ADVANCED TREATMENT OF RAINWATER USING METAL MEMBRANE COMBINED WITH OZONATION

Size: px
Start display at page:

Download "ADVANCED TREATMENT OF RAINWATER USING METAL MEMBRANE COMBINED WITH OZONATION"

Transcription

1 ADVANCED TREATMENT OF RAINWATER USING METAL MEMBRANE COMBINED WITH OZONATION Ree Ho Kim 1*, Sangho Lee 1, Seog-Ku Kim 1, and Jong-Oh Kim 2 1 Korea Institute of Construction Technology, 2311 Deahwa-Dong, Ilsan-Gu, Goyang-Si, Gyeonggi-Do, , South Korea 2 Department of Civil Engineering, Kangnung National University, 12 Gangneung Deahangno, Gangneung-Si, Gangwon-Do, 21-72, South Korea Abstract This paper outlines a metal membrane system for removing contaminants from rainwater. The system consists of submerged metal membranes in a tank and an aerator or an ozone generator. Contaminated rainwater is introduced into the tank after an initial screening of solids and permeate is removed after passing through the membrane. Ozone bubbling as well as aeration in the feed side were applied to reduce membrane fouling, destruct organic pollutants, and inactivate microorganisms. The metal membrane appears to be suitable to be used with ozonation because of its excellent chemical stability. Experiments were performed to compare filtration characteristics of rainwater in storage tank, roof runoff, and roof garden runoff and to investigate the effect of ozone injection on the increase in transmembrane pressure and membrane fouling. * Corresponding author: Tel) ; Fax) ; ) rhkim@kict.re.kr

2 Introduction Growing interests in society for saving water resources have led to different attempts to use or recycle rainwater [1-4]. However, rainwater in the urban area contains substantial amounts of contaminants including dust, particles, halogenated organics [5], heavy metal [6], ions [7, 8], pathogenic microorganisms [9], and endocrine disruptors [5] that cause problems in direct use or discharge. Therefore, a method to effectively remove contaminants from rainwater is critical for rainwater harvesting in urban area. A novel technology that has potential to clarify rainwater is metal membrane filtration [1]. Metal membrane technology hold great promise for rainwater treatment because it has unique advantages over polymeric microfilters [11]: Metal membrane is durable to high pressure up to 1 MPa, high temperature up to 35 o C, outer shock power, and chemical oxidation such as ozonation. Unlike polymeric microfilters, lifetime for metal membrane is long enough to minimize the maintenance cost. Metal membrane can be stored in dry forms, which makes it more attractive than polymeric membranes because rainwater filtration may operate intermittently. This work focuses on the development of a novel treatment system for contaminated rainwater from buildings using metal membranes. A submerged type of metal membrane system was investigated to remove contaminants effectively while maintaining high flux and low transmembrane pressure. In situ injection of ozone was also attempted to minimize membrane fouling and to improve filterability of rainwater [1]. Experiments Rainwater collected from different locations was used in this study as illustrated in Figure 1. These include supernatant from a storage tank; runoff from a roof of the building; and runoff from a roof garden. Table 1 compares the compositions of three rainwaters from a building. The supernatant from storage tank has the best water quality, while the runoff from roof garden contains substantial amounts of particulates (turbidity), ions (conductivity), nutrients (nitrogen and phosphate), and heavy metals. A schematic diagram of the submerged metal membrane system used in this study is shown in Figure 2. The cylindrical reactor had a working volume of 5 L and the feed solution was mixed by aeration at the bottom. A metal membrane module made of stainless steel was

3 immersed and suspended vertically in the reactor. Metal membrane with 1 m and 5 m were compared and the characteristics of membranes are summarized in Table 2. Permeate from the membrane module was pulled by a peristaltic pump. The flux was monitored by collecting permeate on a graduated cylinder. The transmembrane pressure was continuously measured using a pressure gauge. Total recycle mode, where both the retentate from the membrane filtration loop and permeate were recycled into the tank, was adopted to keep the reactor volume constant during the operation time. Ozone was generated using a laboratory ozone generator (Trigen Ozonia). Spectrophotometric methods of Hach [12] using DR-4 spectrophotometer were adapted to measure the ionic concentrations and turbidity. Conductivity, ph, were also measured and automatically corrected for temperature influence. Results and Discussions To determine the optimum operating conditions for membrane filtration of rainwater, transmembrane pressure across the membrane was monitored with a stepwise increase of permeate flux. Fig.8 shows the transmembrane pressure versus time behavior during the filtration of the tank supernatant using the 5 m and 1 m membranes, respectively. In both cases, the transmembrane pressures changed similarly from 5 L/m 2 -hr to 3 L/m 2 -hr. Figure 4 compares the filtration characteristics of three rainwaters using metal membranes. Transmembrane pressure did not increase for supernatant filtration for both membranes. However, a rapid increase in transmembrane pressure with filtration time was observed when filtering runoff rainwaters using the 1 m membrane while no increase in transmembrane pressure was shown for the 5 m membrane. This is because most of the foulants that block the 1 m membrane are small enough to pass through the 5 m membrane. During the filtration of runoff waters, the permeate from 5 m membrane has same water quality as the input water. This suggests that the 5 m membrane is not suitable for clarifying the runoff rainwater. The transmembrane pressure with ozone bubbling was compared with that with aeration (without ozone) in Figure 5. The increasing rate of transmembrane pressure with ozone bubbling was much smaller than that without ozone bubbling. This is probably because ozone

4 in water destruct organic matters and destabilize colloids. These effects have occasionally been referred to as microflocculation/ozone-induced particle destabilization/ coagulation effects of ozone in water treatment. Several proposed hypotheses (metal humates complex, particle aggregation via bridging reaction, disrupted stabilizing organic coatings on particles, in-site production of coagulant, etc.) were well summarized by ref [13]. Similar reduction in ultrafiltration membrane fouling with pre-ozonation due to ozone-induced particle destabilization was reported by other researchers [14]. Conclusion A metal membrane system combined with aeration or ozone injection was investigated as a novel method to remove contaminants from rainwater. The following conclusions can be drawn: (1) Metal membranes appear to be efficient to treat rainwater from storage tank. (2) The membrane with the pore size of 5 m appears to be ineffective to clarify the runoffs from roof and roof garden because of its large pore size. (3) Ozone injection significantly reduces the increase in transmembrane pressure due to membrane fouling. References 1. Kim, R.H. Rainwater utilization for urban establishment of new paradigm,, F in A Joint Conference with Korea Society of Water and Wastewater and Korea Society on Water Quality Kim, R.H., Utilization of ground water and rainwater in urban area. Geoenvironment, 21: p Kim, R.H., Development trend of rainwater utilization. Construction Technology Review. 211: p Kim, R.H., Rainwater utilization and functional changes in building roof. Construction Technology Review. 22: p Dorfler, U. and I. Scheunert, S-Triazine herbicides in rainwater with special reference

