Marine after-treatment from STT Emtec AB

Save this PDF as:
 WORD  PNG  TXT  JPG

Size: px
Start display at page:

Download "Marine after-treatment from STT Emtec AB"

Transcription

1 Marine after-treatment from STT Emtec AB For Your Vessel and the Environment Recommended by Volvo Penta

2 SCR Catalyst 2. Injection nozzle 3. Mixer unit 4. Diagnostic display 5. Urea tank 6. Urea dosing unit 7. Electronic control unit (ECU) 8. Urea pressure sensor 9. Control cabinet 10. Air pressure regulator 11. Temperature sensor 12. Exhaust pressure sensor 13. NOx sensor 14. Urea line; from pump to nozzle 15. Urea line; from pump to tank 16. Urea line; from tank to pump Marine SCR system for engines up to 600 kw Up to 90% NOx reduction Suitable for retrofit This system reduces NOx through selective catalysis with urea as the reduction agent. The urea will decompose to ammonia in the exhaust stream, which in turn will reduce the NOx on the SCR catalyst surface. Compressed air is used to achieve a high degree of urea atomization in the exhaust. This, together with the flow optimized mixer minimizes risk of clogging and guaranties the high level of performance and trouble free operation. The required amount of air is 25 l/min (NTP) with a minimum pressure of 4 bar (absolute). The system operates on fuel sulphur levels up to 1000 ppm. 7 Example of weighted NO x emission from E3 cycle (g/kwh) Engine out With SCR marine

3 SCR Catalyst 2. Injection nozzle 3. Mixer unit 4. Diagnostic display 5. Urea tank 6. Urea dosing unit 7. Electronic control unit (ECU) 8. Urea pressure sensor 9. Control cabinet 10. Air pressure regulator 11. Temperature sensor 12. Exhaust pressure sensor 13. NOx sensor 14. Urea line; from pump to nozzle 15. Urea line; from pump to tank 16. Urea line; from tank to pump 17. POC Combined SCR and POC system for engines up to 600 kw. For low sulphur fuel (EN590) Up to 90% NOx reduction Up to 40% PM reduction More than 90% reduction of HC and CO 0.8 Example of weighted emissions from E3 cycle (g/kwh) With SCR marine Without SCR marine CO HC PM NOx / 10 3

4 Technical specifications Tank: 100 l, preassembled with bulk tank connection Urea consumption: 4-6% of the fuel consumption Air consumption: 25 l/min at 6 bar Supply voltage: 230 VAC or 24 VDC Current consumption: Nominal 10 A Ambient temperature: C or better (complete installation) Installation time complete system: 3-5 days Service interval: visual inspection every 6 month urea inlet filter 8000 hours or 12 month Data Logger embedded in the control unit Dual CAN bus SAE-J1939 4

5 STT Emtec configurations for engines up to 600 kw The SCR marine system is optimized for a wide range of exhaust flows. The exhaust gas flow is related to the engine power. The system is available for engine power up to 600 kw as showed below. Engine power, kw Recommended SCR configuration < 110 SCR marine ME 110 < 210 SCR marine MD 210 < 300 SCR marine LC 300 < 480 SCR marine LB 480 < 600 SCR marine LA 5

6 STT monitoring systems Control cabinet PC based software for system monitoring. Example of parameters that can be viewed and adjusted using the EmtecMapper Monitoring System: Setup the data logger and download logger data. View and clear error codes. View live system operation. STT Diagnostic Module All control cabinets are equipped with a diagnostic module integrated in the cabinet door. This display shows the system status and possible error codes. STT Control Room Rack The control room rack is useful in multiple engine installations. The control room rack works as a hub and collects data from all systems. 6

7 STT monitoring systems In operation

8 STT Emtec in brief The history of STT Emtec, headquartered in Sundsvall, Sweden, goes back to Originally involved in land based diesel engine technologies, the vision has always been to establish the company as one of the world leading technology providers in the field of emissions and engine performance systems, many of which have been developed in house. As well as providing after-market systems STT Emtec is a key component supplier to the world s automotive, marine and industrial engine manufacturers. Layout and original: Areskoog Reklam AB Print: Tryckeribolaget AB, Sundsvall, Sweden, October 2011 The move into emission control systems for the maritime sector is a natural progression from the automotive experience. It is obvious that the technologies from STT Emtec will contribute considerably to the shipping industry s emission reduction efforts. For further information: STT Emtec AB (publ) Box 100 SE Sundsvall SWEDEN Phone: Fax: Web: Your local contact:

Marine after-treatment from STT Emtec AB

Marine after-treatment from STT Emtec AB Marine after-treatment from STT Emtec AB For Your Vessel and the Environment SCR Technology How it works The selective catalytic reduction of nitrous oxides (NOx) by nitrogen compounds such as urea solutions

More information

Marine after-treatment from STT Emtec AB

Marine after-treatment from STT Emtec AB Marine after-treatment from STT Emtec AB For Your Vessel and the Environment 6 7 8 1 11 1 10 9 1. Pick up. Flow direction valve. Filters. Cooler. Condensate trap 6. Flow meter 7. EGR-valve 8. Secondary

More information

EURO VI. Technologies & Strategies. Relatore: M.Maritati Commercial training

EURO VI. Technologies & Strategies. Relatore: M.Maritati Commercial training EURO VI Technologies & Strategies Relatore: M.Maritati Commercial training Euro VI The entering into force of the new Euro VI normative provides a stimulus for Iveco to update the engine offer pursuing

More information

Selective Catalytic Reduction (SCR) and Diesel Exhaust Fluid (DEF) Training Module

