Inrush Apparent power (VA) Flow Characteristics/Weight. Port size Rc. Valve model VS VS VS VS VS

Save this PDF as:
 WORD  PNG  TXT  JPG

Size: px
Start display at page:

Download "Inrush Apparent power (VA) Flow Characteristics/Weight. Port size Rc. Valve model VS3115-01 VS3115-02 VS3110-02 VS3110-03 VS3114-00."

Transcription

1 Port Direct Operated Solenoid Valve Series VS5/0 Metal Seal Multiple pressure supply is possible with balanced spool sleeve. Any given port can accept high or low pressure supply without affecting the system life or operation. No-lubrication and dry-air operation possible. Body ported type With sub-plate Symbol (A) (P) (E) Standard Specifications Fluid Operating pressure range Proof pressure Ambient and fluid temperature Response time () Max. operating frequency () Lubrication Enclosure Impact/Vibration resistance (m/s ) Standard Coil rated voltage Allowable voltage fluctuation Coil insulation type Inrush Apparent power (VA) (Power consumption (W)) Holding Power consumption (W) Bracket (AXT8-)/For body ported type Accessory () Indicator light Note ) Based on JIS B (at 0.5 MPa, without surge voltage suppressor) Note ) Minimum operating frequency is once in 0 days. (Based on JIS B 875.) Note ) Note ) and Note ) are with controlled clean air. Note ) Based on JIS C 090. Note 5) Impact resistance: No malfunction occurred when it is tested with a drop tester in the axial direction and at the right angles to the main valve and armature in both energized and de-energized states every once for each condition. (Values at the initial period) Vibration resistance: No malfunction occurred in a one-sweep test between 5 and 000 Hz. Test was performed at both energized and de-energized states in the axial direction and at the right angles to the main valve and armature. (Values at the initial period) Note 6) Based on JIS C 00. Flow Characteristics/Weight Body type Body ported With sub-plate For manifold use Caution Valve model VS5-0 VS5-0 VS0-0 VS0-0 VS-00 Port size Rc 8 8 Flow characteristics P A A E C [dm /(s bar)] b Cv C [dm /(s bar)] b Cv Without sub-plate Weight (kg) Be sure to read before handling. Refer to front matter 5 for Safety Instructions and pages to 8 for //5 Port Solenoid Valve Precautions. How to Calculate the Flow Rate For obtaining the flow rate, refer to front matters to 5. Air/Inert gas 0 to.0 MPa.5 MPa 0 to 60 C (No freezing) 0 ms or less (), 5 ms or less (),500 c.p.m. (), 80 c.p.m. () Non-locking Not required (Use turbine oil Class ISO VG, if lubricated.) Dustproof [Degrees of protection 0] () 50/50 (5) 50 Hz 60 Hz 50 Hz 60 Hz Grommet, DlN terminal 00, 00 V, 50/60 Hz; V 0, 0, 8, and V (50/60 Hz) 00, 8, and V 5 to +0% of rated voltage Class B or equivalent (0 C) (6) (5.) (.9) VV06 VV00 V00 -V F VS VS 0

2 Series VS5/0 How to Order Piping type 0 With sub-plate Without sub-plate (For Manifold) 5 Body ported Size /8 / /8 Body ported Construction Body ported type VS D L Port size Sub-plate Coil rated voltage 00 V (50/60 Hz) 00 V (50/60 Hz) 0 V (50/60 Hz) 0 V (50/60 Hz) 5 V For other rated voltages, please consult with SMC. De-energized Mounting Nil Without bracket With bracket B (Only Body ported type) G D Grommet With sub-plate De-energized Accessory () With indicator light L (Not available for, grommet type) P (With lock) Thread type Nil Rc N NPT T NPTF F G Sub-plate Assembly Part No.: VS0-S- Mounting bolts and gaskets are not attached. Part No. for Mounting Bolt and BG-VS00 Accessory () 0 0 Component Parts No. Description Body Spool/Sleeve Sub-plate Material Aluminum die-casted Stainless steel Aluminum die-casted Replacement Parts No. Description Material VS5- G VS5- D VS0- G VS0- D Solenoid SCA006- SCAD00- SCA006- SCAD00- capsule assembly SCA00- SCAD00- SCA00- SCAD00-5 AXT- AXT8-5 6 Plug for cap Resin AXT-6 : Enter the operating voltage. (00 V: 0, 00 V: 0, 0 V: 0, 0 V: 0, V: 5) Indicator light When solenoid is energized, indicator light illuminates, thus the electrical state of the solenoid can be seen from the outside. Since internal connections are as shown below for the, make connections to the power supply accordingly. : + ( ) Terminal no. + ( ) (+) There is no polarity. ( type with indicator light has polarity. q+, w ) Use compatible heavy duty cords with cable O.D. of ø6 to mm. Use the tightening torques below for each section. + : (+) Note) There is polarity of () +, (). Remove the rubber plug on the top of the solenoid cap to mount the manual override. Push the override with a screwdriver to the required stroke and the valve will shift. Turn to the right or left at 90 degrees to lock it. Turn it back 90 degrees to unlock. Be sure to unlock the override before energizing the valve electrically. 0 Description (With lock) (Non-locking) PB0- (PB0) PB00 PB0- PB00- ( ): With indicator light Connector Binding head screw with flange Tightening torque 0.5 to 0.6 N m Washer Rubber seal Compatible cable Note) (Cable O.D. ø6 to mm) Binding head screw Tightening torque 0.5 to 0.6 N m Note) For an outside cable diameter of ø9 to mm, remove the internal parts of the rubber seal before using.

3 Port Direct Operated Solenoid Valve Series VS5/0 Dimensions Body ported type VS5- G VS5- D x ø6 mounting hole x ø6 mounting hole VV06 VV00 V00 G / (Cable ø8 to ø0) -V x Rc 8, 89.5 () [9.5] x Rc 8, [9.5] F Bracket x M5, Depth 7 For mounting Bracket x M5, Depth 7 For mounting VS VS ( ): [ ]:, with indicator light With sub-plate VS0- G 0.5 (8.5) 87.5 (.5) [90.5] x ø.5 Mounting hole VS0- D Manual override 0.5 (8.5) 97.5 (08) x ø.5 Mounting hole Manual override 00 (Lead wire length) 87.5 (.5) [90.5] G / (Cable ø8 to ø0) x Rc, 8 x Rc, 8 ( ): [ ]:, with indicator light 0

4 Series VS5/0 Manifold Specifications Specifications Manifold type Max. number of stations Exhaust Port location/port size type Base Base Base Common Accessory P A E P A E 8 8 Side Bottom Side Blanking plate (With gaskets and screw) How to order manifold B mount 0 stations Port direction Applicable valve model Side Side Side VS-00 AXT8-7A 0 VVS 0 P A E Side Side Side Side Bottom Side Valve stations 5 stations EXH port type Common EXH Thread type Nil Rc N NPT T NPTF F Parallel thread 0 0 stations Dimensions 9 (5.5) [9] 65 (89.5) [68] x ø7 Mounting hole n x Rc x Rc 8 ( ): [ ]:, with indicator light L L n L L = 8n +, L = 8n + n: Station Formula for manifold weight M = 0.6n + 0. (kg)

