder C -SC- (applies to special vehicle only) Fuse SC53 - SC56 on fuse holder C -SC- (applies to special vehicle only) 50 A Auxiliary heater element -Z35- (only models with PTC (Positive Temperature Coefficient) heater, from September 2007)
33 Fuse locations on fuse holder B - SB- from November 2007 No. Current Flow Diagram designation 1 - Fuse 1 on fuse holder B -SB1-2 - Fuse 2 on fuse holder B -SB2-3 - Fuse 3 on fuse holder B -SB3-4 - Fuse 4 on fuse holder B -SB4-5 - Fuse 5 on fuse holder B -SB5- Nominal value Function/component Terminal - - Vacant - 5 A - Steering column electronics control unit - J527-5 A - Onboard supply control unit -J519- A - ABS control unit -J104- A - Mechatronic unit for dual clutch gearbox - J743- (only models with direct shift gearbox)
34 6 - Fuse 6 on fuse holder B -SB6-7 - Fuse 7 on fuse holder B -SB7-8 - Fuse 8 on fuse holder B -SB8-9 - Fuse 9 on fuse holder B -SB Fuse 10 on fuse holder B -SB Fuse 10 on fuse holder B -SB Fuse 11 on fuse holder B -SB Fuse 12 on fuse holder B -SB Fuse 13 on fuse holder B -SB Fuse 13 on fuse holder B -SB Fuse 14 on fuse holder B -SB14- - Fuse on fuse holder B -SB- - Fuse on fuse holder B -SB- 5 A - Control unit in dash panel insert -J Vacant - A - - Control unit with display for radio and navigation system -J503- Radio -R- 5 A - Mobile telephone operating electronics control unit -J412- (only models with telephone) 5 A --- Terminal voltage supply relay -J329- (BDJ, BST, BLS, BSU, BJB, BUD) Engine control unit -J623- (BUD, BSX) 10 A --- Motronic current supply relay -J271- (BSX) 20 A - Auxiliary heater control unit -J364-5 A - Data bus diagnostic interface -J533- A - Engine control unit -J623- (BDJ, BST, BLS, BSU, BJB, BMM) A - Engine control unit -J623- (BSE, BSF, BSX, BUD) 20 A ---- Ignition coil 1 with output stage -N70- (BSX, BUD) Ignition coil 2 with output stage -N127- (BSX, BUD) Ignition coil 3 with output stage -N291- (BSX, BUD) Ignition coil 4 with output stage -N292- (BSX, BUD) Ignition transformer -N2- (BSE, BSF, BSX) 5 A --- Fuel pump relay -J17- (BDJ, BST, BLS, BSU, BJB, BMM) Glow plug relay -J52- (BDJ, BST) Automatic glow period control unit -J179- (BLS, BSU, BJB, BMM) 10 A Fuel pump switch-off relay -J333- (BSX) Injector, cylinder 1 -N- (BUD) Injector, cylinder 2 -N31- (BUD) Injector, cylinder 3 -N32- (BUD) Injector, cylinder 4 -N33- (BUD) Gas injection valve 1 -N366- (BSX) Gas injection valve 2 -N367- (BSX)
35 16 - Fuse 16 on fuse holder B -SB Fuse 17 on fuse holder B -SB Fuse 18 on fuse holder B -SB Fuse 19 on fuse holder B -SB Fuse 20 on fuse holder B -SB Fuse 21 on fuse holder B -SB Fuse 21 on fuse holder B -SB Fuse 22 on fuse holder B -SB Fuse 23 on fuse holder B -SB Fuse 23 on fuse holder B -SB Fuse 24 on fuse holder B -SB24- Gas injection valve 3 -N368- (BSX) Gas injection valve 4 -N369- (BSX) A - ABS control unit -J104- A - Treble tone horn -H2- Bass tone horn -H7- A - Special vehicle control unit -J608- A - Windscreen wiper motor -V- 40 A -- Glow plug 3 -Q12- (BDJ, BST) Glow plug 4 -Q13- (BDJ, BST) 10 A - Lambda probe heater -Z19- (BLS with particulate filter/preparation for particulate filter) A -- Lambda probe heater -Z19- (BSE, BSF, BSX, BUD) Lambda probe 1 heater after catalytic converter -Z29- (BSE, BSF, BSX, BUD) 5 A -- Clutch position sender -G476- (only models with manual gearbox) 5 A ---- Secondary air pump relay -J299- (BSE, BSF) Exhaust gas recirculation valve -N18- (BDJ, BST, BJB) Charge pressure control solenoid valve -N75- (BJB) Exhaust gas recirculation cooler change-over valve -N345- (BJB, BLS, BSU) 10 A Fuel tank shut-off valve 1 -N361- (BSX) Fuel tank shut-off valve 2 -N362- (BSX) Fuel tank shut-off valve 3 -N363- (BSX) Fuel tank shut-off valve 4 -N429- (BSX) High pressure valve for gas mode -N372- (BSX) 10 A Injector, cylinder 1 -N- (BSX) Injector, cylinder 2 -N31- (BSX) Injector, cylinder 3 -N32- (BSX) Injector, cylinder 4 -N33- (BSX) Activated charcoal filter system solenoid valve 1 -N80- (BSE, BSF, BUD) Variable intake manifold change-over valve - N6- (BSE, BSF) Intake manifold flap motor -V7- (BDJ, BST) Radiator fan connection (T4x connector) 87
36 25 - Fuse 25 on fuse holder B -SB Fuse 26 on fuse holder B -SB Fuse 27 on fuse holder B -SB Fuse 27 on fuse holder B -SB Fuse 28 on fuse holder B -SB Fuse 29 on fuse holder B -SB29- - Fuse on fuse holder B -SB- 40 A - Onboard supply control unit -J A - Onboard supply control unit -J A --- Glow plug 1 -Q10- (BDJ, BST) Glow plug 2 -Q11- (BDJ, BST) Secondary air pump motor -V101- (BSE, BSF) A - Automatic glow period control unit -J179- (BJB, BLS, BSU) 40 A - Terminal voltage supply relay 2 -J681- A -- Driver door control unit -J386- (only for model with electric window regulator) Front passenger door control unit -J387- (only for model with electric window regulator) A 50 A Fuse SC18 - SC19 on fuse holder C -SC- (applies to special vehicle only) Fuse SC36 - SC38 on fuse holder C -SC- (applies to special vehicle only) Fuse SC53 - SC56 on fuse holder C -SC- (applies to special vehicle only) Auxiliary heater element -Z35- (only models with PTC (Positive Temperature Coefficient) heater, from September 2007)
