Installation instructions, accessories. Alarm, siren. Volvo Car Corporation Gothenburg, Sweden. Instruction No Version Part. No

Save this PDF as:
 WORD  PNG  TXT  JPG

Size: px
Start display at page:

Download "Installation instructions, accessories. Alarm, siren. Volvo Car Corporation Gothenburg, Sweden. Instruction No Version Part. No. 30633795 1."

Transcription

1 Instruction No Version Part. No Alarm, siren Page 1 / 12

2 Equipment A A A IMG Page 2 / 12

3 IMG Page 3 / 12

4 INTRODUCTION Read through all of the instructions before starting installation. Notifications and warning texts are for your safety and to minimise the risk of something breaking during installation. Ensure that all tools stated in the instructions are available before starting installation. Certain steps in the instructions are only presented in the form of images. Explanatory text is also given for more complicated steps. In the event of any problems with the instructions or the accessory, contact your local Volvo dealer. Note! This accessory is connected to the car's electrical system. It requires software unique to the car. 1 Turn the ignition key to position 0. IMG Page 4 / 12

5 2A Illustration A applies to left-hand drive cars Illustration B applies to right-hand drive cars Note the position of the windscreen wipers on the windscreen. Undo the nuts and remove the windscreen wipers. 2B J J Remove the four clips (1) in the panel by tapping out the centre pin. Rotate the two clips (2) 90 towards each other. Applies to left-hand drive cars Detach the panel first on the right-hand side and pull it up from the right-hand wiper shaft. Pull the panel up from the left-hand wiper shaft. Note! J The panel has little space on the left-hand side. Pull carefully so that the clips on the underneath/rear edge do not break. Page 5 / 12

6 Remove the panel carefully. Pull it up at the front edge and then pull it forwards. Applies to right-hand drive cars Detach the panel first on the left-hand side and pull it up from the left-hand wiper shaft. Pull the panel up from the right-hand wiper shaft. Note! The panel has little space on the right-hand side. Pull carefully so that the clips on the underneath/rear edge do not break. Remove the panel carefully. Pull it up at the front edge and then pull it forwards. 4A Illustration A applies to left-hand drive cars Illustration B applies to right-hand drive cars Remove the protective nuts on the car's two studs below the front edge of the windscreen. The siren must be located on the right-hand side for left-hand drive cars and on the left-hand side for right-hand drive cars. Slide the siren as far as possible along the bracket's slot. On right-hand drive cars it must be slid to the right and on left-hand drive cars to the left. Install two nuts from the kit and torque tighten to 10 Nm (7 lbf.ft.). 4B IMG Remove the protective plug from the pre-routed connector and plug the connector into the siren. IMG Page 6 / 12

7 5 Reinstall the panel above the wiper motor. Reinstall the windscreen wipers and set them in the correct position. Tighten the nuts. Tighten to 24 Nm (18 lbf.ft.). 6A Illustration A Remove the covers for the nozzles for the headlamp washers on the right and left-hand sides. Carefully grip the cover. Pull the cover out until its catch becomes accessible. Illustration B Press the catch up. Remove the cover. Do not damage the painted surfaces or the washer nozzles. 6B IMG J Page 7 / 12

8 7 Remove the screws to the air baffle. IMG Remove the five screws holding the bumper cover in the wing liner on the left and right-hand sides. IMG Push in the centre of the clips (1). Remove the clips. Remove the screws (2). IMG Page 8 / 12

9 10 Press in the centre of the four clips on the front air intake and remove them. Note! One clip is concealed. Remove the cover. IMG Press the holders in and remove the front air intake. IMG Remove the two screws on the air intake. IMG Page 9 / 12

10 13 Remove the air intake by turning it clockwise one quarter of a turn. IMG Remove the two screws for the panel over the bonnet catch. Remove the panel. Lift it up at the rear edge and then pull it backwards. J Page 10 / 12

11 15 Unhook the wire sleeve and the wire from the mounting in the bonnet catch. J Remove the bonnet catch screws. Remove the bonnet catch. J Unplug the pre-routed connector from the parking module in the bonnet catch by pressing in the catch and pulling. Place the bonnet catch to one side, it shall not be used again. J Page 11 / 12

12 18 Take the new bonnet catch from the kit and secure it with the existing screws. Torque tighten the screws to 24 Nm (18 lbf.ft.). Plug the bonnet catch's connector (1) into the pre-routed connector (2). Secure the wire and the sleeve in the new bonnet catch. Reinstall the panel above the bonnet catch. Reinstall the air intake. J Reinstall the bumper cover using the five clips and the two screws in the upper edge. Reconnect the connectors for the fog lamps if applicable. Make sure that the air baffle engages its mounting correctly. Reinstall the air baffle screws. Press the end faces for the bumper cover into the body and reinstall the five screws at the front edge of the wheel housing (on the right and left-hand sides). Download the software for the accessory's function following the service information in VIDA. Page 12 / 12

V70 2011. Installation instructions, accessories. Digital radio DAB. Volvo Car Corporation Gothenburg, Sweden. V70 (08-) 2011 Volvo Cars Europe

V70 2011. Installation instructions, accessories. Digital radio DAB. Volvo Car Corporation Gothenburg, Sweden. V70 (08-) 2011 Volvo Cars Europe Instruction No Version Part. No. 31266810 1.1 31266809 Digital radio DAB IMG-295623 Page 1 of 13 Equipment IMG-242205 A0000162 IMG-239664 IMG-285783 Page 2 of 13 IMG-213320 Page 3 of 13 INTRODUCTION Read

More information

Installation instructions, accessories - Alarm siren

Installation instructions, accessories - Alarm siren XC90 Section Group Weight(Kg/Pounds) Year Month 3 36 2003 04 XC90 2003, XC90 2004, XC90 2005, XC90 2006, XC90 2007, XC90 2008, XC90 2009, XC90 2010 R3904364 Page 1 of 6 Required tools A0000162 A0000161

More information

Installation instructions, accessories. Cruise control. Volvo Car Corporation Gothenburg, Sweden. Instruction No Version Part. No. 30739998 1.

