DeltaV workstation hardware includes a monitor, CPU, keyboard, mouse, and speakers.

Transcription

1 February 2007 Page 1 DeltaV workstation hardware includes a monitor, CPU, keyboard, mouse, and speakers. Pre-installed software Easy control network installation Choose between PCs and servers to optimize your cost/performance Choices for data backup, remote diagnostics, RAID, and dual and quad monitors Introduction DeltaV software runs on an Intel Pentium-based workstation. Available as a PC with single or dual monitors, or as a server with a single monitor, the selection of workstations provides the performance you need to engineer your control strategy and operate your process. Emerson Process Management leadership in service and quality is legendary. That is why we supply you with a guaranteed solution. You will never be bothered with incompatible drivers, bad or overwritten DLLs, or substandard hardware. You will not waste time in no-value engineering. Instead, you can focus on the process. Benefits Pre-installed software. When ordered through a DeltaV system integrator, the pre-loaded workstation, monitor, keyboard, and mouse are delivered ready to plug and play in your DeltaV system. This is hassle-free hardware delivery. No third-party interfaces, compatibility problems, nor

2 February 2007 Page 2 software versions to worry you. A trouble-free system is guaranteed! Easy control network installation. The workstation ships from the factory with the appropriate DeltaV control network cards preinstalled no cases to open or network drivers to set up. Just plug a control network segment into the workstation and the other end into the DeltaV control area network (CAN), and you ve just set up a new DeltaV network node. Choose between PCs and servers to optimize your cost/performance. Some systems are served well with PC workstations. But when larger systems demand higher levels of performance, the servers provide exactly what you need. Flexible options. Match our options with your requirements for towers, servers, dual monitors and RAID storage. We provide recommendations, but the choice is yours. Either way, the operating system is pre-loaded and ready to roll. Product Description and Specifications The items covered in this specification are subject to improvements at any time. It is the policy of Emerson Process Management to ship workstation hardware that is current with industry standards. We want you to enjoy the benefits of the increasing performance and decreasing costs inherent with using state-of-the-art, off-the-shelf equipment as much as possible. DeltaV performs testing to help eliminate the risks associated with new platforms, and we continue to focus on measures that extend the life of installed hardware. Plenty of horsepower. All workstations use Intel Pentium 4 processor. This 32-bit processor is well suited for DeltaV performance software. Lots of Memory. All computers come with sufficient memory to handle DeltaV applications. See the specifications for the exact memory installed on each computer type. Secure data. RAID 5 controllers available with the servers maximize data protection. Crystal clear video. DeltaV software works at 1024 x 768 or 1280x1024 pixel resolution. An integrated video controller boosts video performance to meet the resolution you demand. And you can increase your viewing space with dual monitors or four monitors. (Dual monitors and four monitors are available only on Precision workstations.) Sounds alive. To provide the audible alarms for your automation project, 16-bit sound is included on the motherboard of all PCs and workstations. (Sound is not available on server-class computers.) Legendary support. Emerson Process Management consistently receives top honors in service from our customers (ref.: Control magazine January 1998 to January 2006). This service is extended with a variety of optional support plans. When you subscribe to one of these plans, you are supplied with an external modem. This modem enables the factory to perform remote diagnostics on your workstation should the need arise. Communications security. The DeltaV system is solid, secure, and safe. The DeltaV control network is fully redundant, and the workstations are equipped to take advantage of this redundancy. Looking for data security? Tired of using 20-odd floppies? The internally installed tape backup unit (PE2900 tower only) makes backups a breeze. It is standard with the server. The workstations now come with a CDRW drive, and a CDRW is available on server models as well. Primary domain controller. For Server 2003 it is not necessary to pre-order the server setup with primary domain functionality. In Windows 2003 this functionality is called Active Directory Services and can be set up without reinstalling the operating system. Monitor Options Real estate for process graphics. Choose a 21 FPD to display your process. Or choose dual or four monitors for maximum viewing area. Touchscreen is also supported; see the Touchscreen product data sheet for details. Monitor Specifications (specifications as of document publication date subject to change) Consult the Dell Web page for the latest specifications on the monitors specified in our pricebook.