Selective Catalytic Reduction (SCR) and Diesel Exhaust Fluid (DEF) Training Module Selective Catalytic Reduction (SCR) and Diesel Exhaust Fluid (DEF) Training Module DEF SCR Training Module Welcome to the Cummins Filtration DEF SCR training module. DEF & SCR systems are key to Cummins

More information

Tier III Kompatibilität mit Katalysator (SCR)

Tier III Kompatibilität mit Katalysator (SCR) Tier Kompatibilität mit Katalysator (SCR) Workshop Abgasnachbehandlung VDR + Mariko 15.04.2016 1 Contents ntroduction of ERC Technik GmbH What is NOx? Development of Emission Limits SCR technology State

More information

DNO x Taking the Diesel Engine into the Future

DNO x Taking the Diesel Engine into the Future DNO x Taking the Diesel Engine into the Future DNO x Introduction 2 Background 4 Health effects 5 Environmental effects 6 Emission regulations 6 Heavy-Duty diesel vehicles Industrial equipment Environmental

More information

Fault codes DM1. Industrial engines DC09, DC13, DC16. Marine engines DI09, DI13, DI16 INSTALLATION MANUAL. 03:10 Issue 5.0 en-gb 1

Fault codes DM1. Industrial engines DC09, DC13, DC16. Marine engines DI09, DI13, DI16 INSTALLATION MANUAL. 03:10 Issue 5.0 en-gb 1 Fault codes DM1 Industrial engines DC09, DC13, DC16 Marine engines DI09, DI13, DI16 03:10 Issue 5.0 en-gb 1 DM1...3 Abbreviations...3 Fault type identifier...3...4 03:10 Issue 5.0 en-gb 2 DM1 DM1 Fault

More information

Luft- og støjforureningen i Danmark, 16. november 2011

Luft- og støjforureningen i Danmark, 16. november 2011 Tekniske løsninger på NO 2 -forureningen SCR Technology - Selective Catalytic Reduction (SCR) Luft- og støjforureningen i Danmark, 16. november 2011 Ernst Bjerregaard Emitec Denmark A/S ernst.bjerregaard@emitec.com

More information

Tier III emission technology

Tier III emission technology Tier III emission technology By Johan Kaltoft, Senior Project Manager, Emission Reduction Technology < 1 > Tier III emission technology Tier III strategy SCR - Selective Catalytic Reduction EGR Exhaust

More information

Monitoring Air Emissions on Ships. Restricted Siemens AG 2014 All rights reserved.

Monitoring Air Emissions on Ships. Restricted Siemens AG 2014 All rights reserved. Monitoring Air Emissions on Ships siemens.com/answers Why emission monitoring in the marine industry? Main drivers: Meeting regulations: NOx and SOx reduction Energy optimization; CO 2 reduction Resolution

More information

API Marine. BMS Presentation. Ballast Measurement Systems

API Marine. BMS Presentation. Ballast Measurement Systems API Marine BMS Presentation Ballast Measurement Systems BMS4 Typical Configuration BMS4 Typical Configuration BMS4 Extended Configuration BMS4 System (24 tanks) Air regulator Terminal block Drain/Air Filter

More information

3rd Generation SCR System Using Solid Ammonia Storage and Direct Gas Dosing: Expanding the SCR window for RDE

3rd Generation SCR System Using Solid Ammonia Storage and Direct Gas Dosing: Expanding the SCR window for RDE 3rd Generation SCR System Using Solid Ammonia Storage and Direct Gas Dosing: Expanding the SCR window for RDE Dr. Tue Johannessen Chief Technology Officer Amminex A/S tj@amminex.com US DoE DEER conference

More information

Perfectly Adapted. ISB Euro 6 Diesel Engines 150-310PS. Cummins Ltd. Address Line One Address Line Two Address Line Three

Perfectly Adapted. ISB Euro 6 Diesel Engines 150-310PS. Cummins Ltd. Address Line One Address Line Two Address Line Three Perfectly Adapted ISB Euro 6 Diesel Engines 150-310PS Cummins Ltd. Address Line One Address Line Two Address Line Three Tel: +00 0000 000000 Fax: +00 0000 000000 Internet: cummins.com Bulletin 0000000

More information

EPA emission regulations: What they mean for diesel powered generating systems

EPA emission regulations: What they mean for diesel powered generating systems Power topic #9001 Technical information from Cummins Power Generation EPA emission regulations: What they mean for diesel powered generating systems > White paper By Aniruddha Natekar, Sales Application

More information

Online Infrared Flue Gas Analyzer Gasboard 3000

Online Infrared Flue Gas Analyzer Gasboard 3000 Online Infrared Flue Gas Analyzer Gasboard 3000 O 2 CO CO2 SO 2 NO NO x Use of measurement methods Proprietary Infrared NDIR Detectors - Micro-flow in ppm range: CO, NO, SO2, CO2 - Dual beam in % volume

More information

Malmö Hydrogen and CNG/Hydrogen filling station and Hythane bus project

Malmö Hydrogen and CNG/Hydrogen filling station and Hythane bus project Malmö Hydrogen and CNG/Hydrogen filling station and Hythane bus project Bengt Ridell Carl Bro Energikonsult AB, Sweden, 2005-04-15 bengt.ridell@carlbro.se 1. Background The largest private utility company

More information

Exhaust Scrubbers. What you need to know. Move Forward with Confidence

Exhaust Scrubbers. What you need to know. Move Forward with Confidence Exhaust Scrubbers What you need to know Move Forward with Confidence Exhaust Scrubbers - What you need to know 1 What are the rules? From January 1, 2015 ships navigating in designated areas globally will

