COMPLETELY MIXED ACTIVATED SLUDGE PROCESS

Save this PDF as:
 WORD  PNG  TXT  JPG

Size: px
Start display at page:

Download "COMPLETELY MIXED ACTIVATED SLUDGE PROCESS"

Transcription

1 ACTIVATED SLUDGE PROCESS SCHEMATICS COMPLETELY MIXED ACTIVATED SLUDGE PROCESS Primary Settler Aeration Basin (CSTR) Secondary Settler Primary Sludge Return Activated Sludge (RAS) Advantages 1. Allows good nitrification since COD is uniformly low 2. Able to handle peak loads and dilute toxic substances 3. Used in smaller systems, like package plants 1. Larger volume, high aeration costs 2. Not much operational flexibility 3. Associated with biomass instabilities like sludge bulking 1

2 CONVENTIONAL DISPERSED PLUG FLOW ACTIVATED SLUDGE PROCESS Primary Settler Aeration Basin (L:W ~ 5) Secondary Settler Primary Sludge Return Activated Sludge (RAS) STEP FEED MODIFICATION Primary Sludge Return Activated Sludge (RAS) 2

3 Advantages of Conventional Dispersed Plug Flow Process 1. Allows smaller volume than CSTR 2. Flexible operation, zone aeration, step feeding options, accommodates anoxic and aerobic processes with single biomass for biological nutrient removal 3. Less aeration than CSTR 4. Reduced mixing requirement, per unit reactor volume 5. Better settling characteristics 1. High oxygen demand in inlet zone mitigated by step feeding 2. May not buffer peak loads as well as CSTR, although less likely in activated sludge with high biomass 3. Higher construction costs due to serpentine flow in baffled reactor. 3

4 Stabilization Tank CONTACT STABILIZATION ACTIVATED SLUDGE Primary Settler Secondary Settler Contact Tank Primary Sludge Return Activated Sludge (RAS) Advantages 1. Reduced aeration requirement with short contact tank residence time 2. Reportedly better settling sludge 1. Complex operation 2. Possible reduced treatment for soluble contaminants in contact tank 3. Reduced ammonia removal 4

5 HIGH PURITY OXYGEN ACTIVATED SLUDGE Primary Settler O 2 Aeration Basin (covered for O 2 recirculation) Secondary Settler Primary Sludge Return Activated Sludge (RAS) Advantages 1. Five times oxygen transfer rate over air 2. Smaller volume 3. Higher biomass concentration possible, but limited by secondary settler capacity 1. Very expensive: covered tanks, high energy cost for O 2 generation, gas recirculation equipment 2. Headspace CO 2 accumulation and associated ph drop requires alkalinity addition 3. No flexibility (all aerobic processes) 4. Nitrification is problematic low ph, short HRT produces high biomass at short SRT 5. Settling problems have been reported 5

6 OXIDATION DITCH (EXTENDED AERATION) ACTIVATED SLUDGE PROCESS Oxidation Ditch Reactor Brush Aerator Secondary Settler Treated Effluent Influent Return Activated Sludge Brush Aerator 6

7 Advantages of Extended Aeration Oxidation Ditch 1. Typically small systems less than 2 MGD (5 m 3 /min) 2. Flexible operation with placement and use of aerators can be used for nutrient removal 3. Very stable process 4. No primary clarifier simpler sludge handling 5. Good settling characteristics 1. Long aeration time, larger reactor. Typical HRT > 24 hr. 2. Higher aeration requirement due to typically long SRT 3. Mechanical aeration equipment (rotors, large turbines)required to move water around the channel as well as aerate. Can create zones of high oxygen and add maintenance costs. More recent designs use diffusers for aeration and reduce mechanical requirement. 7

8 SEQUENCING BATCH REACTOR (SBR) ACTIVATED SLUDGE PROCESS REACT Influent Mechanical Floating Weir FILL SETTLE DECANT TREATED WASTEWATER 8

9 Advantages of Sequencing Batch Reactor (SBR) Process 1. Single tank for reaction and settling (requires two or more tanks for continuous operation 2. Good settling (quiescent conditions) and no sludge storage 3. Flexible operation, automation possible 4. Typically for smaller plants 5. Often no primary clarifier easier sludge handling 1. Special decanting and aeration equipment (can t use diffusers in tank) 2. Need to recycle early decant if solids in weir trough 3. Setting system sequences (fill/decant/reaction times) can be complex, especially if anoxic denitrification is required 9

10 MICROFILTER MEMBRANE BIOREACTOR (MMBR) Primary Settler Aeration Basin Hollow Fiber Microfiltration Membrane Cassette Advantages 1. No secondary clarifier, virtually no effluent suspended solids, no RAS recycling 2. Maintains high MLVSS 3. Compact footprint 4. Primary clarifier optional 1. Very high aeration requirements 2. Dual aeration system for mixing and to prevent fouling 3. Time-consuming membrane cleaning procedure 4. High capital costs for membrane system 5. Extra power requirements for vacuum on microfilter 6. Waste activated sludge is not thickened larger volume to solids processing 7. Broken membranes result in low effluent quality 10

Completely Mixed Activated Sludge (CMAS) Bioreactor Design Equations

Completely Mixed Activated Sludge (CMAS) Bioreactor Design Equations ompletely Mixed Activated Sludge (MAS) Bioreactor Design Equations Secondary larifier (Q-Q W ), S, X e Q, S O (Q+Q r ), S, X X, S, V Aeration Tank Q r, X r, S Return Activated Sludge (RAS) Q W, X r, S