Installation instructions, accessories. Cruise control. Volvo Car Corporation Gothenburg, Sweden. Instruction No Version Part. No. 30739998 1. Instruction No Version Part. No. 30739998 1.1 Cruise control Page 1 / 11 Equipment A0000162 A0000161 A0801178 D8802049 Page 2 / 11 M8802108 Page 3 / 11 IMG-223164 Page 4 / 11 IMG-213320 Page 5 / 11 INTRODUCTION

More information

Installation instructions, accessories. Body kit. Volvo Car Corporation Gothenburg, Sweden. Page 1 / 21 J

Installation instructions, accessories. Body kit. Volvo Car Corporation Gothenburg, Sweden. Page 1 / 21 J Installation instructions, accessories Instruction No 31372892 Version 1.4 Part. No. 39874286 Body kit J8000369 Volvo Car Corporation Body kit- 31372892 - V1.4 Page 1 / 21 Equipment A0000162 A0000172 A0000161

More information

Installation instructions, accessories - Navigation system, RTI

Installation instructions, accessories - Navigation system, RTI XC90 Section Group Weight(Kg/Pounds) Year Month 3 393 4/8.8 2007 08 Page 1 of 20 Required tools A0000162 IMG-239667 IMG-239664 IMG-239980 IMG-242205 R8802817 R3905015 Page 2 of 20 R3903812 IMG-213320 Page

More information

Wiper mechanism and wiper motor, windscreen, replacing

Wiper mechanism and wiper motor, windscreen, replacing "VCC137971 EN 20101201" file://c:\info\vv132007\ie\en\31\vcc137971.htm Page 1 of 3 Wiper mechanism and wiper motor, windscreen, replacing Removal Preparations Check that the wiper motor is in the parked

More information

Installation instructions, accessories - Handsfree, Volvo Handsfree System with Bluetooth

Installation instructions, accessories - Handsfree, Volvo Handsfree System with Bluetooth XC90 Section Group Weight(Kg/Pounds) Year Month 3 394 1/2.2 2007 11 XC90 2003, XC90 2004, XC90 2005, XC90 2006, XC90 2007, XC90 2007, XC90 2008, XC90 2008, XC90 2009, XC90 2010 Replaces issue: 2006 05

More information

Installation instructions, accessories - Handsfree for cellular phone, system B, entry level

Installation instructions, accessories - Handsfree for cellular phone, system B, entry level XC90 Section Group Weight(Kg/Pounds) Year Month 3 39 0.5/1.1 2006 07 XC90 2003, XC90 2004 IMG-249663 Page 1 of 18 Required tools A0000162 A0000163 IMG-239664 M0000232 IMG-253123 IMG-252223 Page 2 of 18

More information

2007 Hummer H3. 2007 ACCESSORIES & EQUIPMENT Bumpers and Fascias - H3. Fastener Tightening Specifications Specification Application

2007 Hummer H3. 2007 ACCESSORIES & EQUIPMENT Bumpers and Fascias - H3. Fastener Tightening Specifications Specification Application SPECIFICATIONS FASTENER TIGHTENING SPECIFICATIONS REPAIR INSTRUCTIONS FRONT BUMPER REPLACEMENT 2007 ACCESSORIES & EQUIPMENT Bumpers and Fascias - H Fastener Tightening Specifications Specification Application

More information

FUEL TANK KIT FITTING INSTRUCTIONS

FUEL TANK KIT FITTING INSTRUCTIONS A.Tank Fitting FUEL TANK KIT FITTING INSTRUCTIONS 1. Remove side panels and seat, disconnect the battery. 2. Remove SAS valve from LH frame guard and disconnect at plug, remove frame guard. 3. Remove rectifier

More information

5 Mechanisms and accessories

5 Mechanisms and accessories 5 Mechanisms and accessories 51A SIDE OPENING ELEMENT MECHANISMS 52A NON-SIDE OPENING ELEMENT MECHANISMS 54A WINDOWS 55A EXTERIOR PROTECTION 56A EXTERIOR EQUIPMENT 57A INTERIOR EQUIPMENT X79 NOVEMBER 2009

More information

Volkswagen New Beetle Body - Exterior 66 Exterior equipment (Page GR-66)

Volkswagen New Beetle Body - Exterior 66 Exterior equipment (Page GR-66) 66 Exterior equipment (Page GR-66) Wheel house liner, removing and installing Front wheel house liner Rear wheel house liner Rear view mirror Mirror glass, removing and installing Mirror housing, removing

More information

RECOMMENDED SEQUENCE OF APPLICATION

RECOMMENDED SEQUENCE OF APPLICATION SCION XB 2011>> PART NUMBER: 260-1002-XB1 LED DAYTIME RUNNING LIGHTS GENERAL APPLICABILITY ALL MODELS CONFLICTS NONE KIT CONTENTS ITEM QTY DESCRIPTION 1 2 LED DRL ASSEMBLIES 2 1 DRL CONTROL MODULE 3 1

More information

Ford Focus ST 250 fitting Instructions

Ford Focus ST 250 fitting Instructions Ford Focus ST 250 fitting Instructions Tools Required: T2 Torx T30 Torx Flat blade screw driver 6mm socket 7mm socket 10mm socket 13mm socket Trolley jack Axle stands Car lift Note: It will be easier to

More information

INSTALLATION INSTRUCTIONS

INSTALLATION INSTRUCTIONS INSTALLATION INSTRUCTIONS Accessory Application Publications No. BII 37369 WHEEL 2008 TL Issue Date JUN 2007 PARTS LIST 1. Make sure you have the anti-theft code for the radio, then write down the frequencies