5 to the situation in germany. Chemosphere, (1/2): p Reimann, C., et al., Rainwater composition in eight arctic catchment in northern europe (Finland, Norway, and Russia). Atmospheric Environment, (2): p Sanusi, A., et al., Chemical composition of rainwater in eastern France. Atmospheric Environment, (1): p Sequeira, R. and C.C. Lai, Small-scale spatial variability in the representative ionic composition of rainwater within urban Hong Kong. Atmospheric Environment, (2): p Albrechtsen, H.-J., Microbiological investigations of rainwater and graywater collected for toilet flushing. Water Science and Technology, (6-7): p Kim, R.-H., et al., Advanced treatment apparatus and method for rainwater using metal membrane combined with ozonation, in : Korea. 11. KIM, J.-O. and I. SOMIYA, Innovative Fouling Control by Intermittent Back-ozonation in Metal Membrane Micro Filtration System Hach, Hach Water Analysis Handbook. 2nd ed. 1992, Colorado, USA: Hach Company. 13. Rekhow, D.A., P.C. Singer, and R.R. Trusell. Ozone as a Coagulant Aid. in Annual AWWA Conference Proceedings Denver, Colorado: AWWA. 14. Hyung, H., et al., Effect of Preozonation on Flux and Water Quality in Ozonation- Ultrafiltration Hybrid System for Water Treatment. Ozone Science and Technology, 2. 22: p

6 Table 1. Composition of Rainwaters in Different Sources Supernatant Runoff from from Storage Roof Tank Runoff from Roof Garden Turbidity (FAU) ph Conductivity (S/cm) Total phosphate (mg/l) Total Nitrogen (mg/l) Iron (mg/l) Copper (mg/l) Zinc (mg/l) Table 2. Parameters for the Submerged Metal Membrane Systems Parameter Outer Radius (r o ) Nominal Pore Radius (r i ) Filter Area Length (L) Value.7 m 1 m, 5 m.222 m Membrane Area (A m ) m 2 Membrane Resistance (R m ) m -1

7 Building Green Roof Runoff from Green Roof Roof Runoff Utilization Rainwater storage tank Figure 1. Three types of rainwater from buildings: Roof runoff, runoff from green roof, and rainwater in storage tank. Pressure Gauge Peristaltic Pump Graduated Cylinder Metal Membrane Feed Tank Air or Ozone Air Blower or Ozone Generator Figure 2. Schematics of metal membrane filtration system.

8 .2 : Transmembrane Pressure (atm) Flux Pressure Flux (L/m2-hr) Filtration time (min) (a) 5 m Membrane.2 : Transmembrane Pressure (atm) Flux Pressure Flux (L/m2-hr) Filtration time (min) (b) 1 m Membrane Figure 3. Dependence of transmembrane pressure on permeate flux for metal membranes. Conditions: aeration rate = 5 ml/min

9 Transmembrane Pressure (atm) :2 Roof garden runoff Roof runoff Supernatant in storage tank Filtration time (min) (a) 5 m Membrane.2 :2 Transmembrane Pressure (atm) Roof garden Runoff Roof runoff Supernatant in storage tank Filtration time (min) (b) 1 m Membrane Figure 4. Effect of input water characteristics on transmembrane pressure for metal membranes. Conditions: flux = 2 L/m 2 -hr; aeration rate = 5 ml/min

10 Transmembrane Pressure (atm) without Ozonation :2 with Ozonation Filtration time (min) Figure 5. Effect of ozonation on membrane filtration characteristics for roof garden runoff. Conditions: membrane pore size, 1 m; flux, 2 L/m 2 -hr; aeration rate, 5 ml/min, ozone dose, 5 mg/hr.

HUBER Vacuum Rotation Membrane VRM Bioreactor

HUBER Vacuum Rotation Membrane VRM Bioreactor HUBER Vacuum Rotation Membrane VRM Bioreactor VRM The rotating plate membrane for clean water applications. The future-oriented solution designed for the ever increasing requirements in wastewater treatment

More information

SYNERGISTIC APPLICATION OF ADVANCED PRIMARY AND SECONDARY WASTEWATER TREATMENT SYSTEMS

SYNERGISTIC APPLICATION OF ADVANCED PRIMARY AND SECONDARY WASTEWATER TREATMENT SYSTEMS SYNERGISTIC APPLICATION OF ADVANCED PRIMARY AND SECONDARY WASTEWATER TREATMENT SYSTEMS Published in Water and Waste Digest membrane issue, November 2008 Miroslav Colic; Chief Scientist, Clean Water Technology

More information

WASTEWATER TREATMENT OBJECTIVES

WASTEWATER TREATMENT OBJECTIVES WASTEWATER TREATMENT OBJECTIVES The student will do the following: 1. Define wastewater and list components of wastewater. 2. Describe the function of a wastewater treatment plant. 3. Create a wastewater

More information

Sewerage Management System for Reduction of River Pollution

Sewerage Management System for Reduction of River Pollution Sewerage Management System for Reduction of River Pollution Peter Hartwig Germany Content page: 1 Introduction 1 2 Total emissions 3 3 Discharge from the wastewater treatment plants 4 4 Discharge from

More information

Marina Bay on Boston Harbor Water-treatment system by OilTrap Environmental

Marina Bay on Boston Harbor Water-treatment system by OilTrap Environmental Marina Bay on Boston Harbor Water-treatment system by OilTrap Environmental Introduction to Electrocoagulation Electro------Coagulation Electro To cause a pre-determined reaction using a DC electrical

More information

DOW Ultrafiltration. Case History. High Turbidity and Temperature Fluctuation No Obstacle for DOW Ultrafiltration

