Gear Indicator Installation Manual. Rev 1.0

Save this PDF as:
 WORD  PNG  TXT  JPG

Size: px
Start display at page:

Download "Gear Indicator Installation Manual. Rev 1.0"

Transcription

1 Gear Indicator Installation Manual Rev 1.0

2 Table of Contents General Disclaimer... 3 Limitation of Liability... 3 Section 1: Stock Gear Switch Removal... 4 Section 2: Enhanced Gear Switch Installation Section 3: Gear Indicator Installation... 14

3 General Disclaimer Please read all instructions carefully before installing this device on your motorcycle. The content in this manual is for informational purposes and is not in any way intended to constitute advice from trained professionals in any field. By reading this manual, you agree to use the information within the manual at your own risk. Limitation of Liability You understand and agree at the author(s) of this manual and any of its subsidiaries or affiliates shall in no event be liable for any direct, indirect, incidental, consequential, or exemplary damages. The above limitation shall apply whether or not the author(s) of this manual has been advised of or should have been aware of the possibility of such damages.

4 Section 1: Stock Gear Switch Removal Before starting please make sure that you have the following tools ready to be used: Phillips screwdriver Flat head screwdriver Socket driver with 12 mm, 10 mm, and 8 mm sockets Needle nose pliers Scissors Marker WARNING: DISCONNECT THE BATTERY BEFORE PROCEEDING WITH INSTALLATION STEP 1: Locate the gear shifter on the left hand side of the motorcycle.

5 STEP 2: Mark existing gear shifter position with a marker for reinstallation. STEP 3: Use a 10 mm socket to remove the bolt holding the gear shifter. Remove bolt fully and slide the gear shifter off the shaft.

6 STEP 4: Remove 5 hex bolts located on the sprocket cover using an 8 mm socket. Note: Keep bolts in order (They are not the same length).

7 STEP 5: Slide sprocket cover of the gear shaft.

8 STEP 6: Remove gear switch using Philips screwdriver (2 screws) and keep the retaining clip that is on the left screw for reinstallation.

9 STEP 7: Trace switch wires under seat and remove 2 zip ties shown. Note: Use screw driver to release the zip ties in order to reuse them.

10 STEP 8: Disconnect the 2 wire harnesses shown. STEP 9: Remove gear switch entirely from the motorcycle.

11 Section 2: Enhanced Gear Switch Installation STEP 10: Install the enhanced gear switch using the 2 Philips and retaining clip from STEP 6. Note: Make sure that the wire coming off of the gear switch body is in the slot before reinstalling sprocket cover.

12 STEP 11: Guide the wires of the enhanced gear switch so that they are in the location of the stock harnesses. Connect the neutral harness from the gear switch to the mate on the motorcycle. STEP 12: Reinstall sprocket cover from STEP 4.

13 STEP 13: Reinstall gear shift lever from STEP 3. Note: Make sure you match the lines on the gear shaft and lever using the markings you made earlier.

14 Section 3: Gear Indicator Installation STEP 14: Remove stock Philips screw in the between the tachometer and speedometer. Using the longer Phillips screw (provided) attach the gear indicator board to the motorcycle.

15 STEP 15: Loosen the two 12 mm bolts for the gas tank. You do not need to fully remove the gas tank. All that is necessary is to shift the tank slightly to the left to feed the wires along the frame.

16 STEP 16: Guide the wires along the frame to the rear of the bike where the enhanced gear switch connector is located.

17 STEP 17: Connect the harness from the enhanced gear switch to the harness on the gear indicator. STEP 18: Secure the wires to the frame with zip ties if desired.

18 STEP 19: Locate the brown and black/white wires on the sidelight power connector (Found next to the headlight power connector.) STEP 20: a. Connect the brown wire on the sidelight power connector to the red power wire on the gear indicator using the provided wire connector. STEP 20: b. Connect the black/white wire on the sidelight power connector to the black wire on the gear indicator using the provided wire connector.

19 Note: If you d like you can use electrical tape to cover the connections or liquid electrical tape. STEP 21: Realign the gas tank and secure the two 12 mm bolts. STEP 22: Reconnect the battery. STEP 23: Enjoy the gear indicator! For Technical Assistance please contact:

Tug/Pull up on the bottom half of the air box shown below.

Tug/Pull up on the bottom half of the air box shown below. James Barone Racing Custom Fabrication of Aftermarket Parts and Accessories MAZDA 3 JBR Short Shift Plate Installation Instructions Installation may vary slightly by model Stock Air Box Removal Remove

More information

Items Required For Installation Small screw driver Straight O-ring pick Coat hanger or welding rod Electrical Tape

Items Required For Installation Small screw driver Straight O-ring pick Coat hanger or welding rod Electrical Tape J u i c e d H y b r i d s T o y o t a P r i u s 2 0 1 2-2 0 1 3 F o g L i g h t K i t ¼ ratchet ¼ X 6 extension ¼ 10mm shallow socket Philips screw driver Items Required For Installation Small screw driver

More information

Headlight Removal & Installation: BMW E46

Headlight Removal & Installation: BMW E46 Headlight Removal & Installation: BMW E46 DISCLAIMER Buyer assumes any and all risk and liability from the installation and use of this product. Seller, author, or any of their affiliates assume no liability

More information

Extendable Trailer Towing Mirror

Extendable Trailer Towing Mirror Extendable Trailer Towing Mirror Installation Instructions For: 1997-2001 Ford F150 CIPA Part Numbers 72000 & 82000 WARNING Manufacturer recommends this installation be carried out by a professional installer

