Initial: 72 and then every 12 months. I I I Every 24 months. I: Every 24 months R: Every 48 months

Transcription

1 MANTENANCE SCHEDULE - EUOPE 15,000 km/9,000 miles ncludes updates from MACH until JUNE '08 New information: and Lexus S Minor Change 08/08; Minor Change 08/11; Addition of LS460(L) 4WD (USF45,46); Prius, LC120, LC V8, Lexus GS, LS, SC running change; iq new ; Avensis Full Model Change Fill operation added; Fuel njection system maintenance added (Lexus S250, GS300 and LS460 for Croatia only) MANTENANCE OPEATONS GASOLNE ENGNE SEVCE NTEVALS: Odometer reading or months, whichever comes first : nspect and correct or replace as necessary. : eplace or change or lubricate. F: Fill ODOMETE EADNG 1K-FE (1.0 L3) 1,000 km Months KSP90 ZSP90 KSP90 SCP90 NSP90 ZZE150 ZE151 ZZE150 ZE151 2Z-FE (1.8) 1K-FE (1.0 L3) 2SZ-FE (1.3) 1N-FE (1.33) Auris 4ZZ-FE (1.4) 1Z-FE (1.6) TMUK TMMT Auris 4ZZ-FE (1.4) 6/23/2008 1Z-FE (1.6) MANTENANCE TEMS 1,000 miles ( ): for reference 05/08 08/08(MC) 06/ (MC) 06/01 08/11(MC) 06/01 08/11(MC) 06/10 06/10 07/02 07/02 Timing Belt eplace every 150,000 km (90,000 miles) Valve Clearance (Sensory nspection)*1 * (Every 72 months) Drive belt V-ribbed belt nspect 105,000 km (63,000 miles), after 105,000 km nspect every 15,000 km (9,000 miles) Engine oil (AP: SH, SJ) Every 12 months (LSAC) Severe Every 6 months Engine oil (AP: SJ, SL) Every 12 months (LSAC) Severe Every 6 months Engine oil (AP: SL, SM) Every 12 months (LSAC) Severe Every 6 months Every 12 months Engine oil filter Severe Every 6 months Cooling and heater system *2 Every 24 months Engine coolant LLC (red/green) *3 nitial: 36 months nitial: 72 and then every 12 months S-LLC (pink) *4 First replace at 150,000 km (90,000 miles); after, every km ( miles) nverter coolant S-LLC (pink) *4 First replace at 150,000 km (90,000 miles); after, every km ( miles) Exhaust pipes and mountings Spark plugs Platinum or ridium Tipped type Others eplace every 90,000 km (54,000 miles) Every 24 months : Every 24 months Battery No maintenance Fuel filter (Aygo only) eplace every km ( miles) 15 years Fuel injection system F F F F F F Air cleaner filter (from October 2002, applicable to all s in production) Dusty road Air cleaner filter Dusty road Fuel tank cap, fuel lines, connections and fuel vapor control valve nspect every 2,500 km(1,500 miles) and replace every 45,000 km(27,000 miles) or 48 months. : Every 24 months Every 24 months *5 Others Every 24 months Charcoal canister Aygo only Severe Every 24 months Charcoal canister filter Aygo only Severe Every 24 months *1: Check for tappet noise and engine vibration and adjust if necessary. *2: Check that the radiator and condenser are not blocked with leaves, dirt or insects; check radiator fins; check hoses and connections for correct installation, corrosion etc.; clean if necessary *3: After 60,000 km (36,000 miles) or 36 months, replace every 30,000 km (18,000 miles) or 24 months. *4: Only use "Toyota Super-Long Life Coolant" or similar high quality ethylene glycol based non-silicate, non-amine, non-nitrate and non-borate coolant with long-life hybrid organic acid technology (coolant with long-life hybrid organic acid technology is a combination of low phosphates and organic acids) *5: For Sweden, Norway and Finland only. *6: Use Toyota Genuine Fuel njector Cleaner ( ) or equivalent : Every 24 months : Every 12 months