5 Terminal type Caution Nil T TL TZ TLZ WT WTZ Symbol (A) Body size /8 Standard / Standard Port Direct Operated Solenoid Valve Series VS5/5 Metal Seal (P) (E) Be sure to read before handling. Refer to front matter 5 for Safety Instructions and pages to 8 for //5 Port Solenoid Valve Precautions. How to Calculate the Flow Rate For obtaining the flow rate, refer to front matters to VS 5 0 Port size 5 5 Size / /8 / / Specifications Model Coil rated voltage 00 V (50/60 Hz) 00 V (50/60 Hz) 0 V (50/60 Hz) 0 V (50/60 Hz) 5 V For other rated voltages, please consult with SMC. Grommet Conduit terminal Conduit terminal, With light Conduit terminal, With surge voltage suppressor (With AXT07-- ) Conduit terminal, With light/surge voltage suppressor (With AXT07-- ) Dripproof conduit terminal Dripproof conduit terminal, With surge voltage suppressor (With AXT07-- ) Fluid Proof pressure Air/Inert gas.5 MPa Operating pressure range 0 to.0 MPa Ambient and fluid temperature ( C) () 0 to 60 Lubrication () Not required (Non-locking type available) Grommet, Conduit terminal, Dripproof conduit terminal Coil rated voltage Allowable voltage fluctuation 5 to +0% of rated voltage 00, 00 V 50/60 Hz V Coil insulation type Class B or equivalent (0 C) () Impact/Vibration resistance (m/s ) 50/50 () Note ) If it is low temperature, dry air should be used. (No freezing) Note ) Use turbine oil Class (ISO VG), if lubricated. Note ) Based on JIS C 00. Note ) Impact resistance: No malfunction occurred when it is tested with a drop tester in the axial direction and at the right angles to the main valve and armature in both energized and de-energized states every once for each condition. (Values at the initial period) Vibration resistance: No malfunction occurred in a one-sweep test between 5 and 000 Hz. Test was performed at both energized and de-energized states in the axial direction and at the right angles to the main valve and armature. (Values at the initial period) Valve model Flow characteristics / /8 / / Response time () (ms) () Max. operating frequency (c.p.m.) Weight (kg) Apparent 50 Hz Inrush power 60 Hz (VA) 50 Hz Holding Power 60 Hz consumption (W) VS5 VS5 P A A E P A A E C b Cv C b Cv C b Cv C b Cv [dm /(s bar)] [dm /(s bar)] [dm /(s bar)] [dm /(s bar)] WTL WTLZ WTB WTBL WTBZ WTBLZ or less 60 or less 00 or less 80 or less Note ) Based on JIS B (at 0.5 MPa, without surge voltage suppressor) Note ) Min. operating frequency is once in 0 days. (Based on JIS B 875.) Note ) Note ) and Note ) are with controlled clean air. How to Order 8 0 Nil None P (With lock) or less 80 or less 80 or less 80 or less Thread type Nil Rc N NPT T NPTF F G Dripproof conduit terminal, With light Dripproof conduit terminal, With light/surge voltage suppressor (With AXT07-- ) Dripproof conduit terminal (Metallic fittings compliant with standards used.) Dripproof conduit terminal (Metallic fittings compliant with standards used.), With light Dripproof conduit terminal (Metallic fittings compliant with standards used.), With surge voltage suppressor (With AXT07-- ) Dripproof conduit terminal (Metallic fittings compliant with standards used.), With light/surge voltage suppressor (With AXT07-- ) 05 VV06 VV00 V00 -V F VS VS

6 Series VS5/5 Construction A-A cross section Component Parts No. Description Body Material Aluminum die-casted Solenoid cover Spool/Sleeve Aluminum die-casted Stainless steel! Solenoid Coil Assembly Part No. Voltage Grommet Conduit terminal 00 V 00 V V 00 V 00 V V VS5 A0-0 A0-0 VS000-A07-5 A0-0-6 A0-0-6 VS000-A07-5 VS5 A-0 A-0 A08-5 A-0-6 A-0-6 A Replacement Parts No. Description Cap 5 Bushing 6 Spring 7 Rubber plug for wire 8 Round head combination screw 9 Plug for cover 0 Material Resin Resin Steel wire Steel wire VS5 XT0-- XT00-0 XT00- # XT0- XT0-- VS5 XT0- XT00-0 XT00- # XT0- NXT

7 Port Direct Operated Solenoid Valve Series VS5/5 Dimensions VS5/5 x Port size x øq Mounting hole x øq Mounting hole VV06 VV00 V00 -V F VS VS VS5 Model VS5-0 VS5-0 VS5-0 VS5-0 VS5-06 Port size Rc, 8,, A 6 8 B 6 68 C D 70 9 E F 6 8 G 5 5 H 9 J 6 8 K 5 70 L 9 5 M 6 N P 50 5 øq 7 9 Terminal dimensions R S T U Model VS5-0 VS5-0 VS5-0 VS5-0 VS5-06 Port size Rc, 8,, A 9 96 B 6 68 øc

8 Model Number of positions (Single) (Double) ( position) Port size Rc Symbol Model (Nominal size) C [dm /(s bar)] (B) (A) VS0-0 8 ( 6A). VS0-0 ( 8A).0 5 (EB)(P)(EA) VS0-0 8 (0A). (B) (A) VS0-0 8 ( 6A). VS0-0 ( 8A).0 5 (EB)(P)(EA) VS0-0 8 (0A). (B) (A) VS0-0 8 ( 6A). VS0-0 ( 8A).8 (EB)(P)(EA) (Closed center) VS0-0 8 (0A). (B) (A) VS0-0 8 ( 6A). VS0-0 ( 8A).9 (EB)(P) (EA) (Exhaust center) VS0-0 8 (0A).0 P A/B b Note ) Min. operating frequency is once every 0 days. (Based on JIS B 875.) Note ) Based on JIS B (At the pressure of 0.5 MPa, without surge suppressor) Note ) : From sub-plate Note ) Note ) and Note ) are with controlled clean air. Caution Be sure to read before handling. Refer to front matter 5 for Safety Instructions and pages to 8 for //5 Port Solenoid Valve Precautions. How to Calculate the Flow Rate For obtaining the flow rate, refer to front matters to 5. 0 Symbol Single Double Closed center Exhaust center Piping Side ported (Sub-plate) Bottom ported (Sub-plate) Without sub-plate Port Direct Operated Solenoid Valve Series VS 0 Metal Seal VS Port size Without sub-plate /8 / /8 (Bottom ported cannot be selected.) Standard Specifications Solenoid Specifications Flow characteristics Max. () Response operating () Weight (kg) A/B EA/EB cycle (cpm) time (ms) Cv C [dm /(s bar)] b Cv or 5 or,00 80 less less or 0 or,00 80 less less or 5 or less less or 5 or less less Fluid Operating pressure range Ambient and fluid temperature Air/Inert gas 0 to.0 MPa 0 to 60 C Possible Grommet, Conduit,, Conduit terminal Lubrication Non-lube Usable with non-lude Lubrication Use turbine oil Class (ISO VG), if lubricated. Impact/Vibration resistance (m/s ) 50/50 Note) Manifold Possible Use dry air (Dew point: 0 C or less). If using a lubricant, be sure to use a lubricant for low temperatures. Note) Impact resistance: No malfunction occurred when it is tested with a drop tester in the axial direction and at the right angles to the main valve and armature in both energized and de-energized states every once for each condition. (Values at the initial period) Vibration resistance: No malfunction occurred in a one-sweep test between 5 and 000 Hz. Test was performed at both energized and de-energized states in the axial direction and at the right angles to the main valve and armature. (Values at the initial period) Coil rated voltage Allowable voltage fluctuation Coil insulation type Note) Based on JIS C How to Order 0 Coil rated voltage 00 V (50/60Hz) 00 V (50/60Hz) 0 V (50/60Hz) 0 V (50/60Hz) V For other rated voltages,please consult with SMC. C 00, 00 V, 50/60 Hz; V 5 to +0% of rated voltage Class B or equivalent (0 C) Note) Thread type Nil Rc N NPT T NPTF F G Nil None P (With lock) With speed R controller unit U Grommet TZ Conduit terminal, With surge voltage suppressor (With AXT07-- ) UL Grommet, With light ( only) TLZ Conduit terminal, With light/surge voltage suppressor (With AXT07--, only) C Conduit D CL Conduit, With light ( only) DL, With light T Conduit terminal DZ, With surge voltage suppressor TL Conduit terminal, With light ( only) DLZ, With light/surge voltage suppressor 05 VV06 VV00 V00 -V F VS VS