3 February 2007 Page 3 VE2525 Optiplex745 Core2 Duo Mini-tower computer Mini-tower chassis (change from small desktop supplied in previous Optiplex computers) Onboard NIC: Broadcom 10/100/1000 Ethernet port Additional NICs: Two Intel Pro/1000GT desktop adapter NICs (PCI) Single Intel E GHz Core2 Duo 1066FSB or better processor with 2MB L2 cache* Memory: 2.0GB, 667MHz, DDR2 SDRAM, non-ecc Drives: 80GB 3Gbps SATA (7,200 rpm) or greater hard drive 1.44MB floppy drive 48X or better DVD-ROM/CDRW combo drive On-Board Integrated audio On-Board Integrated Video,Intel GMA3000 (single monitor capable) Speakers: Dell Two Piece Stereo Speakers PC2 Serial port adapter with dongle for second PS/2 port USB Optical mouse (2button w/scroll) USB Local country keyboard Documentation Resource CD (diagnostics & drivers) Windows XP Professional, Service Pack 2 on CDROM Windows XP Professional, New Installation and Restore CD (12P3109) Windows XP Professional, MUI Installation CD-ROM pack, required for non-english use only These computers must be installed in a dust-free, contaminant-free environment. These computers are not suitable for mounting in industrial environments unless they are mounted in enclosures that provide the necessary dust-free and contaminant-free environment. * The 1.86 GH processor with the 1066FSB provides higher performance than previous computers running a faster CPU CHASSIS DIMENSIONS Height 41.4 cm (16.3 inches) Width 18.5 cm (7.3 inches) Depth 43.8 cm (17.3 inches) Weight kg (27.2 lb) PHYSICAL ATTRIBUTES (apply to all computers) Temperature Operating 10 to 35 C (50 to 95 F) Storage 40 to 65 C ( 40 to 149 F) Relative humidity 20% to 80% (non-condensing) Maximum vibration Operating 0.25 G at 3 to 200 Hz at 0.5 octave/min Storage 0.5 G at 3 to 200 Hz at 1 octave/min Maximum shock Operating Bottom half-sine pulse with a change in velocity of 50.8 cm/sec (20 inches/sec) Storage 27-G faired square wave with a velocity change of 508 cm/sec (200 inches/sec) Altitude Operating 15.2 to 3048 m ( 50 to 10,000 ft) Storage 15.2 to 10,668 m ( 50 to 35,000 ft)

4 February 2007 Page 4 VE WS390 Dual-Monitor workstation Pentium-D MiniTower PC Onboard NIC, plus two add-in NICs Onboard NIC: Broadcom 10/100/1000 Ethernet port Additional NICS: Broadcom NetXtreme 10/100/1000 PCI Express add-in cards CPU: E6300 Intel Core 2 Duo processor 1.86GH, 1066 FSB, 2MB L2 Cache* Memory: 2GB, 667MHz, DDR2 SDRAM Memory, ECC (2 DIMMS) Drives: One 73GB Ultra 320/M SCSI (15,000rpm) or greater hard-drive 1.44MB floppy drive 48X/32X CD-RW/DVD Combo Drive Ultra 320/M SCSI controller card On-Board Integrated audio Video: ATI FireGL V3400, 128MB, dual VGA or dual DVI or DVI+VGA graphics card (dual-monitor capable) Speakers: Dell Two piece Stereo Speakers USB Optical mouse (2 button w/scroll) Documentation Resource CD (diagnostics and drivers) Windows XP Professional, Service Pack 2 on CDROM Windows XP Professional, New Installation and Restore CD Windows XP Professional, MUI Installation CD-ROM pack, required for non-english use only Chassis: Convertible Mini-tower (H x W x D): 17.6" x 6.8" x 18.4" (H x W x D): 44.7cm x 17.1cm x 46.8cm Weight: 39 lb (17.7 kg) Power watt power supply See Optiplex specification for environmental requirements These computers must be installed in a dust-free, contaminant-free environment. These computers are not suitable for mounting in industrial environments unless they are mounted in enclosures that provide the necessary dust-free and contaminant-free environment. * The 1.86 GH processor with the 1066FSB provides higher performance than previous computers running a faster CPU

