SAMSØ PÅ GAS. Skibsteknisk Selskab København 8. September 2014

Transcription

1 SAMSØ PÅ GAS Skibsteknisk Selskab København 8. September 2014

2 Consulting Naval Architects OSK-ShipTech A/S Denmark World Wide Marine Consultancy Services Since 1966

3 Geography

4 Kanhavekanalen

5 Kanhavekanalen Man formoder, at den har været en del af Vikingetidens omfattende forsvarssystemer og har formentligt stået i forbindelse med en naturhavn i Stavns Fjord. En flådestyrke placeret i den velbeskyttede Stavns Fjord har med udkig fra Hjortholm eller Vorbjerg kunnet kontrollere den nord-sydgående sejlads langs den jyske østkyst og sejladsen mellem Jylland (nord og midt) i vest og Sjælland og Skåne i øst. Undersøgelser foretaget af forskere ved Moesgård Museum, tyder på, at kanalen skal ses som et led i en flådebase i Stavns Fjord eventuelt som bidrag til søforsvaret af vikingetidens (og nutidens red. ) vigtigste danske by, Århus. SAMSØ = SAMLINGSØEN

6 LNG Ferry SAMSØ History: Hou Samsø Ruten ( ) Samson, Samsine SamsøLinien ( ) Vesborg, Kyholm Færgen ( ) Kanhave Samsø Kommune (2014- ) Samsø

7 The Route Crossing Distance: 11.7 nm Crossing Time: 60 min

8 LNG Ferry SAMSØ Choice: 1. Continue Present Ferry Kanhave 2. New Ferry Samsø Municipal Board of Samsø decides to float a tender for construction of a new green ferry August 2012 Building price would decide if feasible or not

9 SAMSØ Gone Green

10 LNG Ferry SAMSØ Why LNG: NOx Limitations SOx Limitations EEDI (CO2) Cost?

11 LNG Ferry SAMSØ NOx Progressive reductions in NOx emissions from marine diesel engines installed on ships are also included, with a Tier II emission limit for engines installed on or after 1 January 2011; then with a more stringent "Tier III" emission limit for engines installed on or after 1 January 2016 operating in ECAs. Marine diesel engines installed on or after 1 January 1990 but prior to 1 January 2000 are required to comply with Tier I emission limits, if an approved method for that engine has been certified by an Administration.

12 LNG Ferry SAMSØ SOx Under the revised MARPOL Annex VI, the global sulphur cap is reduced initially to 3.50% (from the current 4.50%), effective from 1 January 2012; then progressively to 0.50 %, effective from 1 January 2020, subject to a feasibility review to be completed no later than The limits applicable in ECAs for SOx and particulate matter were reduced to 1.00%, beginning on 1 July 2010 (from the original 1.50%); being further reduced to 0.10 %, effective from 1 January 2015.

13 LNG Ferry SAMSØ EEDI Energy Efficiency Design Index

14 LNG Ferry SAMSØ Cost Who Knows???

15 LNG Ferry SAMSØ Conventional vs LNG Powered Savings: SOx ~95% NOx ~85% CO2 ~25%

16 LNG Ferry SAMSØ Prequalification Expression of Interest PQ applications Qualified for Tender

17 LNG Ferry SAMSØ The Tender Package

18 LNG Ferry SAMSØ Tender Design & Specifications

19 LNG Ferry SAMSØ

20 LNG Ferry SAMSØ

21 LNG Ferry SAMSØ

22 LNG Ferry SAMSØ Two Main Design Principles for Engine Room 1. Inherently Gas Safe Arrangement 2. Emergency Shut Down (ESD) Arrangement

23 LNG Ferry SAMSØ

24 LNG Ferry SAMSØ

25 LNG Ferry SAMSØ Engines: Wärtsila DF 6L20 x 4 LNG Tank: Vacuum insulated 10 bar 40 m3 Arrangement: Inherently Gas Safe ER

26 The Case LNG Ferry SAMSØ

27 LNG Ferry SAMSØ Most economical advantageous... 1 st DOMESTIC LNG FERRY In EU... TaDaa!!! Contract signed March 18 th 2013

28 LNG Ferry SAMSØ

29 LNG Ferry SAMSØ Legislation Onboard Well Regulated: IMO (Flag State): Resolution MSC.285(86) Interim Guidelines on Safety for Natural Gas-Fuelled Engine Installations in Ships (Adopted on 1 June 2009) New GAS Code (IGF 2014?) DNV: Rules for Classification of Ships PART 6, Chapter 13 Gas Fueled Ship Installation New January 2014.