More information

DEF Q&A. A. SCR is a technology that uses a urea based diesel exhaust fluid (DEF) and a

DEF Q&A. A. SCR is a technology that uses a urea based diesel exhaust fluid (DEF) and a Selective Catalytic Reduction (SCR) Q. What is Selective Catalytic Reduction (SCR)? A. SCR is a technology that uses a urea based diesel exhaust fluid (DEF) and a catalytic converter to significantly reduce

More information

US Heavy Duty Fleets - Fuel Economy

US Heavy Duty Fleets - Fuel Economy US Heavy Duty Fleets - Fuel Economy Feb. 22, 2006 Anthony Greszler Vice President Advanced Engineering VOLVO POWERTRAIN CORPORATION Drivers for FE in HD Diesel Pending oil shortage Rapid oil price increases

More information

MAN Diesel & Turbo. Frederik Carstens Head of Offshore Sales Marine Medium Speed. Frederik Carstens & Karsten Borneman

MAN Diesel & Turbo. Frederik Carstens Head of Offshore Sales Marine Medium Speed. Frederik Carstens & Karsten Borneman Frederik Carstens Head of Offshore Sales Marine Medium Speed < 1 > Disclaimer All data provided on the following slides is for information purposes only, explicitly non-binding and subject to changes without

More information

Effect of GTL Diesel Fuels on Emissions and Engine Performance

Effect of GTL Diesel Fuels on Emissions and Engine Performance Rudolf R. Maly Research and Technology, Stuttgart Effect of GTL Diesel Fuels on Emissions and Engine Performance 10th Diesel Engine Emissions Reduction Conference August 29 - September 2, 2004 Coronado,

More information

Diesel and gas engine systems for EURO VI on-highway applications

Diesel and gas engine systems for EURO VI on-highway applications Diesel and gas engine systems for EURO VI on-highway applications Mercedes-Benz engines in the OM 93X and OM 47X model series. Outstanding design and efficiency. Specifically developed to comply with the

More information

AVL FUEL MASS FLOW METER & FUEL TEMPERATURE CONTROL

AVL FUEL MASS FLOW METER & FUEL TEMPERATURE CONTROL FUEL CONSUMPTION MEASUREMENT AVL FUEL MASS FLOW METER & FUEL TEMPERATURE CONTROL Description The combination of AVL Fuel Mass Flow Meter and AVL Fuel Temperature Control is a high precise and continuous

More information

Software Features of Auto Gas Gas Analyzer Features HC, CO, CO2, Lambda, Air Fuel, NOx. Has optional RPM and Oil Temp.

Software Features of Auto Gas Gas Analyzer Features HC, CO, CO2, Lambda, Air Fuel, NOx. Has optional RPM and Oil Temp. Auto Gas Ultimate Model Shown Above Software Features of Auto Gas Gas Analyzer Features HC, CO, CO2, Lambda, Air Fuel, NOx. Has optional RPM and Oil Temp. Durable high strength aluminum case with all of

More information

EMISSIONS FROM MARINE ENGINES VERSUS IMO CERTIFICATION AND REQUIREMENTS OF TIER 3

EMISSIONS FROM MARINE ENGINES VERSUS IMO CERTIFICATION AND REQUIREMENTS OF TIER 3 Journal of KONES Powertrain and Transport, Vol. 18, No. 2 2011 EMISSIONS FROM MARINE ENGINES VERSUS IMO CERTIFICATION AND REQUIREMENTS OF TIER 3 Jerzy Herdzik Gdynia Maritime University Marine Power Plant

More information

Development of Current and Future Diesel After Treatment Systems

Development of Current and Future Diesel After Treatment Systems Development of Current and Future Diesel After Treatment Systems Pakorn Bovonsombat, Byung-Sun Kang, Paul Spurk, Harald Klein, Klaus Ostgathe Degussa Metals Catalysts Cerdec AG Rodenbacher Chaussee 4,

More information

The Ship Operator s Guide To NOx Reduction

The Ship Operator s Guide To NOx Reduction The Ship Operator s Guide To NOx Reduction The Comprehensive Resource For NOx Emissions Reduction & Abatement fathom marine energy environment GUIDE SPONSORS SUPPORTING SPONSOR The Ship Operator s Guide

More information

Boiler NOx Emissions and Energy Efficiency

Boiler NOx Emissions and Energy Efficiency Boiler NOx Emissions and Energy Efficiency Prepared For: Boiler Operators and Facility Managers Prepared By: 100 Montgomery Street, Suite 600 San Francisco, CA 94104 AGENDA Introduction Boiler NOx Formation

More information

Improvement and Simplification of Diesel Particulate Filter System Using a Ceria-Based Fuel-Borne Catalyst in Serial Applications

Improvement and Simplification of Diesel Particulate Filter System Using a Ceria-Based Fuel-Borne Catalyst in Serial Applications Improvement and Simplification of Diesel Particulate Filter System Using a Ceria-Based Fuel-Borne Catalyst in Serial Applications Paul WOUTERS Inergy Automotive Systems Olivier KUNSTMANN Inergy Automotive

More information

FAC 7.1: Generators. EPA Impacts on Emergency Gensets for 2015 Installations

FAC 7.1: Generators. EPA Impacts on Emergency Gensets for 2015 Installations FAC 7.1: Generators EPA Impacts on Emergency Gensets for 2015 Installations Speaker: Bob Stelzer, CTO Safety Power Inc bob.stelzer@safetypower.ca Speaker: Randy Sadler, SME, Safety Power Inc. randy.sadler@safetypower.ca