More information

Replacing fuel tank. Copyright 2004 Volvo Car Corporation. All rights reserved. Draining fuel tank

Replacing fuel tank. Copyright 2004 Volvo Car Corporation. All rights reserved. Draining fuel tank "VCC013780 EN 20090609" 1(6) Replacing fuel tank Special tools: 981 2270, 981 2273, 981 2282, 999 5533, 999 5485, 999 5486, 999 5972 Draining fuel tank Use draining unit 981 2270, 2273 and 2282. Insert

More information

INSTALLATION INSTRUCTIONS

INSTALLATION INSTRUCTIONS INSTALLATION INSTRUCTIONS Accessory Application Publications No. AII 24087 2003 ACCORD 2-DOOR Issue Date SEP 2002 PARTS LIST P/N 08U97-SDN-110 (Birdseye) P/N 08U97-SDN-110A (Burlwood) P/N 08U97-SDN-110B

More information

INSTALLATION INSTRUCTIONS

INSTALLATION INSTRUCTIONS INSTALLATION INSTRUCTIONS Accessory Application 2009 PILOT Publications No. AII 39408 Issue Date MAY 2008 PARTS LIST Steering Wheel Trim (With Cruise and Audio) P/N 08Z13-SZA-130B (Chocolate) P/N 08Z13-SZA-140B

More information

Figure 2 The fan and shroud also needs to be removed for access to the four a/c compressor bolts and removal of the compressor from the top.

Figure 2 The fan and shroud also needs to be removed for access to the four a/c compressor bolts and removal of the compressor from the top. Here are some pictures to show what s required when replacing the A/C compressor, expansion valve and receiver/drier on a 2001 Volvo V70. Even if you don t replace these A/C parts these pictures can help

More information

SCION xb FOG LIGHTS Preparation. Part Number: PT Fog Light Kit Contents. General Applicability. Recommended Sequence of Application

SCION xb FOG LIGHTS Preparation. Part Number: PT Fog Light Kit Contents. General Applicability. Recommended Sequence of Application Preparation Part Number: PT857-52110 Fog Light Kit Contents Item # Quantity Reqd. Description 1 1 Light Assembly, Fog Driver Side 2 1 Light Assembly, Fog Passenger Side 3 1 Mounting Hardware Bag 4 1 Hardware

More information

2011 KIA Optima SX / EX Turbo Mesh Grille

2011 KIA Optima SX / EX Turbo Mesh Grille IMPORTANT: PLEASE KEEP THIS INSTRUCTION MANUAL FOR FUTURE REFERENCE! TOOLS REQUIRED 2011 KIA Optima SX / EX Turbo Mesh Grille Upper and Lower Overlay Part #: Complete 1310-0102-11SX / Black Ice Part #1310-B102-11SX

More information

Installation instruction do88 Intercooler for Volvo S40 / V50 / C30

Installation instruction do88 Intercooler for Volvo S40 / V50 / C30 Installation instruction do88 Intercooler for Volvo S40 / V50 / C30 This instruction shows how to replace the OEM intercooler with our performance intercooler. 2. 3. 1. 4. 5. Part number: ICM-170 6. At

More information

ITEM DESCRIPTION QTY PART NO

ITEM DESCRIPTION QTY PART NO SS125HF 1/2/06 ITEM DESCRIPTION QTY PART NO 1 BODY SNORKEL (SS120HF) 1 320-133-000 2 3 ½" AIR RAM ASSEMBLY 1 000-135-800 3 BRACKET - UPPER MOUNTING 1 320-032-000 4 BOLT - HEX 6.0mm x 1.0 x 14mm (SEMS)

More information

BRAKE SYSTEM Volvo 850 DESCRIPTION BLEEDING BRAKE SYSTEM ADJUSTMENTS BRAKE PEDAL HEIGHT PARKING/EMERGENCY BRAKE

BRAKE SYSTEM Volvo 850 DESCRIPTION BLEEDING BRAKE SYSTEM ADJUSTMENTS BRAKE PEDAL HEIGHT PARKING/EMERGENCY BRAKE BRAKE SYSTEM 1995 Volvo 850 1995-96 BRAKES Volvo Brakes - Disc 850 DESCRIPTION All models use front and rear disc brakes with 3 makes of calipers: ATE, Bendix (DBA) and Girling. Service brakes are hydraulically-operated

More information

5800 Temperature Sensor Cable Assembly

5800 Temperature Sensor Cable Assembly 5800 Temperature Sensor Cable Assembly Removal and Replacement Instruction Sheet #60-4702-070 Revision D, January 14, 2013 Overview The 5800 has two refrigeration temperature sensors, one attached to the

More information

8/22/2005 JWT G35 / 350Z TWIN TURBO FUEL MANAGEMENT UNIT (FMU) INSTALLATION GUIDE ADDENDUM

8/22/2005 JWT G35 / 350Z TWIN TURBO FUEL MANAGEMENT UNIT (FMU) INSTALLATION GUIDE ADDENDUM 8/22/2005 JWT G35 / 350Z TWIN TURBO FUEL MANAGEMENT UNIT (FMU) INSTALLATION GUIDE ADDENDUM 1 1. Installing the new fuel pump and FMU. Wear eye protection and insure that you are working in a well-ventilated

More information

SECURITY SYSTEM SMART SIREN KIT

SECURITY SYSTEM SMART SIREN KIT -J00876 REV. 009-0-09 SECURITY SYSTEM SMART SIREN KIT GENERAL Kit Number 688-0 Models For model fitment information, see the P&A Retail Catalog or the Parts and Accessories section of www.harley-davidson.com

More information

POWER LOCK KIT GENERAL INSTALLATION -J04427 REV. 2007-12-04. Kit Number. Models. Additional Parts Required. Kit Contents