2 MANTENANCE SCHEDULE - EUOPE 15,000 km/9,000 miles ncludes updates from MACH until JUNE '08 New information: Lexus S Minor Change 08/08; Minor Change 08/11; LC120 and LC V8 running change; iq new ; Avensis Full Model change Engine oil layout adjusted (information not changed) DESEL ENGNE SEVCE NTEVALS: Odometer reading or months, whichever comes first Timing Belt MANTENANCE TEMS MANTENANCE OPEATONS : nspect and correct or replace as necessary. : eplace or change or lubricate. S: Special C: Clean ODOMETE EADNG new informa new information corrections corrections 1ND-TV (1.4 D-4D) Auris 1ND-TV (1.4 D-4D) 1AD-FTV 2.0 D-4D DP/CCo TMUK TMMT Auris 1ND-TV (1.4 D-4D) 1AD-FTV (2.0 D-4D) DP/CCo 2AD-FHV (2.2 D-4D) 1,000 km Months NLP90 NDE150 ADE150 NDE150 ADE150 ADE157 1,000 miles ( ): for reference 06/01 08/11(MC) 06/10 06/10 07/02 07/02 07/02 *6 eplace every 105,000 km (60,000 miles) eplace every 150,000 km (90,000 miles) Timing pulley*6 Timing belt cover*6 C C C Valve Clearance * : Sensory nspection * * (Every 48 months) A: Adjust A A A A A A Every 12 months 6/23/2008 Drive belt belt Every 12 months V-ribbed belt nitial 72 months; then, every 12 months Engine oil (ACEA: B1; AP: CF-4 or CF)*1 Every 12 months * * *: Engines WTHOUT DPF Severe Every 6 months * * OMMS eplace when the reminder light illuminates or after max. 30,000km/24months * * Every 12 months ** ** Severe Every 6 months ** ** *: Engines WTH DPF OMMS eplace when the reminder light illuminates or after max. 30,000km/24months ** ** Engine oil (ACEA: C2 preferred or B1; AP: CF-4 or CF)*1 Engine oil filter Every 12 months Severe Every 6 months OMMS eplace when the reminder light illuminates or after max. 30,000km/24months Cooling and heater system *2 Every 24 months Engine coolant LLC (red/green) *3 nitial: 36 months S-LLC (pink) *4 First replace at 150,000 km (90,000 miles); after, every km ( miles) Exhaust pipes and mountings Battery Fuel injection pipes No maintenance Every 12 months Every 24 months eplace every 150,000 km (90,000 miles) Fuel filter Every 72 months n-tank filter and in-line filter Every 90 months Fuel pump eplace every 300,000 km (180,000 miles) Diesel smoke Every 48 months Air cleaner filter (from October 2002, applicable to all s in production) Air cleaner filter Dusty road Dusty road nspect at km ( miles). After, inspect every km (9.000 miles) Air flow meter (for EUO V vehicles)*5 S Every 48 months nspect every 2,500 km (1,500 miles) and replace every 45,000 km (27,000 miles) or 48 months. Every 48 months : Every 24 months : Every 12 months : Every 12 months Fuel tank cap, fuel lines, connections *1: You may also use AP CE or CD. NMSC's chonmsc's chonmsc's chonmsc's chonmsc's chonmsc's chonmsc's choice *2: Check that the ratiator and condenser are not blocked with leaves, dirt or insects; check radiator fins; check hoses and connections for correct installation, corrosion etc.; clean if necessary *: engines WTHOUT DPF *3: After 60,000 km (36,000 miles) or 36 months, replace every 30,000 km (18,000 miles) or 24 months. **: engines WTH DPF *4: Only use "Toyota Super-Long Life Coolant" or similar high quality ethylene glycol based non-silicate, non-amine, non-nitrate and non-borate coolant *: engines WTHOUT DPF with long-life hybrid organic acid technology (coolant with long-life hybrid organic acid technology is a combination of low phosphates and organic acids) **: engines WTH DPF *5: Blow air to the sensor interrmittently for about 30 seconds *6: For vehicles often operated in extremely dusty conditions, such as mining. nspect for cracks on the timing belt and abnormal wear on the timing pulley. emove dust and sand from the timing belt cover. Every 24 months