More information

Technical Specification. Generating Set with Waukesha engine burning natural gas

Technical Specification. Generating Set with Waukesha engine burning natural gas Technical Specification Generating Set with Waukesha engine burning natural gas The following presents the Gas Engine Generating Set (GEGS) APG1000 type, based on Waukesha gas engine 16V150LTD. Using the

More information

An overview of Euro VI for trucks over 3.5t. Brought to you by Mercedes-Benz

An overview of Euro VI for trucks over 3.5t. Brought to you by Mercedes-Benz An overview of Euro VI for trucks over 3.5t Brought to you by Mercedes-Benz Contents What is Euro VI? What is Euro VI? 01 What s different about Euro VI? 02 When do you need to think about it? 03 How is

More information

EPA Requirements for Diesel Standby Engines In Data Centers. Bob Stelzer / CTO / Safety Power Inc. For 7x24 Fall 2014 Conference. 1.

EPA Requirements for Diesel Standby Engines In Data Centers. Bob Stelzer / CTO / Safety Power Inc. For 7x24 Fall 2014 Conference. 1. EPA Requirements for Diesel Standby Engines In Data Centers Bob Stelzer / CTO / Safety Power Inc For 7x24 Fall 2014 Conference 1.0 Introduction In order to get the Air Emissions Permit for facilities that

More information

Fuel Quality and Vehicle Emission Standards in GCC countries. Name, event, date

Fuel Quality and Vehicle Emission Standards in GCC countries. Name, event, date Fuel Quality and Vehicle Emission Standards in GCC countries Name, event, date Shoa Ehsani UNEP March 12, 2008 Road Map of Today s Presentation 1. Why have standards and harmonize? (a) LAS declaration

More information

Emission catalyst solutions for Euro 5 and beyond

Emission catalyst solutions for Euro 5 and beyond Emission catalyst solutions for Euro 5 and beyond ECT 2011, New Delhi November 9-10, 2011 Dr Toni Kinnunen CTO, Ecocat Group toni.kinnunen@ecocat.com www.ecocat.com Complete diesel aftertreatment system

More information

Bergen Engines Products and Applications

Bergen Engines Products and Applications Bergen Engines Products and Applications 1 Since 1948 Bergen Engines, a Rolls-Royce Power Systems Company, has delivered more than 6,500 four-stroke medium-speed diesel and gas engines for power generation

More information

Exhaust Emissions Reduction

Exhaust Emissions Reduction Exhaust Emissions Reduction - towards Stage IIIB/Tier 4 Interim non-road diesel exhaust emission standards QUESTIONS & ANSWERS April 2010 Emissions and Legislation 1. What is in focus of Stage IIIB/ Tier4

More information

G-volution Plc. Advanced Multi Fuel Technology

G-volution Plc. Advanced Multi Fuel Technology G-volution Plc G-Volution a new energy future Gas revolution: a new cheap, clean fuel Transport will switch to gas G-Volution s technology is the best Cummins EPA approved dual fuel engine Unique emissions

More information

Alfa Laval PureBallast 3.1

Alfa Laval PureBallast 3.1 Alfa Laval PureBallast 3.1 Ballast water treatment system 1000 m 3 /h system Alfa Laval PureBallast 3.1 is an automated inline treatment system for the biological disinfection of ballast water. Operating

More information

Ingenieurskunst kontra Gesetzgebung: Sind die Emissionsvorgaben Innovationstreiber oder lähmendes Korsett?

Ingenieurskunst kontra Gesetzgebung: Sind die Emissionsvorgaben Innovationstreiber oder lähmendes Korsett? Ingenieurskunst kontra Gesetzgebung: Sind die Emissionsvorgaben Innovationstreiber oder lähmendes Korsett? Dr. Dirk Bergmann, Geschäftsführer FPT Motorenforschung Arbon Switzerland Overview Technological

More information

Diesel Exhaust Fluid (DEF) Q & A

Diesel Exhaust Fluid (DEF) Q & A Diesel Exhaust Fluid (DEF) Q & A BULLETIN SCR: The Leading Technology to Meet 2010 Emission Regulations Q. What is Selective Catalytic Reduction (SCR)? A. SCR is a technology that uses a urea based diesel

More information

Service Information Trucks

Service Information Trucks Service Information Trucks Group 28 Release2 Engine Control Module (ECM), Diagnostic Trouble Code (DTC), Guide 2010 Emissions CHU CXU GU TD 89047073 Foreword The descriptions and service procedures contained

More information

Zero Emission Engine. An Economic and Environmental Benefit

Zero Emission Engine. An Economic and Environmental Benefit Zero Emission Engine An Economic and Environmental Benefit Saskia Scherfling Registration number: 731805 Department: VIII Course of studies: Process and Environmental Engineering September 2007 Table of

More information

INDUSTRIAL ENGINE RATINGS GUIDE

INDUSTRIAL ENGINE RATINGS GUIDE INDUSTRIAL ENGINE RATINGS GUIDE Table of Contents Highly Regulated/Lesser Regulated For purposes of this Guide, Highly Regulated refers to engines that meet stringent emission standards in effect in the

More information

Aging of Zeolite SCR Catalysts

Aging of Zeolite SCR Catalysts 1 Diesel Aftertreatment Accelerated Aging Cycle Development (DAAAC) Aging of Zeolite Based SCR Systems Theodore M. Kostek Aging of Zeolite SCR Catalysts Zeolite structure Steps in SCR reaction Structure,

More information

Summary of the Future Policy for Motor Vehicle Emission Reduction (The 11th Report)