9 Series VS 0 Apparent Power (Power Consumption) Apparent power (VA) (Power consumption (W)) Power consumption (W) In the case of position type. Inrush Holding 50Hz 60Hz 50Hz 60Hz 5 VA (6 VA ) 5 VA (55 VA ) 7 VA (5./5.5 W) VA (.9/. W) 5.5 Accessory (). Indicator light () When solenoid gets energized, indicator light illuminates, thus electrical states of the solenoid can be seen from the outside. Specifications Bottom ported (Sub-plate) Coil rated voltage (0/0 V, /00 V) Enclosure (Based on JIS C 090) Dustproof Dripproof Grommet Sub-plate/ Valve body Standard Conduit Standard DIN terminal Standard Conduit terminal Standard Since internal connections are as shown below for the, make Note) There is polarity of () +, (). : + ( ) + : (+) connections to the power supply accordingly. Terminal no. +( ) (+) There is no polarity.( type with indicator light has polarity. q +, w ) Use compatible heavy duty cords with cable O.D. of ø6 to mm. Use the tightening torques below for each section. Connector Binding head screw with flange Tightening torque 0.5 to 0.6 N m Construction Principle VS0 Compatible cable Note) Washer (Cable O.D. ø6 to mm) Note) For an outside Rubber seal cable diameter of Binding head screw Tightening torque 0.5 to 0.6 N m With Applicable rubber plug Non-locking With lock model SC000- VS0 SC000B- SC000A- VS0 SC00- VS0 SC00B- SC00A- VS0 ø9 to mm, remove the internal parts of the rubber seal before using. Indicate the voltage to be used. (00 V: 0, 00 V: 0) VS0. Remove rubber plug at the top of the solenoid cap to install manual override. Push the override with a screwdriver to the required stroke and the valve will shift. With the override in the same position, turn it to the right or left 90 and it will lock. Turn it back 90 to unlock. Caution Be sure to unlock it before energizing the valve electrically. (Energized) (De-energized) VS0 (Closed center) Description Applicable model In the case of a position PB0 VS0 double solenoid valve, VS0 use a non-locking manual (With lock) PB0- VS0 override because it has a PB00 VS0 locking function in the (Non-locking) PB00- main valve.. Terminal wiring Lead wire from the solenoid is connected to the lower terminal of the terminal block under the junction cover of sub-plate. Connect the lead wire of the power supply corresponding to the solenoid (single solenoid: A side/double solenoid: both A and B sides) to the upper terminal of the terminal block. 06

10 5 Port Direct Operated Solenoid Valve Series VS 0 Construction VS0 VS0 VS0/0 VV06 VV00 V00 -V F VS VS Sub-plate Assembly Part No. BG-VS00 C: Conduit T: Conduit terminal U: Grommet, D: Mounting bolt and gasket are not included. Part No. for Mounting Bolt and 0 VS00-CS VS00-TS VS00-S- 0 0 Component Parts No Description Body Sub-plate Spool/Sleeve Spring Rubber plug for wire Plug for cap Rubber plug Mounting bolt Mounting screw Detent assembly Material Aluminum die-casted Aluminum die-casted Stainless steel Piano wire Carbon steel Carbon steel!5 Solenoid Capsule Assembly (With rubber plug) Standard Specifications Grommet/Conduit Conduit terminal With indicator light Grommet/Conduit Conduit terminal With indicator light VS0/0 VS0/0 SCA00- SCAD00- SCA00- SCAD00- SCA0- SCAD0- SCA0- SCAD0- Indicate the used voltage.(00 V: 0, 00 V: 0, 0 V: 0, 0 V: 0, V: 5) 07

11 Series VS 0 Dimensions Grommet (VS0) (VS0) (VS0/0) x ø6 mounting hole x ø6 mounting hole x ø6 mounting hole 5 x Rc /8, /, /8 5 x Rc /8, /, /8 5 x Rc /8, /, /8 Conduit Conduit terminal (VS0) (VS0) (VS0/0) x ø6 mounting hole x ø6 mounting hole x ø6 mounting hole x G/ 5 x Rc /8, /, /8 Terminal 5 x Rc /8, /, /8 x G/ Terminal 5 x Rc /8, /, /8 x G/ (VS0) (VS0) (VS0/0) x ø6 mounting hole x ø6 mounting hole x ø6 mounting hole G/ Cable ø8 to ø0 G/ Cable ø8 to ø0 G/ Cable ø8 to ø0 5 x Rc /8, /, /8 5 x Rc /8, /, /8 5 x Rc /8, /, /8 Bottom ported (VS0) (VS0) (VS0/0) 08 5 x Rc /8, / 5 x Rc /8, / 5 x Rc /8, / ( ):

12 Series VVS0 Manifold Specifications Conduit Grommet Conduit terminal Specifications How to Order VVS 0 Series VS 0 Manifold Porting specifications Symbol 0 P Side A,B Side EA,EB Side 9 Side Bottom Side Other Symbol position SC Manifold SU Valve body Symbol 5 6 Caution Applicable valve Valve stations Accessory Standard Piping Specifications Type Common EXH Individual EXH Configuration Stations 0 stations 0 0stations SUP Common (side) Common (side) Individual (bottom) Individual (bottom) Dissimilar pressure Dissimilar pressure 05 SC Symbol (passage) EXH Common (side) Individual (bottom) Common (side) Individual (bottom) Common (side) Individual (bottom) VS0/0/0/0 Max. 0 stations (Standard) With interface regulator With terminal With stop valve/with flow controls P Mounting (Side) (Side) (Side) (Side) (Side) (Bottom) T Precautions Port size Rc A, B EA, EB Conduit port size G al piping: Individual SUP and different pressure SUP. But it will be the bottom porting specifications. Note) Each port size will be a big size for standard. When the small size is desired, indicate separately.. SUP port and EXH port are positioned on both sides of manifold block. Air can be supplied from either side; however, the unused port must be plugged in this case. When operating 6 or more valve stations within a manifold at the same time, take SUP air pressure from both sides and open EXH port to the atmosphere., 8 8,, 8, 8 8, 8,, Thread type Nil Rc N NPT T NPTF F G (spacer) Nil None S With stop valve R With throttle valve Accessory Nil None T With terminal block Only SC type applicable. Be sure to read before handling. Refer to front matter 5 for Safety Instructions and pages to 8 for //5 Port Solenoid Valve Precautions.. When manifolding an exhaust center position valve, use the individual EXH style manifold. (Back pressure may cause actuator to malfunction.) 09 VV06 VV00 V00 -V F VS VS

13 ,, Series VVS0 Construction Type SC End plate (U side) 5 Junction cover Dimensions ( ) position: Manifold block 6 Tie-rod 9 O-ring Manifold block 7 Hexagon socket head screw 8 Replacement Parts: Sub-assembly No. Description Manifold block assembly End plate (U side) assembly End plate (D side) assembly Terminal assembly 5 Junction cover assembly 6 Tie-rod Replacement Parts Assembly part no. AXT6-A- 0 0 No. Description Material Hexagon socket head screw O-ring Carbon steel End plate (D side) Manifold al Parts Assembly Terminal n x Rc /8, / Blanking plate Throttle valve spacer Stop valve spacer Interface regulator Block disk Rubber plug 0 AXT6-A- 0 0 AXT6-A- 0 0 AXT6-A AXT6-A AXT6-A AXT6-A-- 0 AXT6-5A AXT6-A- Stations AXT6-5- Stations AXT6-7A AXT9A AXT95A ARB0-00- AXT6-6 AXT6-9 Type SC (T only) Type SU Type SC Type SC Type SU Type SC Type SU M6 x 5 AXT5-- AS (P port regulation) (A/B port regulation) Formula/Stations L = 8n + 7 L = 8n Formula for manifold weight M = 0.05n (kg) x ø7 mounting hole 5n x Rc /8, / (Bottom ported) 6 x Rc /, /8 Type SU position: ( Valve body ) n x Rc /8, / x G, / Formula/Stations L = 8n + 7 L = 8n Formula for manifold weight M = 0.5n (kg) x ø7 mounting hole 5n x Rc /8, / (Bottom ported) ( ): 6 x Rc /, /8 00 ( ):

5 Port Pilot Operated Solenoid Valve Rubber Seal. Specifications Fluid Operating pressure range. 2 position single/3 position 2 position double

5 Port Pilot Operated Solenoid Valve Rubber Seal. Specifications Fluid Operating pressure range. 2 position single/3 position 2 position double For details about certified products conforming to international standards, visit us at www.smcworld.com. 5 Port Pilot Operated Solenoid Valve Rubber Seal Series VF3000 Compact and lightweight: 26.4 mm

More information

3 Port Solenoid Valve

3 Port Solenoid Valve Port Solenoid Valve Series V00 Rubber Seal Power consumption 0. W (with power saving circuit) VV0 VV00 V00 -V F VS temperature rises: C (with power saving circuit) Sonic conductance Series Standard Large

More information

Pilot Operated 2 Port Solenoid Valve for Dry Air

Pilot Operated 2 Port Solenoid Valve for Dry Air Pilot Operated Port Solenoid Valve for Dry Air Series VQ0/30 Compact and lightweight with large flow capacity [Option] VQ0 Weight (g) 46 80 C [dm 3 /(s bar)].5 (C8) 3.0 (C) Series Series VQ0 VCH VDW VQ

More information

5 Port Pilot Operated Solenoid Valve Metal Seal, Body Ported. Flow characteristics 1 4/2 (P A/B) 4/2 5/3 (A/B R1/R2)

5 Port Pilot Operated Solenoid Valve Metal Seal, Body Ported. Flow characteristics 1 4/2 (P A/B) 4/2 5/3 (A/B R1/R2) For details about certified products conforming to international standards, visit us at www.smcworld.com. 5 Port Pilot Operated Solenoid Valve Metal Seal, Body Ported Model position position Type of actuation

More information

3 Port Solenoid Valve

3 Port Solenoid Valve ubber Seal ort Solenoid Valve Series SYJ00/00/700 [Option] SYJ VQZ V VG Improved pilot valve ilot valve cover is stronger using stainless steel. Mounting thread is also reinforced from size M1.7 to M.

