PART I Vendor: Harlow's Bus Sales

Transcription

1 PART I CHASSIS Seating Capacity 84 passenger maximum design capacity seated for 78 passenger. Capacity 78 Engine Transmission Axle Front Axle Rear Axle Ratio Diesel 280 H.P. minimum, located in the rear. Automatic Allison, PTS 3000 or equal. 13,200 lb. minimum total suspension GVWR. 23,000 lb. minimum total suspension GVWR. Must comply with power and gradeability formula. Refer to Washington State School Bus Specifications Manual. Engine mfr. International Model or liters 7.6 Liter Net torque 1300 R.P.M Net H.P R.P.M Mfr. Allison Model no PTS Net input torque 950 Net input H.P. 300 Mfr. Meritor Capacity 14,000 Mfr. Dana Spicer Capacity 23,000 Ratio 5.29 Axle Oil Seals Front and rear oil bath. Mfr. International Alternator Battery(ies) 185 amp minimum CCA 12 volt to be mounted in body battery compartment. Mfr. Bosch LH200 Maximum output 200 amps. 200 Number of batteries 3 CCA 1950 FORM SPI (Rev. 7/12) Part I Page 1

2 PART I (cont.) Brakes Engine Heater Engine Temperature CHASSIS Air: S-cam or Disc. If S-cam, minimum 16.5 x 6 front, minimum 16.5 x 8 rear. Refer to Washington State School Bus Specifications Manual. Engine manufacturer s recommended in-block heater. To be controlled electronically, by fan clutch/drive, or shutters. Disc Front Rear Drum Front Rear Size Front 16.5x6 Rear 16.5x8 Watts 1250 Volts 120 Mfr. Phillips Mfr. Borg Warner Fan clutch Fuel Tank 100 gallon minimum. Capacity 105 Gallon Tires Wheels 6 first quality, radial ply. No low profile tires. 6 to be compatible with tire size. Mfr. Continental Size 11R22.5 Load range H Size 22.5 Rim width 8.25 Electronic Shutters FORM SPI (Rev. 7/12) Part I Page 2

3 PART I (cont.) Auxiliary Fans Back-up Lights Battery Compartment Door, Service Driver s Seat Heaters P.A. System Seat Spacing BODY 2 fans, 6 maximum, mounted to right and left windshield and service door. All required backup lights to be LED (Light Emitting Diode). Refer to Washington State School Bus Specification s Manual. Battery storage tray must be large enough to accommodate batteries as specified in chassis section. Power operated. Suspension type, 6-way adjustable, with lumbar adjustment. Cloth panel covers. Minimum of 3 heaters; 1 front, 1 center, 1 rear. Shutoff valves at engine for all heaters. Two-speed motors. Must include recirculating pump. AM/FM/PA radio with 4 interior and 1 exterior speakers. 78 passenger based upon manufacturer s maximum seat spacing. Mfr. Badder Brown Round: Other: Swing out Diameter 4 Inch Square inches Roll out Folding Other Split, Outward opening Mfr. National Front B.T.U. 90,000 Center B.T.U. 84,500 Rear B.T.U. 84,500 Total B.T.U. 259,000 Mfr. Panasonic Model No. CQ-CM14OU AM/FM/CD Inside measurement from rear of stepwell to appropriate point at rear of passenger seating area: 394 inches Mfg. s C/C seat measurement: inches Steering Wheel Tilt. Step Thread Studded or pebbled top thread covering. Mfr. Koroseal Toolbox Exterior, manufacturer standard. Size (cubic feet) 2.9 Two-way Communications 45-watt, VHF, mil. spec., narrow band capable. Mfr. Icom Model No. F5021S VHF FORM SPI (Rev. 7/12) Part I Page 3

4 PART I (cont.) Line Setting Ticket Owner s/operator s Handbook Repair Manuals Service and Cleaning Warranty ADDITIONAL REQUIREMENTS CHASSIS AND BODY Legible copy of manufacturer s Line Setting Ticket will be delivered with each vendor s packet at the time of delivery of the bus. One copy of the chassis manufacturer s owner s/operator s handbook or manual will be furnished with each bus at time of delivery. A complete set of chassis, engine, transmission, and body repair manuals, including wiring diagram for all components, will be made available at time of delivery, with instructions available on accessing repair materials. Cleaning and service by vendor prior to delivery will include: Chassis lubrication. Check fluid levels: verify all are at recommended full levels. Cooling system protected at -20 F. Interior and exterior will be clean (including glass). All systems (electric, air, hydraulic, mechanical and manual) be inspected to ensure proper operation at time of delivery. All components and accessories will be installed and operational at time of delivery. A complete copy of all warranty agreements will be furnished at time of delivery. FORM SPI (Rev. 7/12) Part I Page 4