5 February 2007 Page 5 VE WS 390 Four Monitor Workstation Pentium-D MiniTower PC 3Network interface ports: Onboard NIC: Broadcom 10/100/1000 Ethernet port Additional NICS: Broadcom NetXtreme 10/100/1000 PCI Express add-in cards CPU: E6300 Intel Core 2 Duo processor 1.86GH, 1066 FSB, 2MB L2 Cache* Memory: 2GB, 667MHz, DDR2 SDRAM Memory, ECC (2 DIMMS) Drives: One 73GB Ultra 320/M SCSI (15,000rpm) or greater hard-drive 1.44MB floppy drive 48X/32X CD-RW/DVD Combo Drive Ultra 320/M SCSI controller card On-Board Integrated audio Video: Matrox PCI G45X4QUAD-B (note - enabling the use of all four monitors requires the use of a DeltaV 4 monitor license) Speakers: Dell Two Piece Stereo Speakers USB Optical mouse (2 button w/scroll) Documentation Precision Workstation Resource CD (diagnostics and drivers) Windows XP Professional, with Service Pack on CDROM Windows XP Professional, New Installation and Restore CD Windows XP Professional, MUI Installation CD-ROM pack, required for non-english use only Chassis: Convertible Mini-tower (H x W x D): 17.6" x 6.8" x 18.4" (H x W x D): 44.7cm x 17.1cm x 46.8cm Weight: 39 lb (17.7 kg) Power watt power supply See the Optiplex specifications for environmental requirements These computers must be installed in a dust-free, contaminant-free environment. These computers are not suitable for mounting in industrial environments unless they are mounted in enclosures that provide the necessary dust-free and contaminant-free environment.

6 February 2007 Page 6 VE PE 840 Pentium-D Dual Core CPU Server Three 10/100/1000 MB Ethernet ports (Broadcom on-board, 2 addnl Broadcom NetXtreme cards) Single Dual Core 3050 Processor, 2MB 2.13GHz, Xeon, 1066MHz,Front Side Bus Integrated graphics controller with 16MB SDRAM PCI SCSI controller card (Adaptec 39160) PCI Parallel Port Card (SIIG) Memory: 2GB DDR2, 533MHZ, 2x1G, Dual Ranked DIMMs Drives: single 73GB, SAS, 3.5-inch, 10K RPM Hard Drive SAS5iR (SATA/SAS drive Controller)- No RAID 1.44MB floppy drive Tape backup unit: PowerVault 100T,IDE,20/40GB, Internal 48X or better DVD-ROM/CDRW Combo drive USB Optical mouse (2 button w/scroll) Simplex power supply (420W) Chassis Size: Height: 17.28" (43.89 cm) Width: 7.80" (19.81 cm) Depth: 19.68" (49.99 cm) Weight: ~ 42.0 lbs. (19.05kg) - fully loaded Environmental Specifications Operating Temperature: 10 to 35 C (50 to 95 F) Operating Relative Humidity: 20% to 80% (noncondensing) with a maximum humidity gradation of 10% per hour Operating Maximum Vibration: 0.25 G's 0-Peak, HZ 1/2 Octaves/minute Operating Maximum Shock: 31G, 2.6ms, 20inch/sec, bottom side Operating Altitude: -16 to 3048 m (-50 to 10,000 ft.) Storage Temperature: -40 to 65 C (-40 to 149 F) Storage Relative Humidity: 5% to 95% (noncondensing) Storage Maximum Vibration: 1.54 GRMS min/side Storage Maximum Shock: 71G, 2ms, 35inch/sec, 6 sides; 32G, 2ms, 270inch/sec, 6 sides Storage Altitude: -16 to 10,600 m (-50 to 35,000 ft.) Windows Server 2003 R2 Standard Edition with 5 Client Access Licenses Windows Server 2003, New Installation and Restore CD Windows Server 2003, MUI Installation CD-ROM pack, required for non-english use only These computers must be installed in a dust-free, contaminant-free environment. These computers are not suitable for mounting in industrial environments unless they are mounted in enclosures that provide the necessary dust-free and contaminant-free environment.