DOW Ultrafiltration. Case History. High Turbidity and Temperature Fluctuation No Obstacle for DOW Ultrafiltration Case History High Turbidity and Temperature Fluctuation No Obstacle for Site Information Location: HeBei, China Capacity: 12 m 3 /h (5283 gpm) Purpose: Pretreat sea water prior to RO system Time in Operation:

More information

Coagulation and Flocculation in Water and Wastewater Treatment

Coagulation and Flocculation in Water and Wastewater Treatment W, A. R, Coagulation and Flocculation in Water and Wastewater Treatment Second Edition 02,/f John Bratby,» :.'; '5 s " - ' '! ' " ; i '. ', ' j ',... -,..,.,.-* ;, 0 61^/16*36 S "+ "J6 27 48 FAX 0 6151/16

More information

Water Treatment and Reverse Osmosis Systems

Water Treatment and Reverse Osmosis Systems Water 2012 Treatment Pure Aqua, and Inc. Reverse All Rights Osmosis Reserved. ystems Worldwide Experience uperior Technology About the Company Pure Aqua is a company with a strong philosophy and drive

More information

Membrane Filtration Technology: Meeting Today s Water Treatment Challenges

Membrane Filtration Technology: Meeting Today s Water Treatment Challenges Membrane Filtration Technology: Meeting Today s Water Treatment Challenges Growing global demand for clean water and increasing environmental concerns make membrane filtration the technology of choice

More information

REMOVAL OF PHOSPHATE FROM WASTEWATER USING LOW-COST ADSORBENTS

REMOVAL OF PHOSPHATE FROM WASTEWATER USING LOW-COST ADSORBENTS International Journal of Engineering Inventions ISSN: 2278-7461, www.ijeijournal.com Volume 1, Issue 7 (October2012) PP: 44-50 REMOVAL OF PHOSPHATE FROM WASTEWATER USING LOW-COST ADSORBENTS Dr. C.R.Ramakrishnaiah

More information

Nine Industrial Scale V SEPs. Feed Tank V SEP. Feed Pumps (Three) Concentrate. Tank. V SEP Treatment System

Nine Industrial Scale V SEPs. Feed Tank V SEP. Feed Pumps (Three) Concentrate. Tank. V SEP Treatment System River Treatment for Ultrapure Production A cost-effective and environmentally-sound solution Abstract New Logic International installed its Vibratory Shear Enhanced Processing (VSEP) Phase I system in

More information

Ion Exchange Softening

Ion Exchange Softening Ion Exchange Softening Ion-exchange is used extensively in small water systems and individual homes. Ion-exchange resin, (zeolite) exchanges one ion from the water being treated for another ion that is

More information

Development of Advanced Wastewater Treatment and Reclamation System

Development of Advanced Wastewater Treatment and Reclamation System 14 Development of Advanced Wastewater Treatment and Reclamation System TAKESHI TERAZAKI *1 HOZUMI OTOZAI *2 KOSUKE SHIGIISHI *2 HIDEO SUZUKI *3 HIROSHI NAKASHOJI *4 HIROYUKI KAWAMOTO *5 Recycling and the

More information

Module 16: The Activated Sludge Process - Part II Instructor Guide Answer Key

Module 16: The Activated Sludge Process - Part II Instructor Guide Answer Key Unit 1 Process Control Strategies Exercise Module 16: The Activated Sludge Process - Part II Instructor Guide Answer Key 1. What are the six key monitoring points within the activated sludge process? Ans:

More information

Reverse Osmosis Membranes for Wastewater Reclamation By Craig R. Bartels, PhD Hydranautics, 401 Jones Road, Oceanside California, USA 92054

Reverse Osmosis Membranes for Wastewater Reclamation By Craig R. Bartels, PhD Hydranautics, 401 Jones Road, Oceanside California, USA 92054 Reverse Osmosis Membranes for Wastewater Reclamation By Craig R. Bartels, PhD Hydranautics, 401 Jones Road, Oceanside California, USA 92054 Abstract Wastewater reclamation has become a viable alternative

More information

Appendix 2-1. Sewage Treatment Process Options

Appendix 2-1. Sewage Treatment Process Options Appendix 2-1 Sewage Treatment Process Options Table of Contents Appendix 2-1 Sewage Treatment Process Options 1 Introduction...1 2 Chemically Enhanced Primary Treatment (CEPT) Processes...2 2.1 CEPT with

More information

MEMBRANE TECHNOLOGY TREATING OILY WASTEWATER FOR REUSE

MEMBRANE TECHNOLOGY TREATING OILY WASTEWATER FOR REUSE MEMBRANE TECHNOLOGY TREATING OILY WASTEWATER FOR REUSE Jeff Peeters, P.Eng. ZENON Environmental Inc. SAWEA 2005 Workshop Al-Khobar Holiday Inn Hotel, Saudi Arabia November 29, 2005 Presentation outline

More information

Natural and Advanced Treatment Systems for Wastewater Management at Municipal Solid Waste Disposal Site in Developing Countries

Natural and Advanced Treatment Systems for Wastewater Management at Municipal Solid Waste Disposal Site in Developing Countries Natural and Advanced Treatment Systems for Wastewater Management at Municipal Solid Waste Disposal Site in Developing Countries C. Chiemchaisri Department of Environmental Engineering, Kasetsart University

More information

SMALL COMMUNITY TREATMENT PLANT EXPANSION WHILE IN OPERATION USING ADVANCED TECHNOLOGY

SMALL COMMUNITY TREATMENT PLANT EXPANSION WHILE IN OPERATION USING ADVANCED TECHNOLOGY SMALL COMMUNITY TREATMENT PLANT EXPANSION WHILE IN OPERATION USING ADVANCED TECHNOLOGY Adel Bassyouni, HDR Engineering, Guillermo Garcia, HDR Engineering, Don Mc Dermott, Viejas Public Works Department

More information

Indiana s Newest Filtration Facility; East Chicago

Indiana s Newest Filtration Facility; East Chicago Indiana s Newest Filtration Facility; East Chicago Innovation and Value-Added Benefits Behind East Chicago s Membrane Treatment Facility Eric Horvath, PE and Kara M. Boyles, PhD, PE August 1, 2012 Presentation

More information

DOMESTIC WASTEWATER SYSTEMS

DOMESTIC WASTEWATER SYSTEMS Environmental PROTECTION Systems DOMESTIC WASTEWATER SYSTEMS Highest quality sewage treatment systems from the name you can trust Hynds Aerated Wastewater Systems Hynds Lifestyle Systems are an elite range