POWER LOCK KIT GENERAL INSTALLATION -J04427 REV. 2007-12-04. Kit Number. Models. Additional Parts Required. Kit Contents -J0 REV. 00--0 POWER LOCK KIT GENERAL Kit Number -0, 0-0 Models For model fitment information, please see the P&A Retail Catalog or the Parts and Accessories section of www.harleydavidson.com (English

More information

GPS AutoSteer System Installation Manual

GPS AutoSteer System Installation Manual GPS AutoSteer System Installation Manual Supported Vehicles John Deere Sprayers 4720 4630 4730 4830 AutoTrac Ready PN: 602-0227-01-A LEGAL DISCLAIMER Note: Read and follow ALL instructions in this manual

More information

www.pure-motorsport.co.uk 01841 531102 Renault Clio 172/182 (with air-con) lightweight pulley kit fitting instructions. This pulley kit has been designed to make it easy to remove the aircon on your 172/182

More information

Installation Instructions

Installation Instructions Installation Instructions For Use with PXPV230, PXPV265, PXPD230, and PXPD265 models Attention! - Please read these instructions completely before attempting installation. Always unplug the power supply

More information

TSB PART NAME PART NUMBER REMARK 56315-2H000FFF

TSB PART NAME PART NUMBER REMARK 56315-2H000FFF 1 of 13 17.10.2008 г. 11:25 TSB Model Group TSB No. Cee'd [ED]() Steering System(61) KFE08-61-V040-ED Subject Published 5/23/2008 MDPS WORM SHAFT FLEXIBLE COUPLING REPLACEMENT TSB Type Field Fix Area &

More information

BULB REPLACEMENT BROCHURE

BULB REPLACEMENT BROCHURE BULB REPLACEMENT BROCHURE Contents Contents Explanation of Symbols 03 Audi A1 04 06 Audi A4 1.9 TDI with Xenon Headlights (from years of manufacture 2000 to 2005) 07 10 Audi A4 (8K5 / 8K2) with Bi-Xenon

More information

Upper Steering Column Bearing Kit Installation Instructions

Upper Steering Column Bearing Kit Installation Instructions Upper Steering Column Bearing Kit Installation Instructions Thank you for purchasing the Moss MGB Upper Steering Column Bearing Kit. In order to remove and replace the bearing in your steering column,

More information

BRAKE SYSTEM Volvo 960 DESCRIPTION BLEEDING BRAKE SYSTEM ADJUSTMENTS BRAKE PEDAL HEIGHT PARKING/EMERGENCY BRAKE STOPLIGHT SWITCH

BRAKE SYSTEM Volvo 960 DESCRIPTION BLEEDING BRAKE SYSTEM ADJUSTMENTS BRAKE PEDAL HEIGHT PARKING/EMERGENCY BRAKE STOPLIGHT SWITCH BRAKE SYSTEM 1994 Volvo 960 1994 BRAKES Volvo Brake System - Disc 960 DESCRIPTION All models use front and rear disc brakes with 3 makes of calipers: ATE, Bendix (DBA) and Girling. Service brakes are hydraulically-operated

More information

AUDI S5 3.0TFSI CHARGECOOLER RADIATOR INSTALLATION INSTRUCTIONS

AUDI S5 3.0TFSI CHARGECOOLER RADIATOR INSTALLATION INSTRUCTIONS AUDI S5 3.0TFSI CHARGECOOLER RADIATOR INSTALLATION INSTRUCTIONS Please thoroughly read through and familiarize yourself with these instructions in their entirety prior to beginning any part of the installation

More information

INSTALL/REMOVAL INSTRUCTIONS: WINDOW REGULATOR

INSTALL/REMOVAL INSTRUCTIONS: WINDOW REGULATOR REMOVAL/INSTALL OF WINDOW REGULATOR (741-306) Honda Accord 2003 07 General Tech Tips: Use painter s tape rather than duct tape to secure window. It will not damage paint or leave sticky residue. A plastic

More information

INSTALLATION INSTRUCTIONS

INSTALLATION INSTRUCTIONS INSTALLATION INSTRUCTIONS Accessory TRIM Application 2008 ACCORD 4-DOOR Publications No. AII 35362 Issue Date AUG 2007 PARTS LIST Steering Wheel Trim (Without Navigation) P/N 08Z13-TA0-100 Right steering

More information

Front brakes (FN- 3), servicing

Front brakes (FN- 3), servicing j a t Front brakes (FN- 3), servicing 46-1 Front brakes, servicing Note: Install complete repair kit. After replacing brake pads and before moving vehicle, depress brake pedal several times firmly to properly

More information

CorkSport Mazdaspeed 6 Rear Sway Bar 2006-2007 Mazdaspeed 6

CorkSport Mazdaspeed 6 Rear Sway Bar 2006-2007 Mazdaspeed 6 CorkSport Mazdaspeed 6 Rear Sway Bar 2006-2007 Mazdaspeed 6 Pre-Installation Notes: The CorkSport Rear Sway Bar is a great addition to improving the handling performance to the Mazdaspeed 6. It will minimize

More information

How To... SERVICE AND REPAIR

How To... SERVICE AND REPAIR SECTION III How To... SERVICE AND REPAIR Page Pedals, Crank Arms, and Side Shrouds...3 Crank Shaft Hub Assembly...5 Crank Shaft and Bearings...7 Clutch Assembly...10 Intermediate Pulley Shaft and Bearings...11

More information

TOYOTA RAV4 2006 - TRAILER WIRE HARNESS Section I Installation Preparation

TOYOTA RAV4 2006 - TRAILER WIRE HARNESS Section I Installation Preparation Section I Installation Preparation Part Number: 08921-42900 Kit Contents Item # Quantity Reqd. Description 1 1 Converter 2 1 Wire harness 3 1 Sub wire harness No.1 4 2 Plastic Tie (300mm) 5 21 Plastic

More information

Tech Article. Raingear Wiper System. From Newsletter st Quarter of Unabridged. 1. Disconnect your battery.