More information

0.35 0.9. 3 Port Solenoid Valve. Series VQZ100/200/300. Compact, High Flow. Power consumption: 0.35 W/0.9 W SYJ VQZ VP VG VP3

0.35 0.9. 3 Port Solenoid Valve. Series VQZ100/200/300. Compact, High Flow. Power consumption: 0.35 W/0.9 W SYJ VQZ VP VG VP3 Port Solenoid Valve 00/00/00 Metal Seal Rubber Seal 0. 0.9 (Standard) (High pressure type, High speed response type) Power consumption: 0. W/0.9 W Compact, High Flow Body ported Base mounted 00 00 00 00

More information

2 position single. (Standard) 100V AC 50/60Hz 200V AC 50/60Hz 24V DC. 2 position double

2 position single. (Standard) 100V AC 50/60Hz 200V AC 50/60Hz 24V DC. 2 position double 4/ Port Solenoid Valve Rubber Seal VZ1000/000/000 Solenoid Valve Variations Port Size Effective area (mm 2 ) Position solenoid Voltage Electrical entry Option/ Indicator light and surge voltage suppressor

More information

5 Port Solenoid Valve

5 Port Solenoid Valve ort Solenoid Valve Series VQ7-6/7-8 Metal Seal Rubber Seal ISO Standard Size /Size VQ7-8/Single unit.70 VQ7-8/Manifold.70 Conforms to ISO standard /I Interface conforms to ISO standard Size (VQ7-6) and

More information

ISO Interface. Large capacity. Light weight. Accommodates enclosure IP65. Solenoid Valve (with M Connector) Conforming to ISO

ISO Interface. Large capacity. Light weight. Accommodates enclosure IP65. Solenoid Valve (with M Connector) Conforming to ISO P-EX01-A Solenoid Valve (with M Connector) Conforming to ISO 1507-1, Large capacity EVS1-01 (Size: 01) EVS1-0 (Size: 0) Light weight Size 01 (-position): 0.6kg Size 0 (-position): 0.18kg Flow rate 1000L/min

More information

1.8 w 101.2. 3 Port Solenoid Valve Direct Operated Poppet Type. New. Series VT307 CAT.ES11-107A. Power consumption

1.8 w 101.2. 3 Port Solenoid Valve Direct Operated Poppet Type. New. Series VT307 CAT.ES11-107A. Power consumption Port Solenoid Valve Direct Operated Poppet Type Power consumption Vacuum applications New [Option] RoHS 4 Standard wtype (Existing product: 4.8 W) 0. kpa Energy-saving type.8 w (Existing product: W) A

More information

Specifications. Model Flow type Pressure type. Air Maximum operating pressure. 1.0 MPa Ambient and fluid temperature. 3% F.S.

Specifications. Model Flow type Pressure type. Air Maximum operating pressure. 1.0 MPa Ambient and fluid temperature. 3% F.S. Electro-Pneumatic Proportional Valve Series /VEP Electro-pneumatic proportional valve: Flow type () Controls the flow rate steplessly according to current. (It is a / port valve that has an electrical

More information

5 Port Solenoid Valve

5 Port Solenoid Valve Metal Seal ort Solenoid Valve Series VQ7-6/7-8 Rubber Seal ISO Standard Size /Size VQ7-8/Single unit.6 VQ7-8/Manifold. Conforms to ISO standard /I Interface conforms to ISO standard Size (VQ7-6) and Size

More information

5.0 MPa Pilot Operated 2/3 Port Solenoid Valve & Check Valve

5.0 MPa Pilot Operated 2/3 Port Solenoid Valve & Check Valve 5.0 Ma ilot Operated /3 ort Solenoid Valve & Check Valve Series VCH VCH4/4: ort VCH40: 3 ort VCHC40: Check Valve ilot Operated ort Solenoid Valve [Option] Series VCH40 Stable responsiveness Response time

More information

Direct acting 2 port solenoid valve (general purpose valve) NC (normally closed) type Port size: Rc1/8, Rc1/4

Direct acting 2 port solenoid valve (general purpose valve) NC (normally closed) type Port size: Rc1/8, Rc1/4 Direct acting port solenoid valve (general purpose valve) Series NC (normally closed) type Port size: Rc/, Rc/ JIS symbol Common specifications Working fluid Working pressure differential range MPa Max.

More information

NAMUR Mount Hygienic Valve

NAMUR Mount Hygienic Valve NF097-D NMUR Mount Hygienic Valve For Wash Down pplications Series VFN Features Engineered Plastic PPS Body (Polyphenylene Sulfide) provides high temperature and chemical/corrosion resistance for use in

More information

Direct solenoid and solenoid pilot operated valves

Direct solenoid and solenoid pilot operated valves Direct solenoid and solenoid pilot operated valves Individual mounting Series inline Manifold mounting 5 stacking sub-base non plug-in 100 Manual operator 00 Sealed solenoid enclosure Armature 55 56 57

More information

Electrically operated valves Series M-05, 3/2-, 5/2- and 5/3-way G1/8 650 and 750 Nl/min (0.661 and 0.762 Cv)

Electrically operated valves Series M-05, 3/2-, 5/2- and 5/3-way G1/8 650 and 750 Nl/min (0.661 and 0.762 Cv) Electrically operated valves Series M-05, 3/2-, 5/2- and 5/3-way G1/8 650 and 750 Nl/min (0.661 and 0.762 Cv) Order code Series and function M-05-310-HN-442 Standard coil HN at ports 2 + 4 HN at ports

More information

SOLENOID VALVES SERIES

SOLENOID VALVES SERIES CAD drawing data catalog is available. VALVES GENERAL CATALOG SOLENOID VALVES SERIES INDEX SOLENOID VALVES 010 SERIES Features 61 Basic Models and Configuration 62 Specifications 63 Solenoid Valve/Manifold

More information

Port Solenoid Valve. Series VQZ1000/2000/3000. Compact, High Flow. Power consumption: 0.35 W/0.9 W

Port Solenoid Valve. Series VQZ1000/2000/3000. Compact, High Flow. Power consumption: 0.35 W/0.9 W ort Solenoid Valve Series // Metal Seal Rubber Seal.. ower consumption:. W/. W Compact, High Flow Series Valve width (mm) (Standard) (High pressure type, High speed response type) ody ported ase mounted

More information

% ^ ) 1.4 W Low Power Solenoid Valves Aluminum, Brass, or Stainless Steel Bodies 1/4" to 1" NPT. 2/2 3/2 4/2 5/2 5/3 SERIES Low Power

% ^ ) 1.4 W Low Power Solenoid Valves Aluminum, Brass, or Stainless Steel Bodies 1/4 to 1 NPT. 2/2 3/2 4/2 5/2 5/3 SERIES Low Power 4.4 W Solenoid Valves Aluminum, Brass, or Stainless Steel Bodies /4" to " NPT / 3/ Features Molded one-piece solenoid with highly efficient solenoid cartridge and special low wattage coil Increased ambient

More information

3/2-way Solenoid Valve, direct-acting, NC or NO

3/2-way Solenoid Valve, direct-acting, NC or NO 3/2-way Solenoid Valve, direct-acting, NC or NO Electrical connection cable plug, Form A With or without manual override as standard Threaded port and sub-base s Impulse optional Type 6014 can be combined

More information

Direct Operated 3 Port Solenoid Valve For Air, Water, Oil, Steam

Direct Operated 3 Port Solenoid Valve For Air, Water, Oil, Steam CAT.ES0-6 Direct Operated Port Solenoid Valve For Air, Water, Oil, Steam Reduced power consumption ( specification). W. 8 W W 0. W.. W 6 W New VX Series VX/ / Reduced power consumption Improved corrosion

More information

Precision Regulator. Series IR1000/2000/3000 ARJ AMR ARM ARP IR IRV VEX1 SRH SRP SRF ARX20 VCHR ITV IC PVQ VER VEA VY2 AP100.