More information

INSTALLATION AND OWNER S MANUAL Side Illumination Lights Z5100 for use with R1100RT and R1150RT

INSTALLATION AND OWNER S MANUAL Side Illumination Lights Z5100 for use with R1100RT and R1150RT INSTALLATION AND OWNER S MANUAL Side Illumination Lights Z5100 for use with R1100RT and R1150RT Read these instructions carefully and thoroughly before beginning work. Before installing the accessory,

More information

INSTALLATION INSTRUCTIONS

INSTALLATION INSTRUCTIONS INSTALLATION INSTRUCTIONS Accessory Application Publications No. ACCORD All 30209 2-AND 4-DOOR SYSTEM (VP, LX, SE) Issue Date AUG 2005 PARTS LIST Security System Attachment: P/N 08E55-SDA-100A Unit panel

More information

INSTALLATION INSTRUCTIONS

INSTALLATION INSTRUCTIONS Accessory Application Publication No. INSTALLATION INSTRUCTIONS FOG LAMP ATTACHMENT P/N 08V70-MJR-640 GL1800C MII Issue Date January 2014 PARTS LIST No. Description Qty ((( Right bracket 1 (1) (2) (((

More information

INSTALLATION INSTRUCTIONS

INSTALLATION INSTRUCTIONS INSTALLATION INSTRUCTIONS Accessory Application Publications No. All 24393 ACCORD (DX, LX) SYSTEM 2-AND 4-DOOR Issue Date AUG 2002 PARTS LIST Security System Attachment (LX): P/N 08E55-SDA-100A Unit panel

More information

Retrofit Instructions Installing a Sport Heated Steering Wheel - Leather, Multifunction BMW X5, E53, 2001 2006

Retrofit Instructions Installing a Sport Heated Steering Wheel - Leather, Multifunction BMW X5, E53, 2001 2006 Retrofit Instructions Installing a Sport Heated Steering Wheel - Leather, Multifunction BMW X5, E53, 2001 2006 Disclaimer: This set of instructions is simply a guide on how I installed my own heated steering

More information

Model A Turn Signal Kit Installation Guide

Model A Turn Signal Kit Installation Guide Model A Turn Signal Kit Installation Guide Consumer Hot Line: 888-471-LOGO 770-476-7322 In Atlanta, GA http://www.logolites.com P/N: 100-005/G 2003 3407 Hwy. 120 Duluth, GA 30096, USA Logo Lites and the

More information

YAMAHA ROADSTAR Standard or Silverado Models Trailer Hitch Installation Instructions READ ALL INSTRUCTIONS BEFORE YOU START

YAMAHA ROADSTAR Standard or Silverado Models Trailer Hitch Installation Instructions READ ALL INSTRUCTIONS BEFORE YOU START YAMAHA ROADSTAR Standard or Silverado Models Trailer Hitch Installation Instructions READ ALL INSTRUCTIONS BEFORE YOU START ATTENTION INSTALLER: THESE INSTRUCTIONS MUST BE GIVEN TO THE END USER!!! YAMAHA

More information

WARNING! REQUIRED TOOLS & SUPPLIES: HIGH VOLTAGE

WARNING! REQUIRED TOOLS & SUPPLIES: HIGH VOLTAGE INSTRUCTIONS Product: GEM Electric Motorcars Models: All Subject: Instructions for installing Stereo Accessory Estimated Completion Time:.75 Hours Parts: See Page # 7 REQUIRED TOOLS & SUPPLIES: (1) 3/8

More information

Step 1. Item 6. Item 1

Step 1. Item 6. Item 1 Voltage Regulators QD3/T350 Motor Replacement Kit Kit Number 57A63675100B Service Information S225-50-35 Contents General..................................... 1 Parts Supplied...............................

More information

INSTALLATION INSTRUCTIONS www.collegehillshonda.com Accessory USB ADAPTER Application 2009 FIT (BASE MODEL) Publications No. AII 39879 Issue Date SEP 2008 PARTS LIST USB Adapter Attachment Kit P/N 08B28-TK6-100

More information

INSTALLATION INSTRUCTIONS

INSTALLATION INSTRUCTIONS INSTALLATION INSTRUCTIONS Accessory Application Publications No. AII23628 2003 PILOT Issue Date MAY 2002 PARTS LIST Security System Kit (sold separately): P/N 08E51-S84-100 2 Remote controls Attachment

More information

Fitting Instruction: Daytona 675 Street Triple from VIN 411984, Street Triple R from VIN 411984 A9930222

Fitting Instruction: Daytona 675 Street Triple from VIN 411984, Street Triple R from VIN 411984 A9930222 English Fitting Instruction: Daytona 675 Street Triple from VIN 98, Street Triple R from VIN 98 A990 Thank you for choosing this Triumph genuine accessory kit. This accessory kit is the product of Triumph's

More information

Fresenius Medical Care North America Service Bulletin

Fresenius Medical Care North America Service Bulletin Fresenius Medical Care North America Service Bulletin Equipment: Bulletin: Subject: 2008 K Hemodialysis Machines 15-FRK-001 Rev A Optional Shunt Box Ferrite Core Installation (Update) 1.0 PURPOSE To inform

More information

GENUINE PARTS INSTALLATION INSTRUCTIONS

GENUINE PARTS INSTALLATION INSTRUCTIONS GENUINE PARTS INSTALLATION INSTRUCTIONS 1. DESCRIPTION: Auto-Dimming Mirror Kit with Compass and HomeLink 2. APPLICATION: Titan 3. PART NUMBER: 999L1 WS000 4. KIT CONTENTS: Item Qty Description Service

More information

PARTS INDEX. Overview. Installation. Rear Wheel Gear - 3 Motor Chain Gas Tank Carburetor Hand Controls Wiring. Operation

PARTS INDEX. Overview. Installation. Rear Wheel Gear - 3 Motor Chain Gas Tank Carburetor Hand Controls Wiring. Operation 1 Overview Installation Operation Rear Wheel Gear - 3 Motor Chain Gas Tank Carburetor Hand Controls Wiring Starting Procedure Maintenance Oil Gas Ratio PARTS INDEX 2 Overview Please take the time to read

More information

Bosch Tuning Dongle Fitting Guide -

Bosch Tuning Dongle Fitting Guide - Bosch Tuning Dongle Fitting Guide - Please read these instructions carefully before fitting and keep them for later use. Please be aware that the use of the tuning dongle is strictly for off road use only.