Tech Article. Raingear Wiper System. From Newsletter st Quarter of Unabridged. 1. Disconnect your battery. Parts you will need Danchuk # 12825 Raingear Wiper System with Intermittent Switch Danchuk # 12828 Raingear Universal Washer Kit Danchuk # 913 Wiper Switch Tool Danchuk # 912 Wiper Escutcheon Nut Tool

More information

VW GOLF Mk4 TDI FRONT MOUNTING INTERCOOLER INSTALLATION INSTRUCTIONS

VW GOLF Mk4 TDI FRONT MOUNTING INTERCOOLER INSTALLATION INSTRUCTIONS VW GOLF Mk4 TDI FRONT MOUNTING INTERCOOLER INSTALLATION INSTRUCTIONS Tools required: 10mm/13mm socket and 3/8 drive ratchet with extension Torx T20/25/30 screwdrivers or bits Phillips head screwdriver,

More information

Installation Instructions PART NUMBERS: 24934, 60372, 77321

Installation Instructions PART NUMBERS: 24934, 60372, 77321 Cequent Performance Products, Inc. Installation Instructions PART NUMBERS: 24934, 60372, 77321 Applications: Years Make Models 2011-Current* Mini Countryman *Visit our website for the most up to date information

More information

INSTALLATION INSTRUCTIONS

INSTALLATION INSTRUCTIONS INSTALLATION INSTRUCTIONS Accessory Application Publications No. AII23628 2003 PILOT Issue Date MAY 2002 PARTS LIST Security System Kit (sold separately): P/N 08E51-S84-100 2 Remote controls Attachment

More information

Windshield Wiper System

Windshield Wiper System Volkswagen Golf 5 - Windshield Wiper System Volkswagen Technical Site: http://volkswagen.msk.ru http://vwts.info Page 1 / 15 92-1 Windshield Wiper System General information The windshield wiper system

More information

TOP AND FRONT OF ENGINE. Timing belt

TOP AND FRONT OF ENGINE. Timing belt 11 Timing belt SPECIAL TOOLING REQUIRED Mot. 1390 Mot. 1536 Mot. 1534 Mot. 1537 Engine and transmission assembly mounting tool TDC setting pin Inlet camshaft timing/locking tool Exhaust camshaft timing/

More information

5 Mechanisms and accessories

5 Mechanisms and accessories 5 Mechanisms and accessories 50A GENERAL INFORMATION 51A SIDE OPENING ELEMENT MECHANISMS 52A NON-SIDE OPENING ELEMENT MECHANISMS 54A WINDOWS 55A EXTERIOR PROTECTION 56A EXTERIOR EQUIPMENT 57A INTERIOR

More information

Installation Instructions Kit, Base Rail Bracket Part # 31404

Installation Instructions Kit, Base Rail Bracket Part # 31404 Installation Instructions Kit, Base Rail Bracket Part # 31404 Dealer / Installer: Provide a copy of these Instructions to the end user of this product. These Instructions. provide important operating and

More information

Supercharger Reduction Pulley Install Instructions for MINI Cooper S

Supercharger Reduction Pulley Install Instructions for MINI Cooper S Page 1 of 8 Technical Service For any technical advice concerning this product or its installation, call our Support Line at: 903-581-1855 PROMINI / BMP Design Inc. 3208 Park Center Drive Tyler, Texas,

More information

INSTALLATION INSTRUCTIONS

INSTALLATION INSTRUCTIONS INSTALLATION INSTRUCTIONS Accessory Application Publications No. AII 26327 2004 S2000 Issue Date OCT 2004 PARTS LIST Security System: P/N 08E51-S84-100 Attachment Kit: P/N 08E55-S2A-101 2 Remote controls

More information

SCION tc LOWERING SPRINGS Preparation

SCION tc LOWERING SPRINGS Preparation Preparation Part Number: PTR11-21100 PTR11-21100-50 Kit Contents Item # Quantity Reqd. Description 1 2 Front Springs 2 2 Rear Springs 3 2 Locking Nuts 4 2 Spring Bumpers, Front 5 1 Instruction Form Hardware

More information

Solstice/Sky Water Pump Replacement

Solstice/Sky Water Pump Replacement Solstice/Sky Water Pump Replacement The water pump on the Solstice/Sky is starting to need replacement on some vehicles. This guide will help in replacing the water pump while the engine is still in the

More information

Bulb Replacement REPLACING BULBS WARNING

Bulb Replacement REPLACING BULBS WARNING Bulb Replacement REPLACING BULBS Check the operation of all exterior lamps before you drive the vehicle. Caution: Before attempting to replace a bulb, ensure that both the affected lamp and the vehicle's

More information

Installation Instructions

Installation Instructions Installation Instructions Page 1 of 8 January 2009 Audio, Alarm Ver. 3.0 Accessory Development These Installation Instructions supersede all previous versions. SUBJECT ALARM RETROFIT KIT - P/N 65 73 0

More information

Instrument panel. Volkswagen Touareg - Instrument panel. Special tools, testers and auxiliary items required. Release lever T10039

Instrument panel. Volkswagen Touareg - Instrument panel. Special tools, testers and auxiliary items required. Release lever T10039 Volkswagen Touareg - Instrument panel Page 1 / 14 70-1 Instrument panel Tools Special tools, testers and auxiliary items required Release lever T10039 Instrument panel, removing and installing Removing

More information

Installing RNS-E SAT NAV for Audi A4

Installing RNS-E SAT NAV for Audi A4 As one of the major options on the A4 you can get a DVD Satellite Navigation System call the RNS-E. With the help of ebay these sat nav systems are now available to by at a rough cost of 650 plus the cost