37 Fuse locations on fuse holder B - SB-, from May 2008 No. Current Flow Diagram designation 1 - Fuse 1 on fuse holder B -SB1-2 - Fuse 2 on fuse holder B -SB2-3 - Fuse 3 on fuse holder B -SB3-4 - Fuse 4 on fuse holder B -SB4-5 - Fuse 5 on fuse holder B -SB5- Nominal value Function/component Terminal - - Vacant Vacant - 5 A - Onboard supply control unit -J519- A - ABS control unit -J104- A - Mechatronic unit for dual clutch gearbox - J743- (only models with direct shift
38 6 - Fuse 6 on fuse holder B -SB6-6 - Fuse 6 on fuse holder B -SB6-7 - Fuse 7 on fuse holder B -SB7-8 - Fuse 8 on fuse holder B -SB8-9 - Fuse 9 on fuse holder B -SB Fuse 10 on fuse holder B -SB Fuse 10 on fuse holder B -SB Fuse 11 on fuse holder B -SB Fuse 12 on fuse holder B -SB Fuse 13 on fuse holder B -SB Fuse 13 on fuse holder B -SB Fuse 14 on fuse holder B -SB14- - Fuse on fuse holder B -SB- - Fuse on fuse holder B -SB- gearbox) 5 A - Control unit in dash panel insert -J285- (applicable up to November 2008) Steering column electronics control unit - J527- (applicable up to November 2008) - - Vacant (applicable from November 2008) - 40 A - Terminal voltage supply relay 2 -J681- A - - Control unit with display for radio and navigation system -J503- Radio -R- 5 A - Mobile telephone operating electronics control unit -J412- (only models with telephone) 5 A --- Terminal voltage supply relay -J329- (BDJ, BST, BLS, BSU, BJB, BMM, BUD) Engine control unit -J623- (BUD, BSX) 10 A --- Motronic current supply relay -J271- (BSX) 20 A - Auxiliary heater control unit -J364-5 A - Data bus diagnostic interface -J533- A - Engine control unit -J623- (BDJ, BST, BLS, BSU, BJB, BMM) A - Engine control unit -J623- (BSE, BSF, BSX, BUD) 20 A ---- Ignition coil 1 with output stage -N70- (BSX, BUD) Ignition coil 2 with output stage -N127- (BSX, BUD) Ignition coil 3 with output stage -N291- (BSX, BUD) Ignition coil 4 with output stage -N292- (BSX, BUD) Ignition transformer -N2- (BSE, BSF, BSX) 5 A --- Fuel pump relay -J17- (BDJ, BST, BLS, BSU, BJB, BMM) Glow plug relay -J52- (BDJ, BST) Automatic glow period control unit -J179- (BLS, BSU, BJB, BMM) 10 A Fuel pump switch-off relay -J333- (BSX) Injector, cylinder 1 -N- (BUD)
39 16 - Fuse 16 on fuse holder B -SB Fuse 17 on fuse holder B -SB Fuse 17 on fuse holder B -SB Fuse 18 on fuse holder B -SB Fuse 19 on fuse holder B -SB Fuse 20 on fuse holder B -SB Fuse 21 on fuse holder B -SB Fuse 21 on fuse holder B -SB Fuse 22 on fuse holder B -SB Fuse 23 on fuse holder B -SB Fuse 23 on fuse holder B -SB23- Injector, cylinder 2 -N31- (BUD) Injector, cylinder 3 -N32- (BUD) Injector, cylinder 4 -N33- (BUD) Gas injection valve 1 -N366- (BSX) Gas injection valve 2 -N367- (BSX) Gas injection valve 3 -N368- (BSX) Gas injection valve 4 -N369- (BSX) A - Onboard supply control unit -J519- A - Treble tone horn -H2- (applicable up to October 2008) Bass tone horn -H7- (applicable up to October 2008) - - Vacant (applicable from November 2008) - A - Special vehicle control unit -J608- A - Windscreen wiper motor -V- 40 A -- Glow plug 3 -Q12- (BDJ, BST) Glow plug 4 -Q13- (BDJ, BST) 10 A - Lambda probe heater -Z19- (BLS with particulate filter/preparation for particulate filter) A -- Lambda probe heater -Z19- (BSE, BSF, BSX, BUD) Lambda probe 1 heater after catalytic converter -Z29- (BSE, BSF, BSX, BUD) 5 A -- Clutch position sender -G476- (only models with manual gearbox) 5 A ---- Secondary air pump relay -J299- (BSE, BSF) Exhaust gas recirculation valve -N18- (BDJ, BST, BJB) Charge pressure control solenoid valve - N75- (BJB, BLS, BSU, BMM) Exhaust gas recirculation cooler changeover valve -N345- (BJB, BLS, BSU, BMM) 10 A Fuel tank shut-off valve 1 -N361- (BSX) Fuel tank shut-off valve 2 -N362- (BSX) Fuel tank shut-off valve 3 -N363- (BSX) Fuel tank shut-off valve 4 -N429- (BSX) High pressure valve for gas mode -N372- (BSX) 87
40 24 - Fuse 24 on fuse holder B -SB Fuse 25 on fuse holder B -SB Fuse 26 on fuse holder B -SB Fuse 27 on fuse holder B -SB Fuse 27 on fuse holder B -SB Fuse 28 on fuse holder B -SB Fuse 29 on fuse holder B -SB29- - Fuse on fuse holder B -SB- 10 A Injector, cylinder 1 -N- (BSX) Injector, cylinder 2 -N31- (BSX) Injector, cylinder 3 -N32- (BSX) Injector, cylinder 4 -N33- (BSX) Activated charcoal filter system solenoid valve 1 -N80- (BSE, BSF, BUD) Variable intake manifold change-over valve -N6- (BSE, BSF) Intake manifold flap motor -V7- (BDJ, BST) Radiator fan connection (T4x connector) 40 A - ABS control unit -J A - Onboard supply control unit -J A --- Glow plug 1 -Q10- (BDJ, BST) Glow plug 2 -Q11- (BDJ, BST) Secondary air pump motor -V101- (BSE, BSF) A - Automatic glow period control unit -J179- (BJB, BLS, BSU, BMM) - - Vacant - A ---- Fuse SC18 - SC19 on fuse holder C -SC- (applies to special vehicle only) Fuse SC35 - SC39 on fuse holder C -SC- (applies to special vehicle only) Fuse SC57 - SC58 on fuse holder C -SC- (applies to special vehicle only) 50 A - Fuse SC39 - SC41 on fuse holder C -SC- (trailer operation only)