More information

Turn Signal Installation Instructions. Parts:

Turn Signal Installation Instructions. Parts: Turn Signal Installation Instructions Before Starting the Installation: 1. REVIEW THE WIRING DIAGRAM ON PAGE 4 2. Locate and disconnect the battery. 3. Determine where on the paneling near the Front and

More information

XJR1300 Gear Position Indicator User Instructions

XJR1300 Gear Position Indicator User Instructions XJR1300 Gear Position Indicator User Instructions Congratulations on acquiring this gear position indicator (GPi) for your Yamaha XJR1300. This leaflet is provided to give an insight to how it works, how

More information

430 Power/Electronics Replacement

430 Power/Electronics Replacement Replacing the main board WARNING Before proceeding, turn off the main power switch and unplug the power cord. Caution Make sure you are properly grounded with an ESD strap before continuing. The main printed

More information

Water Pump Seal Replacement

Water Pump Seal Replacement Water Pump Seal Replacement This Manual provides instructions on how to replace the water pump seals on the Sherco 2001 2003 models (1.25, 2.0, 2.5, 2.9). Water pump seals should be replaced when the transmission

More information

Quickie Rhapsody Service Manual

Quickie Rhapsody Service Manual Quickie Rhapsody Service Manual 2006 Sunrise Medical Inc. 101976 Rev A Quickie Rhapsody Service Manual Contents Introduction... 0.1 VR2 Controller... 0.2 Plugs/Connectors... 0.3 Basic Tool List & Main

More information

1999.5-2001 Audi A4 (B5) HID conversion installation instructions

1999.5-2001 Audi A4 (B5) HID conversion installation instructions 1 of 5 10/26/2007 4:48 PM 1999.5-2001 Audi A4 (B5) HID conversion installation instructions Tools Needed: A drill 1" hole saw T27 Torx bit and driver with a 4" extension Extendable magnet Pliers or A drill

More information

Installation Manual TWM Performance Short Shift Kit 2005 and up Scion TC

Installation Manual TWM Performance Short Shift Kit 2005 and up Scion TC Installation Manual TWM Performance Short Shift Kit 2005 and up Scion TC 1. Unscrew the shift knob by rotating counter clockwise, set it aside for now. 2. Remove the portion of the console with the shift

More information

Installing RNS-E SAT NAV for Audi A4

Installing RNS-E SAT NAV for Audi A4 As one of the major options on the A4 you can get a DVD Satellite Navigation System call the RNS-E. With the help of ebay these sat nav systems are now available to by at a rough cost of 650 plus the cost

More information

HW Yamaha Rhino HO Stator Rectifier Instructions

HW Yamaha Rhino HO Stator Rectifier Instructions HW Yamaha Rhino HO Stator Rectifier Instructions Tools Needed: 10mm socket 8mm socket 10mm wrench 17mm socket Ratchet Philips head screw driver Vise-Grips 1. Remove seats, engine cover and center floorboard

More information

3. SEISCO PARTS & SERVICE REMOVAL AND REPAIR GUIDE

3. SEISCO PARTS & SERVICE REMOVAL AND REPAIR GUIDE 4 3. SEISCO PARTS & SERVICE REMOVAL AND REPAIR GUIDE A. Changing the Control Board B. Replacing a Heating Element C. Thermistor Replacement D. High Limit Switch Replacement E. Level Detector Replacement

More information

How To... SERVICE AND REPAIR

How To... SERVICE AND REPAIR SECTION III How To... SERVICE AND REPAIR Page Pedals, Crank Arms, and Side Shrouds...3 Crank Shaft Hub Assembly...5 Crank Shaft and Bearings...7 Clutch Assembly...10 Intermediate Pulley Shaft and Bearings...11

More information

INSTALLATION INSTRUCTIONS

INSTALLATION INSTRUCTIONS INSTALLATION INSTRUCTIONS Accessory Application Publications No. P/N 08V31-SVA-100A 2007 CIVIC SI All 33486 Issue Date AUG 2006 PARTS LIST Right fog light 5 Wire ties Left fog light Clip Right bracket

More information

Wildman Chip Power Stroke Installation Instructions

Wildman Chip Power Stroke Installation Instructions www.totaldieselperformance.com Wildman Chip - 1999-2003 7.3 Power Stroke Info Chip Name: Pos 1: Burn Date: Pos 2: Model: Pos 3: Year: Pos 4: Transmission: Pos 5: Pos 6: Installation Instructions CAUTION

More information

CorkSport Mazdaspeed 6 Rear Sway Bar 2006-2007 Mazdaspeed 6

CorkSport Mazdaspeed 6 Rear Sway Bar 2006-2007 Mazdaspeed 6 CorkSport Mazdaspeed 6 Rear Sway Bar 2006-2007 Mazdaspeed 6 Pre-Installation Notes: The CorkSport Rear Sway Bar is a great addition to improving the handling performance to the Mazdaspeed 6. It will minimize