More information

Nissan GTR Alpha Fuel System

Nissan GTR Alpha Fuel System Nissan GTR Alpha Fuel System The goal of AMS is to provide the highest quality, best performing products available. By utilizing research and development, and rigorous testing programs AMS will never compromise

More information

SERVICE MANUAL. Corpus 3G. Seat system for electric wheelchair

SERVICE MANUAL. Corpus 3G. Seat system for electric wheelchair SERVICE MANUAL US Corpus 3G Seat system for electric wheelchair How to contact Permobil Head Office of the Permobil group Produced and published by Permobil AB, Sweden Version 4, 2014-07 Item No.: 205260-US-0

More information

Tools Required WARNING. Test Fit Key. Note BMW K 1600 GT / GTL SARGENT WORLD SPORT PERFORMANCE SEAT INSTALLATION GUIDE

Tools Required WARNING. Test Fit Key. Note BMW K 1600 GT / GTL SARGENT WORLD SPORT PERFORMANCE SEAT INSTALLATION GUIDE BMW K 1600 GT / GTL SARGENT WORLD SPORT PERFORMANCE SEAT INSTALLATION GUIDE To protect your heated seats from wiring, lock or key damage, please read all instructions carefully before beginning this installation.

More information

INSTALLATION INSTRUCTIONS

INSTALLATION INSTRUCTIONS INSTALLATION INSTRUCTIONS Accessory TRAILER HITCH CR-V Application Publications No. AII 12095 Issue Date DEC 2011 PARTS LIST Trailer Hitch Kit P/N 08L92-T0A-100 Hex nut, 12 mm Trailer hitch Hitch pin Hitch

More information

Form #5327, Rev. RTP, 03-28-12. Honda Civic DRL KIT 2011-UP Part Number: 260-1022-HN2

Form #5327, Rev. RTP, 03-28-12. Honda Civic DRL KIT 2011-UP Part Number: 260-1022-HN2 Form #5327, Rev. RTP, 03-28-12 Honda Civic DRL KIT 2011-UP Kit Contents Item # Qty. Description 1 1 Controller 2 2 DRLs 3 2 Bezels L, R 4 1 DRL Extension 5 1 Ignition Harness 6 1 Illumination 7 1 Ground

More information

Cisco Unified IP Phone Wall Mount

Cisco Unified IP Phone Wall Mount Wall Mount Components for Cisco Unified IP Phone 690, page Wall Mount Components for Cisco Unified IP Phone 69, page 4 Adjust Handset Rest, page 0 Wall Mount Components for Cisco Unified IP Phone 690 The

More information

BILLET HEADLAMP WITH SHORT/TALL MOUNTS

BILLET HEADLAMP WITH SHORT/TALL MOUNTS -J099 REV. 00-0- BILLET HEADLAMP WITH SHORT/TALL MOUNTS GENERAL Kit Number 9-0, 9-0 Models Kit 9-0 is a -/ inch headlamp and kit 9-0 is a -/ inch headlamp. Both kits will fit the models listed in Table.

More information

INSTALLATION INSTRUCTION. Do not attempt to manually extend or retract the mirrors. They should be moved under their motor power only!!

INSTALLATION INSTRUCTION. Do not attempt to manually extend or retract the mirrors. They should be moved under their motor power only!! INSTALLATION INSTRUCTION Models: 6105 & 6105TK - GM '99-06 (and 07 classics ) Silverado and Sierra Model Pickups, Full Size SUV's and '01-current Heavy Duty without stock power mirrors. Do not attempt

More information

P150SC15. Designed for 2015 Ford F150 Super-Cab and Super-Crew vehicles without Sony System. 2015 Stillwater Designs P150SC15-A2-20150813

P150SC15. Designed for 2015 Ford F150 Super-Cab and Super-Crew vehicles without Sony System. 2015 Stillwater Designs P150SC15-A2-20150813 P150SC15 Designed for 2015 Ford F150 Super-Cab and Super-Crew vehicles without Sony System Subwoofer Assembly Amplifier Assembly Amplifier Harness 2015 Stillwater Designs P150SC15-A2-20150813 M6 Bolt M6

More information

INSTALLATION INSTRUCTIONS

INSTALLATION INSTRUCTIONS INSTALLATION INSTRUCTIONS Accessory Application Publication No. AUXILIARY WIRE HARNESS P/N 0SA30-HL3-100 SXS700M4/M2 MII 14607 Issue Date Revised October 2013 Honda Dealer: Please give a copy of these

More information

Accessing the printer system board

Accessing the printer system board Accessing the printer system board 1 Turn the printer off. 2 Unplug the printer power cord. 3 Disconnect all cables from the back of the printer. 4 Locate the metal plate at the back of the printer. Loosen

More information

FOCUS ST C OLD AIR INDUCTION SYSTEM FITTING INST RUCT IONS

FOCUS ST C OLD AIR INDUCTION SYSTEM FITTING INST RUCT IONS FOCUS ST C OLD AIR INDUCTION SYSTEM FITTING INST RUCT IONS The GGR Cold Air Induction System (CAIS) is designed as a direct replacement for the standard air filter assembly. Although fitting of this is

More information

Removing memory and option cards

Removing memory and option cards These instructions can help you remove memory or option cards. Use the following illustration to locate the connector for the card you want to remove. Hard disk connector 1 Option card connector Firmware

More information

Volkswagen Jetta, Golf, GTI 1999, 2000 Brake System 46 Brakes - Mechanical Components (Page GR-46)

Volkswagen Jetta, Golf, GTI 1999, 2000 Brake System 46 Brakes - Mechanical Components (Page GR-46) 46 Brakes - Mechanical Components (Page GR-46) Front brakes Brake pads, removing and installing Brake pads, removing and installing FN 3 brake caliper, servicing FS III brake caliper, servicing Rear wheel