More information

A NOVEL ION-EXCHANGE/ELECTROCHEMICAL TECHNOLOGY FOR THE TREATMENT OF AMMONIA IN WASTEWATER

A NOVEL ION-EXCHANGE/ELECTROCHEMICAL TECHNOLOGY FOR THE TREATMENT OF AMMONIA IN WASTEWATER A NOVEL ION-EXCHANGE/ELECTROCHEMICAL TECHNOLOGY FOR THE TREATMENT OF AMMONIA IN WASTEWATER ABSTRACT Leonard P. Seed, M.Sc., P.Eng., Enpar Technologies Inc. * Daren D. Yetman, A.Sc.T., Enpar Technologies

More information

Environmental Technology March/April 1998

Environmental Technology March/April 1998 Treating Metal Finishing Wastewater Sultan I. Amer, Ph.D. AQUACHEM INC. Environmental Technology March/April 1998 Wastewater from metal finishing industries contains high concentrations of contaminants

More information

Sterile ReadyToProcess Hollow Fiber Cartridges Instructions for Use

Sterile ReadyToProcess Hollow Fiber Cartridges Instructions for Use GE Healthcare Instructions 28-9226-84 AD ReadyToProcess Sterile ReadyToProcess Hollow Fiber Cartridges Instructions for Use 1 Introduction... 1 2 Inspect the Cartridge... 1 3 General Description... 2 4

More information

SEAR Wastewater Treatment: Contaminant Removal and Material Recovery

SEAR Wastewater Treatment: Contaminant Removal and Material Recovery ESTCP SEAR Wastewater Treatment: Contaminant Removal and Material Recovery U.S. Environmental Protection Agency National Risk Management Research Laboratory Cincinnati, Ohio SEAR Workshop Outline Motivation

More information

WASTE WATER TREATMENT SYSTEM (OPERATING MANUALS )

WASTE WATER TREATMENT SYSTEM (OPERATING MANUALS ) Page 1 of 76 1.0 PURPOSE The purpose of the Wastewater Treatment System is to remove contaminates from plant wastewater so that it may be sent to the Final Plant Effluent Tank and eventually discharged

More information

Best Practice in Boiler Water Treatment

Best Practice in Boiler Water Treatment Best Practice in Boiler Water Treatment Boiler Water Treatment Part 2 Internal Treatment Objectives of Internal Water Treatment 1 To control the level of total dissolved solids (TDS) within the boiler

More information

RO / NF Cleaning Guidelines

RO / NF Cleaning Guidelines Nanostone Water, Inc. Carlsbad Office 2463 Impala Dr. Carlsbad, CA 92010 USA T: +1 (844) 765-7377 www.nanostone.com RO / NF Cleaning Guidelines 2015 Nanostone Water, Inc. www.nanostone.com RO/NF Cleaning

More information

Mine Water Treatment Solutions for Discharge and Re-Use

Mine Water Treatment Solutions for Discharge and Re-Use Mine Water Treatment Solutions for Discharge and Re-Use Bernhard Doll Pall Corporation Summary This paper focusses on the description of reliable, safe and economical treatment of mine water from different

More information

Industrial Storm Water Best Management Practices. Restoring, maintaining, and enhancing the quality of Oregon's water.

Industrial Storm Water Best Management Practices. Restoring, maintaining, and enhancing the quality of Oregon's water. Industrial Storm Water Best Management Practices Restoring, maintaining, and enhancing the quality of Oregon's water. Catch Basin Sampling Device For use on catch basins which have discharge from more

More information

Pall in the Brewery (more value per hectolitre) DE Free Clarification FB1795

Pall in the Brewery (more value per hectolitre) DE Free Clarification FB1795 Pall in the Brewery (more value per hectolitre) DE Free Clarification FB1795 The Pall World Pall Corporation is a world leader in the design, production and supply of filters, membranes and systems for

More information

Treatment of oily wastewater produced from refinery processes using flocculation and ceramic membrane filtration

Treatment of oily wastewater produced from refinery processes using flocculation and ceramic membrane filtration Separation and Purification Technology 32 (2003) 93/98 www.elsevier.com/locate/seppur Treatment of oily wastewater produced from refinery processes using flocculation and ceramic membrane filtration Jing

More information

e ROI Improved Membrane Bio-Reactor (MBR) performance delivers superior effluent quality and major capital savings at Latte Trento Dairy in Italy

e ROI Improved Membrane Bio-Reactor (MBR) performance delivers superior effluent quality and major capital savings at Latte Trento Dairy in Italy Essential Expertise for Water, Energy and Air Improved Membrane Bio-Reactor (MBR) performance delivers superior effluent quality and major capital savings at Latte Trento Dairy in Italy Environmental Results

More information

Oasis Clearwater ENVIRONMENTAL SYSTEMS WASTEWATER TREATMENT ENGINEERS

Oasis Clearwater ENVIRONMENTAL SYSTEMS WASTEWATER TREATMENT ENGINEERS Oasis Clearwater ENVIRONMENTAL SYSTEMS WASTEWATER TREATMENT ENGINEERS The evolution continues in decentralised wastewater technology... The Process Decentralised wastewater treatment systems are defined

More information

Royal Caribbean International Advanced Wastewater Purification Systems

Royal Caribbean International Advanced Wastewater Purification Systems Royal Caribbean International Advanced Wastewater Purification Systems Royal Caribbean International is installing advanced wastewater purification (AWP) systems on all of its ships. These technologically

More information

Complete. Water Solutions. for Rural India

Complete. Water Solutions. for Rural India Complete Water Solutions for Rural India More precious than gold. That s what safe drinking water is to India s rural population. Arsenic, iron, fluoride, nitrate, brackishness and pathogens in ground

More information

CERTIFICATION TO OPERATE WATER AND WASTEWATER TREATMENT SYSTEMS APPLICATION INSTRUCTIONS

CERTIFICATION TO OPERATE WATER AND WASTEWATER TREATMENT SYSTEMS APPLICATION INSTRUCTIONS COMMONWEALTH OF PENNSYLVANIA DEPARTMENT OF ENVIRONMENTAL PROTECTION STATE BOARD FOR CERTIFICATION OF WATER AND WASTEWATER SYSTEMS OPERATORS CERTIFICATION TO OPERATE WATER AND WASTEWATER TREATMENT SYSTEMS