More information

INSTALLATION INSTRUCTIONS

INSTALLATION INSTRUCTIONS INSTALLATION INSTRUCTIONS Accessory TRIM Application 2008 ACCORD 4-DOOR Publications No. AII 35362 Issue Date AUG 2007 PARTS LIST Steering Wheel Trim (Without Navigation) P/N 08Z13-TA0-100 Right steering

More information

TOYOTA RAV4 2006 - TRAILER WIRE HARNESS Section I Installation Preparation

TOYOTA RAV4 2006 - TRAILER WIRE HARNESS Section I Installation Preparation Section I Installation Preparation Part Number: 08921-42900 Kit Contents Item # Quantity Reqd. Description 1 1 Converter 2 1 Wire harness 3 1 Sub wire harness No.1 4 2 Plastic Tie (300mm) 5 21 Plastic

More information

Tech Article. Raingear Wiper System. From Newsletter st Quarter of Unabridged. 1. Disconnect your battery.

Tech Article. Raingear Wiper System. From Newsletter st Quarter of Unabridged. 1. Disconnect your battery. Parts you will need Danchuk # 12825 Raingear Wiper System with Intermittent Switch Danchuk # 12828 Raingear Universal Washer Kit Danchuk # 913 Wiper Switch Tool Danchuk # 912 Wiper Escutcheon Nut Tool

More information

Spreader Light Bulb Replacement Instructions

Spreader Light Bulb Replacement Instructions Spreader Light Bulb Replacement Instructions IMPORTANT: DISCONNECT LIGHT FROM BATTERY BEFORE PROCEEDING. FAILURE TO DO SO MAY RESULT IN PERSONAL INJURY OR OTHER DAMAGE. Tools Needed You will need the following

More information

INSTALLATION INSTRUCTIONS

INSTALLATION INSTRUCTIONS Accessory Application Publications No. INSTALLATION INSTRUCTIONS HEATED GRIP WITH THERMOSTAT P/N 08T50-MCA-102 GL1800 Honda Dealer: Please give a copy of these instructions to your customer. Issue Date

More information

Time needed: ~3h for lid replacement only. Add 1h for operation harness in lid and ~2h more for installing drive unit and cable harness in trunk.

Time needed: ~3h for lid replacement only. Add 1h for operation harness in lid and ~2h more for installing drive unit and cable harness in trunk. DIY for replacing trunk lid and/or retrofitting electrical operation of trunk lid. This document is meant to be a support and give advice on the procedure but I will take no responsibility for any damage

More information

INSTALLATION INSTRUCTIONS: HARLEY-DAVIDSON SPORTSTER HI-OUTPUT GRENADES 2-INTO-2 PART# 16852/46852/16854/46854

INSTALLATION INSTRUCTIONS: HARLEY-DAVIDSON SPORTSTER HI-OUTPUT GRENADES 2-INTO-2 PART# 16852/46852/16854/46854 INSTALLATION INSTRUCTIONS: HARLEY-DAVIDSON SPORTSTER HI-OUTPUT GRENADES 2-INTO-2 PART# 16852/46852/16854/46854 Congratulations, you have purchased the finest exhaust system available for your motorcycle.

More information

Mazda CX9 2007-up 99-7516B

Mazda CX9 2007-up 99-7516B INSTALLATION INSTRUCTIONS FOR PART 99-7516B APPLICATIONS Mazda CX9 2007-up 99-7516B KIT FEATURES DIN radio provision with pocket ISO radio provision with pocket Double DIN radio provision Stacked ISO units

More information

INSTALLATION INSTRUCTIONS

INSTALLATION INSTRUCTIONS INSTALLATION INSTRUCTIONS Accessory S P/N 08V31-SWA-100 Application CR-V Publications No. AII 32952-35942 Issue Date APRIL 2007 PARTS LIST Right fog light Switch Relay Left fog light Bracket Fog light

More information

INSTALLATION INSTRUCTIONS

INSTALLATION INSTRUCTIONS INSTALLATION INSTRUCTIONS Accessory Application 2009 PILOT Publications No. AII 39408 Issue Date MAY 2008 PARTS LIST Steering Wheel Trim (With Cruise and Audio) P/N 08Z13-SZA-130B (Chocolate) P/N 08Z13-SZA-140B

More information

FRONT TURN SIGNAL RELOCATION KIT

FRONT TURN SIGNAL RELOCATION KIT -J0 REV. 00-0-0 FRONT TURN SIGNAL RELOCATION KIT GENERAL Kit Number -0 Models This kit fits 00 and later Dyna model motorcycles (except FXDSE), relocating the front turn signal from the handlebars to the

More information

2009+ Audi R8 V10 SwitchPath TM Exhaust System INSTALLATION GUIDE

2009+ Audi R8 V10 SwitchPath TM Exhaust System INSTALLATION GUIDE INSTALLATION GUIDE 2009+ Audi R8 V10 SwitchPath TM Exhaust System Congratulations on your purchase of the AWE Tuning high performance exhaust for the 2009+ Audi R8 V10. Exquisite build quality with industry

More information

Factory Service Manual for your model Factory Parts Manual

Factory Service Manual for your model Factory Parts Manual DISCLAIMER We Highly Recommend that only a qualified or experienced technician with a background in Harley-Davidson motorcycles and the American Custom aftermarket successfully complete the SMW wide tire

