SAFETY DATA SHEET. This product is a toner preparation that is used in HP LaserJet 4/4 Plus/4M/4M Plus/5/5M series printers.

Transcription

1 SAFETY DATA SHEET 1. Identification Product identifier Other means of identification Recommended use Recommended restrictions Company identification 2. Hazard(s) identification Physical hazards Health hazards Environmental hazards OSHA defined hazards Label elements Hazard symbol Signal word Hazard statement Precautionary statement Prevention Response Storage Disposal Hazard(s) not otherwise classified (HNOC) HP LaserJet 92298A-X Print Cartridge This product is a toner preparation that is used in HP LaserJet 4/4 Plus/4M/4M Plus/5/5M series printers. None known. HP 1501 Page Mill Road Palo Alto, CA United States Telephone HP health effects line (Toll-free within the US) (Direct) HP Customer Care Line (Toll-free within the US) (Direct) hpcustomer.inquiries@hp.com None. None. None of the other ingredients in this preparation are classified as carcinogens according to ACGIH, EU, IARC, MAK, NTP or OSHA. Supplemental information This product is not classified as hazardous according to OSHA CFR (HazCom 2012). 3. Composition/information on ingredients Mixtures Chemical name Common name and synonyms CAS number % Iron oxide Iron oxide <55 Styrene acrylate copolymer Trade Secret <55 Amorphous silica Amorphous silica <3 4. First-aid measures Inhalation Skin contact Move person to fresh air immediately. If irritation persists, consult a physician. Wash affected areas thoroughly with mild soap and water. Get medical attention if irritation develops or persists. 1 / 6

2 Eye contact Ingestion Most important symptoms/effects, acute and delayed Do not rub eyes. Immediately flush with large amounts of clean, warm water (low pressure) for at least 15 minutes or until particles are removed. If irritation persists, consult a physician. Rinse mouth out with water. Drink one to two glasses of water. If symptoms occur, consult a physician. 5. Fire-fighting measures Suitable extinguishing media CO2, water, or dry chemical Unsuitable extinguishing media Specific hazards arising from the chemical Special protective equipment and precautions for firefighters Fire-fighting equipment/instructions Specific methods None known.. 6. Accidental release measures Personal precautions, protective equipment and emergency procedures Methods and materials for containment and cleaning up Environmental precautions 7. Handling and storage If fire occurs in the printer, treat as an electrical fire. None established. Minimize dust generation and accumulation. Do not flush into surface water or sanitary sewer system. See also section 13 Disposal considerations. Precautions for safe handling Keep out of the reach of children. Avoid inhalation of dust and contact with skin and eyes. Use with adequate ventilation. Keep away from excessive heat, sparks, and open flames. Conditions for safe storage, including any incompatibilities Keep out of the reach of children. Keep tightly closed and dry. Store at room temperature. Store away from strong oxidizers. 8. Exposure controls/personal protection Occupational exposure limits US. NIOSH: Pocket Guide to Chemical Hazards Components Type Value Amorphous silica (CAS ) Biological limit values Exposure guidelines TWA 6 mg/m3 No biological exposure limits noted for the ingredient(s). USA OSHA (TWA/PEL): 15 mg/m3 (Total Dust), 5 mg/m3 (Respirable Fraction) Appropriate engineering controls ACGIH (TWA/TLV): 10 mg/m3 (Inhalable Particulate), 3 mg/m3 (Respirable Particulate) TRGS 900 (Luftgrenzwert) - mg/m3 (Einatembare partikel), mg/m3 (Alveolengängige fraktion) UK WEL: 10 mg/m3 (Respirable Dust), 5 mg/m3 (Inhalable Dust) Use in a well ventilated area. Individual protection measures, such as personal protective equipment Eye/face protection Skin protection Hand protection Other 2 / 6

3 Respiratory protection Thermal hazards 9. Physical and chemical properties Appearance Odor Physical state Color Odor threshold ph Fine powder Solid. Black. Slight plastic odor Melting point/freezing point Initial boiling point and boiling range Flash point Evaporation rate Flammability (solid, gas) Upper/lower flammability or explosive limits Flammability limit - lower (%) Flammability limit - upper (%) Explosive limit - lower (%) Explosive limit - upper (%) Vapor pressure Solubility(ies) Solubility (water) Partition coefficient (n-octanol/water) Auto-ignition temperature Decomposition temperature Viscosity Other information Percent volatile Softening point 10. Stability and reactivity Reactivity Chemical stability Possibility of hazardous reactions Conditions to avoid Incompatible materials Hazardous decomposition products Not flammable Negligible in water. Partially soluble in toluene and xylene. > 392 F (> 200 C) 0 % estimated F ( C) Stable under normal storage conditions. Will not occur. Imaging Drum: Exposure to light Strong oxidizers Carbon monoxide and carbon dioxide. 11. Toxicological information Symptoms related to the physical, chemical and toxicological characteristics Information on toxicological effects Acute toxicity Skin corrosion/irritation 3 / 6