More information

Windshield Wiper System

Windshield Wiper System Windshield Wiper System Page 1 / 17 92-1 Windshield Wiper System General information Caution! When disconnecting and reconnecting battery terminals, observe all applicable Notes and torque specifications,

More information

CETAC Z-Drive Assembly

CETAC Z-Drive Assembly CETAC Z-Drive Assembly Replacement Guide Manual Part Number 610144 Rev 1, 2012 CETAC Technologies, Printed in USA Overview This guide describes the necessary steps to replace the Z-drive assembly on your

More information

BMW Parts and Accessories Installation Instructions

BMW Parts and Accessories Installation Instructions BMW Parts and Accessories Installation Instructions Retrofit Anti-theft Alarm System (DWA) series-identical retrofit for BMW 5 Series saloon and touring (E 9, E 9/) left-hand drive F 9 005 W Installation

More information

Lista Shelf Converter Assembly Instructions for Multiple Shelving Applications

Lista Shelf Converter Assembly Instructions for Multiple Shelving Applications Lista Shelf Converter Assembly Instructions for Multiple Shelving Applications Table of Contents Safety Check List...2 Existing Shelving Assembly Notes...3 Three Basic Assembled Types...3 Recommended Drawer

More information

C5 Sound Deadening & Insulation Kit Interior Removal & Installation Instructions

C5 Sound Deadening & Insulation Kit Interior Removal & Installation Instructions C5 Sound Deadening & Insulation Kit Interior Removal & Installation Instructions Ok, let's start with taking the radio bezel dash area off first. Here is what the OEM radio looks like... First you flip

More information

TOYOTA FJ CRUISER TRAILER WIRE HARNESS Preparation

TOYOTA FJ CRUISER TRAILER WIRE HARNESS Preparation Preparation Part Number: 08921-35870 Kit Contents Item # Quantity Reqd. Description 1 1 Converter 2 1 Wire harness 3 1 Plastic tie (black) 4 1 Plastic tie (brown) 5 2 Packing 6 2 Bolt (M6) 7 2 Bolt (M5)

More information

Rear wheel brakes, servicing. Стр. 1 из 45. Note:

Rear wheel brakes, servicing. Стр. 1 из 45. Note: Volkswagen Touareg - Rear wheel brakes, servicing Стр. 1 из 45 46-2 Rear wheel brakes, servicing Rear brakes, FN 44 brake caliper, servicing Note: After replacing brake pads, depress brake pedal firmly

More information

K27 Focus ST CCK Installation

K27 Focus ST CCK Installation 8967 Gilder Rd., Ste. A Houston, TX 77064-1286 281-890-4772 Sales@KozmicMotorsports.com K27 Focus ST CCK Installation Important: On the allen drain plug that is included in the kit - We recommend using

More information

MIRRORS - POWER. Volkswagen Technical Site -

MIRRORS - POWER. Volkswagen Technical Site - MIRRORS - POWER Volkswagen Technical Site - http://volkswagen.msk.ru ARTICLE BEGINNING 1990-92 SAFETY EQUIPMENT Power Mirrors 1990-92 Passat 1991-92 Corrado, Golf, GTI, Jetta, Vanagon DESCRIPTION & OPERATION

More information

3. Remove the plastic cover on the inner wheel arch and expose the top of the turret.

3. Remove the plastic cover on the inner wheel arch and expose the top of the turret. 1. Put the car into gear or park and apply the hand brake, loosen the front wheel nuts on one side, raise the vehicle on a trolley or bottle jack under the axle and then support the vehicle with an axle

More information

INSTALLATION INSTRUCTIONS

INSTALLATION INSTRUCTIONS INSTALLATION INSTRUCTIONS Accessory Application Publications No. All 24393 ACCORD (DX, LX) SYSTEM 2-AND 4-DOOR Issue Date AUG 2002 PARTS LIST Security System Attachment (LX): P/N 08E55-SDA-100A Unit panel

More information

INSTALLATION INSTRUCTIONS

INSTALLATION INSTRUCTIONS INSTALLATION INSTRUCTIONS Accessory Application Publications No. ACCORD All 30209 2-AND 4-DOOR SYSTEM (VP, LX, SE) Issue Date AUG 2005 PARTS LIST Security System Attachment: P/N 08E55-SDA-100A Unit panel

More information

INSTALLATION INSTRUCTIONS

INSTALLATION INSTRUCTIONS INSTALLATION INSTRUCTIONS Accessory S P/N 08V31-SWA-100 Application CR-V Publications No. AII 32952-35942 Issue Date APRIL 2007 PARTS LIST Right fog light Switch Relay Left fog light Bracket Fog light

More information

INSTALLATION INSTRUCTIONS ELEVATION REAR BUMPER RAM

INSTALLATION INSTRUCTIONS ELEVATION REAR BUMPER RAM INSTALLATION INSTRUCTIONS PARTS LIST: 1 Elevation Bumper Assembly 4 8mm x 40mm Hex Bolts 1 Universal License Plate Light 4 8mm x 28mm x 3mm Flat Washers 8 12-1.75mm x 50mm Hex Bolts 4 8mm Lock Washers

More information

EXTERIOR 51-1 CONTENTS SERVICE SPECIFICATIONS... 2 MOULDINGS... 8 SEALANT AND ADHESIVE... 2 AERO PARTS SPECIAL TOOLS...