Summary of the Future Policy for Motor Vehicle Emission Reduction (The 11th Report) Transmitted by the expert from Japan Informal document No. GRPE-65-14 (65 th GRPE, 15-18 January 2012, agenda item 16) Summary of the Future Policy for Motor Vehicle Emission Reduction (The 11th Report)

More information

Possible Technical Modifications on Pre-2000 Marine Diesel Engines for NOx Reductions

Possible Technical Modifications on Pre-2000 Marine Diesel Engines for NOx Reductions Possible Technical Modifications on Pre-2000 Marine Diesel Engines for NOx Reductions Report No. MPU 2008.017 Version 1/1 Department MPU Combustion Engines Environmental Contents Executive Summary 0 Introduction

More information

Spark Ignited Natural Gas Engine Technology

Spark Ignited Natural Gas Engine Technology Spark Ignited Natural Gas Engine Technology Clean Fleets Technology Conference Sugar Land, TX, June 2014 Jorge Gonzalez Regional Manager Agenda Corporate Overview Natural Gas Technology Evolution Products

More information

ISX15 and ISX Well Servicing Applications. ISX15 (EPA 2010) 2-3 400-600 hp (298-447 kw) ISX (EPA 2007) 4-5 400-600 hp (298-447 kw)

ISX15 and ISX Well Servicing Applications. ISX15 (EPA 2010) 2-3 400-600 hp (298-447 kw) ISX (EPA 2007) 4-5 400-600 hp (298-447 kw) ISX15 and ISX Well Servicing Applications Model Pages ISX15 (EPA 2010) 2-3 400-600 hp (298-447 kw) ISX (EPA 2007) 4-5 400-600 hp (298-447 kw) Better Every Mile. ISX15 For EPA 2010. n Cooled Exhaust Gas

More information

OESAA Original Equipment Suppliers Aftermarket Association

OESAA Original Equipment Suppliers Aftermarket Association POWERED BY OESAA Original Equipment Suppliers Aftermarket Association OE Suppliers. Trust Our Quality. Protect Your Reputation. OESAA Original Equipment Suppliers Aftermarket Association GOOD reasons to

More information

HEAVY-DUTY, REDEFINED. REDEFINED.

HEAVY-DUTY, REDEFINED. REDEFINED. HEAVY-DUTY, REDEFINED. TO GET YOUR TOUGHEST JOBS DONE, you need an engine that works even harder than you do. That s why Caterpillar offers the CT13 engine for our vocational trucks. It delivers every

More information

Cat Electronic Technician 2015A v1.0 Product Status Report 4/20/2016 2:49 PM

Cat Electronic Technician 2015A v1.0 Product Status Report 4/20/2016 2:49 PM Page 1 of 19 Cat Electronic Technician 2015A v1.0 Product Status Report 2:49 PM Product Status Report Parameter Value Product ID WRK00337 Equipment ID WRK00337 Comments A01-52 C9 330D (THX37891) Parameter

More information

A.Pannirselvam*, M.Ramajayam, V.Gurumani, S.Arulselvan and G.Karthikeyan *(Department of Mechanical Engineering, Annamalai University)

A.Pannirselvam*, M.Ramajayam, V.Gurumani, S.Arulselvan and G.Karthikeyan *(Department of Mechanical Engineering, Annamalai University) A.Pannirselvam, M.Ramajayam, V.Gurumani, S.Arulselvan, G.Karthikeyan / International Journal of Vol. 2, Issue 2,Mar-Apr 212, pp.19-27 Experimental Studies on the Performance and Emission Characteristics

More information

Link 2 Vehicle Maintenance System

Link 2 Vehicle Maintenance System Link 2 Vehicle Maintenance System Link 2 Data Module - Monitors Critical Vehicle Information - Records CAN J1939 data bus for engine, transmission and ABS along with aerial, PTO and generator information

More information

Electronic Service Tools Newsletter. New and ReCon Parts March 2013

Electronic Service Tools Newsletter. New and ReCon Parts March 2013 Electronic Service Tools Newsletter New and ReCon Parts March 2013 1 Contents INSITE 8.0.0 Licensing Requirements Cummins Inc. Update Manager Issue INSITE Simulator Changes Tech Tips INSITE 7.6.1 Information

More information

Automatic Back-Flushing Filter AutoFilt RF9.

Automatic Back-Flushing Filter AutoFilt RF9. Automatic Back-Flushing Filter AutoFilt RF9. AutoFilt RF9 Clearing the Way. The Challenge: In response to the Tier III standard which will come into effect in 2016, the International Maritime Organization

More information

LOEMEATS 2. (Energieffektiv emissionsreduktion II,35558-1) Jan Eismark, Joop Somhorst Volvo ATR, Volvo Cars. Energi & Miljö

LOEMEATS 2. (Energieffektiv emissionsreduktion II,35558-1) Jan Eismark, Joop Somhorst Volvo ATR, Volvo Cars. Energi & Miljö 1 LOEMEATS 2 (Energieffektiv emissionsreduktion II,35558-1), Volvo ATR, 1 Intro Title Alias p35558-1. 855Energieffektiv emissionsreduktion II LOEMEATS II: LOw EMissions & Exhaust After Treatment System

More information

Hydrogen Powered Bus Fleets Hydrogen Supply & Fueling. National Fuel Cell Bus Workshop October 5, 2011 - New Orleans, LA

Hydrogen Powered Bus Fleets Hydrogen Supply & Fueling. National Fuel Cell Bus Workshop October 5, 2011 - New Orleans, LA Hydrogen Powered Bus Fleets Hydrogen Supply & Fueling National Fuel Cell Bus Workshop October 5, 2011 - New Orleans, LA Agenda! Air Liquide hydrogen fueling experience! Overview of hydrogen supply and