More information

TREATMENT OPTIONS FOR REMOVAL OF SPECIFIC IMPURITIES FROM WATER. S. Vigneswaran Faculty of Engineering, University of Technology, Sydney, Australia

TREATMENT OPTIONS FOR REMOVAL OF SPECIFIC IMPURITIES FROM WATER. S. Vigneswaran Faculty of Engineering, University of Technology, Sydney, Australia TREATMENT OPTIONS FOR REMOVAL OF SPECIFIC IMPURITIES FROM WATER S. Vigneswaran Faculty of Engineering, University of Technology, Sydney, Australia C. Visvanathan Asian Institute of Technology, Bangkok,

More information

Microfiltration for Removal of Manganese from Surface Water

Microfiltration for Removal of Manganese from Surface Water Microfiltration for Removal of Manganese from Surface Water Carl Schneider, Ph.D., P.E., Senior Process Engineer Wiedeman & Singleton, Inc., Atlanta, GA Peter Johns, P.E., Vice-President Wiedeman & Singleton,

More information

EASTERN IRRIGATION SCHEME, VICTORIA: OPERATION OF AN ULTRA-FILTRATION PLANT FOR A CLASS A RECYCLED WATER SCHEME. David Aitken. Earth Tech Engineering

EASTERN IRRIGATION SCHEME, VICTORIA: OPERATION OF AN ULTRA-FILTRATION PLANT FOR A CLASS A RECYCLED WATER SCHEME. David Aitken. Earth Tech Engineering EASTERN IRRIGATION SCHEME, VICTORIA: OPERATION OF AN ULTRA-FILTRATION PLANT FOR A CLASS A RECYCLED WATER SCHEME Paper Presented by : David Aitken Authors: David Aitken, Plant Operator, Liz Roder, Operations

More information

Pall Aria AP Series Packaged Water Treatment Systems

Pall Aria AP Series Packaged Water Treatment Systems Pall Aria AP Series Packaged Water Treatment Systems Pall Aria AP Series Packaged Water Treatment Systems Installations Point Hope, AK Wainwright, AK Nuiqsut, AK Point Lay, AK Atqasuk, AK Anchorage, AK

More information

TREATMENT OF PHOSPHATE FERTILIZER PLANT WASTE WATER IN FLORIDA FOR DISCHARGE AND RE USE PURPOSES

TREATMENT OF PHOSPHATE FERTILIZER PLANT WASTE WATER IN FLORIDA FOR DISCHARGE AND RE USE PURPOSES TREATMENT OF PHOSPHATE FERTILIZER PLANT WASTE WATER IN FLORIDA FOR DISCHARGE AND RE USE PURPOSES JOHN F. BOSSLER, SIEMENS Water Technologies Corp., Hoffman Estates, IL RONALD TRAVIS, SIEMENS Water Technologies

More information

Municipal Standard Solutions. Water Treatment WATER TECHNOLOGIES

Municipal Standard Solutions. Water Treatment WATER TECHNOLOGIES Municipal Standard Solutions Water Treatment WATER TECHNOLOGIES Standard Units and Tailor-made Systems Veolia provides the complete range of services required to design, build, maintain and upgrade water

More information

Iron and manganese are two similar elements

Iron and manganese are two similar elements L-5451 2-04 Drinking Water Problems: Iron and Manganese Mark L. McFarland, Associate Professor and Extension Soil Fertility Specialist Monty C. Dozier, Assistant Professor and Extension Water Resources

More information

1. Inspection and monitoring... 3

1. Inspection and monitoring... 3 1 Index 1. Inspection and monitoring... 3 1.1 Handling of new elements... 3 1.1.1 Storage of original packaged RO elements... 3 1.1.2 Packing... 3 1.2 Initial start- up checks of a plant... 3 1.2.1 Preparation

More information

PROPAK AquaBio Complete Water Restoration Systems

PROPAK AquaBio Complete Water Restoration Systems PROPAK AquaBio Complete Water Restoration Systems Conserving natural resources and lowering operating expenses is no longer an option, it is a necessity. Water, sewer and discharge fees are continuing

More information

Biological Wastewater Treatment

Biological Wastewater Treatment Biological Wastewater Treatment This article briefly discusses the differences between aerobic and anaerobic biological treatment processes and subsequently focuses on select aerobic biological treatment

More information

How To Water System

How To Water System Mid-Monroe Water System: Soluble Iron and Manganese Removal via Oxidation & Filtration Daniel Rickard, P.E. Engineering Project Manager Pennsylvania-American Water Company Who Is American Water We are

More information

Application Note NEW LOGIC RESEARCH. Treating Fuel Storage Tank Bottom Water With VSEP. Overview

Application Note NEW LOGIC RESEARCH. Treating Fuel Storage Tank Bottom Water With VSEP. Overview Treating Fuel Storage Tank Bottom Water With VSEP Overview Fuel storage tank bottom water (FSTBW) is one of several types of petroleum contaminated wastewater sources that can be treated using V SEP technology.

More information

Innovation and Progress in Water Treatment Technology

Innovation and Progress in Water Treatment Technology Innovation and Progress in Water Treatment Technology Degree of separation of ultrafiltration Summary of the various processes The water will be pressed through the between the raw water side and the filtrate

More information

Removing Heavy Metals from Wastewater

Removing Heavy Metals from Wastewater Removing Heavy Metals from Wastewater Engineering Research Center Report David M. Ayres Allen P. Davis Paul M. Gietka August 1994 1 2 Removing Heavy Metals From Wastewater Introduction This manual provides

More information

Cooling Tower Sidestream Filtration A Green, Proven Cost Reduction Technology

Cooling Tower Sidestream Filtration A Green, Proven Cost Reduction Technology Cooling Tower Sidestream Filtration A Green, Proven Cost Reduction Technology TAB0411 Typical crossflow cooling tower installation Due to the large air-water interface needed to obtain good evaporative

More information

AP ENVIRONMENTAL SCIENCE 2007 SCORING GUIDELINES

AP ENVIRONMENTAL SCIENCE 2007 SCORING GUIDELINES AP ENVIRONMENTAL SCIENCE 2007 SCORING GUIDELINES Question 1 Read the Fremont Examiner article below and answer the questions that follow. (a) Identify ONE component of the sewage that is targeted for removal