41 Fuse locations on fuse holder B - SB- from May 2009 No. Current Flow Diagram designation 1 - Fuse 1 on fuse holder B -SB1-2 - Fuse 2 on fuse holder B -SB2-3 - Fuse 3 on fuse holder B -SB3-4 - Fuse 4 on fuse holder B -SB4-5 - Fuse 5 on fuse holder B -SB5- Nominal value Function/component Terminal - - Vacant Vacant - 5 A - Onboard supply control unit -J519- A - ABS control unit -J104- A - Mechatronic unit for dual clutch gearbox - J743- (only models with direct shift gearbox)
42 6 - Fuse 6 on fuse holder B -SB6-7 - Fuse 7 on fuse holder B -SB7-8 - Fuse 8 on fuse holder B -SB8-9 - Fuse 9 on fuse holder B -SB Fuse 10 on fuse holder B -SB Fuse 10 on fuse holder B -SB Fuse 11 on fuse holder B -SB Fuse 12 on fuse holder B -SB Fuse 12 on fuse holder B -SB Fuse 13 on fuse holder B -SB Fuse 13 on fuse holder B -SB Fuse 14 on fuse holder B -SB14- - Fuse on fuse holder B -SB- - Fuse on fuse holder B -SB- - - Vacant - 40 A - Terminal voltage supply relay 2 -J681- A - - Control unit with display for radio and navigation system -J503- Radio -R- 5 A - Mobile telephone operating electronics control unit -J412- (only models with telephone, applicable up to May 2009) 5 A - Terminal voltage supply relay -J329- (BDJ, BST, BLS, BSU, BJB, BMM, CHWA) 10 A --- Main relay -J271- (BSX) Engine control unit -J623- (BUD, BSX) Terminal voltage supply relay -J329- (BUD) 20 A - Auxiliary heater control unit -J364-5 A - Data bus diagnostic interface -J533- (applicable up to May 2009) - - Vacant - A - Engine control unit -J623- (BDJ, BST, BLS, BSU, BJB, BMM, CHWA) A - Engine control unit -J623- (BSE, BSF, BSX, BUD) 20 A ---- Ignition coil 1 with output stage -N70- (BSX, BUD) Ignition coil 2 with output stage -N127- (BSX, BUD) Ignition coil 3 with output stage -N291- (BSX, BUD) Ignition coil 4 with output stage -N292- (BSX, BUD) Ignition transformer -N2- (BSE, BSF) 5 A --- Fuel pump relay -J17- (BDJ, BST, BLS, BSU, BJB, BMM,CHWA) Glow plug relay -J52- (BDJ, BST) Automatic glow period control unit -J179- (BLS, BSU, BJB, BMM, CHWA) 10 A Fuel pump switch-off relay -J333- (BSX) Injector, cylinder 1 -N- (BUD) Injector, cylinder 2 -N31- (BUD) Injector, cylinder 3 -N32- (BUD) Injector, cylinder 4 -N33- (BUD)
43 16 - Fuse 16 on fuse holder B -SB Fuse 17 on fuse holder B -SB Fuse 17 on fuse holder B -SB Fuse 18 on fuse holder B -SB Fuse 19 on fuse holder B -SB Fuse 20 on fuse holder B -SB Fuse 20 on fuse holder B -SB Fuse 21 on fuse holder B -SB Fuse 21 on fuse holder B -SB Fuse 22 on fuse holder B -SB Fuse 23 on fuse holder B -SB Fuse 23 on fuse holder B -SB Fuse 24 on fuse holder B -SB24- Gas injection valve 1 -N366- (BSX) Gas injection valve 2 -N367- (BSX) Gas injection valve 3 -N368- (BSX) Gas injection valve 4 -N369- (BSX) A - Onboard supply control unit -J519- A - Treble tone horn -H2- (applicable up to November 2008) Bass tone horn -H7- (applicable up to November 2008) - - Vacant (applicable from November 2008) - A - Special vehicle control unit -J608- A - Windscreen wiper motor -V- 40 A -- Glow plug 3 -Q12- (BDJ, BST) Glow plug 4 -Q13- (BDJ, BST) 10 A - Fuel pump relay -J17- (BSX) (applicable from May 2009) 10 A - Lambda probe heater -Z19- (BLS with particulate filter/preparation for particulate filter) A -- Lambda probe heater -Z19- (BSE, BSF, BSX, BUD) Lambda probe 1 heater after catalytic converter -Z29- (BSE, BSF, BSX, BUD) 5 A -- Clutch position sender -G476- (only models with manual gearbox) 5 A -- Secondary air pump relay -J299- (BSE, BSF) Exhaust gas recirculation valve -N18- (BDJ, BST) 10 A Gas Shut-Off Valve Relay -J908- (BSX) High pressure valve for gas mode -N372- (BSX) Exhaust gas recirculation cooler change-over valve -N345- (BJB, BLS, BSU, BMM, CHWA) Charge pressure control solenoid valve -N75- (BJB, BLS, BSU, BMM, CHWA) Exhaust gas recirculation valve -N18- (BJB) 10 A Injector, cylinder 1 -N- (BSX) Injector, cylinder 2 -N31- (BSX) Injector, cylinder 3 -N32- (BSX) Injector, cylinder 4 -N33- (BSX) 87
44 25 - Fuse 25 on fuse holder B -SB Fuse 26 on fuse holder B -SB Fuse 27 on fuse holder B -SB Fuse 27 on fuse holder B -SB Fuse 28 on fuse holder B -SB Fuse 29 on fuse holder B -SB29- - Fuse on fuse holder B -SB- Activated charcoal filter system solenoid valve 1 -N80- (BSE, BSF, BUD) Variable intake manifold change-over valve - N6- (BSE, BSF) Intake manifold flap motor -V7- (BDJ, BST) Radiator fan connection (T4x connector) 40 A - ABS control unit -J A - Onboard supply control unit -J A --- Glow plug 1 -Q10- (BDJ, BST) Glow plug 2 -Q11- (BDJ, BST) Secondary air pump motor -V101- (BSE, BSF) A - Automatic glow period control unit -J179- (BJB, BLS, BSU, BMM, CHWA) - - Vacant - A --- Fuse SC18, SC19 on fuse holder C -SC- (applies to special vehicle taxi only) Fuse SC35, SC39 on fuse holder C -SC- (applies to special vehicle police only) Fuse SC57, SC58 on fuse holder C -SC- (applies to special vehicle police only) 50 A - Fuse SC40 - SC42 on fuse holder C -SC- (trailer operation only)
Transporter Current Flow Diagram No. 80 / 1
Transporter Current Flow Diagram No. 80 / 1 2.5 l/65 kw direct injection turbo diesel, engine code AJT From May 1999 2.5 l/75 kw direct injection turbo diesel, engine codes ACV, AUF 2.5 l/111 kw direct