More information

ADVANCED LAGOON TREATMENT TECHNOLOGIES FOR WASTEWATER TREATMENT

ADVANCED LAGOON TREATMENT TECHNOLOGIES FOR WASTEWATER TREATMENT ADVANCED LAGOON TREATMENT TECHNOLOGIES FOR WASTEWATER TREATMENT ABSTRACT by Vikram M Pattarkine*, Randall C Chann**, Charles E Tharp** *Brinjac Engineering Inc, 114 North 2 nd Street, Harrisburg, PA 1711

More information

Module 16: The Activated Sludge Process - Part II Instructor Guide Answer Key

Module 16: The Activated Sludge Process - Part II Instructor Guide Answer Key Unit 1 Process Control Strategies Exercise Module 16: The Activated Sludge Process - Part II Instructor Guide Answer Key 1. What are the six key monitoring points within the activated sludge process? Ans:

More information

OPTIMIZING BIOLOGICAL PHOSPHORUS REMOVAL FROM AN SBR SYSTEM MIDDLEBURY, VT. Paul Klebs, Senior Applications Engineer Aqua-Aerobic Systems, Inc.

OPTIMIZING BIOLOGICAL PHOSPHORUS REMOVAL FROM AN SBR SYSTEM MIDDLEBURY, VT. Paul Klebs, Senior Applications Engineer Aqua-Aerobic Systems, Inc. OPTIMIZING BIOLOGICAL PHOSPHORUS REMOVAL FROM AN SBR SYSTEM ABSTRACT MIDDLEBURY, VT Paul Klebs, Senior Applications Engineer Aqua-Aerobic Systems, Inc. The Middlebury Wastwater Treatment Plant, located

More information

Module 17: The Activated Sludge Process Part III

Module 17: The Activated Sludge Process Part III Wastewater Treatment Plant Operator Certification Training Module 17: The Activated Sludge Process Part III Revised October 2014 This course includes content developed by the Pennsylvania Department of

More information

1.85 WATER AND WASTEWATER TREATMENT ENGINEERING FINAL EXAM DECEMBER 20, 2005

1.85 WATER AND WASTEWATER TREATMENT ENGINEERING FINAL EXAM DECEMBER 20, 2005 1.85 WATER AND WASTEWATER TREATMENT ENGINEERING FINAL EXAM DECEMBER 20, 2005 This is an open-book exam. You are free to use your textbook, lecture notes, homework, and other sources other than the internet.

More information

CHAPTER 8 UPGRADING EXISTING TREATMENT FACILITIES

CHAPTER 8 UPGRADING EXISTING TREATMENT FACILITIES CHAPTER 8 UPGRADING EXISTING TREATMENT FACILITIES 8-1. General. Upgrading of wastewater treatment plants may be required to handle increased hydraulic and organic loadings to meet existing effluent quality

More information

Wastewater Nutrient Removal

Wastewater Nutrient Removal Wastewater Nutrient Removal An overview of phosphorus and nitrogen removal strategies Presented by: William E. Brown, P.E. Peter C. Atherton, P.E. Why are nutrients an issue in the environment? Stimulates

More information

Advanced Wastewater Treatment and Disposal Systems. Water and Wastewater Utility Operation and

Advanced Wastewater Treatment and Disposal Systems. Water and Wastewater Utility Operation and Advanced Wastewater Treatment and Disposal Systems Water and Wastewater Utility Operation and Management for Tribes Preliminary Treatment Primary Treatment Secondary Treatment Tertiary Treatment Disinfection

More information

Appendix 2-1. Sewage Treatment Process Options

Appendix 2-1. Sewage Treatment Process Options Appendix 2-1 Sewage Treatment Process Options Table of Contents Appendix 2-1 Sewage Treatment Process Options 1 Introduction...1 2 Chemically Enhanced Primary Treatment (CEPT) Processes...2 2.1 CEPT with

More information

Penrith Wastewater Treatment Plant

Penrith Wastewater Treatment Plant Penrith Wastewater Treatment Plant Treating wastewater at Penrith Wastewater Treatment Plant Wastewater that comes into a wastewater treatment plant is about 99% water and about one percent solids and

More information

Experts Review of Aerobic Treatment Unit Operation and Maintenance. Bruce Lesikar Texas AgriLife Extension Service

Experts Review of Aerobic Treatment Unit Operation and Maintenance. Bruce Lesikar Texas AgriLife Extension Service Experts Review of Aerobic Treatment Unit Operation and Maintenance Bruce Lesikar Texas AgriLife Extension Service Overview Overview of Aerobic Treatment Units Installing for accessibility to system components

More information

Activated Sludge Treatment and SBRs ATUs

Activated Sludge Treatment and SBRs ATUs Activated Sludge Treatment and SBRs ATUs Pre-class questions Name 4 components necessary to have an activated sludge system for wastewater treatment. Aeration tank Sludge recycle Clarification tank Oxygen

More information

Biological Nutrient Removal

Biological Nutrient Removal 1 Biological Nutrient Removal Activated Sludge Process Flow Diagram Influent Basin Clarifier Effluent Mixed Liquor Suspended Solids - MLSS ( bugs eat the crap and grow to make more bugs) Return Activated

More information

Biological Wastewater Treatment

Biological Wastewater Treatment Biological Wastewater Treatment This article briefly discusses the differences between aerobic and anaerobic biological treatment processes and subsequently focuses on select aerobic biological treatment

More information

Activated Sludge Design, Startup, Operation, Monitoring and Troubleshooting

Activated Sludge Design, Startup, Operation, Monitoring and Troubleshooting Activated Sludge Design, Startup, Operation, Monitoring and Troubleshooting Ohio Water Environment Association Plant Operations Workshop Columbus, Ohio September 1, 2010 Phil Anderson Operations Specialist

More information

Water Technologies. Davco Field-Erected Wastewater Treatment Systems

Water Technologies. Davco Field-Erected Wastewater Treatment Systems Water Technologies Davco Field-Erected Wastewater Treatment Systems Concept to Completion The Comprehensive Treatment Solution Biological Nutrient Removal Process 2 mgd Installation in Florida MUNICIPAL