More information

Sterilization methods and equipment Lab 1-2

Sterilization methods and equipment Lab 1-2 Sterilization methods and equipment Lab 1-2 PHT 434 Sterilization Sterilization a process that by which all viable M.O are removed or destroyed, based on a probability function. Sterilization concept Sterilization

More information

Combination of advanced aeration system and membrane bioreactor for winery waste water treatment

Combination of advanced aeration system and membrane bioreactor for winery waste water treatment Combination of advanced aeration system and membrane bioreactor for winery waste water treatment G. Tanzi*, A. Mazzei** * Sepra S.r.l., via Como 69/A, 20031 Cesano Maderno, Italy (e-mail: gctanzi@sepra.it)

More information

Self Assessment Exercise

Self Assessment Exercise Self Assessment Exercise Read the following extract of supporting documentation for Permit Application for Galvos plc galvanising facility and the accompanying tables. Decide if the proposed control techniques

More information

WISCONSIN WASTEWATER OPERATORS ASSOCIATION

WISCONSIN WASTEWATER OPERATORS ASSOCIATION Integrity. People. Knowledge. WISCONSIN WASTEWATER OPERATORS ASSOCIATION ANNUAL CONFERENCE GREEN BAY Resources. MEETING LOW LEVEL PHOSPHORUS LIMITS BY CHEMICAL ADDITION WHAT IS PHOSPHORUS Atomic # 15 Electron

More information

Cross Flow Filtration Method Handbook

Cross Flow Filtration Method Handbook Cross Flow Filtration Method Handbook Page intentionally left blank Table of Contents Table of Contents 1 Introduction... 1.1 What is cross flow filtration?... 1.2 Key features of CFF... 1.3 CFF application

More information

Water Water Treatment Plant Tour

Water Water Treatment Plant Tour Water Water Treatment Plant Tour Don Rankin, Superintendent Topeka, KS 66606 785-368-3111 Tel 785-368-3825 FAX For a complete list of contacts with phone numbers, FAX numbers and email addresses, click

More information

Water Specialists for the Petrochemical Sector. ovivowater.com. creating value in water through innovation, creativity and expertise

Water Specialists for the Petrochemical Sector. ovivowater.com. creating value in water through innovation, creativity and expertise Water Specialists for the Petrochemical Sector creating value in water through innovation, creativity and expertise ovivowater.com Ovivo - Industrial Services A New Global Force in Water As society and

More information

CHEMICAL CLEANING EXPERIMENTS FOR PERFORMANCE RESTORATION OF NF MEMBRANES OPERATED ON SEAWATER FEED 1

CHEMICAL CLEANING EXPERIMENTS FOR PERFORMANCE RESTORATION OF NF MEMBRANES OPERATED ON SEAWATER FEED 1 CHEMICAL CLEANING EXPERIMENTS FOR PERFORMANCE RESTORATION OF NF MEMBRANES OPERATED ON SEAWATER FEED 1 A. Mohammed Farooque, Ahamed S. Al-Amoudi and Ata M. Hassan Saline Water Conversion Corporation P.O.Box

More information

HIFLOW NICKEL MICROFILTRATION MEDIA FOR GAS AND LIQUID FILTRATION

HIFLOW NICKEL MICROFILTRATION MEDIA FOR GAS AND LIQUID FILTRATION HIFLOW NICKEL MICROFILTRATION MEDIA FOR GAS AND LIQUID FILTRATION Dr. Kenneth L. Rubow Dr. Sunil Jha Mott Corporation Published in Conference Proceedings Volume 13 Advances in Filtration and Separation

More information

LANDSCAPING AQUA SPORT. Rainwater treatment using filter substrate channel. DIBt approval applied for

LANDSCAPING AQUA SPORT. Rainwater treatment using filter substrate channel. DIBt approval applied for CIVILS LANDSCAPING AQUA SPORT Drainfix Clean Rainwater treatment using filter substrate channel DIBt approval applied for CIVILS LANDSCAPING AQUA SPORT Drainfix Clean Application areas For the treatment

More information

ADVANCED TREATMENT TECHNOLOGIES FOR RECYCLE/REUSE OF DOMESTIC WASTEWATER

ADVANCED TREATMENT TECHNOLOGIES FOR RECYCLE/REUSE OF DOMESTIC WASTEWATER ADVANCED TREATMENT TECHNOLOGIES FOR RECYCLE/REUSE OF DOMESTIC WASTEWATER H. H. Ngo and S. Vigneswaran Faculty of Engineering, University of Technology, Sydney, Australia M. Sundaravadivel Graduate School

More information

Table 1.1: Typical Characteristics of Anaerobically Digested Wastewater

Table 1.1: Typical Characteristics of Anaerobically Digested Wastewater Solar Detoxification of Distillery Waste Anil K. Rajvanshi and Nandini Nimbkar Nimbkar Agricultural Research Institute (NARI), P.O. Box 44, PHALTAN-415523, Maharashtra E-mail : nariphaltan@gmail.com Introduction

More information

Department of Environmental Engineering

Department of Environmental Engineering Department of Environmental Engineering Master of Engineering Program in Environmental Engineering (International Program) M.Eng. (Environmental Engineering) Plan A Option 1: (1) Major courses: minimum

More information

Well Water Iron Removal Using Quantum DMI-65 Granular Filter Media

Well Water Iron Removal Using Quantum DMI-65 Granular Filter Media Well Water Iron Removal Using Quantum DMI-65 Granular Filter Media ASME Research Committee Power Plant and Environmental Chemistry Overland Park, Kansas April 2-4, 2007 Prepared by: W. H. Stroman Primary

More information

To meet the demands of a high-purity deionized (DI) water system, filters must:

To meet the demands of a high-purity deionized (DI) water system, filters must: Ultrapure Water General Filter Requirements Achieving and maintaining ultrapure water (UPW) is extremely important in light of its widespread presence throughout the manufacture of semiconductor integrated

More information

Design of Purified Water and Water For Injection Systems. Hugh Hodkinson Engineers Ireland Chemical & Process Division

Design of Purified Water and Water For Injection Systems. Hugh Hodkinson Engineers Ireland Chemical & Process Division Design of Purified Water and Water For Injection Systems Hugh Hodkinson Engineers Ireland Chemical & Process Division Introduction My Background What s this lecture about? What should you get out of it?

More information

How do you treat water based on water quality from different water sources?