More informationTouareg Component Locations No. 802 / 1
Touareg Component Locations No. 802 / 1 1 Fuses 1.1 Fuses 1.1.1 Overview of Fuses 1 - Fuses (SB) on fuse panel B on left instrument panel Location page 3 Fuse Arrangements, from November 2006 page 4 2
More informationElectronic Diesel Control EDC 16
Service. Self-Study Programme 304 Electronic Diesel Control EDC 16 Design and Function The new EDC 16 engine management system from Bosch has its debut in the V10-TDI- and R5-TDI-engines. Increasing demands
More informationThe 2.0l FSI engine with 4-valve technology
Service Training Self-study programme 322 The 2.0l FSI engine with 4-valve technology Design and function The 2.0l engine is based on the tried and tested 827/113 series. Thanks to FSI technology (Fuel
More informationTransporter. -Fitting Locations: Fuses. Overview of fuse carrier. Page 1 of32. Fitting Locations No. 803/1. Copyright VW AG. Current flow diagrams
Page 1 of32 Copyright VW AG Current flow diagrams Engine code: CAAC Model year: 2012 Model description: TRANSPORTER KombiKR103 SG6 Gearbox code: KUP Final drive code: Service advisor name: Transporter
More informationTransporter Fitting Locations No. 804 / 1
Page 1 of 10 Transporter Fitting Locations No. 804 / 1 Pin connector assigment of selected connections Overview: 1 - Ignition/starter switch -D- On steering column Connector assigment chapter 2 - Onboard
More informationWiring diagrams 14 1. Component key for wiring diagrams 1 to 29 Note: Not all the items listed will be fitted to all models
Wiring diagrams 14 1 Component key for wiring diagrams 1 to 29 Note: Not all the items listed will be fitted to all models No Description 00200 Alternator with built-in regulator 00500 Battery 01001 Starter
More informationE - THEORY/OPERATION
E - THEORY/OPERATION 1995 Volvo 850 1995 ENGINE PERFORMANCE Volvo - Theory & Operation 850 INTRODUCTION This article covers basic description and operation of engine performance-related systems and components.
More informationELECTRICAL WIRING (R.H. DRIVE VEHICLES)
C-1 ELECTRICAL WIRING (R.H. DRIVE VEHICLES) CONTENTS GENERAL.......................... 3 WIRING HARNESS CONFIGURATION DIAGRAMS......................... 4 ENGINE COMPARTMENT................ 4 DASH PANEL...........................
More informationWynn s Extended Care
Wynn s Extended Care Every car deserves to receive the very best care... especially yours. How Do You Keep Your Reliable Transportation Reliable? Count on Wynn s Because Wynn s has been caring for cars
More informationG PART NUMBER OF CONNECTORS
A 1 A/C Ambient Temp. Sensor 90980 11070 Buckle SW RH (w/ Power Seat) A/C Condenser Fan Motor (1G FE) 90980 10928 B 9 Buckle SW RH (w/o Power Seat) 90980 11212 A 2 A/C Condenser Fan Motor (2JZ GE) 90980
More informationKobelco Extended Warranty Program. www.kobelco-europe.com
Kobelco Extended Warranty Program www.kobelco-europe.com Kobelco Extended Warranty is a convenient, value added way to give your Kobelco customers added security and peace of mind. Benefits of the Kobelco
More informationFault codes DM1. Industrial engines DC09, DC13, DC16. Marine engines DI09, DI13, DI16 INSTALLATION MANUAL. 03:10 Issue 5.0 en-gb 1
Fault codes DM1 Industrial engines DC09, DC13, DC16 Marine engines DI09, DI13, DI16 03:10 Issue 5.0 en-gb 1 DM1...3 Abbreviations...3 Fault type identifier...3...4 03:10 Issue 5.0 en-gb 2 DM1 DM1 Fault
More informationTechnical Service Information
Technical Service Information COMPLAINT: CAUSE: 1996-20 DEFINITIONS When a VW/Audi vehicle is exhibiting a symptom or is in fail-safe, the technician, in many cases, is unable to communicate with the on-board
More information6-years/75,000 miles Comprehensive coverage Subsequent Owner Warranty $100 Deductible
LINCOLN PREMIER LIMITED WARRANTY 6-years/75,000 miles Comprehensive coverage Subsequent Owner Warranty $100 Deductible Comprehensive Coverage Because Lincoln has always been a brand you can trust and respect,
More informationAir conditioning, electrical testing
just a test. Air conditioning, electrical testing 01-253 Wire and component test using VAG1598 A test box Special tools and equipment VAG 1598 A test box and VAG 1598/11 adapter cable and VAG 1598/12 VAG1526
More informationElectronic Power Control
Service. Self-Study Programme 210 Electronic Power Control Design and Function With the Electronic Power Control system, the throttle valve is actuated only by an electric motor. This eliminates the need
More informationNote: This information obtained from internet sources and not verified- use at your own risk!!!!
Cummins Engine Diagnostic Fault Codes for 2003 and later engines (generally for 2004 and later Alpines; see page 13 for earlier engine diagnostic codes): Note: This information obtained from internet sources
More informationElectronic Manual Gearbox
Service. Self-Study Programme 221 Electronic Manual Gearbox Design and Function Taking the Lupo as the basis, Volkswagen has developed the world's first 3 L car that will also go into volume production.