EXTERIOR 51-1 CONTENTS SERVICE SPECIFICATIONS... 2 MOULDINGS... 8 SEALANT AND ADHESIVE... 2 AERO PARTS SPECIAL TOOLS... 5- EXTERIOR CONTENTS 5090000 SERVICE SPECIFICATIONS... SEALANT AND ADHESIVE... SPECIAL TOOLS... FRONT BUMPER... 3 REAR BUMPER... 5 RADIATOR GRILLE... 7 ROOF RAIL... 7 MOULDINGS... 8 AERO PARTS... WINDSHIELD

More information

FL ADJUSTABLE RIDER BACKREST MOUNTING HARDWARE KIT

FL ADJUSTABLE RIDER BACKREST MOUNTING HARDWARE KIT -J070 REV. 0-0-0 FL ADJUSTABLE RIDER BACKREST MOUNTING HARDWARE KIT GENERAL Kit Number 9-09A Models For model fitment information, see the P&A Retail Catalog or the Parts and Accessories section of www.harley-davidson.com

More information

Application. Accessory. Publications No. HP TYPE 11 AM/FM RADIO GL1100. Issue Date DECEMBER 1981 PREFACE

Application. Accessory. Publications No. HP TYPE 11 AM/FM RADIO GL1100. Issue Date DECEMBER 1981 PREFACE PREFACE Accessory TYPE 11 AM/FM RADIO Congratulations on purchasing this quality Type 11 Honda Motorcycle Audio system. This booklet is your guide to the installation of your new Type II Honda Motorcycle

More information

Rating when used as a weight carrying hitch without spring bars:

Rating when used as a weight carrying hitch without spring bars: BOLT-TOGETHER WEIGHT DISTRIBUTING HITCH SYSTEM Rating when used as a weight distributing hitch with spring bars: Part Number 48051 4805 48053 48054 Max Tongue Weight 550 Ibs. 750 Ibs. 1000 Ibs. 1400 lbs.

More information

FRONT BUMPER INSTALLATION INSTRUCTIONS 2007-2011 DODGE / MERCEDES SPRINTER

FRONT BUMPER INSTALLATION INSTRUCTIONS 2007-2011 DODGE / MERCEDES SPRINTER Aluminess Products Inc 9402 Wheatlands Ct. #A Santee, CA 92071 619-449-9930 FRONT BUMPER INSTALLATION INSTRUCTIONS 2007-2011 DODGE / MERCEDES SPRINTER Please read before beginning Stainless steel hardware

More information

Electronic Stability Program (ESP) hydraulic unit, servicing

Electronic Stability Program (ESP) hydraulic unit, servicing Page 1 of 18 45-41 Electronic Stability Program (ESP) hydraulic unit, servicing The tightening torque for all brake lines on the Audi A4 is 15 Nm (11 ft lb). 1 - ESP hydraulic unit 2 - Nut Always replace

More information

AT AICS INSTALLATION AND OPERATION

AT AICS INSTALLATION AND OPERATION AT AICS INSTALLATION AND OPERATION Please ensure you read and fully understand this text before attempting any installation or maintenance. If you are unsure about any of the operations described below,

More information

CorkSport Lightweight Crank Pulley MazdaSpeed3

CorkSport Lightweight Crank Pulley MazdaSpeed3 A x l 6 3 1 0 www.corksport.com 2007-2011 MazdaSpeed3! WARNING: You will be removing several parts (including the valve cover and fuel pump) and unplugging numerous electrical and fuel components. Only

More information

WIPER/WASHER SYSTEM Nissan 240SX SYSTEM DESCRIPTION & OPERATION WIPER MOTOR DESCRIPTION & OPERATION WIPER AMPLIFIER DESCRIPTION & OPERATION

WIPER/WASHER SYSTEM Nissan 240SX SYSTEM DESCRIPTION & OPERATION WIPER MOTOR DESCRIPTION & OPERATION WIPER AMPLIFIER DESCRIPTION & OPERATION WIPER/WASHER SYSTEM 1990 Nissan 240SX 1990-92 ACCESSORIES & EQUIPMENT Wiper/Washer Systems Axxess, Maxima, Pathfinder, Pickup, Pulsar NX, Sentra, Stanza, 240SX, 300ZX NOTE: This article has been updated

More information

INSTALLATION GUIDE PREMIUM FRONT BUMPER. AEV30103AD Last Updated: 12/03/13 US PATENT: D683,281 CHINESE PATENT: ZL

INSTALLATION GUIDE PREMIUM FRONT BUMPER. AEV30103AD Last Updated: 12/03/13 US PATENT: D683,281 CHINESE PATENT: ZL PREMIUM FRONT BUMPER AEV30103AD Last Updated: 12/03/13 US PATENT: D683,281 CHINESE PATENT: ZL 2012 3 0026032.0 INSTALLATION GUIDE PLEASE READ BEFORE YOU START TO GUARANTEE A QUALITY INSTALLATION, WE RECOMMEND

More information

Dismantling and Reassembly Guide

Dismantling and Reassembly Guide Super X3 Mill Dismantling and Reassembly Guide A picture story book to help you dismantle and reassemble your Sieg Super X3 Mill Arc Euro Trade Ltd. 10 Archdale Street, Syston, Leicester, LE7 1NA. Web:

More information

XL1200C TURN SIGNAL RELOCATION KIT

XL1200C TURN SIGNAL RELOCATION KIT REV. 011-08-18 XL100C TURN SIGNAL RELOCATION KIT GENERAL Kit Numbers 67800071, 67800077 Models For model fitment information, see the P&A retail catalog or the Parts and Accessories section of www.harley-davidson.com

More information

INSTALLATION INSTRUCTIONS

INSTALLATION INSTRUCTIONS INSTALLATION INSTRUCTIONS Accessory Application Publications No. XM RADIO SYSTEM 2003 ACCORD 4 DOOR AII 24378 Issue Date MARCH 2003 The XM Radio will not fit in a vehicle equipped with a rear entertainment

More information

Fresenius Medical Care North America Service Bulletin

Fresenius Medical Care North America Service Bulletin Fresenius Medical Care North America Service Bulletin Equipment: Bulletin: Subject: 2008 K Hemodialysis Machines 15-FRK-001 Rev A Optional Shunt Box Ferrite Core Installation (Update) 1.0 PURPOSE To inform

More information