How do you treat water based on water quality from different water sources? How do you treat water based on water quality from different water sources? Why? Authors: Wendy Lane and Kim Sciarrone Seattle Public Schools; Seattle, WA Water from different sources will contain different

More information

RO Reverse Osmosis equipments

RO Reverse Osmosis equipments RO SYSTEMS RO Reverse Osmosis equipments A range of Reverse Osmosis equipment designed to provide the highest performances with flow rates demand from 50 to 1000 l/h. Every component of the equipment is

More information

Case Study: Research Leads To Large-Scale Microfiltration Plants 10/01/1999

Case Study: Research Leads To Large-Scale Microfiltration Plants 10/01/1999 Case Study: Research Leads To Large-Scale Microfiltration Plants 10/01/1999 What are the advantages of low-pressure membrane treatment processes for surface water supplies? How are the requirements of

More information

Diafiltration: A Fast, Efficient Method for Desalting, or Buffer Exchange of Biological Samples

Diafiltration: A Fast, Efficient Method for Desalting, or Buffer Exchange of Biological Samples Scientific & Technical Report PN 33289 Diafiltration: A Fast, Efficient Method for Desalting, or Buffer Exchange of Biological Samples By Larry Schwartz, Senior Technical Manager, Pall Life Sciences Diafiltration

More information

Wastewater Reuse. Typical treated wastewater is:

Wastewater Reuse. Typical treated wastewater is: Wastewater Reuse Most metal finishing industries have in-house wastewater treatment to economically dispose of the acids, alkali, oils, and dissolved metals in the rinse water and occasional tank solution

More information

Active Treatment Systems

Active Treatment Systems Categories EC Erosion Control SE Sediment Control TC Tracking Control WE Wind Erosion Control Non-Stormwater NS Management Control Waste Management and WM Materials Pollution Control Legend: Primary Category

More information

Enhanced Organic Precursor Removals Using Aged Filter Media Page 1. Enhanced Organic Precursor Removals Using Aged Filter Media

Enhanced Organic Precursor Removals Using Aged Filter Media Page 1. Enhanced Organic Precursor Removals Using Aged Filter Media Enhanced Organic Precursor Removals Using Aged Media Page 1 Enhanced Organic Precursor Removals Using Aged Media O b j e c t i v e s The main goals of this project was to evaluate the dissolved organic

More information

A Low Cost Chemical Remediation Technology for Heavy Metals in Shipyard Stormwater. SBIR Topic N06 133

A Low Cost Chemical Remediation Technology for Heavy Metals in Shipyard Stormwater. SBIR Topic N06 133 A Low Cost Chemical Remediation Technology for Heavy Metals in Shipyard Stormwater SBIR Topic N06 133 1 Normal Ave, CSAM RI 121A Montclair, NJ 07043 973 655 7385 SIROM TECHNOLOGY SIROM has developed a

More information

by: Juan Pedrerol Gallego Repsol Quimica, S.A. Tarragona, Spain Salvador Ruiz Lopez Repsol Quimica, S.A. Tarragona, Spain-

by: Juan Pedrerol Gallego Repsol Quimica, S.A. Tarragona, Spain Salvador Ruiz Lopez Repsol Quimica, S.A. Tarragona, Spain- The Use of Wet Oxidation and PACT for the Treatment of Propylene Oxide/Styrene Monomer (PO/SM) Industrial Wastewaters at the Repsol PO/SM Plant in Tarragona, Spain by: Juan Pedrerol Gallego Repsol Quimica,

More information

Iron and Manganese BACTERIA AND IRON AND MANGANESE

Iron and Manganese BACTERIA AND IRON AND MANGANESE Iron and Manganese Iron and manganese control is the most common type of municipal water treatment in Minnesota. Iron and manganese occur naturally in groundwater. Neither element causes adverse heath

More information

Water Pollution. A Presentation for Café Scientifique Cherie L. Geiger, Ph.D. Department of Chemistry, UCF

Water Pollution. A Presentation for Café Scientifique Cherie L. Geiger, Ph.D. Department of Chemistry, UCF Water Pollution A Presentation for Café Scientifique Cherie L. Geiger, Ph.D. Department of Chemistry, UCF Overview What is Causing it? Problems with Groundwater Contamination Traditional Remediation Techniques

More information

THE USE OF OZONE IN COOLING TOWERS

THE USE OF OZONE IN COOLING TOWERS THE USE OF OZONE IN COOLING TOWERS Paul D. McNicholas Ozonia Ltd Duebendorf, Switzerland Abstract Ozone has been successfully applied to industrial cooling water systems with the resultant improvement

More information

Improper storage of potential pollutants will increase the risk of water pollution that may occur because of spills.

Improper storage of potential pollutants will increase the risk of water pollution that may occur because of spills. WQ-3 Best Management Practice (BMP) Water Quality Protection Guideline Secondary Containment Design and Operation Standards Section 1. Introduction According to the EPA, the majority of water pollution

More information

8 Chemicals from water treatment and distribution

8 Chemicals from water treatment and distribution 8 Chemicals from water treatment and distribution 8.1 Introduction Chemicals from water treatment and distribution reach drinking-water by the most direct route. They fall into three broad categories:

More information

Removing Thallium from Industrial FGD Scrubber Water with Sorbster Adsorbent Media

Removing Thallium from Industrial FGD Scrubber Water with Sorbster Adsorbent Media Case History MAR Systems Inc. Removing Thallium from Industrial FGD Scrubber Water with Sorbster Adsorbent Media Trace thallium levels in process and wastewater streams pose a human toxicity threat. Tidwell

More information

Water Recycles poster

Water Recycles poster Water Recycles poster The "Water ReCycles" poster is designed for students of all ages. It shows the natural water cycle and humans influence on water resources. Raincloud illustration The raincloud in

More information

POSITIVE DISPLACEMENT BLOWERS & VACUUM PUMPS. Water & Wastewater Treatment Solutions

POSITIVE DISPLACEMENT BLOWERS & VACUUM PUMPS. Water & Wastewater Treatment Solutions POSITIVE DISPLACEMENT BLOWERS & VACUUM PUMPS Water & Wastewater Treatment Solutions Water & Wastewater Treatment Solutions Gardner Denver understands the complex needs and challenges of the water and wastewater

More information

Common Problems with Online Water Quality Analyzers. Greg Macy Director AquatiPro LLC