More information

Area 451 Parts cruise control Installation Instructions

Area 451 Parts cruise control Installation Instructions DISCLAIMER OF LIABILITY Area 451 Parts cruise control Installation Instructions Installing, operating, or otherwise utilizing this device in any way, indicates the owner of this device and/or the vehicle

More information

Lincoln Mark VII Power Window Motor Repair

Lincoln Mark VII Power Window Motor Repair Lincoln Mark VII Power Window Motor Repair Is your door no longer going up and down? Does the window motor make a horrible sound when in use? Does your window no longer work at all? You may need to replace

More information

Mini Cooper and S Trailer Receiver Hitch Installation Instructions

Mini Cooper and S Trailer Receiver Hitch Installation Instructions Application Mini Cooper and S 3 Door Hatch or Convertible; M1001-02-06 Mini Cooper M1002-02-06 Mini Cooper S Hitch Capacity 1400 lbs gross, 200 lb max tongue Notes: This hitch features a removable ball

More information

INSTALLATION INSTRUCTIONS

INSTALLATION INSTRUCTIONS INSTALLATION INSTRUCTIONS Accessory Application Publications No. AII 26327 2004 S2000 Issue Date OCT 2004 PARTS LIST Security System: P/N 08E51-S84-100 Attachment Kit: P/N 08E55-S2A-101 2 Remote controls

More information

Installation instructions for Kirk Key Interlock Kit (2C12891G21) in MagnumT low voltage circuit breakers

Installation instructions for Kirk Key Interlock Kit (2C12891G21) in MagnumT low voltage circuit breakers Supersedes January 2013 MagnumT low voltage circuit breakers WARNING (1) ONLY QUALIFIED ELECTRICAL PERSONNEL SHOULD BE PERMITTED TO WORK ON THE EQUIPMENT. (2) ALWAYS DE-ENERGIZE PRIMARY AND SECONDARY CIRCUITS

More information

Corbeau Black 3-Point Retractable Seat Belt (SKU# CS-2SB-BRSB) Installation Instructions

Corbeau Black 3-Point Retractable Seat Belt (SKU# CS-2SB-BRSB) Installation Instructions Instructions Created by an: Corbeau Black 3-Point Retractable Seat Belt (SKU# CS-2SB-BRSB) Installation Instructions CAUTION: Safety glasses should be worn at all times when working with vehicles and related

More information

www.odometergears.com Ford Ranger and Mazda Pickup Odometer Worm Gear Replacement

www.odometergears.com Ford Ranger and Mazda Pickup Odometer Worm Gear Replacement www.odometergears.com Ford Ranger and Mazda Pickup Odometer Worm Gear Replacement http://www.therangerstation.com/magazine/fall2008/odometer_worm_gear.htm ****************************************************************************************************

More information

INSTALLATION INSTRUCTIONS

INSTALLATION INSTRUCTIONS Accessory Application Publications No. INSTALLATION INSTRUCTIONS S 2005 CIVIC HYBRID AII 28002 Issue Date SEP 2004 PARTS LIST 33 Wire ties Fog Lights (sold separately): P/N 08V31-S5D-102A Left fog light

More information

Equipped with AEM Dryflow Filter No Oil Required! INSTALLATION INSTRUCTIONS PART NUMBER 21-754DS. 2012-2015 BMW 335i 3.0L

Equipped with AEM Dryflow Filter No Oil Required! INSTALLATION INSTRUCTIONS PART NUMBER 21-754DS. 2012-2015 BMW 335i 3.0L Equipped with AEM Dryflow Filter No Oil Required! INSTALLATION INSTRUCTIONS PART NUMBER 21-754DS 2012-2015 BMW 335i 3.0L 1 ITEM NO. PART NUMBER DESCRIPTION QTY. 1 21-2057DK AIR FILTER 1 2 9-0442 TUBE;

More information

INSTALLATION INSTRUCTIONS

INSTALLATION INSTRUCTIONS DURAMAX POWER STEERING LINES 01-10 6.6L DURAMAX DIESEL 2500 / 3500 TRUCKS INSTALLATION INSTRUCTIONS Thank You for purchasing the Driven Diesel High Pressure Power Steering Line kit for the 2001-2010 GM

More information

Standard Includes: 2 Predator ICE Modules 2 Resistors (attached) 2 Sets of adapters (E60 Style and E39 Style)

Standard Includes: 2 Predator ICE Modules 2 Resistors (attached) 2 Sets of adapters (E60 Style and E39 Style) Predator ICE Installation Guide Written exclusively for Umnitza s Predator ICE Product This step-by-step guide is designed to be used in together with other available documentation including bumper removal,

More information

GENUINE PARTS INSTALLATION INSTRUCTIONS

GENUINE PARTS INSTALLATION INSTRUCTIONS GENUINE PARTS INSTALLATION INSTRUCTIONS DESCRIPTION: Illuminated Kick Plate APPLICATION: Rogue (2011) PART NUMBER: 999G6 GX010 KIT CONTENTS: Item A B C G H QTY 1 1 1 D 1 E 1 F 3 15 6 Description Kick Plate,

More information

Here I Will Explain How To Install Recon Cab Lights In A 3rd Gen Dodge Ram.