Precision Regulator. Series IR1000/2000/3000 ARJ AMR ARM ARP IR IRV VEX1 SRH SRP SRF ARX20 VCHR ITV IC PVQ VER VEA VY2 AP100. Precision Regulator Series // Basic Type Air Operated Type Series Model Regulating pressure range Page Series Series Series Series Series.5 to MPa. to MPa. to.8 MPa /8 55.5 to MPa. to MPa /4 55. to.8 MPa.

More information

Q1 Q2 Q3. 2 stage performance. 3 stage performance. Suction flow rate. 250% suction flow rate increase. Release flow rate adjusting needle.

Q1 Q2 Q3. 2 stage performance. 3 stage performance. Suction flow rate. 250% suction flow rate increase. Release flow rate adjusting needle. Multistage Ejector Series 112/212 Energy-saving, large flow rate, 3 stage diffuser construction Suction flow rate increased 25% and air consumption reduced 2% with 3 stage diffuser construction (ersus

More information

L01 Series Direct Solenoid Actuated Valves

L01 Series Direct Solenoid Actuated Valves Series Direct Solenoid ctuated Valves www.numatics.com Table of Contents L0 Series Technical and Operating Data 3 How to Order 4 Valve Dimensions 5 Manifold ssembly 6 Speed Control Kit 7 Mounting Kit 7

More information

Direct Operated Regulator for 6.0 MPa (Relieving Type) How to Order. Body size 30 40

Direct Operated Regulator for 6.0 MPa (Relieving Type) How to Order. Body size 30 40 Direct Operated Regulator for (Relieving Type) Series Service life: 0 million cycles Using NSF-H-certified grease on the guide ring (sliding) part. Improved durability under a high environment with a polyurethane

More information

AB/AG. General purpose direct acting 2, 3 port solenoid valve. (General purpose valve) For air, vacuum, water, oil CONTENTS.

AB/AG. General purpose direct acting 2, 3 port solenoid valve. (General purpose valve) For air, vacuum, water, oil CONTENTS. / (eneral purpose valve) eneral purpose direct acting, 3 port solenoid valve For air, vacuum, water, oil N/ US/ F/ F/ Overview The general purpose valve series enables control of various types of fluids

More information

Max-Air Technology Inc. NAMUR SOLENOID VALVE 4 and NEMA 7. Technical Data. Material

Max-Air Technology Inc. NAMUR SOLENOID VALVE 4 and NEMA 7. Technical Data. Material Technical Data Port connections Inlet and exhaust Outlet DIN connector (NEMA 4 Pictured) NAMUR SOLENOID VALVE NEMAs 4 and NEMA 7 1/4 NPT NAMUR interface 1/2" NPT Pressure Range: 30 to 150 PSI Flow factor:

More information

Valve systems Base plates, according to standard ISO 5599-1. Brochure

Valve systems Base plates, according to standard ISO 5599-1. Brochure ISO 5599-1 Brochure 2 ISO 5599-1 Single subbase Single subbase, thread connections on the side standard: ISO 5599-1 Frame size: ISO 1 - ISO 4 compressed air connection output: G 1/4 - G 1 Reversed pressure

More information

Valve series MN-06 acc. to NAMUR, 3/2-way G1/4 750 Nl/min (0.762 Cv)

Valve series MN-06 acc. to NAMUR, 3/2-way G1/4 750 Nl/min (0.762 Cv) Valve series MN-06 acc. to NAMUR, 3/2-way G1/4 750 Nl/min (0.762 Cv) Order code Series and function 1) Plug socket see page 5.042. MN-06-310-HN-442 Standard coil 1) 441 = 12 V DC, 4.2 W 442 = 24 V DC,

More information

Single sub-base valve

Single sub-base valve solenoid valves Mini-valves 10 mm Electrical connection... Mounting... Port sizes... Rated temperature... Fluid... Working pressure... Nominal flow... Pneumatic connections Voltage... Power... NC poppet

More information

Process Valve. 2 Port Valve For Compressed Air and Air-hydro Circuit Control

Process Valve. 2 Port Valve For Compressed Air and Air-hydro Circuit Control Process Valve Series VN Port Valve For Compressed ir and ir-hydro Circuit Control Exclusively for air pressure system and air-hydro circuit control Universal Port Valve [Option] Cylinder actuation by external

More information

System 8. ü www.nassmagnet.com ( +49 511 6746-0. System 8

System 8. ü www.nassmagnet.com ( +49 511 6746-0. System 8 System 8 ü www.nassmagnet.com ( +9 11 7-0 System 8 The name System 8 stands for a modular system of solenoid coils, armature systems, solenoid operators and solenoid valves. The diameter of the armatures

More information

Fluid. Flu. Fluid Fluid. uid Power d Power P. Fluid Power P. Fluid Power. Fluid Power Power. d Power. Directional Cetop Valves DCV 03.

Fluid. Flu. Fluid Fluid. uid Power d Power P. Fluid Power P. Fluid Power. Fluid Power Power. d Power. Directional Cetop Valves DCV 03. Catalogue Directional Cetop Valves DCV 03 Power Flu uid Power d Power P wer Power Power Power Power Power d Power Power Power ower Power Power wer Power Power P Power Power Powe d Power Power Power Power

More information

RPE3-04. Functional Description HA 4014 10/2010. Directional Control Valves Solenoid Operated. Replaces HA 4014 12/2007

RPE3-04. Functional Description HA 4014 10/2010. Directional Control Valves Solenoid Operated. Replaces HA 4014 12/2007 Directional Control Valves Solenoid Operated RPE3-04 Size D 04 (02) 320 bar (4600 PSI) 30 L/min(8.0 GPM) HA 4014 10/2010 Replaces HA 4014 12/2007 4/3-, 4/2- way directional control valves with solenoid

More information

4 Posiflow Proportional Solenoid Valves

4 Posiflow Proportional Solenoid Valves 4 Posiflow Solenoid Brass or Stainless Steel Bodies 1/4" to 1/2" NPT 2/2 Features Flow rates adjustable between 0% and 100% of rating Flow rate can also be regulated by a range of electrical inputs (sensors,

More information

aerospace climate control electromechanical filtration fluid & gas handling hydraulics pneumatics process control sealing & shielding Valves

aerospace climate control electromechanical filtration fluid & gas handling hydraulics pneumatics process control sealing & shielding Valves aerospace climate control electromechanical filtration fluid & gas handling hydraulics pneumatics process control sealing & shielding Catalog 095 Warning, Offer of Sale! WARNING FAILURE OR IMPROPER SELECTION

More information

Air Catch Sensor. Series ISA. For Workpiece Placement Confirmation

Air Catch Sensor. Series ISA. For Workpiece Placement Confirmation Air Catch Sensor Series For Workpiece Placement Confirmation No-contact sensor for confirming workpiece placement, with a configuration that is less affected by supply pressure change. Easy-to-set-up LED

More information

Pressure relief valves type AGAM two stage, subplate mounting - ISO 6264 size 10, 20 and 32

Pressure relief valves type AGAM two stage, subplate mounting - ISO 6264 size 10, 20 and 32 www.atos.com Table C06619/E Pressure relief valves type AGAM two stage, subplate mounting ISO 6264 size 10, 20 and 32 1 MODEL CODE AGAM10/11...E AGAM20/.../V AGAM are two stage pressure relief valves with

More information

RPE3-04. Functional Description HA 4014 09/2013. Directional Control Valves Solenoid Operated. Replaces HA 4014 10/2010

RPE3-04. Functional Description HA 4014 09/2013. Directional Control Valves Solenoid Operated. Replaces HA 4014 10/2010 Directional Control Valves Solenoid Operated RPE3-04 Size 04 (D 02) 320 bar (4600 PSI) 30 L/min (8.0 GPM) HA 4014 09/2013 Replaces HA 4014 10/2010 4/3-, 4/2- way directional control valves with solenoid

More information

Assisted lift operated 2/2-way solenoid valves Type EV250B

Assisted lift operated 2/2-way solenoid valves Type EV250B MAKING MODERN LIVING POSSIBLE Data sheet Assisted lift operated 2/2-way solenoid valves Type EV250B EV250B with assisted lift can operate from zero and up to 10 bar differential pressure. This 2/2-way