3 MANTENANCE SCHEDULE - EUOPE 15,000 km/9,000 miles ncludes updates from MACH until JUNE '08 New information: Manual transmission oil "AP Gear oil GL-5" added; and Lexus S Minor Change 08/08; Minor change 08/11; Addition of LS460(L) 4WD (USF45,46); Prius, LC120, LC V8, Lexus GS, LS and SC running change; iq new ; Avensis Full Model Change Aygo 1.0p Clutch mechanism: nspection interval shortened; Clutch fluid eplacement added for new MMT's; Toyota Genuine CVTF maintenance added for new CVT's Transfer oil "Toyota Genuine ATF WS" added for LS460(L) 4WD. MANTENANCE OPEATONS Correction: Lexus S Manual transmission oil changed to "AP Gear oil GL-5" only : nspect and correct or replace as necessary. T: Tighten to specified torque. CHASSS AND BODY 1/2 : eplace or change or lubricate. L: Lubricate SEVCE NTEVALS: Odometer reading or months, whichever comes first ODOMETE EADNG MANTENANCE TEMS Clutch pedal, return spring and damper - Mechanical type Brake pedal and parking brake Brake linings and drums (nclude brake linings of parking brake) Brake pads and discs Clutch fluid Brake fluid Months 1,000 km ,000 miles /08 KSP90 ZSP90 KSP90 SCP90 NLP90 08/08(MC ) 06/11 08/08(MC ) KSP90 NSP90 NLP90 06/01 08/11 Every 24 months Every 24 months Severe Every 12 months Every 12 months Severe Every 6 months Every 24 months Every 24 months * Every 24 months * ** Every 24 months Every 24 months Every 24 months Every 24 months Every 24 months Every 24 months Every 24 months ixetic (Luk-AT) or Pierburg eplace every km ( miles) or 120 months Others nspect every km ( miles) or 120 months Power steering fluid A/T fluid DEXON or Every 24 months TOYOTA P.S. fluid EH or equivalent Propeller shaft SAE J1703, J1704 or FMVSS No. 116 DOT3, DOT4 Clutch fluid for auto clutch system Sequential M/T system fluid SAE J1703, J1704 or FMVSS No. 116 DOT3, DOT4 Brake pipes and hoses Vacuum pump for brake booster (Diesel engines only) Steering wheel, linkage and steering gear box SS airbag *1 NLG No. 1 or No. 2 Every 24 months Every 24 months Severe Every 12 months nitial inspect at first 120 months from the vehicle registration date. L L L L L L Every 24 months Severe L L L L L L L L L L L L Every 12 months Propeller shaft bolts Drive shaft boots Drive shaft bolts Suspension ball joints and dust covers T T T Every 24 months Severe T T T T T T Every 12 months Every 24 months Severe Every 12 months Every 12 months Severe Every 6 months T T T Every 24 months Severe T T T T T T Every 12 months T T T T T T Every 12 months Severe T T T T T T T T T T T T Every 6 months Every 24 months Severe Every 12 months Every 12 months Severe Every 6 months Shift lever of 6-speed manual transmission -- : Every 12 months Vehicles produced before July, '99 Severe : Every 12 months : Every 24 months Every 36 months Toyota Genuine ATF type Every 48 months T-V : Every 36 months Severe : Every 72 months Automatic transmission fluid Manual transmission oil and transfer oil if so equipped (ncluding auto clutch system) Vehicles produced after August, '99 Toyota Genuine ATF WS Toyota Genuine CVTF TC Other AP Gear oil GL-5 AP Gear oil GL-4 or GL-5 LV Gear oil AP GL-4 Every 36 months Every 48 months : Every 36 months Severe : Every 72 months Every 48 months Severe Severe : Every 36 months : Every 72 months : Every 36 months : Every 72 months : Every 18 months : Every 36 months Every 48 months Severe Every 48 months Every 48 months Severe Every 48 months Every 48 months Severe Every 48 months Every 48 months Other (GL-4 or GL-5) Severe Every 48 months Every 48 months AP Gear oil GL-4 or GL-5 Severe Every 48 months AP Gear oil GL-5 Every 48 months Every 48 months AP Gear oil GL-5 Severe Every 48 months Transfer oil Every 48 months Toyota Genuine Oil LX85 (AP: GL-5) Severe Every 48 months Every 48 months Toyota Genuine ATF WS : Every 36 months Severe : Every 72 months *1: After 120 months from the vehicle registration date, inspect every 24 months. *: ZSP90 with EC6# M/T *: KSP90 and NLP90 **: NSP90 with EC6# M/T