7 February 2007 Page 7 Dell PE2900 Tower Servers Specifications and DeltaV Workstation Product Details VE PE 2900 Tower Chassis Xeon CPU Server general specifications 5U Tower Tower Dimensions (without bezel): 18.85" (47.89cm) H w/feet x 8.92" (22.66cm) W x 26.55" (67.43cm) D; (including LCD panel). Tower Weight 49.9 kg (110 lb), maximum configuration Operating Temperature: 10º C to 35º C (50º F to 95º F) Storage Temperature: -40º C to 65º C (-40º F to 149º F) Operating Relative Humidity (non-condensing twmax=29c): 20% to 80% non-condensing Maximum humidity gradient: 10% per hour, operational and non-operational conditions. Storage Relative Humidity: 5% to 95% non-condensing (twmax=38c) Operating Vibration: 0.26G at 5Hz to 350Hz for 2 minutes Storage Vibration: 1.54Grms Random Vibration at 10Hz to 250Hz for 15 minutes Operating Shock: 1 shock pulse of 41G for up to 2ms Storage Shock: 6 shock pulses of 71G for up to 2ms Operating Altitude: -16 to 3,048m (-50 ft to 10,000 ft) Storage Altitude: -16m to 10,600m (-50 ft to 35,000 ft) These servers must be installed in a dust-free, contaminant-free environment. These servers are not suitable for mounting in industrial environments unless they are mounted in enclosures that provide the necessary dust-free and contaminant-free environment. Dell Servers do not support multi-monitors, sound cards (no speakers provided with servers) or DVD Write drives.

8 February 2007 Page 8 VE2519C2 - PE 2900 Tower Chassis Dual Xeon CPU Server Three 10/100/1000 MB Ethernet ports (Broadcom NetXtreme II 5708, 1 on-board, 2 addnl cards) Five SAS hard-drives PERC 5/i RAID Controller with 5 drives in RAID 5 Array. Hot pluggable drive backplane Redundant, Hot pluggable power supplies Tower chassis Two CPUs - Dual Core Intel Xeon 5130, 4MB Cache, 2.00GHz, 1333MHz FSB Integrated graphics controller with 16MB SDRAM (add-in video cards not supported) Integrated PERC 5/i RAID controller Memory: 2GB DDR SDRAM; (2MB Cache on CPU cartridge) PCI Parallel Port Card (SIIG) Drives: Five 73GB or greater SAS 10K RPM hard-drives in RAID 5 Array 48X or better CD-RW/DVD-ROM combo drive (DVD-Write not available) 1.44 MB floppy drive SCSI PV100T, DAT72 tape drive with U320 SCSI controller card USB mouse (2 button w/ scroll) Windows Server 2003 R2 Standard Edition with 5 Client Access Licenses Windows Server 2003, New Installation and Restore CD Windows Server 2003, MUI Installation CD-ROM pack, required for non-english use only Sound card not supported no speakers provided

9 February 2007 Page 9 VE2519C1 - PE 2900 Tower Chassis server Single Xeon CPU Server Three 10/100/1000 MB Ethernet ports (Broadcom NetXtreme II 5708, 1 on-board, 2 addnl cards) Two SAS hard-drives Hot pluggable drive backplane Redundant, hot pluggable power supplies Rack-mountable chassis with rails Single CPU - Dual Core Intel Xeon 5130, 4MB Cache, 2.00GHz, 1333MHz FSB Integrated graphics controller with 16MB SDRAM Integrated SAS 5/i controller Memory: 1GB DDR SDRAM; (2MB Cache on CPU cartridge) PCI Parallel port card (SIIG) Drives: Two 73GB or greater SAS 10K RPM hard-drives 1.44MB floppy drive 48X or better CD-RW/DVD-ROM Combo drive SCSI PV100T, DAT72 tape drive with U320 SCSI controller card USB mouse (2 button w/ scroll) Windows Server 2003 R2 Standard Edition with 5 Client Access Licenses Windows Server 2003, New Installation and Restore CD Windows Server 2003, MUI Installation CD-ROM pack, required for non-english use only

10 February 2007 Page 10 Dell PE 2950 Specifications and DeltaV Workstation Product Details VE PE 2950 Rack mount Xeon CPU Server Chassis 2U Rack-mountable chassis 29.31" (74.4cm) D x 17.5" (44.43cm) W x 3.4" (8.64cm) H with bezel attached Rack Weight lbs (23 Kg), maximum configuration Environmental Operating Temperature: 10º C to 35º C (50º F to 95º F) Storage Temperature: -40º C to 65º C (-40º F to 149º F) Operating Relative Humidity (non-condensing twmax=29c): 20% to 80% non-condensing Maximum humidity gradient: 10% per hour, operational and non-operational conditions. Storage Relative Humidity: 5% to 95% non-condensing (twmax=38c) Operating Vibration: 0.26G at 5Hz to 350Hz for 2 minutes Storage Vibration: 1.54Grms Random Vibration at 10Hz to 250Hz for 15 minutes Operating Shock: 1 shock pulse of 41G for up to 2ms Storage Shock: 6 shock pulses of 71G for up to 2ms Operating Altitude: -16 to 3,048m (-50 ft to 10,000 ft) Storage Altitude: -16m to 10,600m (-50 ft to 35,000 ft) These servers must be installed in a dust free, contaminant free environment. These servers are not suitable for mounting in industrial environments unless they are mounted in enclosures that provide the necessary dust free and contaminant free environment Dell servers do not support multi-monitors, sound cards (no speakers provided with servers) or DVD Write drives.