More informationON-Board Diagnostic Trouble Codes
ON-Board Diagnostic Trouble Codes The list below contains standard diagnostic trouble codes (DTC s) that are used by some manufacturers to identify vehicle problems. The codes provide below are generic
More informationSignature and ISX CM870 Electronics
Signature and ISX CM870 Electronics Cummins West Training Center System Description General Information The Signature and ISX CM870 engine control system is an electronically operated fuel control system
More informationSubaru Reference. This reference contains the following information: connector pinouts. connector pinouts
Subject: Source: 1993 2010 Impreza, WRX, and Sti and 2002 07 Outback Sport ABS wiring diagrams, harness routing, and connector locations and pinouts Subaru service manuals This reference contains the following
More informationINSTALLATION MANUAL 3RP / 5RP 4-BUTTON SERIES VEHICLE SECURITY SYSTEMS
3RP / 5RP 4-BUTTON SERIES VEHICLE SECURITY SYSTEMS INSTALLATION MANUAL Before you begin the installation Read the INSTRUCTIONS! Always use a multi-meter when verifying vehicle wiring. Before mounting the
More informationSAS light Check Engine Malfunction Indicator Lamp
SAS light Check Engine Malfunction Indicator Lamp Here's how to do it: In car ECM Diagnostics/ECM Reset procedure: 1) Sit in the driver's seat. 2) Turn the ignition key to the ON position and wait three
More informationMINI EXTENDED SERVICE CONTRACTS
MINI EXTENDED SERVICE CONTRACTS LESS WORRY, MORE WEEEE! CONTINUING COVERAGE FOR YOUR NEW, USED, OR CERTIFIED PRE-OWNED MINI. Whether your odometer is ticking toward the end of your original 4-year/50,000-mile
More information1993 WIRING DIAGRAMS Volkswagen Wiring Diagrams. Volkswagen; EuroVan
Article Text ARTICLE BEGINNING 1993 WIRING DIAGRAMS Volkswagen Wiring Diagrams Volkswagen; EuroVan COMPONENT LOCATION MENU COMPONENT LOCATIONS TABLE ÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄ
More informationMOTOR VEHICLE MECHANIC REPAIR CATEGORIES
Chapter 8: Motor Vehicle Mechanic Repair Categories Page 1 CHAPTER 8 MOTOR VEHICLE MECHANIC REPAIR CATEGORIES Section 8-1 REQUIREMENT Section 10 of the Motor Vehicle Service and Repair Act (MCL 257.1310)
More informationCONTINUED COVERAGE FOR YOUR NEW, USED, OR CERTIFIED PRE-OWNED BMW.
BMW EXTENDED SERVICE CONTRACTS FEEL THE RUSH OF ASSURANCE. CONTINUED COVERAGE FOR YOUR NEW, USED, OR CERTIFIED PRE-OWNED BMW. Whether your original 4-year/50,000-mile BMW Warranty is coming to an end,
More informationThis file is available for free download at http://www.iluvmyrx7.com
This file is available for free download at http://www.iluvmyrx7.com This file is fully text-searchable select Edit and Find and type in what you re looking for. This file is intended more for online viewing
More informationREMOVAL AND INSTALLATION
303-01C-1 REMOVAL AND INSTALLATION Engine Body On Special Tool(s) Adapter For 303-D043 303-D043-02 or equivalent Special Tool(s) 303-01C-1 Turbocharger Lifting Bracket 303-1266 Wrench, Fan Clutch Nut 303-214
More informationDiagnostic Fault Codes For Cummins Engines
Section - Diagnostic Fault Codes For Cummins Engines Applies to Engine Models T, T, QSL T, QSM, QS, QSK9, QSK, QST, QSK//8 Note: These fault codes are current at date of publication. Always refer to engine
More information01-3 0000-00 6810-20 AIR CONDITIONING SYSTEM 1. FFH SPECIFICATION AIR CONDITIONING SYSTEM RODIUS 2004.09
0000-00 01-3 6810-20 1. FFH SPECIFICATION 01-4 0000-00 2. SYSTEM LAYOUT AND COMPONENTS 0000-00 01-5 01-6 0000-00 3. FFH GENERAL INFORMATION The system is to increase the coolant temperature quickly by
More informationAUTOMOBILE MECHANIC STUDENT INTERNSHIP SKILLS LIST Provo School District
AUTOMOBILE MECHANIC STUDENT INTERNSHIP SKILLS LIST Provo School District Repairs and overhauls automobiles, buses, trucks, and other automotive vehicles: Examines vehicle and discusses with customer or
More informationFZ400 1997-1998 WIRING DIAGRAM (JAPANESE MARKET FAZER 400) 5
FZ400 1997-1998 WIRING DIAGRAM (JAPANESE MARKET FAZER 400) 5 1 2 4 7 6 11 12 13 13 12 13 3 13 8 9 56 14 59 52 54 15 48 55 34 22 16 51 50 60 47 46 36 35 23 17 49 24 25 18 44 37 38 39 40 58 33 26 27 28 29
More informationDTC Database (OBD-II Trouble Codes)
Auto Consulting S.a.s di Cofano A. & C. Attrezzature diagnostiche Elaborazioni elettroniche Formazione tecnica DTC Database (OBD-II Trouble Codes) Definitions for generic powertrain diagnostic trouble
More informationPowertrain DTC (P000-P0999) for EOBD Vehicles (Directive 98/69/EC of the European Parliament)
Powertrain DTC (P000-P0999) for EOBD Vehicles (Directive 98/69/EC of the European Parliament) 1 Trouble Fault location Probable cause code 1 P0000 No fault found - P0001 Fuel volume regulator control -
More informationCopyright 2002-2004 Triple S Customs
CHEVROLET SILVERADO 1988-2005 VEHICLE WIRING Copyright 2002-2004 Triple S Customs WIRING INFORMATION: 1988 Chevy Silverado Full-Size 2- POWER DOOR LOCK (5-wire reverse polarity) POWER DOOR UNLOCK (5-wire
More informationThe 2.3-ltr. V5 Engine
The 2.3-ltr. V5 Engine Design and Function Self-Study Programme No. 195 195_118 The new 2.3-ltr. V5 engine is related to the VR6 engine as regards design. For this reason this Self-Study Programme will
More informationThe 1.2 ltr. 3-cylinder petrol engines
Service. Self-Study Programme 260 The 1.2 ltr. 3-cylinder petrol engines Design and Function The two 1.2 ltr. engines mark the introduction of 3-cylinder petrol engines at Volkswagen. This pair of entry-level
More informationKEYLESS ENTRY UPGRADE SECURITY SYSTEM for 2004 TOYOTA HIGHLANDER
KEYLESS ENTRY UPGRADE SECURITY SYSTEM for 2004 TOYOTA HIGHLANDER DEALER SERVICE AND INSTALLATION MANUAL KIT NO. 00016-30915 Contents PARTS LIST... 2 PARTS ILLUSTRATIONS... 2 VEHICLE PREPARATION... 3 INSTALLING
More informationVehicle electrics in Polo Model Year 2002
Service. Self-Study Programme 265 Vehicle electrics in Polo Model Year 2002 265_061 The range of electrical systems in new vehicles is expanding increasingly as a result of the ever more effective safety
More informationEmission Control Systems Warranties
2004 Chevrolet TrailBlazer - 2WD Emission Control Systems Warranties This section outlines the emission warranties that General Motors provides for your vehicle in accordance with the U.S. Federal Clean
More informationCOVERING MILLIONS Preferred Protection Plan, a Service Group Company www.sgifs.com PO Box 26830, Austin, TX 78755-0800.