Here I Will Explain How To Install Recon Cab Lights In A 3rd Gen Dodge Ram. 1 P age Here I Will Explain How To Install Recon Cab Lights In A 3rd Gen Dodge Ram. *Now, There Are Many Ways of Installing Them, Including Wiring Methods, Wiring Connectors, And Other Variables - In This

More information

INSTALL/REMOVAL INSTRUCTIONS: WINDOW LIFT MOTOR

INSTALL/REMOVAL INSTRUCTIONS: WINDOW LIFT MOTOR REMOVAL/INSTALL OF WINDOW LIFT MOTOR (742-273) Ford Expedition 1997 2002, Lincoln Navigator 1998 2002, Ford F-150 Super Crew Cab 2001 General Tech Tips: Use painter s tape rather than duct tape to secure

More information

Companion Service Guide

Companion Service Guide Companion Service Guide This Service Guide contains: Troubleshooting Replacement Instructions Contact Information Golden Technologies 401 Bridge Street Old Forge, PA 18518 Toll-free: 800-624-6374 Fax:

More information

How To... SERVICE AND REPAIR GUIDE

How To... SERVICE AND REPAIR GUIDE SECTION III How To... SERVICE AND REPAIR GUIDE 1 How To... Replace the Display Console and Accessory Tray Tools required: Phillips screwdriver 1. Remove the (4) MOUNTING SCREWS from under the CONSOLE,

More information

INSTALL/REMOVAL INSTRUCTIONS: WINDOW REGULATOR

INSTALL/REMOVAL INSTRUCTIONS: WINDOW REGULATOR REMOVAL/INSTALL OF WINDOW REGULATOR (741-644) Cadillac Escalade, Chevrolet Suburban, Chevrolet Tahoe, GMC Yukon, Chevrolet Silverado, GMC Sierra 2000 05 General Tech Tips: Use painter s tape rather than

More information

INSTALLATION MANUAL INSIDE PASSENGER COMPARTMENT. HFC 134a FOR EUROPEAN SPEC. / GENERAL SPEC. AIR CONDITIONING ENGLISH

INSTALLATION MANUAL INSIDE PASSENGER COMPARTMENT. HFC 134a FOR EUROPEAN SPEC. / GENERAL SPEC. AIR CONDITIONING ENGLISH HFC 134a Ozone Friendly Refrigerant FOR EUROPEAN SPEC. / GENERAL SPEC. AIR CONDITIONING ENGLISH AAAMU-60 / INSIDE PASSENGER COMPARTMENT INSTALLATION MANUAL 2000 (EUROPE) B.V.. All Rights Reserved. This

More information

Mazda CX7 2007-09 99-7508

Mazda CX7 2007-09 99-7508 INSTALLATION INSTRUCTIONS FOR PART 99-7508 APPLICATIONS Mazda CX7 2007-09 99-7508 KIT FEATURES DIN Radio Provision with Pocket ISO Mount Radio Provision with Pocket Double DIN Mount Radio Provision Stacked

More information

Notification of Potential Operator Safety Hazard SAFETY

Notification of Potential Operator Safety Hazard SAFETY 3070-58A-S S E R V I C E N O T E Agilent 3070/79000 Board Test System SUPERSEDES: 3070-58-S Serial Numbers: US32050226 through US32050244 US34230001 through US34230762 US34240001 through US34240775 US37280101

More information

BMW-Motorrad Installing LED flashing turn indicators

BMW-Motorrad Installing LED flashing turn indicators 77 51 151 Installing LED flashing turn indicators + 77 51 651 Equipment trim-level variant: LED flashing turn indicators Preparatory work => Removing and installing the rear-wheel stand special tool (motorcycles

More information

Owner s Manual Ignition Upgrade Module for 2004-up Carbureted Harley Davidson Motorcycles P/N ASM5075

Owner s Manual Ignition Upgrade Module for 2004-up Carbureted Harley Davidson Motorcycles P/N ASM5075 Owner s Manual Ignition Upgrade Module for 2004-up Carbureted Harley Davidson Motorcycles P/N ASM5075 Thunder Heart Performance Corporation MANUAL P/N EI5075 120 Industrial Drive Revision 7/15/05 White

More information

Front Panel Board Cable Replacement Instructions

Front Panel Board Cable Replacement Instructions apple Mac Pro Front Panel Board Cable Replacement Instructions First Steps 1 Shut down computer. Note: Follow these instructions carefully. Failure to do so could damage your equipment and void its warranty.

More information

Trailer Receiver Hitch Installation Instructions

Trailer Receiver Hitch Installation Instructions Model/Applications: 1004: R56 07-10 Mini Cooper Hatch R57 09-10 Mini Cooper Convertible 1003: R5 07-10 Mini Cooper S Hatch and 09-10 Mini Cooper S Convert Hitch Capacity 1400 lbs gross, 200 lb max tongue

More information

BILLET HEADLAMP SHELL

BILLET HEADLAMP SHELL -J008 REV. 007-07- BILLET HEADLAMP SHELL GENERAL Kit Number 770-0 Models For model fitment information, please see the P&A Retail Catalog or the Parts and Accessories section of www.harleydavidson.com

More information

Mazda MX-5 Soft Top Installation Instructions

Mazda MX-5 Soft Top Installation Instructions Mazda MX-5 Soft Top Installation Instructions These instructions show how to replace your soft top with the frame remaining attached to the car. This requires the use of a right angled driver which is

More information

Processor Cage Fans, Front and Rear Replacement Instructions

Processor Cage Fans, Front and Rear Replacement Instructions apple Mac Pro Processor Cage Fans, Front and Rear Replacement Instructions First Steps 1 Shut down computer. Note: Follow these instructions carefully. Failure to do so could damage your equipment and

More information

TOYOTA FJ CRUISER TRAILER WIRE HARNESS Preparation

TOYOTA FJ CRUISER TRAILER WIRE HARNESS Preparation Preparation Part Number: 08921-35870 Kit Contents Item # Quantity Reqd. Description 1 1 Converter 2 1 Wire harness 3 1 Plastic tie (black) 4 1 Plastic tie (brown) 5 2 Packing 6 2 Bolt (M6) 7 2 Bolt (M5)