More information

MEMBRANE TECHNOLOGY TREATING OILY WASTEWATER FOR REUSE

MEMBRANE TECHNOLOGY TREATING OILY WASTEWATER FOR REUSE MEMBRANE TECHNOLOGY TREATING OILY WASTEWATER FOR REUSE Jeff Peeters, P.Eng. ZENON Environmental Inc. SAWEA 2005 Workshop Al-Khobar Holiday Inn Hotel, Saudi Arabia November 29, 2005 Presentation outline

More information

Questionnaire: Operation of Wastewater Treatment Plants

Questionnaire: Operation of Wastewater Treatment Plants This questionnaire has been designed by a work team of the Technological Center CARTIF to obtain information about the wastewater treatment plant in the field of the project - Development of tools and

More information

TABLE OF CONTENTS 2. PHOSPHORUS AND NITROGEN IN WASTEWATER 3. PHOSPHORUS AND NITROGEN REMOVAL MECHANISM 4. PROCESS REQUIREMENT AND CONTROL FACTOR

TABLE OF CONTENTS 2. PHOSPHORUS AND NITROGEN IN WASTEWATER 3. PHOSPHORUS AND NITROGEN REMOVAL MECHANISM 4. PROCESS REQUIREMENT AND CONTROL FACTOR TABLE OF CONTENTS Submittal 1. INTRODUCTION 2. PHOSPHORUS AND NITROGEN IN WASTEWATER 3. PHOSPHORUS AND NITROGEN REMOVAL MECHANISM 3.1 Chemical Phosphorus Removal 3.2 Biological Phosphorus Removal 3.2.1

More information

SMALL COMMUNITY TREATMENT PLANT EXPANSION WHILE IN OPERATION USING ADVANCED TECHNOLOGY

SMALL COMMUNITY TREATMENT PLANT EXPANSION WHILE IN OPERATION USING ADVANCED TECHNOLOGY SMALL COMMUNITY TREATMENT PLANT EXPANSION WHILE IN OPERATION USING ADVANCED TECHNOLOGY Adel Bassyouni, HDR Engineering, Guillermo Garcia, HDR Engineering, Don Mc Dermott, Viejas Public Works Department

More information

Nutrient Removal at Wastewater Treatment Facilities. Nitrogen and Phosphorus. Gary M. Grey HydroQual, Inc. ggrey@hydroqual.com 201 529 5151 X 7167

Nutrient Removal at Wastewater Treatment Facilities. Nitrogen and Phosphorus. Gary M. Grey HydroQual, Inc. ggrey@hydroqual.com 201 529 5151 X 7167 Nutrient Removal at Wastewater Treatment Facilities Nitrogen and Phosphorus Gary M. Grey HydroQual, Inc. ggrey@hydroqual.com 201 529 5151 X 7167 1 Agenda Nitrification and Denitrification Fundamentals

More information

Bio-P Removal- Principles and examples in MI and elsewhere S. Joh Kang, Ph.D., P.E. Tetra Tech, Inc. Ann Arbor, MI 2010 Presentation Outline Optimization of Chemicals and Energy Bio-P Removal - Review

More information

Department of Civil Engineering-I.I.T. Delhi CEL 212: Environmental Engineering

Department of Civil Engineering-I.I.T. Delhi CEL 212: Environmental Engineering Department of Civil Engineering-I.I.T. Delhi CEL 212: Environmental Engineering Q1. An anaerobic reactor, operated at 35 o C, treats wastewater with a flow of 2000m 3 /d and a biological soluble COD (bscod)

More information

TECHNOLOGY DETAIL FACT SHEET: Biological Aerated Filter (BAF)

TECHNOLOGY DETAIL FACT SHEET: Biological Aerated Filter (BAF) TECHNOLOGY DETAIL FACT SHEET: Biological Aerated Filter (BAF) DESCRIPTION In the BAF process, wastewater flows upwards through tanks (called cells) that are filled with media. The media within the filter

More information

Producing Energy, Not Biosolids, Through Anaerobic Domestic Wastewater Treatment

Producing Energy, Not Biosolids, Through Anaerobic Domestic Wastewater Treatment Producing Energy, Not Biosolids, Through Anaerobic Domestic Wastewater Treatment Perry L. McCarty, Jaeho Bae, Jeonghwon Kim, Po-Heng Lee Inha University, South Korea Stanford University, USA INHA University,

More information

Example: 2. Solution. Provide depth D = 1.5 m. Sewage flow = 10000 x 170 x 0.80 x 10-3 = 1360 m 3 /d. Now, 0.182(1+. = 1.562. Q L = 2.

Example: 2. Solution. Provide depth D = 1.5 m. Sewage flow = 10000 x 170 x 0.80 x 10-3 = 1360 m 3 /d. Now, 0.182(1+. = 1.562. Q L = 2. Example: 2 Design low rate trickling filter for secondary treatment of sewage generated from 10000 persons with rate of water supply 170 LPCD. The BOD 5 after primary treatment is 110 mg/l and BOD 5 of

More information

ANAEROBIC DIGESTION OF SEWAGE SLUDGE USING THE ANOXIC GAS FLOTATION (AGF) PROCESS

ANAEROBIC DIGESTION OF SEWAGE SLUDGE USING THE ANOXIC GAS FLOTATION (AGF) PROCESS ANAEROBIC DIGESTION OF SEWAGE SLUDGE USING THE ANOXIC GAS FLOTATION (AGF) PROCESS Dennis A. Burke Cyclus Envirosystems, 6007 Hill Road NE, Olympia, WA 98516-9551 ABSTRACT The AGF (Anoxic Gas Flotation)

More information

Retrofitting an Aeration Basin with Anoxic Zone to Reduce Operations Cost and Improve Performance