COVERING MILLIONS Preferred Protection Plan, a Service Group Company www.sgifs.com PO Box 26830, Austin, TX 78755-0800. 1-877-565-0816 PPP-308 0903 rev 0408 BENEFITS New and Pre-Owned Vehicles Preferred
More informationColour codes. Diagrams index
BMW - electrical systems - WIRING DIAGRAM Models covered : 3-Series (E30) 316 (83 to 88), 316i (88 to 91), 318i (83 to 91), 320i (87 to 91), 325i (87 to 91). Also Touring and Convertible versions of these
More informationHeating/Ventilation. As regards the heating and ventilation system in the Fabia, two equipment versions are available:
Heating/Ventilation SP 32_111 As regards the heating and ventilation system in the Fabia, two equipment versions are available: a heater unit an automatic heater/air conditioning unit. A recirculated air
More informationCooling system components, removing and installing
Page 1 of 30 19-1 Cooling system components, removing and installing Notes: When the engine is warm the cooling system is under pressure. If necessary release pressure before commencing repair work. Secure
More informationPUSH BUTTON START INSTALLATION MANUAL
PUSH BUTTON START INSTALLATION MANUAL ALTHOUGH THIS PRODUCT HAS BEEN THOROUGHLY TESTED KPIERSON TECHNOLOGIES ASSUMES NO RESPONSIBILITY FOR ANY DAMAGE THAT MAY RESULT BY THE INSTALLATION OF THIS PRODUCT.
More informationPower Door Locks Cruise Control System. Cigarette Lighter. Blower. Fan. Windshield Wiper System. See Note. High Wiper. Med. Low.
+ + Power Door Locks Cruise Control System Cigarette Lighter Power Windows Blower Fan Windshield Wiper System Clock Radio Rev. Light Switch See Note HVAC Side Marker Light Park/Turn Signal Low/High Beam
More informationThe Touareg Electrical System
Service. Self-Study Programme 298 The Touareg Electrical System Design and Function Vehicles with off-road capability are no longer just utility vehicles for a limited group of people. At all levels in
More informationWIRING HARNESS FOR AS635P4. BLUE PLUG RED, BLUE, BLACK, WHITE - Plug in dual stage sensor harness
WIRING HARNESS FOR AS635P4 ANTENNA NOT USED 5 PIN WHITE PLUG 2 PIN WHITE PLUG GREEN - PARKING BRAKE INPUT (-) BLUE - NOT USED 3 PIN BLUE PLUG RED, BLUE, BLACK, WHITE - Plug in dual stage sensor harness
More informationCIRCUIT DIAGRAMS GROUP 90 90-1 CONTENTS TAILLIGHT, POSITION LIGHT, REAR SIDE MAKER LIGHT, LICENSE PLATE LIGHT AND LIGHTING MONITOR TONE ALARM...
90-1 GROUP 90 DIAGRAMS CONTENTS HOW TO READ DIAGRAMS.................... 90-4 ETACS-ECU.................... 90-10............. 90-14 CENTRALIZED JUNCTION........ 90-19 POWER DISTRIBUTION SYSTEM.. 90-26
More informationBODY ELECTRICAL TOYOTA ELECTRICAL WIRING DIAGRAM WORKBOOK. ASSIGNMENT Version 1.8 WORKSHEETS. http://www.autoshop101.com
BODY ELECTRICAL ASSIGNMENT Version 1.8 WORKSHEETS TOYOTA ELECTRICAL WIRING DIAGRAM WORKBOOK http://www.autoshop101.com Developed by Kevin R. Sullivan All Rights Reserved TOYOTA Table of Contents Wiring
More informationCOMMON RAIL SYSTEM (CRS) SERVICE MANUAL: Operation
ISUZU ELF 4HK1/4JJ1 Engine COMMON RAIL SYSTEM (CRS) SERVICE MANUAL: Operation Issued : June 2007 Revised : July 2009 00400601EA 2009 DENSO CORPORATION All rights reserved. This material may not be reproduced
More informationPorsche Approved Certified Pre-Owned. Limited Warranty
Porsche Approved Certified Pre-Owned Limited Warranty Porsche Approved. A guaranteed mark of quality. At Porsche, we re committed to exceptional performance. The inherent reliability and longevity of
More informationHEATER, AIR CONDITIONING AND VENTILATION
55-1 GROUP 55 HEATER, AIR CONDITIONING AND VENTILATION CONTENTS GENERAL DESCRIPTION 55-2 HEATER AND AIR CONDITIONING SYSTEM 55-4 HEATER CONTROL 55-6 A/C-ECU 55-7 A/C COMPRESSOR 55-9 CONDENSER 55-9 DUCT
More informationAudi A4 No. 2/1. Standard Equipment. Wiring diagram. from 2002 m. y. Edition 08/01 W42.USA.5504.01.21. Main fuse
Audi A4 No. / Standard Equipment fm 00 m. y. Main fuse A97--00 Connector station E-box, plenum chamber 4 5 6 7 A97--048 4-Pin Relay Carrier w ith threaded connection A B C D E F 4 G H A97--045 Edition
More information2007 W-SERIES (CHEVROLET & GMC) N-SERIES (ISUZU) 250 NPR/W3500, NPR HD/W4500, NQR/W5500, NRR/W5500-HD Diesel Electrical Symbols
2007 W-SERIES (CHEVROLET & GMC) N-SERIES (ISUZU) 250 NPR/W3500, NPR HD/W4500, NQR/W5500, NRR/W5500-HD Diesel Electrical Symbols Symbol Meaning Symbol Meaning Symbol Meaning Fuse Electronic Parts Coil (Inductor),
More informationWiring diagram layout
Wiring diagram layout 3 30 Relay panel Indicated by grey area. 500 0,0 WIRING COLOR CODE 00 D/50,5 / T0a/ ws = white = black = red br = bwn gn = green bl = blue gr = grey li = lilac ge = yellow bl T 4e/
More informationTouareg Heating/air-conditioning system
Service. Self-Study Programme 301 Touareg Heating/air-conditioning system Design and function The automobile is accompanying people more and more in their recreational time. In addition to the pure transport
More informationGuide to the... Nissan Leaf. Completely harmless fun with. City Car Club 100% electric
Guide to the... Nissan Leaf Completely harmless fun with City Car Club 100% electric Contents 1. First arrival at the car 2. Starting the car 3. Basic controls 4. Getting the most from the battery 5. Finished
More informationTurbocharger system components, servicing
21-1 Turbocharger system components, servicing Engine codes: AAZ, 1Z, AHU Observe rules of cleanliness Page 21-10 Turbocharger hoses and lines, connecting Page 21-11 WARNING! Do not re-use any fasteners
More information510351 92970196 instruction rev 0.0 11/13/2012
INSTRUMENT LUSTER ISNET AESSORY NETOR INITION Sheet 2 FLOOR IMMER WIPER PA AS ROUN LEFT AN RIT AN ELETRI SPEEO ROUN ORN RELAY TURN SINAL PARIN BRAE NEUTRAL SAFETY EALIT BRAE RAIO IARETTE LITER BA UP INSTALLIN
More informationExtended Protection Plans for New and Pre-Owned Vehicles
Extended Protection Plans for New and Pre-Owned Vehicles Extended Protection you can count on from Old Republic Insured Automotive Services, Inc. (ORIAS) Your vehicle is a major investment. Next to your
More informationISUZU RODEO 1992-2003
ISUZU RODEO 1992-2003 VEHICLE WIRING Copyright 2002-2004 Triple S Customs WIRING INFORMATION: 1992 Isuzu Rodeo 12V CONSTANT WIRE BLACK Ignition Harness STARTER WIRE WHITE/BLUE OR BLACK/WHITE Ignition Harness
More informationHOW TO READ THE WIRING DIAGRAMS
A-1 HOW TO READ THE WIRING DIAGRAMS CONTENTS COMPOSITION AND CONTENTS OF WIRING DIAGRAMS... 2 HOW TO READ CONFIGURATION DIAGRAMS... 3 MARKING FOR CONNECTOR EARTHING... 6 WIRE COLOUR CODES... 9 ABBREVIATION
More information1R / 4-BUTTON SERIES
Button 1 1R / 4-BUTTON SERIES VEHICLE SECURITY SYSTEM Standard Features: Two 4-Button Remote Transmitters Status indicator (LED) Valet / override switch Multi-tone siren Dual stage impact detector Remote
More informationGUIDE. We are proud to introduce the first new release 2016! This release is named 2016.10.