4 MANTENANCE SCHEDULE - EUOPE 15,000 km/9,000 miles ncludes updates from MACH until JUNE '08 New information: and Lexus S Minor Change 08/08; Minor change 08/11; Addition of LS460(L) 4WD (USF45,46); Prius, LC120, LC V8, Lexus GS, LS and SC running change; iq new ; Avensis Full Model Change Toyota Genuine CVTF maintenance added for new CVT's MANTENANCE OPEATONS : nspect and correct or replace as necessary. T: Tighten to specified torque. CHASSS AND BODY 2/2 : eplace or change or lubricate. C: Clean SEVCE NTEVALS: ODOMETE EADNG Odometer reading or months, whichever comes firs KSP90 ZSP90 KSP90 KSP90 SCP90 NSP90 Months NLP90 NLP90 1,000 km MANTENANCE TEMS 1,000 miles /08 08/08(MC) 06/11 08/08(MC) 06/01 08/11 6/23/2008 M/T AP Gear oil GL-4 or GL-5 LV Gear oil AP GL-4 Every 48 months Severe Every 48 months Every 48 months Severe Every 48 months Front oil integrated with transmission A/T Toyota Genuine ATF type T-V Toyota Genuine ATF WS Toyota Genuine CVTF TC Every 36 months Every 48 months Severe : Every 36 months : Every 72 months Every 36 months Every 48 months Severe : Every 36 months : Every 72 months Every 48 months Severe : Every 36 months : Every 72 months ear differential oil separated from transmission (AP Gear oil GL-5) Every 48 months AP Gear oil GL-5 Every 48 months Every 36 months A/T fluid WS Wheel bearing grease (tapered roller type wheel bearing only) and ball joint grease NLG No. 2 Severe : Every 36 months : Every 72 months Every 24 months Severe Every 12 months Front and rear suspension Every 24 months Severe Every 12 months Active height control suspension fluid - Suspension fluid AHC or equivalent Active height control gas chamber Bolts and nuts on chassis and body Tires and inflation pressure : initial 48 months; then every 12 months Severe only T T T T T T Every 12 months Every 24 months Severe Every 12 months Air conditioning filter Particle filter Combination filter Foldable type Pollen removal type Standard type & high efficiency type Every 24 months Dusty road Every 12 months Every 24 months Dusty road Every 12 months & Dusty road Every 24 months "Clean" replaced by "nspect" efer to TME letter of October 2007 on "Potential Health isk From Cleaning of Cabin Air Filter Elements Dusty road Combination filter (high efficiency type) Dusty road eplace when the service indicator light illuminates Corrosion nspection Every 24 months

5 6/23/2008 MANTENANCE SCHEDULE - GENEAL 10,000 km ncludes updates from MACH until JUNE '08 New information: and Lexus S Minor Change 08/08; Addition of, LS460(L) 4WD (USF45,46); LC120, LC V8, Lexus GS, LS and SC running change; Avensis Full Model Change Fuel njection Cleaner added on Avensis 1AZ and 2AZ GASOLNE ENGNE SEVCE NTEVALS: Odometer reading or months, whichever comes first Timing Belt MANTENANCE TEMS MANTENANCE OPEATONS : nspect and correct or replace as necessary : eplace or change or lubricate. F: Fill new information corrections 2SZ-FE (1.3) 1,000 km Months SCP90 ( ): for reference Valve Clearance Sensory nspection *1 Every 96 months Drive belts Every 24 months Engine oil (AP: SJ, SL) Every 12 months (LSAC) Severe Every 6 months Engine oil (AP: SL, SM) Every 12 months Engine oil filter (LSAC) Severe Every 6 months 06/01 08/08(MC) Every 12 months Severe Every 6 months Cooling and heater system *2 First inspect at 40,000km/24months and 80,000km/48months; after, every 20,000km/12months Engine coolant S-LLC (pink) *4 Every 24 months First replace at 160,000 km; after, every km nverter coolant S-LLC (pink) *4 Every 24 months First replace at 160,000 km; after, every km Exhaust pipes and mountings Every 12 months Spark plugs Platinum or ridium Tipped type eplace every 100,000 km Others Every 48 months Battery Every 12 months Every 96 months Fuel filter (including the filter in the fuel tank) Aygo only Every 48 months Fuel injection system *5 F F F F F F F F -- When the "njector Maintenance equired" message is displayed on the multi-information display Air cleaner filter (including checking pre-air cleaner if equipped) Paper type eplace every 150,000 km ODOMETE EADNG : Every 24 months Dusty road nspect every 