More information

ATTACHMENT B California Energy Commission Air Quality Self-Certification Checklist for Simple-Cycle Gas Turbine Generation Units

ATTACHMENT B California Energy Commission Air Quality Self-Certification Checklist for Simple-Cycle Gas Turbine Generation Units ATTACHMENT B California Energy Commission Air Quality Self-Certification Checklist for Simple-Cycle Gas Turbine Generation Units License Application for: [ X ] New Emissions Unit(s) at a New Stationary

More information

Emissions pollutant from diesel, biodiesel and natural gas refuse collection vehicles in urban areas

Emissions pollutant from diesel, biodiesel and natural gas refuse collection vehicles in urban areas Emissions pollutant from diesel, biodiesel and natural gas refuse collection vehicles in urban areas José Mª López, Nuria Flores, Felipe Jiménez, Francisco Aparicio Polytechnic University of Madrid (UPM),

More information

Note: This information obtained from internet sources and not verified- use at your own risk!!!!

Note: This information obtained from internet sources and not verified- use at your own risk!!!! Cummins Engine Diagnostic Fault Codes for 2003 and later engines (generally for 2004 and later Alpines; see page 13 for earlier engine diagnostic codes): Note: This information obtained from internet sources

More information

01-3 0000-00 6810-20 AIR CONDITIONING SYSTEM 1. FFH SPECIFICATION AIR CONDITIONING SYSTEM RODIUS 2004.09

01-3 0000-00 6810-20 AIR CONDITIONING SYSTEM 1. FFH SPECIFICATION AIR CONDITIONING SYSTEM RODIUS 2004.09 0000-00 01-3 6810-20 1. FFH SPECIFICATION 01-4 0000-00 2. SYSTEM LAYOUT AND COMPONENTS 0000-00 01-5 01-6 0000-00 3. FFH GENERAL INFORMATION The system is to increase the coolant temperature quickly by

More information

ETC -SV. Class 0 oil-free compressed air through catalysis

ETC -SV. Class 0 oil-free compressed air through catalysis Innovation QUALITy Reliability Worldwide ETC -SV Class 0 oil-free compressed air through catalysis The way to oil-free compressed air The ETC operating principle Through the process of catalytic oxidation,

More information

TECHNICAL NOTE - DIAGNOSTICS

TECHNICAL NOTE - DIAGNOSTICS TECHNICAL NOTE - DIAGNOSTICS Standard 23500 Date 02-2011 EN G0023/10 Document reserved exclusively for the RENAULT TRUCKS network. It must not be communicated to third parties without written authorization

More information

Diesel Generating Set

Diesel Generating Set MODEL Standby Power(50Hz) Prime Power(50Hz) 44KW /55KVA 40KW /50KVA Standard Features General Features: Engine( DCEC Cummins 4BTA3.9 -G) Radiator 40 O C max,fans are driven by belt, with safety guard 24V

More information

Tips for a Successful Diesel Retrofit Project

Tips for a Successful Diesel Retrofit Project Tips for a Successful Diesel Retrofit Project Tips for a Successful Diesel Retrofit Project Transportation and Climate Division Office of Transportation and Air Quality U.S. Environmental Protection Agency

More information

COMMON RAIL SYSTEM (CRS) SERVICE MANUAL: Operation

COMMON RAIL SYSTEM (CRS) SERVICE MANUAL: Operation ISUZU ELF 4HK1/4JJ1 Engine COMMON RAIL SYSTEM (CRS) SERVICE MANUAL: Operation Issued : June 2007 Revised : July 2009 00400601EA 2009 DENSO CORPORATION All rights reserved. This material may not be reproduced

More information

TECHNICAL SPECIFICATION. StirLIN-1 Economy Liquid Nitrogen System

TECHNICAL SPECIFICATION. StirLIN-1 Economy Liquid Nitrogen System TECHNICAL SPECIFICATION StirLIN-1 Economy Liquid Nitrogen System Reference 80 8120_01 Issue Date August 1, 2015 1. INTRODUCTION Since more than sixty years Stirling Cryogenics has designed and manufactured

More information

EFFECTS &BENEFITS LOW SULPHUR DIESEL

EFFECTS &BENEFITS LOW SULPHUR DIESEL EFFECTS &BENEFITS LOW SULPHUR DIESEL HEALTH BENEFITS Populations Some populations are more sensitive than others as follows: Children Elderly People with Heart and Lung Disease Diabetics High levels of

More information

Cleaner vehicle fleets in. Central and Eastern Europe

Cleaner vehicle fleets in. Central and Eastern Europe Cleaner vehicle fleets in Central and Eastern Europe Training for REC Country Offices Friday 19 September 2008 Regional Environmental Center for Central and Eastern Europe Szentendre, Hungary Agenda 19

More information

Engineered Solutions for Exhaust Emissions

Engineered Solutions for Exhaust Emissions Engineered Solutions for Exhaust Emissions GAS COMPRESSION POWER GENERATION CO-GENERATION FLUID PUMPING Engineered to Reduce Your Total Cost of Compliance At DCL, we apply the knowledge gained through

More information

IMO WORK PROGRAMME OF THE COMMITTEE AND SUBSIDIARY BODIES

IMO WORK PROGRAMME OF THE COMMITTEE AND SUBSIDIARY BODIES INTERNATIONAL MARITIME ORGANIZATION E IMO MARINE ENVIRONMENT PROTECTION COMMITTEE 51st session Agenda item 20 MEPC 51/INF.6 23 January 2004 ENGLISH ONLY WORK PROGRAMME OF THE COMMITTEE AND SUBSIDIARY BODIES