Common Problems with Online Water Quality Analyzers. Greg Macy Director AquatiPro LLC Common Problems with Online Water Quality Analyzers Greg Macy Director AquatiPro LLC Objectives Diagnosing Colorimetric Analyzers Identifying Common Problems with Sodium Analyzers Troubleshooting ph Analyzers

More information

Water Purification Treatment. General Information. Water Purification Treatment Business of the Teijin Group. Water. Purification Treatment

Water Purification Treatment. General Information. Water Purification Treatment Business of the Teijin Group. Water. Purification Treatment Business of the Teijin Group General Information Teijin's Technologies and Their Features Core Technologies Environmentally Friendly Biological Technologies Greater Potential for Reuse Advanced Technologies

More information

Water Purification Treatment System

Water Purification Treatment System Introductions to Tap Water Purification Treatment System A diagram of water treatment process : Raw water Flash mixer Floccula;on basin Sedimenta;on tank Add PAC Add disinfectant Sludge Surface thickening

More information

1.85 WATER AND WASTEWATER TREATMENT ENGINEERING FINAL EXAM DECEMBER 20, 2005

1.85 WATER AND WASTEWATER TREATMENT ENGINEERING FINAL EXAM DECEMBER 20, 2005 1.85 WATER AND WASTEWATER TREATMENT ENGINEERING FINAL EXAM DECEMBER 20, 2005 This is an open-book exam. You are free to use your textbook, lecture notes, homework, and other sources other than the internet.

More information

Wastewater Nutrient Removal

Wastewater Nutrient Removal Wastewater Nutrient Removal An overview of phosphorus and nitrogen removal strategies Presented by: William E. Brown, P.E. Peter C. Atherton, P.E. Why are nutrients an issue in the environment? Stimulates

More information

OF EOR CHEMICALS. Ying Guo, Total E&P. Presented at FORCE - EOR Competence Building Workshop 6. November 2013

OF EOR CHEMICALS. Ying Guo, Total E&P. Presented at FORCE - EOR Competence Building Workshop 6. November 2013 3 1 0 2 v o N 7 6 p o h s k r o w e c r o F ENVIRONMENTAL ASPECT OF EOR CHEMICALS Ying Guo, Total E&P Presented at FORCE - EOR Competence Building Workshop 6. November 2013 PRESENTATION OUTLINE Problems

More information

NUTRIENT REMOVAL FROM SECONDARY EFFLUENT BY ALUM FLOCCULATION AND LIME PRECIPITATION*

NUTRIENT REMOVAL FROM SECONDARY EFFLUENT BY ALUM FLOCCULATION AND LIME PRECIPITATION* University of Wisconsin Engineering Experiment Station Reprint Number 708 Int. J. Air Wat. Poll. Pergamon Press 1964. Vol. 8, pp. 487-500. Printed in Great Britain. NUTRIENT REMOVAL FROM SECONDARY EFFLUENT

More information

The Fouling of Zirconium(IV) Hydrous Oxide Polyacrylate Dynamically Formed Membranes during the Nanofiltration of Lactic Acid Solutions

The Fouling of Zirconium(IV) Hydrous Oxide Polyacrylate Dynamically Formed Membranes during the Nanofiltration of Lactic Acid Solutions Membranes 213, 3, 415-423; doi:1.339/membranes34415 Article OPEN ACCESS membranes ISSN 277-375 www.mdpi.com/journal/membranes The Fouling of Zirconium(IV) Hydrous Oxide Polyacrylate Dynamically Formed

More information

Life Sciences USD 2260. High Purity Water Systems for the Biopharmaceutical Industry. Improving security, flexibility and operation costs

Life Sciences USD 2260. High Purity Water Systems for the Biopharmaceutical Industry. Improving security, flexibility and operation costs Life Sciences USD 2260 High Purity Water Systems for the Biopharmaceutical Industry Improving security, flexibility and operation costs Pall's total turnover is more than $1.5billion. Our staff of more

More information

THE MC CLARIFLOW UPFLOW SOLIDS CONTACT CLARIFIER

THE MC CLARIFLOW UPFLOW SOLIDS CONTACT CLARIFIER The Ultimate UPFLOW SOLIDS CONTACT CLARIFIER by Arthur C. Schlicht November 1999 Walker Process Equipment Division of McNish Corporation 840 North Russell Avenue Aurora, IL 60506-2853 PHONE: (630) 892-7921

More information

Brewery Wastewater: 2010 Water and Wastewater Conference. 11.02.2011 Page 1

Brewery Wastewater: 2010 Water and Wastewater Conference. 11.02.2011 Page 1 Brewery Wastewater: Solutions for the Problem By Fred M. Scheer 2010 Water and Wastewater Conference Madison, WI 11.02.2011 Page 1 vr74 What We Will Discuss: Biochemical i Oxygen Demand (BOD): Where does

More information

Advanced Treatment of Hazardous Wastes(1) Advanced Treatment of Hazardous Wastes(2) Advanced Environmental Chemistry. Design of Solid Waste Landfill

Advanced Treatment of Hazardous Wastes(1) Advanced Treatment of Hazardous Wastes(2) Advanced Environmental Chemistry. Design of Solid Waste Landfill Course Description (전체 개설 교과목 개요) Advanced Treatment of Hazardous Wastes(1) This course is concerned with the management of hazardous materials and wastes in depth. We will deal with the physico-chemical

More information

Background. 179 million gallons saved for make-up water

Background. 179 million gallons saved for make-up water Essential Expertise for Water, Energy and Air Gallatin Steel Achieves Significant eroi Savings Through the Use of Nalco Innovative Technologies Background Gallatin Steel is a mini-mill that produces steel

More information

ADDENDUM TO THE FACT SHEET FOR NATIONAL POLLUTANT DISCHARGE ELIMINATION SYSTEM (NPDES) PERMIT NO. WA-002264-1 June 25, 2010

ADDENDUM TO THE FACT SHEET FOR NATIONAL POLLUTANT DISCHARGE ELIMINATION SYSTEM (NPDES) PERMIT NO. WA-002264-1 June 25, 2010 ADDENDUM TO THE FACT SHEET FOR NATIONAL POLLUTANT DISCHARGE ELIMINATION SYSTEM (NPDES) PERMIT NO. WA-002264-1 June 25, 2010 I. GENERAL INFORMATION Facility: City of Blaine Wastewater Treatment Plants 9235

More information