Retrofitting an Aeration Basin with Anoxic Zone to Reduce Operations Cost and Improve Performance Retrofitting an Aeration Basin with Anoxic Zone to Reduce Operations Cost and Improve Performance Ed Griffenberg, Operations Specialist HDR Engineering, Edmonds, WA 2012 PNCWA Conference, Boise, Idaho Case

More information

Waste Water Treatment Process

Waste Water Treatment Process Waste Water Treatment Process INCLINED SCREW PUMPS The raw influent flows into a wet well where it is carried up nearly thirty feet by one of two inclined screw pumps. The 78-inch diameter screw pumps

More information

MODELING WASTEWATER AERATION SYSTEMS TO DISCOVER ENERGY SAVINGS OPPORTUNITIES By Steven A. Bolles Process Energy Services, LLC

MODELING WASTEWATER AERATION SYSTEMS TO DISCOVER ENERGY SAVINGS OPPORTUNITIES By Steven A. Bolles Process Energy Services, LLC Introduction MODELING WASTEWATER AERATION SYSTEMS TO DISCOVER ENERGY SAVINGS OPPORTUNITIES By Steven A. Bolles Process Energy Services, LLC Aeration systems for conventional wastewater activated sludge

More information

Membrane Bioreactor Performance Compared to Conventional Wastewater Treatment

Membrane Bioreactor Performance Compared to Conventional Wastewater Treatment Technical Paper Membrane Bioreactor Performance Compared to Conventional Wastewater Treatment Authors: Thomas C. Schwartz and Brent R. Herring, Woodard and Curran Incorporated Ricardo Bernal and Janet

More information

Natural and Advanced Treatment Systems for Wastewater Management at Municipal Solid Waste Disposal Site in Developing Countries

Natural and Advanced Treatment Systems for Wastewater Management at Municipal Solid Waste Disposal Site in Developing Countries Natural and Advanced Treatment Systems for Wastewater Management at Municipal Solid Waste Disposal Site in Developing Countries C. Chiemchaisri Department of Environmental Engineering, Kasetsart University

More information

SECONDARY TREATMENT ACTIVATED SLUDGE

SECONDARY TREATMENT ACTIVATED SLUDGE SECONDARY TREATMENT ACTIVATED SLUDGE Activated sludge is another biological process used to remove organics from wastewater. Like the trickling filter, activated sludge processes are used to grow a biomass

More information

WASTE WATER TREATMENT SYSTEM (OPERATING MANUALS )

WASTE WATER TREATMENT SYSTEM (OPERATING MANUALS ) Page 1 of 76 1.0 PURPOSE The purpose of the Wastewater Treatment System is to remove contaminates from plant wastewater so that it may be sent to the Final Plant Effluent Tank and eventually discharged

More information

Optimized Nutrient Removal in Waste Water Treatment Plants

Optimized Nutrient Removal in Waste Water Treatment Plants Optimized Nutrient Removal in Waste Water Treatment Plants Activated Return Sludge Process Sille Bendix Larsen, Jeanne Agertved Madsen & Gert Petersen EnviDan East A/S Copenhagen, Denmark sbl@envidan.dk

More information

INVESTIGATION OF OXIDATION DITCH PERFORMANCE IN lxeatment OF DOMESTIC WASTEWATER. Edward C. Fiss, Jr. Robert M. Stein George P.

INVESTIGATION OF OXIDATION DITCH PERFORMANCE IN lxeatment OF DOMESTIC WASTEWATER. Edward C. Fiss, Jr. Robert M. Stein George P. INVESTIGATION OF OXIDATION DITCH PERFORMANCE IN lxeatment OF DOMESTIC WASTEWATER Edward C. Fiss, Jr. Robert M. Stein George P. lptan AWARE Environmental Inc. 9305 Monroe Road, Suite J Charlotte, North

More information

Holistic Aeration and Chemical Optimization Saves Big Money from 1 MGD to 600 MGD. Trevor Ghylin, PE PhD

Holistic Aeration and Chemical Optimization Saves Big Money from 1 MGD to 600 MGD. Trevor Ghylin, PE PhD Holistic Aeration and Chemical Optimization Saves Big Money from 1 MGD to 600 MGD Trevor Ghylin, PE PhD Outline Background Case Study: Sterno, Sweden (~1.8 MGD) 65% Aeration Energy Reduction Case Study:

More information

Aerobic Digestion, or, It s a Bug eat Bug World. Brett Ward Municipal Technical Advisory Service The University of Tennessee

Aerobic Digestion, or, It s a Bug eat Bug World. Brett Ward Municipal Technical Advisory Service The University of Tennessee Aerobic Digestion, or, It s a Bug eat Bug World Brett Ward Municipal Technical Advisory Service The University of Tennessee Aerobic Digestion Continuation of the Activated Sludge Process Super Extended

More information

SMBR Process with Peenox Floating Media

SMBR Process with Peenox Floating Media SMBR Process with Peenox Floating Media Fixed-film fluidized media reactor Media added to the bioreactor Retaining screen A simple screen retains the media in the bioreactor The media is fluidized by air

More information

MBR. Challenge and a new approach

MBR. Challenge and a new approach MBR Wastewater treatment plants Wastewater treatment plants Challenge and a new approach - Sensitive area - Highly developed tourist destination - During summer, population increases even 5 times - Great

More information

A NOVEL ION-EXCHANGE/ELECTROCHEMICAL TECHNOLOGY FOR THE TREATMENT OF AMMONIA IN WASTEWATER

A NOVEL ION-EXCHANGE/ELECTROCHEMICAL TECHNOLOGY FOR THE TREATMENT OF AMMONIA IN WASTEWATER A NOVEL ION-EXCHANGE/ELECTROCHEMICAL TECHNOLOGY FOR THE TREATMENT OF AMMONIA IN WASTEWATER ABSTRACT Leonard P. Seed, M.Sc., P.Eng., Enpar Technologies Inc. * Daren D. Yetman, A.Sc.T., Enpar Technologies