More information

The Use of Exhaust Gas Recirculation (EGR) Systems in Stationary Natural Gas Engines. The Engine Manufacturers Association August 2004

The Use of Exhaust Gas Recirculation (EGR) Systems in Stationary Natural Gas Engines. The Engine Manufacturers Association August 2004 www.enginemanufacturers.org Two North LaSalle Street Suite 2200 Chicago, Illinois 60602 Tel: 312/827-8700 Fax: 312/827-8737 The Use of Exhaust Gas Recirculation (EGR) Systems in Stationary Natural Gas

More information

REFINED ENGINE COMPONENTS

REFINED ENGINE COMPONENTS MBE 900 FIRE & EMERGENCY The Obvious Choice for commercial fire and emergency apparatus Since diesel engines were first installed in fire apparatus, Detroit Diesel has been the leader. Combining our long

More information

Vogt Power Emission Control Solutions

Vogt Power Emission Control Solutions ONE SOURCE ONE PURPOSE MANY SOLUTIONS Vogt Power Emission Control Solutions Kelly Flannery Kristen Cooper Andrew Heid Chief Thermal Engineer Simple Cycle Design Lead Emission Catalyst Design Lead Presented

More information

IMO. REVIEW OF MARPOL ANNEX VI AND THE NO x TECHNICAL CODE. Development of Standards for NO x, PM, and SO x. Submitted by the United States

IMO. REVIEW OF MARPOL ANNEX VI AND THE NO x TECHNICAL CODE. Development of Standards for NO x, PM, and SO x. Submitted by the United States INTERNATIONAL MARITIME ORGANIZATION E IMO SUB-COMMITTEE ON BULK LIQUIDS AND GASES 11th session Agenda item 5 BLG 11/5/15 9 February 2007 Original: ENGLISH REVIEW OF MARPOL ANNEX VI AND THE NO x TECHNICAL

More information

CVCOL - > / > (1) 07 1 07 ISB/ISC/ISL # 2006-38Q & 39Q

CVCOL - > / > (1) 07 1 07 ISB/ISC/ISL # 2006-38Q & 39Q Cummins Engine - Classroom Descriptions, Days and Costs. >All students registering for class MUST download the Smart Program Guide per program number listed. Please Note: All Technicians attending class

More information

Green Ship of the Future

Green Ship of the Future Green Ship of the Future Green Ship of the Future (GSF) is a partnership, a joint initiative in which companies across the Danish Maritime Cluster join forces to develop and test environmentally and climate

More information

With the introduction of slide fuel valves, engine conditions for service at low loads for long term operation have been significantly improved.

With the introduction of slide fuel valves, engine conditions for service at low loads for long term operation have been significantly improved. MAN Diesel MAN Diesel A/S Service Letter SL07-480/SBE June 2007 Low Load Operation for MC and ME engines Long Term Operation Mode Action Code: WHEN CONVENIENT In connection with requests from shipowners

More information

Clean Power for Today

Clean Power for Today Clean Power for Today How Emissions Standards Affect Our Products and Customers Table of Contents Section Page Regulations for Diesel Engines...1 Technologies...2 Kubota Solutions by Horsepower Class...3

More information

TransTech Energy. One of the largest LPG contractors in the country, based out of North Carolina

TransTech Energy. One of the largest LPG contractors in the country, based out of North Carolina TransTech Energy One of the largest LPG contractors in the country, based out of North Carolina Long-term relationship with AmeriGas, primary contractor for national 2011 internal valve program Design,

More information

Cummins Westport, Inc. Engine Overview. March 2015

Cummins Westport, Inc. Engine Overview. March 2015 Cummins Westport, Inc. Engine Overview March 2015 Cummins Westport Inc. (CWI) A Cummins JV Company CWI was established in 2001 as a 50/50 joint venture company between Cummins Inc and Westport Innovations.

More information

Mcllvaine Hot Topic Hour Air pollution control for gas turbines

Mcllvaine Hot Topic Hour Air pollution control for gas turbines Mcllvaine Hot Topic Hour Air pollution control for gas turbines Craig Sharp, Key Account manager Nathan White, Director Air Pollution Control Catalyst & Technology September 19, 2013 Topsøe - A global

More information

Better. Where It Counts. Cummins 2013 ISB6.7 For Truck Applications.

Better. Where It Counts. Cummins 2013 ISB6.7 For Truck Applications. Better. Where It Counts. Cummins 2013 ISB6.7 For Truck Applications. Better. Where It Counts. Every Job. Every aspect of the ISB6.7 has been improved, from fuel efficiency to reliability and durability.

More information

Testing of various fuel and additive options in a compression-ignited heavy-duty alcohol engine

Testing of various fuel and additive options in a compression-ignited heavy-duty alcohol engine Testing of various fuel and additive options in a compression-ignited heavy-duty alcohol engine 2015 Polttomoottori- ja turboteknologian seminaari Espoo, 7.5.2015 Timo Murtonen, Nils-Olof Nylund, Mårten

More information

VM 32. Efficiency and Performance New Product Development Modular Design 12 16 Cylinder

VM 32. Efficiency and Performance New Product Development Modular Design 12 16 Cylinder VM 32 E with Efficiency and Performance New Product Development Modular Design 12 16 Cylinder VM 32 E Power Output 6,720 8,960 kw The new VM 32 E engine is designed for our offshore customers seeking the

More information

www.vdo.com Road speed limitation for commercial vehicles

www.vdo.com Road speed limitation for commercial vehicles www.vdo.com Road speed limitation for commercial vehicles Mobility shapes our life moving ahead is our passion A passion for mobility drives us to achieve new goals, to push further and to move boundaries.