30 LNG Ferry SAMSØ

31 LNG Ferry SAMSØ - BUNKER Bunkering Procedures 1. Direct Bunkering (Truck to Ship) 2. Local Storage Tank or Similar Facilities 3. Bio LNG (Samsø)

32 LNG Ferry SAMSØ - BUNKER 1. Direct Bunkering - 2 x Bunkering per week Trucks from nearest possible supplier I. Zeebrugge LNG Terminal (975 km) II. Świnoujście LNG Terminal (625 km) III. Hamburg LNG Terminal (350 km) IV. Copenhagen LNG Terminal (300 km) V. Hirtshals LNG Terminal (225 km) VI. Aarhus LNG Terminal (30 km)

33 LNG Ferry SAMSØ - BUNKER Aarhus LNG Terminal

34 LNG Ferry SAMSØ - BUNKER 2. Local Storage Tank Bunkering 1 x per day Local Storage Tank and Pump facility arranged in Hou or Sælvig. Storage Tank fill from nearest possible supplier I. Zeebrugge LNG Terminal II. Świnoujście LNG Terminal III. Hamburg LNG Terminal IV. Copenhagen LNG Terminal V. Hirtshals LNG Terminal

35 LNG Ferry SAMSØ - BUNKER 3. BIO LNG Plant on Samsø Bunkering 1 x per day BIO LNG Plant: I. BIO Gas Facility II. CryoBox (Galileo) III. Tank / Pump Facility

36 LNG Ferry SAMSØ - BUNKER Bunkering Procedures Flag State National Rules Danish Emergency Management Agency Local Rules Local Emergency Responce Team SHIP SHORE

37 LNG Ferry SAMSØ - BUNKER Bunkering Procedures Optimized Bunkering Procedure Minimize Bunker Time Bunkering when loading/unloading Plant (shore/onboard) Capacities Optimize Safety Procedures Training

38 LNG Ferry SAMSØ - BUNKER Bunkering Procedures We Did not Know

39 LNG Ferry SAMSØ - BUNKER Tender for Bunkering

40 LNG Ferry SAMSØ - BUNKER Tender for Bunkering Consumerables: Supply and delivery of Liquefied Natural Gas (LNG) to the ferry operation. Minimum quality as required for the engine type Wartsila 6L20DF. TTF as reference for Qoute Installation: Supply and delivery of necessary installation (pumps, tanks, trucks etc) as may be required for the daily bunkering of LNG to the ferry. An estimated cum LNG shall be bunkered daily in only one (1) procedure. Minimum bunkering time is essential to the operation. Training: Necessary training of dedicated Vessel Crew, allowing for the Vessel Crew to carry out the daily bunkering procedures. Deadline was

41 LNG Ferry SAMSØ - BUNKER Tender for Bunkering - Prequalification 25 Companies Interested 12 Companies Applied for PQ 8 Companies pass (original 3-5)

42 LNG Ferry SAMSØ - BUNKER Tender for Bunkering TENDER Submission 5 Companies submitted quotation

43 LNG Ferry SAMSØ - BUNKER Tender for Bunkering TENDER Submission And The Winner is...

44 LNG Ferry SAMSØ - BUNKER Tender for Bunkering TENDER Submission And The Winner is COSAN Q8

45 LNG Ferry SAMSØ - BUNKER

47 LNG Ferry SAMSØ

49 LNG Ferry SAMSØ LNG is COOL!