2,500km/3months and replace every 40,000km/48months. : Every 24 months : Every 24 months Dusty road TNF (Thin Nonwoven Fabrics) type Dusty road nspect every 5,000km/6months and replace every 100,000km/120months. nspect every 10,000km/12months and replace every 100,000km/120months. Fuel tank cap, fuel lines, connections and fuel vapor control valve First inspect at 40,000km/24months and 80,000km/48months; after, every 20,000km/12months Every 24 months Charcoal canister : Every 24 months Aygo only : Every 24 months Charcoal canister filter Aygo only *1: Check for tappet noise and engine vibration and adjust if necessary. *2: Check that the radiator and condenser are not blocked with leaves, dirt or insects; check radiator fins; check hoses and connections for correct installation, corrosion etc.; clean if necessary *4: Only use "Toyota Super-Long Life Coolant" or similar high quality ethylene glycol based non-silicate, non-amine, non-nitrate and non-borate coolant with long-life hybrid organic acid technology (coolant with long-life hybrid organic acid technology is a combination of low phosphates and organic acids) *5: Toyota genuine fuel injector cleaner (P/N ) or equivalent

6 MANTENANCE SCHEDULE - GENEAL 10,000 km ncludes updates from MACH until JUNE '08 New information: Manual transmission oil "AP Gear oil GL-5" added; and Lexus S Minor Change 08/08; Addition of LS460(L) 4WD (USF45,46); LC120, LC V8, Lexus GS, LS and SC running change; Avensis new. Transfer oil "Toyota Genuine ATF WS" added for LS460(L) 4WD. MANTENANCE OPEMANTENANCE OPEATONS A/T fluid: "Toyota Genuine CVTF TC" added for New Avensis : nspect and correct : nspect and correct or replace as necessary. T: Tighten to specified torque. new information CHASSS AND BODY 1/2 : eplace or change: eplace or change or lubricate. L: Lubricate corrections SEVCE NTEVALS: ODOMETE EADNG Odometer reading or months, whichever comes first Months 1,000 km MANTENANCE TEMS Clutch pedal No maintenance Clutch pedal return spring and damper Aygo only Brake pedal and parking brake Brake linings and drums (nclude brake linings of parking brake) Brake pads and discs SCP90 06/01 08/08(MC) Every 6 months Every 12 months Severe Every 6 months Every 6 months Severe Every 3 months : Every 6 months : Every 24 months Brake fluid SAE J1703, J1704 or FMVSS No. 116 DOT3, DOT4 : Every 6 months : Every 24 months : Every 6 months : Every 24 months Every 6 months Every 6 months Clutch SAE J1703, J1704 or FMVSS No. 116 DOT3, DOT4 fluid : Every 6 months : Every 24 months Every 6 months Brake pipes and hoses Every 12 months Severe Every 6 months Vacuum pump for brake booster (Diesel Luk-AT or Pierburg eplace every km ( miles) or 120 months engines only) Others nspect every km Power steering fluid A/T fluid DEXON or Every 6 months Every 12 months Steering wheel, linkage and steering gear box Every 6 months Severe Every 3 months Front wheel alignment (side slip) Every 48 months SS airbag *1 nitial inspect at first 120 months from the vehicle registration date. Steering knuckle, drag link, kingpin, center arm and steering linkage grease NLG No. 2 Every 3 months Propeller shaft NLG No. 2 L L L L L L L L Every 6 months Severe L L L L L L L L L L L L L L L L Every 6 months T T T T Every 12 months Tightening bolts for propeller shaft Severe T T T T T T T T Every 6 months T T T T T T T T Every 6 months Drive shaft boots Tightening bolts for drive shaft Suspension ball joints and dust covers Severe T T T T T T T T T T T T T T T T Every 3 months Every 24 months Severe Every 12 months T T T T Every 24 months Severe T T T T T T T T Every 12 months T T T T T T T T Every 6 months Severe T T T T T T T T T T T T T T T T Every 3 months Every 12 months Severe Every 6 months Every 6 months Shift lever for 6-speed manual transmission -- Every 24 months WS : Every 24 months Severe Every 24 months T-V : Every 24 months Severe Automatic transmission fluid Every 24 months Toyota Genuine CVTF TC : Every 24 months Manual transmission oil Transfer oil A/T fluid D- or DEXON Severe LV Gear oil AP GL-4 AP Gear oil GL-4 or GL-5 : Every 24 months : Every 12 months : Every 24 months Every 48 months Severe Every 48 months Every 48 months Severe Every 48 months Every 48 months AP Gear oil GL-5 Severe Every 48 months Every 48 months Gear oil AP GL-4 or GL-5 Severe Every 48 months : Every 12 months Gear oil AP GL-5 Every 48 months Severe Every 48 months : Every 12 months Gear oil AP GL-5 Severe : Every 24 months : Every 12 months Toyota Genuine Oil LX85 (AP GL-5) Severe : Every 24 months Toyota Genuine ATF WS : Every 24 months Severe : Every 24 months *1: After 120 months from the vehicle registration date, inspect every 24 months.

7 MANTENANCE SCHEDULE - GENEAL 10,000 km ncludes updates from MACH until JUNE '08 New information: and Lexus S Minor Change 08/08; Addition of LS460(L) 4WD (USF45,46); LC120, LC V8, Lexus GS, LS and SC running change; Avensis new Fr diff. oil: "Toyota Genuine CVTF TC" added for New Avensis MANTENANCE OPEATONS : nspect and correct or replace as necessary. T: Tighten to specified t T: Tighten to specified torque. new information CHASSS AND BODY 2/2 : eplace or change or lubricate. corrections SEVCE NTEVALS: ODOMETE EADNG Odometer reading or months, whichever comes first Front oil integrated with transmission ear differential oil 1,000 km Months Every 48 months SCP90 06/01 08/08(MC) Severe Every 48 months Every 48 months Every 48 months Every 24 months Severe : Every 24 months Every 24 months Severe : Every 24 months Every 24 months Severe : Every 24 months : Every 12 months Severe : Every 24 months : Every 12 months : Every 12 months Severe Every 24 months : Every 12 months A/T fluid WS Every 24 months Severe : Every 24 months NLG No. 2 Every 12 months Every 12 months Severe Every 6 months Every 6 months Severe Every 3 months Active height control suspension fluid - Suspension fluid AHC or equivalent eplace every km Active height control gas chamber : initial 48 months; then every 12 months Bolts and nuts on chassis and body Severe only T T T T T T T T Every 6 months Tires and inflation pressure Every 6 months Lights, horn, wipers and washers Every 6 months Particle filter MANTENANCE TEMS M/T A/T AP Gear oil GL-4 or GL-5 separated from transmission (AP Gear oil GL-5) Standard type LV Gear oil AP GL-4 WS T-V Toyota Genuine CVTF TC AP Gear oil GL-5 Wheel bearing grease (tapered roller type wheel bearing only) Front and rear suspension Pollen removal type Semi-standard type High efficiency type C C C C C C Severe C C C C C C C C C C C Severe & Severe Severe Combination filter High efficiency type & Severe eplace when the service indicator light illuminates Air conditioner refrigerant amount Every 12 months 6/23/2008 *3: Customers should inspect by themselves

8 6/23/2008 MANTENANCE SCHEDULE - GENEAL 10,000 km ncludes updates from MACH until JUNE '08 New information: and Lexus S Minor Change 08/08; Addition of, LS460(L) 4WD (USF45,46); LC120, LC V8, Lexus GS, LS and SC running change; Avensis Full Model Change Fuel njection Cleaner added on Avensis 1AZ and 2AZ GASOLNE ENGNE SEVCE NTEVALS: Odometer reading or months, whichever comes first MANTENANCE TEMS MANTENANCE OPEATONS : nspect and correct or replace as necessary : eplace or change or lubricate. F: Fill 1N-FE (1.33) 1,000 km Months NSP90 ( ): for reference 08/11(MC) Timing Belt eplace every 150,000 km Valve Clearance Sensory nspection *1 Every 96 months Drive belts Every 24 months Engine oil (AP: SJ, SL) Every 12 months (LSAC) Severe Every 6 months Engine oil (AP: SL, SM) Every 12 months (LSAC) Severe Every 6 