11 February 2007 Page 11 VE2521C2 - PE 2950 Rack mount Dual Xeon CPU Server Three 10/100/1000 MB Ethernet ports (Broadcom NetXtreme II 5708, 1 on-board, 2 addnl cards) Five SAS hard-drives PERC 5/i RAID Controller with 5 drives in RAID 5 Array. Hot pluggable drive backplane Redundant, Hot pluggable power supplies Rack-mountable chassis with rails Two CPUs- Dual Core Intel Xeon 5130, 4MB Cache, 2.00GHz, 1333MHz FSB Integrated graphics controller with 16MB SDRAM Integrated PERC 5/i RAID controller Memory: 2GB DDR SDRAM; (2MB Cache on CPU cartridge) PCI Parallel Port Card (SIIG) Drives: Five 73GB or greater SAS 10K RPM hard-drives in RAID 5 Array 24X or better CD-RW/DVD-ROM combo drive External USB 1.44 MB floppy drive USB mouse (2 button w/ scroll) Windows Server 2003 R2 Standard Edition with 5 Client Access Licenses Windows Server 2003, New Installation and Restore CD Windows Server 2003, MUI Installation CD-ROM pack, required for non-english use only Sound card not supported no speakers provided

12 February 2007 Page 12 VE2521C1 - PE 2950 Rack mount server Single Xeon CPU Server Three 10/100/1000 MB Ethernet ports (Broadcom NetXtreme II 5708, 1 on-board, 2 addnl cards) Two SAS hard-drives Hot pluggable drive backplane Redundant, hot pluggable power supplies Rack-mountable chassis with rails Single CPU -Dual Core Intel Xeon 5130, 4MB Cache, 2.00GHz, 1333MHz FSB Integrated graphics controller with 16MB SDRAM Integrated SAS 5/i controller Memory: 1GB DDR SDRAM; (2MB Cache on CPU cartridge) PCI Parallel port card (SIIG) Drives: Two 73GB or greater SAS 10K RPM hard-drives Internal 1.44 MB floppy drive 24X or better CD-RW/DVD-ROM Combo drive USB mouse (2 button w/ scroll) Windows Server 2003 R2 Standard Edition with 5 Client Access Licenses Windows Server 2003, New Installation and Restore CD Windows Server 2003, MUI Installation CD-ROM pack, required for non-english use only

13 February 2007 Page 13 Ordering Information The DeltaV pricebook contains the exact specifications for the PCs and server hardware. Also consult for more details on the PC, server, or monitor specifications. Note: The DeltaV system is supported only on the specific Dell computer configurations sold from our pricebook. The DeltaV system is not supported on other Dell computers or computer configurations or on non-dell computers unless specifically noted otherwise. Any use of non-supported computers will affect our ability to provide technical support and will involve additional costs for technical support. To locate a sales office near you, visit our website at: or call us at: Asia Pacific: Europe, Middle East: North America, Latin America: or For large power, water, and wastewater applications contact Power and Water Solutions at: Emerson Process Management All rights reserved. or call us at: Asia Pacific: Europe, Middle East, Africa: North America, Latin America: DeltaV, the DeltaV design, SureService, the SureService design, SureNet, the SureNet design, and PlantWeb are marks of one of the Emerson Process Management group of companies. All other marks are property of their respective owners. The contents of this publication are presented for informational purposes only, and while every effort has been made to ensure their accuracy, they are not to be construed as warrantees or guarantees, express or implied, regarding the products or services described herein or their use or applicability. All sales are governed by our terms and conditions, which are available on request. We reserve the right to modify or improve the design or specification of such products at any time without notice.