More information

Headlight Removal & Installation: BMW E90 (3 Series)

Headlight Removal & Installation: BMW E90 (3 Series) Headlight Removal & Installation: BMW E90 (3 Series) DISCLAIMER Buyer assumes any and all risk and liability from the installation and use of this product. Seller, author, or any of their affiliates assume

More information

Post Mount Light Installation*

Post Mount Light Installation* Post Mount Light Installation* *For the general installation of most Post Mount Spotlights, many vehicles may need slight modifications to these instructions. You will need the following tools: High torque

More information

Form #5327, Rev. RTP, 03-28-12. Honda Civic DRL KIT 2011-UP Part Number: 260-1022-HN2

Form #5327, Rev. RTP, 03-28-12. Honda Civic DRL KIT 2011-UP Part Number: 260-1022-HN2 Form #5327, Rev. RTP, 03-28-12 Honda Civic DRL KIT 2011-UP Kit Contents Item # Qty. Description 1 1 Controller 2 2 DRLs 3 2 Bezels L, R 4 1 DRL Extension 5 1 Ignition Harness 6 1 Illumination 7 1 Ground

More information

TOYOTA FJ CRUISER 2007 AUXILIARY LIGHTS Preparation

TOYOTA FJ CRUISER 2007 AUXILIARY LIGHTS Preparation TOYOTA FJ CRUISER 2007 AUXILIARY LIGHTS Preparation Part Number: PT297-35061 Kit Contents Item # Quantity Reqd. Description 1 2 Driving Lamp Assembly 2 1 Switch Harness 3 1 Lamp Harness 4 2 Stone Shield

More information

CAM-03, Camshaft Assembly Oil Seal Replacement

CAM-03, Camshaft Assembly Oil Seal Replacement CAM-03, Camshaft Assembly Oil Seal Replacement Tools Jack stands Floor Jack Metric Socket set Metric Wrench set Porsche Timing Belt Tension tool (P9201) Flywheel Lock (P9206) Balance Shaft Pin Spanner

More information

HP Laser Jet 4200/4240/4250/4300/4350 Swing Plate

HP Laser Jet 4200/4240/4250/4300/4350 Swing Plate HP Laser Jet 4200/4240/4250/4300/4350 Swing Plate 1 Swing Plate Assembly-RM1-0043 1 Swing Plate Kit-5851-2766 (RM1-0043 plus RM1-1091 gear) CAUTION: Fuser may be hot. Turn off printer, unplug it and allow

More information

TOYOTA TACOMA 2012 - TRAILER WIRE HARNESS Preparation

TOYOTA TACOMA 2012 - TRAILER WIRE HARNESS Preparation Preparation Part Number: PT725-35120 Kit Contents Item # Quantity Reqd. Description 1 1 Flasher Assembly (F/A) 2 1 Wire Harness 3 1 Sub Wire Harness 4 2 Plastic Tie (300mm) 5 4 Plastic Tie (200mm) 6 13

More information

INSTALLATION INSTRUCTIONS ELEVATION REAR BUMPER RAM

INSTALLATION INSTRUCTIONS ELEVATION REAR BUMPER RAM INSTALLATION INSTRUCTIONS PARTS LIST: 1 Elevation Bumper Assembly 4 8mm x 40mm Hex Bolts 1 Universal License Plate Light 4 8mm x 28mm x 3mm Flat Washers 8 12-1.75mm x 50mm Hex Bolts 4 8mm Lock Washers

More information

RHINO 700 Z-Fi MX INSTALLATION INSTRUCTIONS P/N F713

RHINO 700 Z-Fi MX INSTALLATION INSTRUCTIONS P/N F713 2008-2013 RHINO 700 Z-Fi MX INSTALLATION INSTRUCTIONS P/N F713 WARNING! USE ONLY IN RACE OR OTHER CLOSED COURSE APPLICATIONS AND NEVER ON PUBLIC ROADS PARTS LIST: Z-Fi MX Control Unit Fuel Harness DOWNLOAD

More information

HI-4 SINGLE FIRE RACE MOTORCYCLE IGNITION

HI-4 SINGLE FIRE RACE MOTORCYCLE IGNITION INSTALLATION INSTRUCTIONS HI SINGLE FIRE RACE MOTORCYCLE IGNITION PART NO. 80 CAUTION: READ INSTRUCTIONS CAREFULLY BEFORE ING INSTALLATION INTRODUCTION The HI ignition system is intended for use with HarleyDavidson

More information

Part Number: TCA-715. Hardware Bag Contents. General Applicability SE and LE MODELS. Conflicts - XSE and XLE

Part Number: TCA-715. Hardware Bag Contents. General Applicability SE and LE MODELS. Conflicts - XSE and XLE Date: 03.11.2015 TOYOTA CAMRY 2015 - LED DRL w/turn signal Part Number: TCA-715 Kit Contents Item # Quantity Reqd. Description 1 2 DRL housings w/integrated turn singal 2 1 Harness bag 3 1 User s card

More information

Mazda CX7 2010-up 99-7520B

Mazda CX7 2010-up 99-7520B INSTALLATION INSTRUCTIONS FOR PART 99-7520B APPLICATIONS Mazda CX7 2010-up 99-7520B KIT FEATURES DIN radio provision with pocket ISO radio provision with pocket Double DIN radio provision Painted matte

More information

CONTENTS TOOLS REQUIRED: Ratchet 13mm Socket 10mm Socket Phillips Screwdriver Pliers Panel Removal Tool. Amp Installation