months Every 12 months Engine oil filter Severe Every 6 months Cooling and heater system *2 First inspect at 40,000km/24months and 80,000km/48months; after, every 20,000km/12months Engine coolant S-LLC (pink) *4 Every 24 months First replace at 160,000 km; after, every km nverter coolant S-LLC (pink) *4 Every 24 months First replace at 160,000 km; after, every km Exhaust pipes and mountings Every 12 months Spark plugs Platinum or ridium Tipped type eplace every 100,000 km Others Every 48 months Battery Every 12 months Every 96 months Fuel filter (including the filter in the fuel tank) Aygo only Every 48 months Fuel injection system *5 F F F F F F F F -- When the "njector Maintenance equired" message is displayed on the multi-information display Air cleaner filter (including checking pre-air cleaner if equipped) Paper type ODOMETE EADNG : Every 24 months Dusty road nspect every 2,500km/3months and replace every 40,000km/48months. : Every 24 months Dusty road TNF (Thin Nonwoven Fabrics) type Dusty road nspect every 5,000km/6months and replace every 100,000km/120months. nspect every 10,000km/12months and replace every 100,000km/120months. Fuel tank cap, fuel lines, connections and fuel vapor control valve First inspect at 40,000km/24months and 80,000km/48months; after, every 20,000km/12months Every 24 months Charcoal canister : Every 24 months Aygo only : Every 24 months Charcoal canister filter Aygo only *1: Check for tappet noise and engine vibration and adjust if necessary. *2: Check that the radiator and condenser are not blocked with leaves, dirt or insects; check radiator fins; check hoses and connections for correct installation, corrosion etc.; clean if necessary *4: Only use "Toyota Super-Long Life Coolant" or similar high quality ethylene glycol based non-silicate, non-amine, non-nitrate and non-borate coolant with long-life hybrid organic acid technology (coolant with long-life hybrid organic acid technology is a combination of low phosphates and organic acids) *5: Toyota genuine fuel injector cleaner (P/N ) or equivalent : Every 24 months

9 MANTENANCE SCHEDULE - GENEAL 10,000 km ncludes updates from MACH until JUNE '08 New information: Manual transmission oil "AP Gear oil GL-5" added; and Lexus S Minor Change 08/08; Addition of LS460(L) 4WD (USF45,46); LC120, LC V8, Lexus GS, LS and SC running change; Avensis new. Transfer oil "Toyota Genuine ATF WS" added for LS460(L) 4WD. MANTENANCE OPEMANTENANCE OPEATONS A/T fluid: "Toyota Genuine CVTF TC" added for New Avensis : nspect and correct : nspect and correct or replace as necessary. T: Tighten to specified torque. CHASSS AND BODY 1/2 : eplace or change: eplace or change or lubricate. L: Lubricate SEVCE NTEVALS: Odometer reading or months, whichever comes first ODOMETE EADNG Months 1,000 km MANTENANCE TEMS Clutch pedal No maintenance Clutch pedal return spring and damper Aygo only Brake pedal and parking brake Brake linings and drums (nclude brake linings of parking brake) Brake pads and discs NSP90 08/11(MC) Every 6 months Every 12 months Severe Every 6 months Every 6 months Severe Every 3 months : Every 6 months : Every 24 months Brake fluid SAE J1703, J1704 or FMVSS No. 116 DOT3, DOT4 : Every 6 months : Every 24 months : Every 6 months : Every 24 months Every 6 months Every 6 months Clutch SAE J1703, J1704 or FMVSS No. 116 DOT3, DOT4 fluid : Every 6 months : Every 24 months Every 6 months Brake pipes and hoses Every 12 months Severe Every 6 months Vacuum pump for brake booster (Diesel Luk-AT or Pierburg eplace every km ( miles) or 120 months engines only) Others nspect every km Power steering fluid A/T fluid DEXON or Every 6 months Every 12 months Steering wheel, linkage and steering gear box Every 6 months Severe Every 3 months Front wheel alignment (side slip) Every 48 months SS