4 Serious eye damage/eye irritation Respiratory or skin sensitization Respiratory sensitization Skin sensitization Germ cell mutagenicity Carcinogenicity Negative, does not indicate mutagenic potential (Ames Test: Salmonella typhimurium) IARC Monographs. Overall Evaluation of Carcinogenicity Reproductive toxicity Specific target organ toxicity - single exposure Specific target organ toxicity - repeated exposure Aspiration hazard Further information Components Acute Oral LD50 3 Not classifiable as to carcinogenicity to humans. Complete toxicity data are not available for this specific formulation Refer to Section 2 for potential health effects and Section 4 for first aid measures. Species Mouse Rat Test Results > mg/kg > mg/kg 12. Ecological information Ecotoxicity Product 92298A-X Aquatic Fish LL50 Persistence and degradability Bioaccumulative potential Mobility in soil Other adverse effects Species Fish Test Results > 1000 mg/l, 96 Hours 13. Disposal considerations Disposal instructions 14. Transport information DOT Not regulated as dangerous goods. IATA UN number UN2807 UN proper shipping name Magentized Material Transport hazard class(es) Class Subsidiary risk - Do not shred toner cartridge, unless dust-explosion prevention measures are taken. Finely dispersed particles may form explosive mixtures in air. Dispose of in compliance with federal, state, and local regulations. HP's Planet Partners (trademark) supplies recycling program enables simple, convenient recycling of HP original inkjet and LaserJet supplies. For more information and to determine if this service is available in your location, please visit 4 / 6

5 Packing group. Environmental hazards No. Special precautions for user IMDG Not regulated as dangerous goods. ADR Not regulated as dangerous goods. Further information 15. Regulatory information US federal regulations 13 or more of these cartridges shipped together in a single package (e.g., box, container), by air, are regulated as a magnetized material. These requirements do not apply to single or dual pack cartridges contained in an original HP package and shrink wrapped on a pallet for shipment by air. US EPA TSCA Inventory: All chemical substances in this product comply with all rules or orders under TSCA. TSCA Section 12(b) Export Notification (40 CFR 707, Subpt. D) CERCLA Hazardous Substance List (40 CFR 302.4) SARA 304 Emergency release notification OSHA Specifically Regulated Substances (29 CFR ) Superfund Amendments and Reauthorization Act of 1986 (SARA) Hazard categories Immediate Hazard - No Delayed Hazard - No Fire Hazard - No Pressure Hazard - No Reactivity Hazard - No SARA 302 Extremely hazardous substance SARA 311/312 Hazardous chemical Other federal regulations Safe Drinking Water Act (SDWA) US state regulations No US. Massachusetts RTK - Substance List US. New Jersey Worker and Community Right-to-Know Act US. Pennsylvania Worker and Community Right-to-Know Law US. Rhode Island RTK US. California Proposition 65 Not Listed. Regulatory information All chemical substances in this HP product have been notified or are exempt from notification under chemical substances notification laws in the following countries: US (TSCA), EU (EINECS/ELINCS), Switzerland, Canada (DSL/NDSL), Australia, Japan, Philippines, South Korea, New Zealand, and China. 16. Other information, including date of preparation or last revision Issue date 14-May-2015 Revision date 22-Sep / 6

6 Version # 03 Disclaimer Revision Information Manufacturer information Explanation of abbreviations This Safety Data Sheet document is provided without charge to customers of HP. Data is the most current known to HP at the time of preparation of this document and is believed to be accurate. It should not be construed as guaranteeing specific properties of the products as described or suitability for a particular application. This document was prepared to the requirements of the jurisdiction specified in Section 1 above and may not meet regulatory requirements in other countries. Other information, including date of preparation or last revision: Disclaimer HP Chinden Boulevard Boise, ID USA (Direct) (Toll-free within the US) ACGIH CAS CERCLA CFR COC DOT EPCRA IARC NIOSH NTP OSHA PEL RCRA REC REL SARA STEL TCLP TLV TSCA VOC American Conference of Governmental Industrial Hygienists Chemical Abstracts Service Comprehensive Environmental Response Compensation and Liability Act Code of Federal Regulations Cleveland Open Cup Department of Transportation Emergency Planning and Community Right-to-Know Act (aka SARA) International Agency for Research on Cancer National Institute for Occupational Safety and Health National Toxicology Program Occupational Safety and Health Administration Permissible Exposure Limit Resource Conservation and Recovery Act Recommended Recommended Exposure Limit Superfund Amendments and Reauthorization Act of 1986 Short-Term Exposure Limit Toxicity Characteristics Leaching Procedure Threshold Limit Value Toxic Substances Control Act Volatile Organic Compounds 6 / 6