More information

Treatment and Biosolids Technologies. City of Morro Bay New Water Reclamation Facility

Treatment and Biosolids Technologies. City of Morro Bay New Water Reclamation Facility Treatment and Biosolids Technologies City of Morro Bay New Water Reclamation Facility Engineering Component of Siting Study Project engineering team will look at the following parameters related to each

More information

Phosphorus Removal. Wastewater Treatment

Phosphorus Removal. Wastewater Treatment Phosphorus Removal In Wastewater Treatment by Derek Shires (512) 940-2393 Derek.Shires@ett-inc.com Why do we care? Eutrophication of surface water - Especially reservoirs Maximum agronomic uptake - Limiting

More information

NUTRIENT REMOVAL WASTEWATER TREATMENT CLIFFORD W. RANDALL, PHD EMERITUS PROFESSOR VIRGINIA TECH

NUTRIENT REMOVAL WASTEWATER TREATMENT CLIFFORD W. RANDALL, PHD EMERITUS PROFESSOR VIRGINIA TECH NUTRIENT REMOVAL WASTEWATER TREATMENT CLIFFORD W. RANDALL, PHD EMERITUS PROFESSOR VIRGINIA TECH The Impacts of Excess Nutrients Nitrogen and Phosphorus Are the nutrients that cause over fertilization of

More information

TRIAL OPERATION OF A SELECTOR AT THE NORTHPEST WASTEWATER TREATMENT PLANT 1

TRIAL OPERATION OF A SELECTOR AT THE NORTHPEST WASTEWATER TREATMENT PLANT 1 PERIODICA POLYTECHNICA SER. CHEM. ENG. VOL. 45, NO. 1, PP. 41 52 (21) TRIAL OPERATION OF A SELECTOR AT THE NORTHPEST WASTEWATER TREATMENT PLANT 1 Andrea JOBBÁGY, Ferenc FARKAS,GY. GARAI, Béla SEVELLA and

More information

PRIMARY TREATMENT PRIMARY CLARIFIERS

PRIMARY TREATMENT PRIMARY CLARIFIERS PRIMARY TREATMENT Primary treatment is the next step in the wastewater treatment process. Pretreatment removed the rags and inorganic grit. Primary treatment will remove the majority of the suspended solids

More information

Description of the Water Conserv I Facility

Description of the Water Conserv I Facility Description of the Water Conserv I Facility Introduction The Water Conserv I (WCI) facility has a design capacity of 7.5 mgd and is classified by FDEP as a Class A, Level 1 treatment plant. The facility

More information

Best Practice Guide NO. BPGCS002. Wastewater Treatment Activated Sludge Process

Best Practice Guide NO. BPGCS002. Wastewater Treatment Activated Sludge Process Best Practice Guide NO. BPGCS002 Wastewater Treatment Activated Sludge Process The following is intended to provide a first check for those involved in the operation, management and monitoring of the activated

More information

Engineers Edge, LLC PDH & Professional Training

Engineers Edge, LLC PDH & Professional Training 510 N. Crosslane Rd. Monroe, Georgia 30656 (770) 266-6915 fax (678) 643-1758 Engineers Edge, LLC PDH & Professional Training Copyright, All Rights Reserved Engineers Edge, LLC An Introduction to Advanced

More information

WASTEWATER TREATMENT OBJECTIVES

WASTEWATER TREATMENT OBJECTIVES WASTEWATER TREATMENT OBJECTIVES The student will do the following: 1. Define wastewater and list components of wastewater. 2. Describe the function of a wastewater treatment plant. 3. Create a wastewater

More information

During the past decade, the city of

During the past decade, the city of An Advanced Pollution Control Facility s Conversion to Four-Stage Bardenpho to Improve Biological Nitrogen Removal Timur Deniz, Thomas W. Friedrich, and John Milligan During the past decade, the city of

More information

THE MARSHALL STREET ADVANCED POLLUTION CONTROL FACILITY (CLEARWATER, FLORIDA) CONVERSION TO 4-STAGE BARDENPHO TO IMPROVE BIOLOGICAL NITROGEN REMOVAL

THE MARSHALL STREET ADVANCED POLLUTION CONTROL FACILITY (CLEARWATER, FLORIDA) CONVERSION TO 4-STAGE BARDENPHO TO IMPROVE BIOLOGICAL NITROGEN REMOVAL THE MARSHALL STREET ADVANCED POLLUTION CONTROL FACILITY (CLEARWATER, FLORIDA) CONVERSION TO 4-STAGE BARDENPHO TO IMPROVE BIOLOGICAL NITROGEN REMOVAL ABSTRACT Timur Deniz, Ph.D., Thomas W. Friedrich, P.E.

More information

Small Wastewater Treatment Systems

Small Wastewater Treatment Systems Small Wastewater Treatment Systems By Michael Albanese, P.Eng. H2FLOW EQUIPMENT INC. www.h2flow.com Why do you need one? Typical Reasons Enviromental Regulations New Development Failing Septic Systems

More information

PULP AND PAPER MAKING WASTES, TREATMENT AND ENVIRONMENTAL EFFECTS

PULP AND PAPER MAKING WASTES, TREATMENT AND ENVIRONMENTAL EFFECTS PULP AND PAPER MAKING WASTES, TREATMENT AND ENVIRONMENTAL EFFECTS BIOPROA Departamento de Ingeniería de Reactores Liliana Borzacconi María Noel Cabrera Facultad de Ingeniería Universidad de la República

More information

2015 YEAR END REPORT WATER/WASTEWATER TREATMENT PLANTS

2015 YEAR END REPORT WATER/WASTEWATER TREATMENT PLANTS 2015 YEAR END REPORT WATER/WASTEWATER TREATMENT PLANTS Madison s water and wastewater treatment operations specialists are highly trained professionals who strive to give the citizens of Madison the best

More information

Energy Savings with High Rate Aeration

Energy Savings with High Rate Aeration 87th OWEA Annual Conference, Mason, OH, Wednesday, June 19, 2013 Energy Savings with High Rate Aeration Mark R. Greene, Ph.D. Senior Technical Director O Brien & Gere 87th OWEA Annual Conference Today

More information

Alkalinity Profiling in Wastewater Operations. OPS Challenge Laboratory Event 2015 Description and Procedure. Alkalinity Defined.