airbag *1 nitial inspect at first 120 months from the vehicle registration date. Steering knuckle, drag link, kingpin, center arm and steering linkage grease NLG No. 2 Every 3 months Propeller shaft NLG No. 2 L L L L L L L L Every 6 months Severe L L L L L L L L L L L L L L L L Every 6 months T T T T Every 12 months Tightening bolts for propeller shaft Severe T T T T T T T T Every 6 months T T T T T T T T Every 6 months Drive shaft boots Tightening bolts for drive shaft Suspension ball joints and dust covers Severe T T T T T T T T T T T T T T T T Every 3 months Every 24 months Severe Every 12 months T T T T Every 24 months Severe T T T T T T T T Every 12 months T T T T T T T T Every 6 months Severe T T T T T T T T T T T T T T T T Every 3 months Every 12 months Severe Every 6 months Every 6 months Shift lever for 6-speed manual transmission -- Every 24 months WS : Every 24 months Severe Every 24 months T-V : Every 24 months Severe Automatic transmission fluid Every 24 months Toyota Genuine CVTF TC : Every 24 months A/T fluid D- or DEXON Severe LV Gear oil AP GL-4 : Every 24 months : Every 12 months : Every 24 months Every 48 months Severe Every 48 months Every 48 months Manual transmission oil AP Gear oil GL-4 or GL-5 Severe Every 48 months AP Gear oil GL-5 Every 48 months Severe Every 48 months Every 48 months Gear oil AP GL-4 or GL-5 Severe Every 48 months : Every 12 months Gear oil AP GL-5 Every 48 months Severe Every 48 months Transfer oil : Every 12 months Gear oil AP GL-5 Severe : Every 24 months : Every 12 months Toyota Genuine Oil LX85 (AP GL-5) Severe : Every 24 months Toyota Genuine ATF WS : Every 24 months Severe : Every 24 months *1: After 120 months from the vehicle registration date, inspect every 24 months.

10 MANTENANCE SCHEDULE - GENEAL 10,000 km ncludes updates from MACH until JUNE '08 New information: and Lexus S Minor Change 08/08; Addition of LS460(L) 4WD (USF45,46); LC120, LC V8, Lexus GS, LS and SC running change; Avensis new Fr diff. oil: "Toyota Genuine CVTF TC" added for New Avensis CHASSS AND BODY 2/2 SEVCE NTEVALS: Odometer reading or months, whichever comes first Front oil integrated with transmission ear differential oil 1,000 km MANTENANCE OPEATONS : nspect and correct or replace as necessary. T: Tighten to specified t T: Tighten to specified torque. : eplace or change or lubricate Months 08/11(MC) Every 48 months Severe Every 48 months Every 48 months Severe : Every 24 months NLG No. 2 Every 12 months Every 12 months Severe Every 6 months Every 6 months Severe Every 3 months Active height control suspension fluid - Suspension fluid AHC or equivalent eplace every km Active height control gas chamber : initial 48 months; then every 12 months Bolts and nuts on chassis and body Severe only T T T T T T T T Every 6 months Tires and inflation pressure Every 6 months Lights, horn, wipers and washers Every 6 months Particle filter MANTENANCE TEMS M/T A/T AP Gear oil GL-4 or GL-5 Every 48 months Every 24 months WS : Every 24 months Severe Every 24 months T-V : Every 24 months Severe Toyota Genuine CVTF Every 24 months TC Severe : Every 24 months : Every 12 months Severe : Every 24 months : Every 12 months : Every 12 months AP Gear oil GL-5 Severe Every 24 months : Every 12 months A/T fluid WS Every 24 months separated from transmission (AP Gear oil GL-5) Standard type LV Gear oil AP GL-4 Wheel bearing grease (tapered roller type wheel bearing only) Front and rear suspension Pollen removal type Semi-standard type High efficiency type C C C C C C Severe C C C C C C C C C C C Severe & Severe ODOMETE EADNG Severe Combination filter High efficiency type & Severe eplace when the service indicator light illuminates Air conditioner refrigerant amount Every 12 months NSP90 6/23/2008 *3: Customers should inspect by themselves