More information

www.optimumheat.co.uk

www.optimumheat.co.uk The modern wood pellet boiler with built-in flexibility and remote fingertip control Up to 98% efficient Wide output range Simple touch-panel control Remote control & maintenance Extremly low emissions

More information

POWER PLANT GAS CONVERSIONS WÄRTSILÄ SPARK IGNITED GAS ENGINE (SG) CONCEPT

POWER PLANT GAS CONVERSIONS WÄRTSILÄ SPARK IGNITED GAS ENGINE (SG) CONCEPT POWER PLANT GAS CONVERSIONS WÄRTSILÄ SPARK IGNITED GAS ENGINE (SG) CONCEPT WÄRTSILÄ DUAL FUEL GAS ENGINE (DF) CONCEPT CONVERSION CONCEPTS BASED ON EXISTING WÄRTSILÄ VASA 32/32LN, WÄRTSILÄ 32 AND WÄRTSILÄ

More information

Alternative drivmidler

Alternative drivmidler Alternative drivmidler Hvilke muligheder er der for lastvogne og busser? Præsenteret af Steffen Müller The Volvo Group Volvo Trucks Renault Trucks Mack Trucks UD Trucks Buses Construction Equipment Volvo

More information

Reducing Emissions from Diesel Vehicles An essential guide on how to switch to a clean and efficient diesel fleet

Reducing Emissions from Diesel Vehicles An essential guide on how to switch to a clean and efficient diesel fleet The Fleet Operator s Guide to call 0845 602 1425 or visit www.transportenergy.org.uk Reducing Emissions from Diesel Vehicles An essential guide on how to switch to a clean and efficient diesel fleet For

More information

MONITORING & MEASURING EQUIPMENT FOR EMISSIONS CONTROL, HAZARD DETECTION & ENERGY OPTIMIZATION

MONITORING & MEASURING EQUIPMENT FOR EMISSIONS CONTROL, HAZARD DETECTION & ENERGY OPTIMIZATION MONITORING & MEASURING EQUIPMENT FOR EMISSIONS CONTROL, HAZARD DETECTION & ENERGY OPTIMIZATION YOUR GLOBAL MONITORING & MEASURING EXPERT service and delivery Our head office and production facilities are

More information

HYBRID POWER SYSTEMS for TELECOM applications

HYBRID POWER SYSTEMS for TELECOM applications HYBRID POWER SYSTEMS HYBRID POWER SYSTEMS HYBRID POWER SYSTEM WITH AC GENSET PRAMAC has developed a new solution that allow coupling a traditional AC constant speed diesel genset with an energy storage

More information

Diagnostic Fault Codes For Cummins Engines

Diagnostic Fault Codes For Cummins Engines Section - Diagnostic Fault Codes For Cummins Engines Applies to Engine Models T, T, QSL T, QSM, QS, QSK9, QSK, QST, QSK//8 Note: These fault codes are current at date of publication. Always refer to engine

More information

The Ambient Air Monitoring System

The Ambient Air Monitoring System The Ambient Air Monitoring System 1.0 Introduction: The Ambient Air Monitoring System (AAMS) can measure a range of toxic and flammable gases, particulate matter, meteorological and environmental parameters

More information

Perfectly Adapted. ISL Euro 6 Gas Engine 250-320PS

Perfectly Adapted. ISL Euro 6 Gas Engine 250-320PS Perfectly Adapted ISL Euro 6 Gas Engine 250-320PS Cummins ISL-G The ISL G is the natural choice in alternative-fuel engine technology. With industry leading performance, it combines all the advantages

More information

Gas Fuelled ships. LNG-Fuelled Engines and Fuel Systems for Medium- Speed Engines in Maritime Applications. Dag Stenersen, MARINTEK

Gas Fuelled ships. LNG-Fuelled Engines and Fuel Systems for Medium- Speed Engines in Maritime Applications. Dag Stenersen, MARINTEK Gas Fuelled ships LNG-Fuelled Engines and Fuel Systems for Medium- Speed Engines in Maritime Applications Dag Stenersen, MARINTEK GTS Technical Seminar Series, 2011-09-28 MARINTEK 1 Presentation outline

More information

OBD Vehicle Integration OEM Variation Management 2009 SAE OBD Symposium. Jeff Potts Cummins Inc September 22, 2009

OBD Vehicle Integration OEM Variation Management 2009 SAE OBD Symposium. Jeff Potts Cummins Inc September 22, 2009 OBD Vehicle Integration OEM Variation Management 2009 SAE OBD Symposium Jeff Potts Cummins Inc September 22, 2009 Agenda Heavy Duty On Board Diagnostics (HD OBD) OBD Challenges for Engine Manufacturers

More information

Pr oduct Overview Product Overview SMC Pneumatics BV

Pr oduct Overview Product Overview SMC Pneumatics BV Product Overview Terms of Delivery General delivery and payment conditions Applicable to all offers and contract concerning deliveries and/or services to be executed by SMC Pneumatics BV are the ORGALIME

More information

Integrated electronics for enhanced performance, energy efficiency and reduced emissions

Integrated electronics for enhanced performance, energy efficiency and reduced emissions Integrated electronics for enhanced performance, energy efficiency and reduced emissions A SHARED DRIVE Hyperdrive Innovation develops powertrain systems for electric, hybrid and conventionally powered

More information