We are proud to introduce the first new release 2016! This release is named 2016.10. The database is updated on totally 30 brands, for year models between 1998 and 2016. There are many reasons to keep
More informationThe Aftertreatment System Technician's Guide has been revised.
NUMBER: 2 ATS 07 S.M. REF.: Listed in Table 1 ENGINE: ATS DATE: April 2007 SUBJECT: UPDATES TO AFTERTREATMENT SYSTEM TROUBLESHOOTING PUBLICATION: 7SE63 The Aftertreatment System Technician's Guide has
More informationThe Phaeton Heating and Air Conditioning System
Service. Self-Study Programme 271 The Phaeton Heating and Air Conditioning System Design and Function An outstanding climate As a luxury performance saloon, the Phaeton is fitted with a four-zone cabin
More informationCDS TROUBLESHOOTING SECTION I. VACUUM. 1.0. Weak vacuum at wand. Gauge reads normal (10hg to 14hg)
CDS TROUBLESHOOTING SECTION I. VACUUM 1.0. Weak vacuum at wand. Gauge reads normal (10hg to 14hg) 1.1. Clogged hoses or wand tube. Disconnect hoses and carefully check for an obstruction. 1.2. Excessive
More information2003 ACCORD - Automatic Transmission Removal
2003 ACCORD - Automatic Transmission Removal Special Tools Required Engine support hanger, A and Reds AAR-T-12566 Engine hanger balancer bar VSB02C000019 Front subframe adapter VSB02C000016 These special
More informationModel 124 Relay and Control Modules Locations. 00-B.2a
00-B.2a Page No. Fig. No. K1/2 Overvoltage protection relay (87E/87L/30a, 9-pole) B.2/2 1 K2 Headlamp washer relay B.2/1 K3/1 Intake manifold preheater relay B.2/4 14 K5 Power seat relay B.2/1 K9 Auxiliary
More informationFAULT CODE READER OBD11 FOR PETROL ENGINES PART NO
FAULT CODE READER OBD11 FOR PETROL ENGINES PART NO 77004 HANDBOOK FAULT CODE READER FOR PETROL ENGINES with OBD11 INDEX Page 1. Introduction 4 2. Instructions 5 3. Common Terms 6 4. Precautions 6 5. Fault
More informationTHERMO KING TRUCK & TRAILER UNIT ALARM CODES THIS DOCUMENT SHOWS ALL CURRENT ALARM CODES FOR THERMO KING TRUCK AND TRAILER UNITS.
THERMO KING TRUCK & TRAILER UNIT ALARM CODES THIS DOCUMENT SHOWS ALL CURRENT ALARM CODES FOR THERMO KING TRUCK AND TRAILER UNITS. NOT ALL CODES ARE POSSIBLE ON ANY INDIVIDUAL UNIT. IF THE ALARM APPLIES
More informationElectrical Systems - IQAN Digital Control System. IQAN Control System Components... 5.1.3
Section 5.1 Electrical Systems - IQAN Digital Control System IQAN Control System Components........................... 5.1.3 IQAN Operational Description: At Machine Startup.....................................
More informationENGINE DIAGNOSTICS & CONTROL
ENGINE DIAGNOSTICS & CONTROL CONTROL SYSTEM WIRING DIAGRAM Page 1 Page 2 MONITORING SYSTEM AND CONTROL SYSTEM DEVICE RELATIONSHIP CHART : Applicable Component Input Battery Ignition switch A/C switch,
More informationHeating, Ventilation, Air Conditioning and Refrigeration (HVACR)
Heating, Ventilation, Air Conditioning and Refrigeration (HVACR) I. Demonstrate safety skills in typical HVACR work situations to NATE Core Installer Knowledge Areas for Technician Excellence for Safety
More informationRail 001 112 2 Canvas, folding top 001 101 3 Rear panel 001 102 4 Stip in window, left 001 106 dto. right 001 107
U 411 1 Rear view mirror, round, metall 13cm Ø 002 045 2 Raised airintake 002 060 3 Side panelling, front, left 002 030 Side panelling, front, right 002 031 4 Panelling left 002 051 dto. right 002 052
More informationThe Touran Electrical system
Service. Self-study programme 307 The Touran Electrical system Design and function The networking technology, used until now only in luxury class vehicles, will be a feature in compact vans, such as the
More informationEngine/Gearbox Combinations
Engine/Gearbox Combinations Engine code letters ARV/ATY AME ATZ Displacement 1.0 ltr. 1.4 ltr. 1.4 ltr. Power output 37 kw/50 HP 50 kw/68 HP 50 kw/68 HP Engine management system Simos 3PB Simos 3PB Simos
More informationMERCEDES FIRST EDITION - 2013
FIRST EDITION - 2013 CONTENTS Accessories... 1 Hydraulic Jacks Air Intake... 2 Air Filter Charger Charging System Intake Charger Hose Intake Manifold Intake Pipe Air Filter Intercooler Charger Aircondition...