More information

type V46, solenoid or pneumatic operated

type V46, solenoid or pneumatic operated SPECIFICATION general type of construction spool valve operator solenoid or pneumatic operated or by manual override. Manual override is equipped with a monostable function (push) and a bistable function

More information

Series VM. Mechanical Valves VM200. VM1000 Side ported 11 x 36 x 16 Bottom ported 11 x 28 x 25

Series VM. Mechanical Valves VM200. VM1000 Side ported 11 x 36 x 16 Bottom ported 11 x 28 x 25 Mechanical Valves Series VM Model Dimensions (mm) VM1000 Side ported 11 x 36 x 16 Bottom ported 11 x 28 x 25 VM100 Side ported 17 x 44 x 25 Bottom ported 17 x 44 x 30 VM200 25 x 40 x 52 One way roller

More information

% ^ ) 0.55 W Low Power Solenoid Valves Aluminum, Brass, or Stainless Steel Bodies 1/4" to 1" NPT. 2/2 3/2 4/2 5/2 5/3 SERIES Low Power

% ^ ) 0.55 W Low Power Solenoid Valves Aluminum, Brass, or Stainless Steel Bodies 1/4 to 1 NPT. 2/2 3/2 4/2 5/2 5/3 SERIES Low Power .55 W Solenoid Valves Aluminum, Brass, or Stainless Steel Bodies /" to " NPT / 3/ / 5/ 5/3 Features Molded one-piece solenoid with highly efficient solenoid cartridge and.55 W low wattage coil Standard

More information

VSNG6 SOLENOID OPERATED DIRECTIONAL CONTROL VALVE COMPACT SIZE

VSNG6 SOLENOID OPERATED DIRECTIONAL CONTROL VALVE COMPACT SIZE VSNG6 SOLENOID OPERATED DIRECTIONAL CONTROL VALVE COMPACT SIZE NFPA D03 MOUNTING INTERFACE ISO 4401-03-02-0-94 (CETOP 4.2-4-03-250) SUBPLATE MOUNTING NFPA D03 ISO 4401-03 (CETOP 03) NG6 Pressure max 4060

More information

Valves. Sub-Base Mounted Valves to ISO 5599/2

Valves. Sub-Base Mounted Valves to ISO 5599/2 Valves Sub-Base Mounted Valves to ISO 5599/2 General Information ISO 1, ISO 2 and ISO 3 valve series incorporate the famous Numatics lapped spool and sleeve for ultimate service life. Due to the great

More information

3 Way Proportional Pressure Control Valve Nominal diameter 2 Direct operated poppet valves Flange design Low hysteresis

3 Way Proportional Pressure Control Valve Nominal diameter 2 Direct operated poppet valves Flange design Low hysteresis VP0 Way Proportional Pressure Control Valve Nominal diameter Direct operated poppet valves Flange design Low hysteresis Good repeatability High flow capacity at exhaust port Manifold mountable system Compact

More information

Chapter 6: Check Valves

Chapter 6: Check Valves Contents Chapter : Check Valves Series Description Size Mounting Page Parker Standard DIN / ISO 1/8 1/4 3/8 1/2 3/4 1 0 10 1 25 32 Shuttle valves SSR -2 Check valves, direct operated RK / R CS SPZE SPV

More information

3/2, 5/2, 5/2 bistable and 5/3 way pneumatic solenoid valve

3/2, 5/2, 5/2 bistable and 5/3 way pneumatic solenoid valve 3/2, 5/2, 5/2 bistable and 5/3 way pneumatic solenoid valve Type 6518 Type 6519 Type 6518/6519 can be combined with... Single or block mounting Suitable for outdoor and chemical atmospheres Suitable for

More information

3/2, 5/2, 5/2 bistable and 5/3 way pneumatic solenoid valve

3/2, 5/2, 5/2 bistable and 5/3 way pneumatic solenoid valve 3/2, 5/2, 5/2 bistable and 5/3 way pneumatic solenoid valve Type 6518 Type 6519 Type 6518/6519 can be combined with... Single or block mounting Suitable for outdoor and chemical atmospheres Suitable for

More information

Fluid Control Products. A Constant Flow Of Ideas. 2 Way General Purpose Solenoid Valves

Fluid Control Products. A Constant Flow Of Ideas. 2 Way General Purpose Solenoid Valves Fluid Control Products A Constant Flow Of Ideas 2 Way General Purpose Solenoid Valves T A B L E O F C O N T E N T S Series General Description Pipe Body Material Page 8030 Low Pressure 3/8" - 3/" Brass

More information

3/2- and 2/2-way cartridge valve type BVE

3/2- and 2/2-way cartridge valve type BVE 3/2- and 2/2-way cartridge valve type BVE for any flow direction, zero leakage, all ports pressure resistant Flow Q max = 70 lpm Perm. pressure p max = 400 bar Additional valves with same function: ' Type

More information

4/2-Way Pneumatic Solenoid Valve

4/2-Way Pneumatic Solenoid Valve 4/2-Way Pneumatic Solenoid Valve Robust servo assisted piston valve Service friendly manual override Single or block assembly Explosion-proof versions Type 5413 cam be combined with Type 2508 Cable plug

More information

2/2 and 3/2 Way Size 6 Seat Valves

2/2 and 3/2 Way Size 6 Seat Valves 2/2 and 3/2 Way Size 6 Seat Valves Directly operated Interface and subplate dimensions according to DIN 24340 and ISO Line connection port size G 3/8" Cartridge design PN [p max. ] = 315 bar 7501856.06.12.08

More information

Electro-pneumatic control valves

Electro-pneumatic control valves Electropneumatic control valves 7 Miniature solenoid valves for alternating current Conform to the Low Voltage Directive or mounting on subbase or footprint in accordance with CNOMO recoendation E 066120N

More information

VALVES ISO 5599/1 SERIES SAFE AIR

VALVES ISO 5599/1 SERIES SAFE AIR Starting from a series of sturdy, reliable valves, such as those to ISO 5599/1, some special features have been added, such as the presence of a valve status diagnostic system and the creation of a double

More information

UM/22000 5/2 & 5/3 valves, solenoid and pilot actuated ISO 5599-1, ISO size 1, 2, 3 & 4 Sub-base mounted

UM/22000 5/2 & 5/3 valves, solenoid and pilot actuated ISO 5599-1, ISO size 1, 2, 3 & 4 Sub-base mounted U/ / & / valves, solenoid and pilot actuated ISO 99-, ISO size,, & Sub-base mounted Steel reinforced main seals 6 bar and bar NOO solenoid pilots with locking or non-locking manual override Low power coils

More information

G1/4 Q8. Standard with biased position

G1/4 Q8. Standard with biased position Contents Version Actuation Page Characteristics Dimensions x / Way Valves pneumatic 6,7, 0 9 electric 6,7 9, 9 / Way Valves pneumatic 6,7, 0 electric 6,7, 0 / Way Valves pneumatic 6,7,, 6, 7 electric 6,7,,

More information

PPS-PPQ-BT-PIAS RESIN INSULATORS FOR OIL INSULATED ELECTRICAL MACHINES

PPS-PPQ-BT-PIAS RESIN INSULATORS FOR OIL INSULATED ELECTRICAL MACHINES PPS-PPQ-BT-PIAS RESIN INSULATORS FOR OIL INSULATED ELECTRICAL MACHINES BUSHING WITH PLUG CONNECTION WITH OUTER CONE PPS CHARACTERISTICS The PPS bushing can be used as a fixed section for the entry of medium

More information

Compact cylinder Double acting single rod type. SSD SSD-L (with switch) Double acting Compressed air 1.0. 1.6-10 to 60 (no freezing) Rc1/8 Rc1/4 Rc3/8

Compact cylinder Double acting single rod type. SSD SSD-L (with switch) Double acting Compressed air 1.0. 1.6-10 to 60 (no freezing) Rc1/8 Rc1/4 Rc3/8 * U S 4 Specifications escriptions Bore size mm Actuation Working fluid ax. working pressure Pa in. working pressure Pa Withstanding pressure Pa Ambient temperature Port size Stroke length Rubber cushioned

More information

PILOT VALVE BOXES containing 2 to 12 valves 2/2 normally closed, direct operated 1/8

PILOT VALVE BOXES containing 2 to 12 valves 2/2 normally closed, direct operated 1/8 PILOT VALVE BOXES containing 2 to 12 valves 2/2 normally closed, direct operated 1/8 NC OUT IN 2/2 Series 110 EATURES Compact pilot boxes with direct operated, integrated pilot valves Especially designed