Alkalinity Profiling in Wastewater Operations. OPS Challenge Laboratory Event 2015 Description and Procedure. Alkalinity Defined. Alkalinity Profiling in Wastewater Operations OPS Challenge Laboratory Event 2015 Description and Procedure The purpose of this competition will be to familiarize participating teams to the definition

More information

Operation and Maintenance of Onsite Waster Systems in Maryland. A growing challenge for the industry and regulators

Operation and Maintenance of Onsite Waster Systems in Maryland. A growing challenge for the industry and regulators Operation and Maintenance of Onsite Waster Systems in Maryland A growing challenge for the industry and regulators Operation and Maintenance of Onsite Waster Systems in Maryland New law and regulations

More information

Sewerage Management System for Reduction of River Pollution

Sewerage Management System for Reduction of River Pollution Sewerage Management System for Reduction of River Pollution Peter Hartwig Germany Content page: 1 Introduction 1 2 Total emissions 3 3 Discharge from the wastewater treatment plants 4 4 Discharge from

More information

(Refer Slide Time: 05:33)

(Refer Slide Time: 05:33) Water and Wastewater Engineering Dr. Ligy Philip Department of Civil Engineering Indian Institute of Technology, Madras Sedimentation (Continued) Lecture # 9 Last class we were discussing about sedimentation.

More information

Under the direction of the MOP 11 Subcommittee of the Technical Practice Committee

Under the direction of the MOP 11 Subcommittee of the Technical Practice Committee Operation of Municipal Wastewater Treatment Plants WEF Manual of Practice No. 11 Chapter 22 Biological Nutrient Removal Processes Sixth Edition Prepared by the Operation of Municipal Wastewater Treatment

More information

William E. Dunn Water Reclamation Facility. Facility Overview & Information

William E. Dunn Water Reclamation Facility. Facility Overview & Information William E. Dunn Water Reclamation Facility Facility Overview & Information General Area Served: Plant History Facility Highlights Northern Pinellas County St. Joseph Sound to East Lake Road (E/W) Tampa

More information

Novel Process for the Treatment of Wastewaters from the Microelectronics Industry IWC 13-34

Novel Process for the Treatment of Wastewaters from the Microelectronics Industry IWC 13-34 Novel Process for the Treatment of Wastewaters from the Microelectronics Industry IWC 13-34 Authors: Temple Ballard 1, Nabin Chowdhury 2, Bruno Heiniger 4, Denise Horner 2, Antonio Lau 1, Sunil Mehta 2,

More information

ANAEROBIC/ANOXIC TANKS

ANAEROBIC/ANOXIC TANKS PROCESS DESCRIPTION In the anaerobic/anoxic tanks, wastewater is prepared for further treatment in the biological reactors. Denitrification and luxury uptake of phosphorus take place by mixing a food source

More information

Example Calculations Evaluation for Fine Bubble Aeration System. Red Valve Company, Inc. 700 NORTH BELL AVENUE CARNEGIE, PA 15106-0548

Example Calculations Evaluation for Fine Bubble Aeration System. Red Valve Company, Inc. 700 NORTH BELL AVENUE CARNEGIE, PA 15106-0548 Revision Date 6/10/02 9:52 Red Valve Company, Inc. 700 NORTH BELL AVENUE CARNEGIE, PA 15106-0548 PHONE (412) 279-0044 FAX (412) 279-5410 Red Valve Representative Sample Air Diffuser Calcs.xls Input Data

More information

Dewatering Equipment Selection Squeezing the Most Out of Your Decision for Municipal Solids Handling

Dewatering Equipment Selection Squeezing the Most Out of Your Decision for Municipal Solids Handling Squeezing the Most Out of Your Decision for Municipal Solids Handling Dewatering Selection Why dewater anyway? 21,594 Publicly Operated Treatment Works (POTW s) provide wastewater collection, treatment

More information

CHAPTER 14 WASTEWATER TREATMENT PONDS

CHAPTER 14 WASTEWATER TREATMENT PONDS CHAPTER 14 WASTEWATER TREATMENT PONDS 14-1, Background. A wastewater stabilization pond is a relatively shallow body of wastewater contained in an earthen basin which is designed to treat wastewater. (

More information

Designing a Flow Through Raceway System for Salmonids - Westers Design

Designing a Flow Through Raceway System for Salmonids - Westers Design Designing a Flow Through Raceway System for Salmonids - Westers Design North Central Aquaculture Conference Toledo, Ohio February 22-23, 2014 Chris Weeks Intensive Flow-Through Systems Salmon and trout

More information

Istanbul Water and Sewerage Administration (ISKI), Department of Wastewater Treatment, Istanbul, Turkey

Istanbul Water and Sewerage Administration (ISKI), Department of Wastewater Treatment, Istanbul, Turkey Comparison of Full-Scale a Conventional Activated Sludge Plant and a Ceramic Membrane Bioreactor: Nitrification Efficiency in Domestic Wastewater Treatment Mingled With Industrial Wastewater B.Peduk, B.Ozdemir

More information

Mine Water Management & Treatment Mining & Metals

Mine Water Management & Treatment Mining & Metals Mine Water Management & Treatment Mining & Metals Water is a critical resource for mining projects. Its management and protection are of paramount importance to every mine. Amec Foster Wheeler offers industry-leading

More information

HUBER Vacuum Rotation Membrane VRM Bioreactor

HUBER Vacuum Rotation Membrane VRM Bioreactor HUBER Vacuum Rotation Membrane VRM Bioreactor VRM The rotating plate membrane for clean water applications. The future-oriented solution designed for the ever increasing requirements in wastewater treatment

More information

Phosphorus Removal. P.F. Strom, 2006; do not copy without written permission.