5 PUPIL TRANSPORTATION Old Capitol Building PO BOX Olympia, WA (360) TTY (360) VEHICLE DATA SHEET AND OFFICIAL PRICE QUOTATION TYPE D 84 PASSENGER VENDOR S COMPANY NAME Harlow's Bus Sales ADDRESS 1240 W. Main St PO Box 1107 Auburn, WA REPRESENTATIVE S NAME Jim Landgraf TELEPHONE NUMBER Estimated delivery date to school district from time purchase order is received: 180 Days ARO Firm where engine and chassis can be serviced or repaired and parts obtained: Any IC or International Dealer Firm where body can be serviced or repaired and parts obtained: Harlow's Bus Sales, Inc. MAKE IC Corporation MODEL RE 305 YEAR 2014 BODY Warranty: Years 5 Miles Unlimit Seat color: Gray Floor color: Black Inside measurement from rear of stepwell to appropriate point at rear of passenger seating area: w/o lift 394 w/lift 394 Equipped seating capacity: w/o lift 78 w/lift 66+1 Overall vehicle length (inches): w/o lift w/lift MAKE IC Corporation CHASSIS Warranty: Years 5 Miles Unlimit MANUFACTURER International ENGINE Torque: 1300 RPM H.P.: 2200 RPM MODEL PB 305 MANUFACTURER Allison MODEL 3000 PTS YEAR 2014 Wheel base: 276 MODEL MaxxForce DT TRANSMISSION Warranty: Years 5 Speeds forward: 5 Miles Unlimit Warranty: Years 3 Miles 100,000 Number of cylinders: 6 Inline X V-type YEAR 2014 C.I.D.: 466 Fuel type: Diesel Battery type/grp: Number batteries: 3 3 Total CCA: QUOTED PRICE Quoted price is based upon payment within 30 days after delivery to the school district (without sales tax). Bid w/o lift $ 108,810 VENDOR REPRESENTATIVE S SIGNATURE DATE FORM SPI (Rev. 7/12)

6 DISTRICT-SUPPORTED OPTIONS PART II Air Conditioning To cool passenger compartment as required in the Washington State Mfr. TransAir 120k School Bus Specifications manual. Cost $ 16, Alternate Fuel Mfr. N/A CNG Must comply with power and gradeability formula. Refer to CNG Cost $ N/A LPG Washington State School Bus Specifications manual. LPG Cost $ N/A Other Other Cost $ N/A Anti-spray Device Rubber fender extenders. Cost $ 272 Alternator 200 amp. minimum. Cost $ Standard Back-up Alarm Must meet state minimum specification. Mfr. Ecco # SA Cost $ 123 Color Exterior white roof. Cost $ 776 Door Locks Vandal lock system on all exterior doors. Cost $ 742 Jomarr VT-6-E-NAF, or equal engine compartment fire suppression Fire Suppression Mfr. Jomar system of appropriate size to be installed according to manufacturer System recommendation. Cost $ 2,725 Floor Color Nonstandard color. Cost $ 371 Headlights Halogen. Cost $ Standard Heater (Auxiliary water) Lights, Exterior Auxiliary fuel-fired heating systems. Refer to Washington State School Bus Specifications Manual, page 27. LED (Light Emitting Diode). Complete package includes clearance lights, stop lights, tail lights and turn signals, but does not include eight-light system. Brand: Webasto Model: Scholastic Cost $ 3,799 Clearance Lights Cost $ 97 Eight-Light System Cost $ 1049 Stop Lights 7 Cost $ 106 Tail Lights Cost $ 156 Turn Signals Cost $ 252 Complete Package Cost $ 611 FORM SPI (Rev. 7/12) Part II Page 1

7 PART II (cont.) Specification DISTRICT-SUPPORTED OPTIONS Noise Reduction Passenger Securement Retarder Exceeding minimum specifications. 2-passenger position seats with lap-shoulder belts in all passenger positions. Manufacturer s standard. Driver compartment Cost $ 363 Engine compartment Cost $ 156 Full acoustical headliner Cost $ 156 Passenger Capacity 52 Cost $ 31,824 Driveline Cost $ 9,500 Exhaust Cost $ 1,531 Transmission Cost $ Steering Wheel Tilt and telescoping column. Cost $ 556 Storage Compartments Strobe Light Student Protection System Installed Suspension Largest available for unit bid. Exterior roof mounted white strobe light. Electronic system to insure driver post-trip inspection of passenger compartment. Air ride. Left-side 28.5 cubic feet. Cost $ 1,494 Right-side 28.5 cubic feet. Cost $ 1,494 Push-thru 137 cubic feet. Cost $ 4,596 Mfr. Ecco Model No. 6550C Cost $ 139 Mfr. Doran Model No. FCC-OEM Cost $ 399 Front Rear Cost $ 2,157 Cost $ 282 FORM SPI (Rev. 7/12) Part II Page 2

8 PART II (cont.) Specification DISTRICT-SUPPORTED OPTIONS Toolbox Interior, manufacturer standard. Cost $ 47 Deduct $ 62 Traction Device Traction Device Vehicle Securement System Video Camera Systems Installed Warning Light Monitor Wheelchair Lift Installed Additional Wheelchair/Occup ant Tie-down System Installed Automatic chains. Sanders. Mfr. On Spot Cost $ 2,228 Capacity 10 Gallon Cost $ 2,490 Must meet state minimum specification. Mfr. SBS Cost $ 782 Digital audio/video system for monitoring the passenger compartment with more than two cameras. 16 light monitoring system. Must meet state minimum specification. Platform shall be a minimum of 32 x 52. Must meet state minimum specification. Mfr. Seon Model No. TL4 Cost $ 2365 How many cameras 3 Incandescent LED Lights Cost $ 191 Cost $ 217 Mfr. Braun Century Model No. NCL919IB-2 Cost $ 5,833 Mfr. Q-Straint Model No. Q-8100-A1-SC Cost per station $ 1,115 FORM SPI (Rev. 7/12) Part II Page 3

9 PART II (cont.) Specification DISTRICT-SUPPORTED OPTIONS Windows Laminated passenger-compartment side or rear glass. Side Cost $ 816 Rear Cost $ 103 Both Cost $ 919 Windows Tinted. Cost $ 980 Windows Thermal pane, left of driver and service door. Cost $ 495 FORM SPI (Rev. 7/12) Part II Page 4