More information

UM/22000 5/2 or 5/3 Solenoid and air pilot actuated soft spool valves

UM/22000 5/2 or 5/3 Solenoid and air pilot actuated soft spool valves U/ / or / > > Sub-base mounted, 99- s,, or > > Steel reinforced main seals > > Low power coils (,W) > > Wide range of sub-bases and accessories > > 6 bar and bar NOO solenoid pilots with locking or non-locking

More information

3/2-, 5/2- and 5/3-way Solenoid Valves for process pneumatics

3/2-, 5/2- and 5/3-way Solenoid Valves for process pneumatics 3/2-, 5/2-5/3-way Solenoid Valves for process pneumatics Type 6518 stard High flow-rate capacity Reduced power consumption Single or manifold mounting stard Type 6518/6519 can be combined with... Stard-,

More information

Direct Operated 2 Port Solenoid Valve For Water, Oil, Steam, Air

Direct Operated 2 Port Solenoid Valve For Water, Oil, Steam, Air CAT.EUS0- A -UK Direct Operated Port Solenoid Valve For Water, Oil, Steam, Air New Series VX// Reduction of power consumption ( specification) W. W W W.. W 0. W Low power consumption type: 0. W (Held at

More information

Check Valves. Pilot Operated Check Valves. Vickers. PCGV-6/8, 10 Series; PCG5V-6/8, 20 Series. Typical Section. Features and Benefits

Check Valves. Pilot Operated Check Valves. Vickers. PCGV-6/8, 10 Series; PCG5V-6/8, 20 Series. Typical Section. Features and Benefits Vickers Check Valves Pilot Operated Check Valves PCGV-6/8, 10 Series; PCG5V-6/8, 20 Series Typical Section Typical PCG5V model with internally drained pilot piston internal leakage through the closed pilot

More information

Cartridge Valves. Solenoid Valves. Vickers. Screw-in Cartridge Valves. Maximum Pressure 210 bar (3000 psi) Maximum Flow 227 l/min (60 USgpm)

Cartridge Valves. Solenoid Valves. Vickers. Screw-in Cartridge Valves. Maximum Pressure 210 bar (3000 psi) Maximum Flow 227 l/min (60 USgpm) Vickers Cartridge Valves Solenoid Valves Screw-in Cartridge Valves Maximum Pressure bar ( psi) Maximum Flow 7 l/min (6 USgpm) Rev /99 77 Introduction For over seventy years, Vickers has provided its customers

More information

http://www.daikinpmc.com/en/ For latest information, PDF catalogs and operation manuals Features MPa {kgf/cm 2 } 100 17.5 {175}

http://www.daikinpmc.com/en/ For latest information, PDF catalogs and operation manuals Features MPa {kgf/cm 2 } 100 17.5 {175} Solenoid Valve Features 2 For DC power supply 3 For C power supply These models realize high-pressure large-flow-rate control at 35 MPa {35 kgf/cm 2 } and 1 L/min (2) or 16 L/min (3). They are best suited

More information

On-off valves MS-EM/EE, MS series, NPT

On-off valves MS-EM/EE, MS series, NPT On-off valves MS-EM/EE, MS series, NPT On-off valves MS9-EM, MS series, NPT Peripherals overview 5 3 4 aa -H- Note Additional accessories: Module connector for combinations with size MS6, MS9 or size MS12

More information

3 WAY (3/2) POPPET VALVES FOR AIR AND VACUUM SERVICE SOLENOID OR AIR ACTUATED BROCHURE N-223

3 WAY (3/2) POPPET VALVES FOR AIR AND VACUUM SERVICE SOLENOID OR AIR ACTUATED BROCHURE N-223 3 WAY (3/2) POPPET VALVES FOR AIR AND VACUUM SERVICE SOLENOID OR AIR ACTUATED BROCHURE N-223 HERION S HIGH PERFORMANCE POPPET VALVES For those applications requiring high Cv, fast response times, large

More information

KTM Pneumatic Actuators AW, AWN series (for large sized valves)

KTM Pneumatic Actuators AW, AWN series (for large sized valves) Pneumatic actuator for large-sized valves, ideally suited for control valves and remotely controlling process lines Features Scotch yoke construction ideal for large sized valves Two pistons in double

More information

Pressure relief valves type ARAM two stage, in line mounting - G 3/4" and G 1 1 /4" threaded ports

Pressure relief valves type ARAM two stage, in line mounting - G 3/4 and G 1 1 /4 threaded ports www.atos.com Table C04520/E Pressure relief valves type ARAM two stage, in line mounting G 3/4" and G 1 1 /4" threaded ports ARAM20/20...E ARAM32.../V ARAM are two stage pressure relief valves with balanced

More information

97300 NAMUR series, 3/2 & 5/2 Indirect solenoid actuated spool valve

97300 NAMUR series, 3/2 & 5/2 Indirect solenoid actuated spool valve 9700 NAMUR series, / & / > > Port size: G/, / NPT, NAMUR Interface > > Crossover-free switching > > Main application: Single and double acting actuators > > / way valve usable as / way valve > > Manual

More information

Solenoid/pneumatic valves, Tiger Classic

Solenoid/pneumatic valves, Tiger Classic Solenoid/pneumatic valves, Tiger Classic Electrically or pneumatically actuated valves With internal or external pilot air Sturdy and reliable Specified types in accordance with ATEX directive for potentially

More information

2 WAY (2/2) AND 3 WAY (3/2) BRASS AND STAINLESS STEEL SOLENOID VALVES

2 WAY (2/2) AND 3 WAY (3/2) BRASS AND STAINLESS STEEL SOLENOID VALVES 2 WAY (2/2) AND 3 WAY (3/2) BRASS AND STAINLESS STEEL SOLENOID VALVES DIRECT ACTING Brochure N-289 SPECIFICATIONS Port Size: 1/8 and1/4 Solenoid Valve for air, oil, water and other fluids Flow Direction:

More information

Table of Contents. MicroAir Series...3-9

Table of Contents. MicroAir Series...3-9 Table of Contents MicroAir Series...-9 Technical and Operating Data.... How to Order.... Valve on ndividual Base... 5 Manifold Assemblies... 6 End Plate Kits... 7 Blank Station Plate Kit.... 7 Blocking

More information

HOSE, TUBE, AND PIPE CLAMPS

HOSE, TUBE, AND PIPE CLAMPS HOSE, TUBE, AND PIPE CLAMPS HOSE, TUBE, AND PIPE CLAMPS TABLE OF CONTENTS Introduction 3 Construction 3 Application 3 Mounting 3 Standard Duty Clamps (HRL) Arrangements 4 Dimensions 5 Heavy Duty Clamps

More information

MICRO SOLENOID VALVE pinch mechanism for flexible tube O.D. 1.65 to 9.5 mm

MICRO SOLENOID VALVE pinch mechanism for flexible tube O.D. 1.65 to 9.5 mm MICRO SOLENOID VALVE pinch mechanism for flexible tube O.D. 1.65 to 9.5 mm NC 2/2 Series 284 EATRES Solenoid valve suitable for cutting off the flow of a fluid by pinch or sterile, aseptic, physiological

More information

MUELLER A-20806/A ADJUSTABLE VERTICAL INDICATOR POST

MUELLER A-20806/A ADJUSTABLE VERTICAL INDICATOR POST INSTALLATION INSTRUCTIONS MUELLER A-20806/A-20807 STARTING YEAR DATE 2011 GENERAL DESCRIPTION Vertical Indicator Posts (Ref. Figure A) are designed to operate non-rising stem (inside screw) gate valves,

More information

Line-Mounted Valves L Series

Line-Mounted Valves L Series Spare Part Kit for Valve Series B1LSAD3 Line-Mounted L Series Accessories Spare Part Kits All Series Valve Series B1LSAD3 40.1609 Incl. O-rings, gaskets, spring or muffl er Spare Part Kit for Valve Series

More information

SPOOL & SLEEVE VALVES solenoid air operated monostable / bistable function threaded ports G 1/8-G 1/4

SPOOL & SLEEVE VALVES solenoid air operated monostable / bistable function threaded ports G 1/8-G 1/4 SPOO & SV VAVS monostable / bistable function threaded ports -G 1/ 5/-5/3 Series 1 FATURS Reliability: steel spool & sleeve technology with long service life Robust valve design, particularly recommended