More informationVAG VW AUDI SEAT SKODA
VAG VW AUDI SEAT SKODA Diagnostic Trouble Code (DTC) Definitions The following Diagnostic Trouble Code (DTC) definitions lists provide both VAG and SAE (OBD-II) trouble codes. For codes not listed in this
More information2003/2004/2005 TOYOTA COROLLA
2003/2004/2005 TOYOTA COROLLA KEYLESS ENTRY UPGRADE SECURITY SYSTEM INSTALLATION INSTRUCTIONS KIT NO. 00016-30120 SPECIAL NOTE: Installation Sequences After TMS and Safety mandated preparatory steps have
More informationIntroduction to Electronic Signals
Introduction to Electronic Signals Oscilloscope An oscilloscope displays voltage changes over time. Use an oscilloscope to view analog and digital signals when required during circuit diagnosis. Fig. 6-01
More informationLeft Hand Limit Switch. Housing. Left Hand. Connections. Motor Connector BROWN PURPLE GRAY BLACK DARK BLUE BLACK BROWN BROWN LIGHT BLUE.
LIGHT BLUE GRAY PURPLE Circuit Breaker Intput Circuit Breaker Output #1 Relay Left Hand Limit Switch Housing Left Hand Motor Connector Right Hand Limit Switch on Radiator Support Right Hand Limit Switch
More informationDiagnosing and Understanding Starting Problems on the ZR-1 Marc Haibeck 28-Sep-13
Diagnosing and Understanding Starting Problems on the ZR-1 Marc Haibeck 28-Sep-13 There are three basic failure conditions: - A VATS security system lockout - A click from the starter solenoid but no engine
More informationBODY ELECTRICAL MAZDA
BODY ELECTRICAL ASSIGNMENT WORKSHEETS Version 1.3 MAZDA ELECTRICAL WIRING DIAGRAM WORKBOOK http://www.autoshop101.com Developed by Kevin R. Sullivan All rights reserved. MAZDA Table of Contents Wiring
More informationHONDA ACCORD 1985-2005
HONDA ACCORD 1985-2005 VEHICLE WIRING Copyright 2002-2004 Triple S Customs WIRING INFORMATION: 1985 Honda Accord WIRE WIRE COLOR WIRE LOCATION 12V CONSTANT WHITE or WHITE/BLACK Ignition Harness STARTER
More information4 Star 4 Star Plus. Vehicle
4 Star 4 Star Plus Vehicle Service Contracts WARRANTY SOLUTIONS Experience you can rely on Throughout our history, Warranty Solutions has demonstrated strength and versatility while evolving through ever-changing
More informationINSTRUMENT PANEL. 1995 Volvo 850 DESCRIPTION & OPERATION. 1995-96 ACCESSORIES & EQUIPMENT Volvo Instrument Panels
INSTRUMENT PANEL 1995 Volvo 850 1995-96 ACCESSORIES & EQUIPMENT Volvo Instrument Panels 850 WARNING: When working around steering column and before performing repairs, disconnect and shield battery ground
More informationBasic manual: Contents ELECTRONICALLY CONTROLLED HYDRAULIC SYSTEMS
TECHNICAL NOTE Edition Anglaise 77 11 205 445 JUNE 1999 Type 3239A Service 0422 Sub-section JE0 X BOSCH 5.3 ABS WITH SPEED INFORMATION FUNCTION Engine: Gearbox: XXX XXX Basic manual: N.T. 3034A This note
More informationMAKE OF AUTOMOBILE: NUMBER : 076/0800901 DATE : 2008-12-08 Copyright Prins Autogassystemen B.V. 2008 VERSION NR : 2008-10-24 B
MAKE OF AUTOMOBILE: HONDA TYPE: CIVIC PISTON DISPLACEMENT: 1800 NUMBER OF VALVES: 16 ENGINE NUMBER: R18A TYPE VSI INJECTOR ( COLOR ) ORANGE MODEL YEAR: 2008 ENGINE SET NUMBER 348/0250200.07 NUMBER : 076/0800901
More informationThe 02E Direct Shift Gearbox Design and Function
The 02E Direct Shift Gearbox Design and Function Self-Study Program Course Number 851403 Volkswagen of America, Inc. Service Training Printed in U.S.A. Printed 05/2004 Course Number 851403 2004 Volkswagen
More informationUDOT RPMS VEHICLE RECORDS, PREVENTIVE MAINTENANCE & SURVEILLANCE
UDOT RPMS VEHICLE RECORDS, PREVENTIVE MAINTENANCE & SURVEILLANCE VEHICLE RECORDS AND PREVENTIVE MAINTENANCE Prepared by: UTAH DEPARTMENT OF TRANSPORTATION OFFICE OF PLANNING AND PROGRAMMING IN COOPERATION
More informationhttp://waterheatertimer.org/how-to-troubleshoot-gas-water-heater.html
http://waterheatertimer.org/how-to-troubleshoot-gas-water-heater.html TECHNICAL SERVICE DEPARTMENT Effective October 2007, we transitioned to the White Rodgers (Intelli-Vent TM )Thermostat Control for
More informationElectrical System From The Top Down By Rick Denney, GMC Eastern States April 2006
GMC Motorhome Electrical System From The Top Down By Rick Denney, GMC Eastern States April 2006 The electrical system of the GMC is fairly simple when considered as a system, but it s easy to get lost
More informationThe Crafter Electrical system
Service Training Self-study Programme 370 Commercial Vehicles The Crafter Electrical system Design and function Innovations in automotive engineering are also taking place in the commercial vehicle segment.
More informationILISC515-A Shift Interlock (Manual Lift Door) 2015 Ford Transit, 3.7L and 3.5L
An ISO 9001:2008 Registered Company ILISC515-A Shift Interlock (Manual Lift Door) 2015 Ford Transit, 3.7L and 3.5L Introduction The ILISC515-A is a microprocessor driven system for controlling wheelchair
More informationAssembly overview - fuel tank
Assembly overview - fuel tank vw-wi://rl/n.en-gb.k02589829.wi::33090894.xml?xsl=3 Page 1 of 2 Assembly overview - fuel tank 1 - Fuel tank 2 - Sleeve When removing, support using engine and gearbox jack
More informationExclusively Marketed by Anthola Pte Ltd & Singapore Insurance & Credit LLP (Supported by Lonpac Insurance SIngapore) Copyright 2012 AIC
Exclusively Marketed by Anthola Pte Ltd & Singapore Insurance & Credit LLP (Supported by Lonpac Insurance SIngapore) Copyright 2012 AIC Agenda 1 2 3 4 5 6 7 Executive Summary Who are we? What are Singapore
More information