Phosphorus Removal. P.F. Strom, 2006; do not copy without written permission. Phosphorus Removal Dr. Peter F. Strom, Professor Dept. of Environmental Sciences Cook College, Rutgers University 14 College Farm Road New Brunswick, NJ 08901-8551 (732) 932-8078; strom@aesop.rutgers.edu

More information

Sludge Minimization A Paradigm Shift in Sludge Management

Sludge Minimization A Paradigm Shift in Sludge Management Sludge Minimization A Paradigm Shift in Sludge Management Sam Jeyanayagam, PhD, PE, BCEE Vice President/Senior Principal Technologist CH2M Hill OWEA Biosolids Specialty Workshop December 9, 2010 1 Our

More information

CIBO Focus Group Meeting. Biological Treatment for Power Generation Wastewater

CIBO Focus Group Meeting. Biological Treatment for Power Generation Wastewater CIBO Focus Group Meeting Biological Treatment for Power Generation Wastewater June 11, 2013 Outline New ELGs for Fossil Fuel Power Generation Biological Treatment Fundamentals Aerobic Treatment Ammonia,

More information

Biogas Recovery from Domestic Wastewater with Anaerobic Membrane Bioreactor Jaeho Bae Inha WCU research team

Biogas Recovery from Domestic Wastewater with Anaerobic Membrane Bioreactor Jaeho Bae Inha WCU research team Biogas Recovery from Domestic Wastewater with Anaerobic Membrane Bioreactor Jaeho Bae Inha WCU research team INHA University, World Class University Research Team CONTENTS I II III IV Wastewater as Resources

More information

Biological wastewater treatment plants of BIOGEST

Biological wastewater treatment plants of BIOGEST Biological wastewater treatment plants of BIOGEST by: Thorsten ten Neuerer and Markus Batschauer from: BIOGEST AG, Taunusstein The so-called batch technology represents a particularly interesting and effective

More information

Using Membrane Bioreactors for Wastewater Treatment in Small Communities

Using Membrane Bioreactors for Wastewater Treatment in Small Communities Technical Paper Using Membrane Bioreactors for Wastewater Treatment in Small Communities Authors: Ricardo Bernal, Antonia von Gottberg, and Bernie Mack Introduction This paper will discuss the application

More information

Energy Use at Water and Wastewater Treatment Plants

Energy Use at Water and Wastewater Treatment Plants Energy Use at Water and Wastewater Treatment Plants Larry W. Moore, Ph.D., P.E. University of Memphis Civil Engineering Department March 13, 2012 Energy Use at WTPs Energy Energy is the ability or capacity

More information

CLEAR AND CLEAN WATER WITH PEACE OF MIND

CLEAR AND CLEAN WATER WITH PEACE OF MIND CLEAR AND CLEAN WATER WITH PEACE OF MIND DO YOU SEE HERE A SAFE & RELIABLE SEWAGE TREATMENT SYSTEM THAT IS INVISIBLE! DOES NOT STINK! NO PUMPS INSIDE! CONSUMES 50% LESS POWER! AUTOMATIC REMOTE MONITORING!

More information

The Sewage Plant. The Original! Fully biological. Small sewage. wastewater treatment for. new construction. & retrofitting

The Sewage Plant. The Original! Fully biological. Small sewage. wastewater treatment for. new construction. & retrofitting The Sewage Plant The Original! Fully biological wastewater treatment for new construction & retrofitting Ssb Small sewage treatment plant AQuato stabi-kom AQUATO STABI-KOM THE NEW GENERATION AMONG THE

More information

INTBIOAMB - Introduction to Environmental Biotechnology

INTBIOAMB - Introduction to Environmental Biotechnology Coordinating unit: Teaching unit: Academic year: Degree: ECTS credits: 2015 250 - ETSECCPB - Barcelona School of Civil Engineering 745 - EAB - Department of Agri-Food Engineering and Biotechnology MASTER'S

More information

WINERY WASTEWATER TREATMENT***

WINERY WASTEWATER TREATMENT*** WINERY WASTEWATER TREATMENT*** by Edwin Haynes*, George Stevens*, and Paul Russell, Jr.** INTRODUCTION In 1969 experience with treatment of winery wastewaters in this Country was limited to one winery

More information

EWI Workshop for Technology Roadmaps Dec 07

EWI Workshop for Technology Roadmaps Dec 07 EWI Workshop for Technology Roadmaps Dec 07 Technology Roadmap Why Technology Roadmaps Drive and direct targeted R&D areas (directed R&D) Develop R&D capabilities Develop local water technologies First

More information

SEWAGE TREATMENT PLANT AT BRAMPTON FARMS, ST. CATHERINE FCS # 0853/76/C ENGINEERING REPORT

SEWAGE TREATMENT PLANT AT BRAMPTON FARMS, ST. CATHERINE FCS # 0853/76/C ENGINEERING REPORT CIVIL & STRUCTURAL ENGINEERING CONSULTANTS 7A Barbados Avenue, Kingston 5, Jamaica, Tele: (876) 754-2154/5 Fax: (876) 754-2156 E-mail: mail@fcsconsultants.com SEWAGE TREATMENT PLANT AT BRAMPTON FARMS,