More information

SOLENOID VALVES AND PNEUMATIC VALVES

SOLENOID VALVES AND PNEUMATIC VALVES 2 A S E R I E S Catalogue 2005-2006 Directly operated solenoid valves Series A 2/2 way, 3/2 way monostable, bistable (with magnetic memory) Ports M5,, cartridge ø4 The Series A solenoid valves are of the

More information

PR*SP - PR*SPU - PILOT OPERATED PRESSURE RELIEF VALVE SERIES

PR*SP - PR*SPU - PILOT OPERATED PRESSURE RELIEF VALVE SERIES CONTINENTAL HYDRAULICS PR*SP - PR*SPU PILOT OPERATED PRESSURE RELIEF VALVE SERIES 5505 WEST 123RD STREET SAVAGE, MN 55378-1299 / PH: 952.895.6400 / WWW.CONTINENTALHYDRAULICS.COM POWERFUL PR*SP - PR*SPU

More information

Universal type. Elbow type AS13 1FG-M5 AS23 1FG-01 AS23 1FG-02 AS33 1FG-02 AS33 1FG-03 AS43 1FG-04. Specifications

Universal type. Elbow type AS13 1FG-M5 AS23 1FG-01 AS23 1FG-02 AS33 1FG-02 AS33 1FG-03 AS43 1FG-04. Specifications Speed Controller with One-touch Fitting Stainless Steel Series Elbow Type/Universal Type Series -FG RoHS Stainless specifications for use in corrosive environments. Stainless steel used for metal parts.

More information

Pilot Operated Pressure Relief Valves Series R4V / R6V

Pilot Operated Pressure Relief Valves Series R4V / R6V Characteristics Series RV / R6V Pilot operated pressure relief valves series RV (DIN 230 Form D) and R6V (DIN 230 Form E) consist of a manually adjusted pilot stage and a seated type main stage. A vent

More information

Axial piston pumps type PVPC variable displacement, by a full line of mechanical controls

Axial piston pumps type PVPC variable displacement, by a full line of mechanical controls www.atos.com Table A609/E Axial piston pumps type PVPC variable displacement, by a full line of mechanical controls PVPCCH4046 PVPC are variable displacement axial piston pumps for high pressure operation,

More information

3/2-way Mini Solenoid Valve

3/2-way Mini Solenoid Valve 3/2way Mini Solenoid Valve Directacting 0... bar DN mm... DN mm,,, subbase, banjobolt connection 21mm coil spacing when mounted on manifold Type can be combined with... Type 20 Type 207 Type able plug

More information

Pressure Relief. Pressure Relief and Sequence Valves CG2V-6/8, 10 Series; CG5V-6/8, 20 Series. Vickers. Features and Benefits.

Pressure Relief. Pressure Relief and Sequence Valves CG2V-6/8, 10 Series; CG5V-6/8, 20 Series. Vickers. Features and Benefits. Vickers Pressure Relief Pressure Relief and Sequence Valves CG2V-6/8, 1 Series; CG5V-6/8, 2 Series Typical Section CG2V-6*W-1 relief valve Basic Characteristics Maximum pressure.......... 35 bar (5 psi)

More information

Direct solenoid and solenoid pilot operated valves

Direct solenoid and solenoid pilot operated valves Direct solenoid and solenoid pilot operated valves Individual mounting Series non plug-in plug-in Manifold mounting 35 non plug-in plug-in 100 Pilot air accumulator Integral ground wire Manual operator

More information

Water Separator. Main Line Filter. Mist Separator. Micro Mist Separator 150C 250C 350C 450C AMG 550C 2C 4C 8C 11C AFF 22C 37B 75B 150C 250C 350C 450C

Water Separator. Main Line Filter. Mist Separator. Micro Mist Separator 150C 250C 350C 450C AMG 550C 2C 4C 8C 11C AFF 22C 37B 75B 150C 250C 350C 450C Water droplet removal Water Separator Water droplet separation rate: % Model Flow capacity l/min (ANR) Max. flow capacity at 0.7 MPa inlet pressure 300 750 1,500 AMG 2,0 AMG to AMG/ Large dust particle

More information

Miniature Pneumatic Solenoid Valve. Power Options: 0.5 Watt (6 psig model) 1.0 Watt (30, 100 psig model) Voltage Options: 3, 5, 12 or 24 VDC

Miniature Pneumatic Solenoid Valve. Power Options: 0.5 Watt (6 psig model) 1.0 Watt (30, 100 psig model) Voltage Options: 3, 5, 12 or 24 VDC 8mm Solenoid Valve Typical Applications Portable Equipment Blood Pressure Monitoring Wound Therapy Air and Oxygen Delivery Sensor Zeroing Product Specifications Mechanical Valve Type: 3-Way, Solenoid-actuated

More information

-10 +45 C 50 μm filtered air, with or without lubrication spool 10 bar G/18 G1/4 6,5 8,5 890

-10 +45 C 50 μm filtered air, with or without lubrication spool 10 bar G/18 G1/4 6,5 8,5 890 CL/CM UNIVERSAL Valves G1/8 - CHARACTERISTICS -10 +45 C 50 μm filtered air, with or without lubrication spool 10 bar G/18 6,5 8,5 890 1480 die-cast zamak (G1/8), aluminium () NBR aluminium AA series/u1-u,5

More information

Limit Switch D4B- N. Ordering Information. Model Number Legend D4B- N-

Limit Switch D4B- N. Ordering Information. Model Number Legend D4B- N- Limit Switch Snap-action or slow-action contact for accurate switching with safe operation via direct drive positive contact opening even with metal deposition between mating contacts. Two sets of contact:

More information

Auto Reset Gas Solenoid Valves GV-VMR

Auto Reset Gas Solenoid Valves GV-VMR Page 1 of 5 Description The VMR type valve is a fast opening single-stage solenoid valve, normally closed. This type of device is suitable for air or gas blocking and releasing controls, required in gas

More information

Solenoid Operated Directional Valves

Solenoid Operated Directional Valves INDUSTRIAL FLUID POWER COMPONENTS AND SYSTEMS SERIES 35 Solenoid Operated Directional Valves SD-2B-115A-35 SDS-2H-12D-35 S-2B-115A-35 Features High Flow/ High Pressure: Up to 25 gpm / 5000 psi working

More information

Compressed Air Cleaning Filter Series

Compressed Air Cleaning Filter Series Compressed Air Cleaning ilter Series Series / or Water, Solid/Oil Separation and Deodorization Modular connection, Space-saving design, Labor-saving in piping! Uses the same spacer as the.r.l. combination

More information

KEYSTONE. Keystone MRP and MRA Pneumatic Actuators

KEYSTONE. Keystone MRP and MRA Pneumatic Actuators KEYSTONE A comprehensive range of pneumatic actuators, providing compact, reliable and economical powered operation for all types of quarter-turn valves Features Direct mounting to all Keystone butterfly

More information

size 3 15 4200 size 4 19 6600

size 3 15 4200 size 4 19 6600 BE/BE ISO 99/ Valves - Compliance with ISO 99/ international standards - Full range: - - - size - Two different internal commutation system: mixed and spool, appreciated for decades thanks to their maximum

More information

Proportional pressure relief valve

Proportional pressure relief valve Proportional pressure relief valve RE 29161/07.05 1/10 Type DBETX Nominal size 6 Unit series 1X Maximum working pressure P 315 bar, T 250 bar Nominal flow rate Q nom 1 l/min List of contents Contents Page

More information

E4E PILOT OPERATED DIRECTIONAL CONTROL VALVE WITH ELECTRIC PROPORTIONAL CONTROL SERIES 51

E4E PILOT OPERATED DIRECTIONAL CONTROL VALVE WITH ELECTRIC PROPORTIONAL CONTROL SERIES 51 83 300/100 ED E4E PILOT OPERATED DIRECTIONAL CONTROL VALVE WITH ELECTRIC PROPORTIONAL CONTROL SUBPLATE MOUNTING CETOP P05 p max 250 bar Q max (see specification table) MOUNTING INTERFACE OPERATING PRINCIPLE

More information

2.12. page 223 2.12. Products for Explosion hazardous Environment

2.12. page 223 2.12. Products for Explosion hazardous Environment 2.12 page 223 2.12 Products for Explosion hazardous Environment Non-electric valves for explosion 2.12.1 page 224 hazardous environment The following manually and mechanically actuated valves are available

More information