CONTENTS TOOLS REQUIRED: Ratchet 13mm Socket 10mm Socket Phillips Screwdriver Pliers Panel Removal Tool. Amp Installation CONTENTS 1EA. SUBWOOFER ASSEMBLY P/N RUWRANGLER 1EA. 200 WATT AMP/BRACKET ASSEMBLY P/N RM11JKBTL - Bracket P/N RE08BTL200R - Amp 1EA. POWER HARNESS P/N RHWRANGLERPWR 1EA. OVERLAY HARNESS P/N RHWRANGLER

More information

BD VALVE BODY INSTALLATION MANUAL

BD VALVE BODY INSTALLATION MANUAL 21-Jun-02 ValveBody #1030418/419 1 DODGE RAM 47RE TRANSMISSION (#1030418) 48RE TRANSMISSION (#1030419) BD VALVE BODY INSTALLATION MANUAL IMPORTANT READ ALL INSTRUCTIONS BEFORE INSTALLATION 21-Jun-02 ValveBody

More information

Installation instructions and tips on using the Dodge Ram HID conversion kit from Headlight Revolution.

Installation instructions and tips on using the Dodge Ram HID conversion kit from Headlight Revolution. www.headlightrevolution.com Installation instructions and tips on using the 2013-2014 Dodge Ram HID conversion kit from Headlight Revolution. NOTE: 2015 Ram Truck with same headlights have a different

More information

KTM AC to DC Stator Conversion Instructions (Floating the ground)

KTM AC to DC Stator Conversion Instructions (Floating the ground) KTM AC to DC Stator Conversion Instructions (Floating the ground) Overview: The following procedure is intended to convert AC (Alternating Current) electrical systems to DC (Direct Current). A qualified

More information

Cub/Passport 6 Volt Headlight Voltage Regulator

Cub/Passport 6 Volt Headlight Voltage Regulator Cub/Passport 6 Volt Headlight Voltage Regulator This unique device is the result of several years of owning, riding, and repairing Honda Cub and Passport motorcycles. This particular design is only for

More information

Automatic Transmission Removal from under a 1956 T-Bird

Automatic Transmission Removal from under a 1956 T-Bird Automatic Transmission Removal from under a 1956 T-Bird These are the notes I took when I removed the automatic transmission from under my 1956 Thunderbird. I did this by leaving the engine in place. Authored

More information

M-9424-463V Intake Manifold INSTALLATION INSTRUCTIONS

M-9424-463V Intake Manifold INSTALLATION INSTRUCTIONS Please visit www.fordracingparts.com for the most current instruction information!!! PLEASE READ ALL OF THE FOLLOWING INSTRUCTIONS CAREFULLY PRIOR TO INSTALLATION. AT ANY TIME YOU DO NOT UNDERSTAND THE

More information

PRODUCT: JK Frame-Built Combo Bumper Base READ INSTRUCTIONS IN FULL BEFORE INSTALLATION. QUESTIONS? CALL M-F 7:00 AM 5:00 PM PST

PRODUCT: JK Frame-Built Combo Bumper Base READ INSTRUCTIONS IN FULL BEFORE INSTALLATION. QUESTIONS? CALL M-F 7:00 AM 5:00 PM PST PRODUCT: JK Frame-Built Combo Bumper Base READ INSTRUCTIONS IN FULL BEFORE INSTALLATION. QUESTIONS? CALL 916-631-8071 M-F 7:00 AM 5:00 PM PST REV: C 06-22-2016 II-3160 The MetalCloak experience includes

More information

TECHNICAL INFORMATION

TECHNICAL INFORMATION TECHNICAL INFORMATION Models No. Description GN900 Cordless Clipped Head Framing Nailer CONCEPT AND MAIN APPLICATIONS Model GN900 is a cordless clipped head nailer developed for a wide range of framing

More information

2011 F250 6 SUSPENSION KIT

2011 F250 6 SUSPENSION KIT 92156400 Thank you for choosing Rough Country for your suspension needs. 2011 F250 6 SUSPENSION KIT Rough Country recommends a certified technician installs this system. In addition to these instructions,

More information

Sport Coil Springs (19425) Scion tc

Sport Coil Springs (19425) Scion tc Sport Coil Springs (19425) Scion tc Thank you for your purchase from our new line of Scion tc parts. Please call us at (877) 4NO-ROLL if you have any questions regarding the service or installation of

More information

INSTALLATION INSTRUCTIONS: HARLEY-DAVIDSON DYNA HI-OUTPUT GRENADES 2-INTO-2 PART# 16899/16896/46896/46899

INSTALLATION INSTRUCTIONS: HARLEY-DAVIDSON DYNA HI-OUTPUT GRENADES 2-INTO-2 PART# 16899/16896/46896/46899 INSTALLATION INSTRUCTIONS: HARLEY-DAVIDSON DYNA HI-OUTPUT GRENADES 2-INTO-2 PART# 16899/16896/46896/46899 Congratulations, you have purchased the finest exhaust system available for your motorcycle. Your

More information

How-To: Replace Timing Belt, Timing Balancer Belt and Water Pump 1994 Honda Accord EX Coupe with a F22B1

How-To: Replace Timing Belt, Timing Balancer Belt and Water Pump 1994 Honda Accord EX Coupe with a F22B1 HowTo: Replace Timing Belt, Timing Balancer Belt and Water Pump 1994 Honda Accord EX Coupe with a F22B1 Tool List 1/4 Drive Ratchet 1/4 Drive 3 Extension 1/4 Drive 6pt Metric Sockets (8mm 12mm) 1/4 Drive

More information