More information

SYNERGISTIC APPLICATION OF ADVANCED PRIMARY AND SECONDARY WASTEWATER TREATMENT SYSTEMS

SYNERGISTIC APPLICATION OF ADVANCED PRIMARY AND SECONDARY WASTEWATER TREATMENT SYSTEMS SYNERGISTIC APPLICATION OF ADVANCED PRIMARY AND SECONDARY WASTEWATER TREATMENT SYSTEMS Published in Water and Waste Digest membrane issue, November 2008 Miroslav Colic; Chief Scientist, Clean Water Technology

More information

Advanced Wastewater Treatment Process

Advanced Wastewater Treatment Process 7 th Workshop on Greenhouse Gas Inventories in Asia Possibly Co-benefit? Advanced Wastewater Treatment Process Tomonori ISHIGAKI Dept. of Environmental Solution Technology Ryukoku University, Japan Introductory

More information

MBR Pretreatment of Landfill Leachate for the Removal of Ammonia and Potential Future Removal of Total Dissolved Solids

MBR Pretreatment of Landfill Leachate for the Removal of Ammonia and Potential Future Removal of Total Dissolved Solids MBR Pretreatment of Landfill Leachate for the Removal of Ammonia and Potential Future Removal of Total Dissolved Solids Clifford S. Wilkinson 1, *, Jurek Patoczka 1, James Williams 2 and Thomas G. Grau

More information

LUCAS CYCLIC ACTIVATED SLUDGE SYSTEM

LUCAS CYCLIC ACTIVATED SLUDGE SYSTEM LUCAS CYCLIC ACTIVATED SLUDGE SYSTEM THE BLUE GOLD BIOLOGICAL WASTE WATER TREATMENT People are becoming increasingly aware of the importance and scarcity of clean water. Households, agriculture and industry

More information

Combination of advanced aeration system and membrane bioreactor for winery waste water treatment

Combination of advanced aeration system and membrane bioreactor for winery waste water treatment Combination of advanced aeration system and membrane bioreactor for winery waste water treatment G. Tanzi*, A. Mazzei** * Sepra S.r.l., via Como 69/A, 20031 Cesano Maderno, Italy (e-mail: gctanzi@sepra.it)

More information

WATER TREATMENT PROCESSES. Primary treatment. runoff

WATER TREATMENT PROCESSES. Primary treatment. runoff WATER TREATMENT PROCESSES Effluent Primary treatment Secondary Treatment runoff Tertiary treatment Water Treatment Processes PRIMARY TREATMENT to prepare the wastewater for biological treatment Purpose

More information

7/99 Technical Support Document for the Evaluation of Aerobic Biological Treatment Units with Multiple Mixing Zones

7/99 Technical Support Document for the Evaluation of Aerobic Biological Treatment Units with Multiple Mixing Zones 7/99 Technical Support Document for the Evaluation of Aerobic Biological Treatment Units with Multiple Mixing Zones I. OVERVIEW AND PURPOSE This document is intended to provide information to assist anyone

More information

Module 16: The Activated Sludge Process Part II Revised October 2014

Module 16: The Activated Sludge Process Part II Revised October 2014 Wastewater Treatment Plant Operator Certification Training Module 16: The Activated Sludge Process Part II Revised October 2014 This course includes content developed by the Pennsylvania Department of

More information

Homework #9 Wastewater Treatment

Homework #9 Wastewater Treatment 5 points total for CEE 371 entire homework Fall 2009 Homework #9 Wastewater Treatment Consider the design of a wastewater treatment plant (WWTP) for a community with average daily and peak hourly wastewater

More information

ACTIFLO Process For Wet Weather and Wastewater Treatment

ACTIFLO Process For Wet Weather and Wastewater Treatment ACTIFLO Process For Wet Weather and Wastewater Treatment ACTIFLO Microsand Ballasted Clarification Process ACTIFLO is a high rate, compact process developed by Veolia Solutions & Technologies. The process

More information

CONSTANT WATERLEVEL SBR (CWSBR ) New Arrival on the Australian Waste Water Market

CONSTANT WATERLEVEL SBR (CWSBR ) New Arrival on the Australian Waste Water Market CONSTANT WATERLEVEL SBR (CWSBR ) New Arrival on the Australian Waste Water Market Werner Gebauer, Axel Dederichs, Dr. Tim Köckritz GWS Technology, Taupo, New Zealand Gesellschaft für Abwasser- und Abfalltechnik

More information

Wastewater Treatment Aeration

Wastewater Treatment Aeration Wastewater Treatment Aeration We live and breathe aeration What is it that makes our aeration systems the trusted choice the world over? The fact that ITT Water & Wastewater have been designing, installing

More information

Advanced Wastewater Treatment Technology. Mechanical Vapor Recompression and Membrane Polishing Presented to

Advanced Wastewater Treatment Technology. Mechanical Vapor Recompression and Membrane Polishing Presented to Advanced Wastewater Treatment Technology Mechanical Vapor Recompression and Membrane Polishing Presented to 10 th Annual Chemical Management Services Workshop San Francisco, California John Burke Director

More information

Module 18 The Activated Sludge Process Part IV Revised November 2014

Module 18 The Activated Sludge Process Part IV Revised November 2014 Wastewater Treatment Plant Operator Certification Training Module 18 The Activated Sludge Process Part IV Revised November 2014 This course includes content developed by the Pennsylvania Department of

More information

GUIDELINES FOR LEACHATE CONTROL

GUIDELINES FOR LEACHATE CONTROL GUIDELINES FOR LEACHATE CONTROL The term leachate refers to liquids that migrate from the waste carrying dissolved or suspended contaminants. Leachate results from precipitation entering the landfill and

More information